NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
37 reportsClear category filterMileage unknown · Sep 9, 2024
Electrical SystemFire
Sunday September 8 I plugged my Taycan into my charger at approxmately 1PM. Later I went into my garage approximately 3PM to get something, and it was filled with smoke. After extinguishing the fire, I noticed the cause was the PLUG attached to the Porsche charger had caurght fire and melted the outlet which then caught my gar…
Read full complaint
Sunday September 8 I plugged my Taycan into my charger at approxmately 1PM. Later I went into my garage approximately 3PM to get something, and it was filled with smoke. After extinguishing the fire, I noticed the cause was the PLUG attached to the Porsche charger had caurght fire and melted the outlet which then caught my garage wall on fire. Had I not been home, my house would have caught fire.
NHTSA ODI #11613405
Mileage unknown · Jul 4, 2024
Electrical SystemEngineFuel/propulsion System
When accelerating the has a sudden loss of power. I get a message to pull off the.road. After turning offf the engine and restarting car begins to function properly again.
NHTSA ODI #11598805
Mileage unknown · Dec 7, 2023
Electrical System
The heater does not work, requires a part change and this is the 2nd time in two years. Only blowing cold air.
NHTSA ODI #11558966
Mileage unknown · Aug 14, 2023
Electrical SystemFire
While charging the vehicle at a reduced rate (30 amps out of a 40 amp maximum) there was a thermal event in the outlet box that the Mobile Charger Connect was plugged into. There were no witnesses to the event, but it was later noticed that the wall around the outlet was blackened and one prong of the plug had melted the housing…
Read full complaint
While charging the vehicle at a reduced rate (30 amps out of a 40 amp maximum) there was a thermal event in the outlet box that the Mobile Charger Connect was plugged into. There were no witnesses to the event, but it was later noticed that the wall around the outlet was blackened and one prong of the plug had melted the housing of the plug along with the receptacle. The Mobile Charger Connect had previously shown a high temperature warning, so the operating current was reduced from 40 to 30 amps at the direction of service personnel at the dealership. The Mobile Charger Connect was plugged into the specified NEMA 14-50 receptacle that has been in use for the entire duration of ownership.
NHTSA ODI #11538414
Mileage unknown · Mar 28, 2023
Electrical SystemEngineUnknown Or Other
Car died after being on the charger for 8 weeks. Main battery is at 83% but apparently there is a 12v small battery that failed. Car is inoperable. Doors will not open, windows stuck partially down, car will not go into gear, can't be moved.
NHTSA ODI #11514322
Mileage unknown · Feb 17, 2023
Electrical SystemVisibility/wiper
On December 29, 2022, the heater unit in the car failed. This caused ice to form on the inside of the car, all windows. Winter in Chicago. Dealer said they are aware of other Tacans having this came issue but there are no parts available and could be 4 to 6 weeks for parts. it is now February 15th and still no parts and the car …
Read full complaint
On December 29, 2022, the heater unit in the car failed. This caused ice to form on the inside of the car, all windows. Winter in Chicago. Dealer said they are aware of other Tacans having this came issue but there are no parts available and could be 4 to 6 weeks for parts. it is now February 15th and still no parts and the car is unsafe to drive as you can not see out of the windows. If you look on the website in Europe there are reported over 800 of these cars with the same issue and now Audi is having the same issue. These cars are unsafer and should be removed from the roads.
NHTSA ODI #11507742
Mileage unknown · Jan 10, 2023
Electrical SystemEngine
Several times when driving (3) the vehicle loses all power and stops. Warning error messages are displayed on the dashboard screen ("Electrical system error") and "Engine Control Error" This is a dangerous situation, as the car suddenly just went dead on the middle of the highway. with cars having to swerve out of the way to avo…
Read full complaint
Several times when driving (3) the vehicle loses all power and stops. Warning error messages are displayed on the dashboard screen ("Electrical system error") and "Engine Control Error" This is a dangerous situation, as the car suddenly just went dead on the middle of the highway. with cars having to swerve out of the way to avoid hitting my vehicle. The vehicle has been in the Porsche dealer once to have this issue rectified, but has happened again twice since that time.
NHTSA ODI #11501045
Mileage unknown · Dec 11, 2022
Electrical System
While driving my Porsche Taycan 2021 (5000 miles) Nov 4th, 2022, at highway speeds on I-15 to Vegas, the instrument cluster started flashing "Electric System Error" and instructed me to park in safe place immediately and call Roadside Assistance. I had to park on the hard shoulder and wait for a tow truck. It was scary as there …
Read full complaint
While driving my Porsche Taycan 2021 (5000 miles) Nov 4th, 2022, at highway speeds on I-15 to Vegas, the instrument cluster started flashing "Electric System Error" and instructed me to park in safe place immediately and call Roadside Assistance. I had to park on the hard shoulder and wait for a tow truck. It was scary as there were big rigs passing my every 10-20 seconds. Car was towed to the Porsche dealer in Vegas. Upon inspection it was found that the "High Voltage Converter" had malfunctioned and had to be replaced. This is very concerning that a critical EV component can fail in new car, which had done just over 5000 miles. Dealer replaced the component and now the vehicle is running fine but I am very skeptical to take the car out on long drives.
NHTSA ODI #11496955
Mileage unknown · Dec 11, 2022
Electrical SystemEnginePower Train
Spontaneous shutdown of the vehicle while driving. Critical failure of motility while driving. Driving at 50km per hour extremely dangerous as car just shutdown and I had to try to roll off the road but it died so I had to put it in neutral and push it by hand on a busy road. Car has been at the dealer for 3 weeks now. The spont…
Read full complaint
Spontaneous shutdown of the vehicle while driving. Critical failure of motility while driving. Driving at 50km per hour extremely dangerous as car just shutdown and I had to try to roll off the road but it died so I had to put it in neutral and push it by hand on a busy road. Car has been at the dealer for 3 weeks now. The spontaneous shut occurred and a red light came on.
NHTSA ODI #11496914
Mileage unknown · Jul 6, 2022
Electrical SystemEngine
November 27,2021 Electrical System Failure . Car was parked in a parking lot . RED system failure error . After 30 minutes the car started and I drove it to Town Motors Porsche , Englewood NJ (purchase dealer). They had car for ~ 3 weeks and "everything is fine." July 6th 2022: Identical Electrical Systems failure . Again while…
Read full complaint
November 27,2021 Electrical System Failure . Car was parked in a parking lot . RED system failure error . After 30 minutes the car started and I drove it to Town Motors Porsche , Englewood NJ (purchase dealer). They had car for ~ 3 weeks and "everything is fine." July 6th 2022: Identical Electrical Systems failure . Again while car was parked in my garage . Car started on its own several hours later . Drove car to Town Englewood Porsche , Englewood NJ . The car is clearly unsafe and I do not feel comfortable driving this car. I do NOT want to be the first casualty because it fails on a highway . Porsche needs to take ownership . Taycan forum online clearly show that this is an issue with this car .
NHTSA ODI #11472637
Official recalls
21Dec 19, 2025
Porsche Cars North America, Inc. (Porsche) is recalling certain 2019-2025 Cayenne, Cayenne E-Hybrid, 2020-2025 911, Taycan, 2024-2025 Panamera, and 2025 Panamera E-Hybrid vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview image that does not display properly reduces the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will update the driver assistance software, free of charge. Owner notification letters were mailed February 13, 2026. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is ASB2. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning January 19, 2026.
Oct 1, 2024
Porsche Cars North America, Inc. (Porsche) is recalling certain 2020-2023 Taycan vehicles. The high-voltage battery may experience a short circuit within the battery module.
Consequence & remedy
Consequence: A short circuit in a high-voltage battery increases the risk of a fire.
Remedy: Owners are advised to only charge their vehicles to a maximum of 80% battery capacity until the repair has been completed. Dealers will replace the affected modules in the high-voltage battery, free of charge. Owner notification letters were mailed November 22, 2024. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is ARB5. This recall expands previous recall numbers 23V-840, 24V-215, and 24V-217. Vehicles previously repaired under the prior recalls will need to have the new remedy completed.
Additional source detail variants (2)
Electrical System:propulsion System:traction Battery
Porsche Cars North America, Inc. (Porsche) is recalling certain 2020-2023 Taycan vehicles. The high-voltage battery may experience a short circuit within the battery module.
Consequence: A short circuit in a high-voltage battery increases the risk of a fire.
Remedy: Owners are advised to only charge their vehicles to a maximum of 80% battery capacity until the repair has been completed. Dealers will replace the affected modules in the high-voltage battery, free of charge. Owner notification letters were mailed November 22, 2024. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is ARB5. This recall expands previous recall numbers 23V-840, 24V-215, and 24V-217. Vehicles previously repaired under the prior recalls will need to have the new remedy completed.
Electrical System:software
Porsche Cars North America, Inc. (Porsche) is recalling certain 2020-2023 Taycan vehicles. The high-voltage battery may experience a short circuit within the battery module.
Consequence: A short circuit in a high-voltage battery increases the risk of a fire.
Remedy: Owners are advised to only charge their vehicles to a maximum of 80% battery capacity until the repair has been completed. Dealers will replace the affected modules in the high-voltage battery, free of charge. Owner notification letters were mailed November 22, 2024. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is ARB5. This recall expands previous recall numbers 23V-840, 24V-215, and 24V-217. Vehicles previously repaired under the prior recalls will need to have the new remedy completed.
Oct 1, 2024
Porsche Cars North America, Inc. (Porsche) is recalling certain 2021-2024 Taycan vehicles. The high-voltage battery may experience a short circuit within the battery module.
Consequence & remedy
Consequence: A short circuit in a high-voltage battery increases the risk of a fire.
Remedy: Dealers will install advanced diagnostic software as the final remedy, anticipated to be available in the first quarter of 2025. Porsche will monitor available online vehicle data and contact owners as necessary, to advise them to only charge the vehicle to 80% capacity until the battery can be replaced. For vehicles in which online data is unavailable, dealers will perform a diagnostic test and replace the battery module assembly, if necessary and advise owners to only charge to 80% capacity. Repairs will be performed free of charge. Owner notification letters were mailed August 6, 2025. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's numbers for this recall are ARB6 and ARB7. This recall expands and replaces previous recall numbers 23V-840, 24V-215, and 24V-217.
Additional source detail variants (2)
Electrical System:propulsion System:traction Battery
Porsche Cars North America, Inc. (Porsche) is recalling certain 2021-2024 Taycan vehicles. The high-voltage battery may experience a short circuit within the battery module.
Consequence: A short circuit in a high-voltage battery increases the risk of a fire.
Remedy: Dealers will install advanced diagnostic software as the final remedy, anticipated to be available in the first quarter of 2025. Porsche will monitor available online vehicle data and contact owners as necessary, to advise them to only charge the vehicle to 80% capacity until the battery can be replaced. For vehicles in which online data is unavailable, dealers will perform a diagnostic test and replace the battery module assembly, if necessary and advise owners to only charge to 80% capacity. Repairs will be performed free of charge. Owner notification letters were mailed August 6, 2025. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's numbers for this recall are ARB6 and ARB7. This recall expands and replaces previous recall numbers 23V-840, 24V-215, and 24V-217.
Electrical System:software
Porsche Cars North America, Inc. (Porsche) is recalling certain 2021-2024 Taycan vehicles. The high-voltage battery may experience a short circuit within the battery module.
Consequence: A short circuit in a high-voltage battery increases the risk of a fire.
Remedy: Dealers will install advanced diagnostic software as the final remedy, anticipated to be available in the first quarter of 2025. Porsche will monitor available online vehicle data and contact owners as necessary, to advise them to only charge the vehicle to 80% capacity until the battery can be replaced. For vehicles in which online data is unavailable, dealers will perform a diagnostic test and replace the battery module assembly, if necessary and advise owners to only charge to 80% capacity. Repairs will be performed free of charge. Owner notification letters were mailed August 6, 2025. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's numbers for this recall are ARB6 and ARB7. This recall expands and replaces previous recall numbers 23V-840, 24V-215, and 24V-217.
Jun 19, 2024
Porsche Cars North America, Inc. (Porsche) is recalling certain 2020-2025 Taycan vehicles. The front brake hoses can develop cracks and leak brake fluid.
Consequence & remedy
Consequence: A brake fluid leak can reduce braking performance and extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will replace the front brake hoses, free of charge. Owner notification letters were mailed on January 29, 2025. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is ARB0.
Mar 20, 2024
Porsche Cars North America, Inc. (Porsche) is recalling certain 2021-2023 Taycan, Taycan 4 Cross Turismo, 2020-2023 Taycan 4S, Taycan Turbo S, 2021-2022 Taycan 4S Cross Turismo, 2022 Taycan Turbo S Cross Turismo, 2022-2023 Taycan GTS, 2023 Taycan GTS Sport Turismo, and 2020-2021 Taycan Turbo vehicles. The high-voltage battery may experience a short circuit within the battery modules.
Consequence & remedy
Consequence: A short circuit in the battery increases the risk of a fire.
Remedy: Owners are advised to only charge their vehicles to a maximum of 80% battery capacity until the repair has been completed. Dealers will replace the affected modules in the high-voltage battery, free of charge. Owner notification letters were mailed on October 8, 2024. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is ARA4.
Mar 20, 2024
Porsche Cars North America, Inc. (Porsche) is recalling certain 2021-2024 Taycan, 2020-2024 Taycan 4S, Taycan Turbo, 2021-2023 Taycan 4 Cross Turismo, 2022-2023 Taycan 4S Cross Turismo, Taycan Turbo S Cross Turismo, 2023 Taycan Turbo Cross Turismo, 2022-2024 Taycan GTS, Taycan GTS Sport Turismo, and 2020-2023 Taycan Turbo S vehicles. The high-voltage battery may experience a short circuit within the battery modules.
Consequence & remedy
Consequence: A short circuit in the battery increases the risk of a fire.
Remedy: Owners are advised to only charge their vehicles to a maximum of 80% battery capacity until the repair has been completed. Dealers will analyze the battery data and replace the high-voltage battery modules as necessary, free of charge. Owner notification letters were mailed on October 9, 2024. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is ARA5.
Dec 13, 2023
Porsche Cars North America, Inc. (Porsche) is recalling certain 2021-2023 Porsche Taycan, 2021-2022 Taycan 4S, Taycan Turbo S, Taycan Turbo, Taycan 4 Cross Turismo, Taycan 4S Cross Turismo, Taycan Turbo Cross Turismo, 2022 Taycan GTS, and Taycan GTS Sport Turismo vehicles. The high-voltage battery may experience a short circuit within the battery modules.
Consequence & remedy
Consequence: A short circuit in the battery increases the risk of a fire.
Remedy: Dealers will inspect and repair the high-voltage battery by replacing modules as necessary, free of charge Owner notification letters were mailed on June 14, 2024. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is APB5.
Dec 13, 2023
Porsche Cars North America, Inc. (Porsche) is recalling various models and model years. Please see the recall report for a list of the included vehicles. When using the industrial 220V/240V plug at the 100% charge setting, some home power outlets may be incapable of handling the electrical current required to utilize the compact charging system, causing the outlet or charging cable to overheat.
Consequence & remedy
Consequence: An overheated outlet or charging cable can increase the risk of a fire.
Remedy: Owners are advised not to use the 220V/240V compact/portable charging cable and only use the 110V home charging cable or public charging stations. Dealers will supply a new 220V/240V compact/portable charging cable with an incorporated temperature sensor, free of charge. Owner notification letters were mailed on October 24, 2024. A second notice will be sent once remedy parts become available, anticipated mid-2024. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is APB6.
May 16, 2023
Porsche Cars North America, Inc. (Porsche) is recalling certain 2020-2022 Taycan vehicles. An incorrect warning indicator with an incorrect color is displayed in the instrument cluster when notifying owners of worn brake pads. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 135, "Light Vehicle Brake Systems," and 101, "Control and Displays."
Consequence & remedy
Consequence: An incorrect warning indicator may be misinterpreted and result in driving on worn brake pads with reduced brake performance, increasing the risk of a crash.
Remedy: Dealers will update the software for the instrument cluster, free of charge. Owner notification letters are expected to be mailed July 14, 2023. Owners may contact Porsche's customer service at 1-800-767-7243. Porsche's number for this recall is APA5.
Additional source detail variants (2)
Electrical System: Instrument Cluster/panel
Porsche Cars North America, Inc. (Porsche) is recalling certain 2020-2022 Taycan vehicles. An incorrect warning indicator with an incorrect color is displayed in the instrument cluster when notifying owners of worn brake pads. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 135, "Light Vehicle Brake Systems," and 101, "Control and Displays."
Consequence: An incorrect warning indicator may be misinterpreted and result in driving on worn brake pads with reduced brake performance, increasing the risk of a crash.
Remedy: Dealers will update the software for the instrument cluster, free of charge. Owner notification letters are expected to be mailed July 14, 2023. Owners may contact Porsche's customer service at 1-800-767-7243. Porsche's number for this recall is APA5.
Service Brakes, Hydraulic
Porsche Cars North America, Inc. (Porsche) is recalling certain 2020-2022 Taycan vehicles. An incorrect warning indicator with an incorrect color is displayed in the instrument cluster when notifying owners of worn brake pads. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 135, "Light Vehicle Brake Systems," and 101, "Control and Displays."
Consequence: An incorrect warning indicator may be misinterpreted and result in driving on worn brake pads with reduced brake performance, increasing the risk of a crash.
Remedy: Dealers will update the software for the instrument cluster, free of charge. Owner notification letters are expected to be mailed July 14, 2023. Owners may contact Porsche's customer service at 1-800-767-7243. Porsche's number for this recall is APA5.
Mar 17, 2023
Porsche Cars North America, Inc. (Porsche) is recalling certain 2020 Taycan Turbo, 2021 Taycan, Taycan 4S Cross Turismo, 2022 Taycan, Taycan Turbo, Taycan GTS, Taycan 4 Cross Turismo, Taycan 4S Cross Turismo, 2020-2022 Taycan 4S and Taycan Turbo S, and 2023 Taycan vehicles. When there is an unbelted passenger, the seat belt warning light and audible chime will not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: A malfunctioning seat belt warning system may not alert the passenger to buckle their seat belt, increasing the risk of injury in the event of a crash.
Remedy: Dealers will update the instrument cluster software, free of charge. Owner notification letters are expected to be mailed May 16, 2023. Owners may contact Porsche's customer service at 1-800-767-7243. Porsche's number for this recall is APA2.
Additional source detail variants (2)
Electrical System: Instrument Cluster/panel
Porsche Cars North America, Inc. (Porsche) is recalling certain 2020 Taycan Turbo, 2021 Taycan, Taycan 4S Cross Turismo, 2022 Taycan, Taycan Turbo, Taycan GTS, Taycan 4 Cross Turismo, Taycan 4S Cross Turismo, 2020-2022 Taycan 4S and Taycan Turbo S, and 2023 Taycan vehicles. When there is an unbelted passenger, the seat belt warning light and audible chime will not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: A malfunctioning seat belt warning system may not alert the passenger to buckle their seat belt, increasing the risk of injury in the event of a crash.
Remedy: Dealers will update the instrument cluster software, free of charge. Owner notification letters are expected to be mailed May 16, 2023. Owners may contact Porsche's customer service at 1-800-767-7243. Porsche's number for this recall is APA2.
Seat Belts:front:warning Light/devices
Porsche Cars North America, Inc. (Porsche) is recalling certain 2020 Taycan Turbo, 2021 Taycan, Taycan 4S Cross Turismo, 2022 Taycan, Taycan Turbo, Taycan GTS, Taycan 4 Cross Turismo, Taycan 4S Cross Turismo, 2020-2022 Taycan 4S and Taycan Turbo S, and 2023 Taycan vehicles. When there is an unbelted passenger, the seat belt warning light and audible chime will not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: A malfunctioning seat belt warning system may not alert the passenger to buckle their seat belt, increasing the risk of injury in the event of a crash.
Remedy: Dealers will update the instrument cluster software, free of charge. Owner notification letters are expected to be mailed May 16, 2023. Owners may contact Porsche's customer service at 1-800-767-7243. Porsche's number for this recall is APA2.
Dec 13, 2022
Porsche Cars North America, Inc. (Porsche) is recalling certain 2021 Taycan, Taycan 4S, Taycan Turbo S, Taycan 4 Cross Turismo, and Taycan 4S Cross Turismo vehicles. A retaining ring on top of the suspension strut may come loose, resulting in a dislodged strut and air loss from the strut spring.
Consequence & remedy
Consequence: An air suspension strut failure may cause a loss of vehicle handling and control, increasing the risk of a crash.
Remedy: Dealers will inspect the suspension strut and replace it, if necessary, free of charge. Owner notification letters are expected to be mailed February 10, 2023. Owners may contact Porsche's customer service at 1-800-767-7243. Porsche's number for this recall is ANB8.
Jun 8, 2022
Porsche Cars North America, Inc. (Porsche) is recalling certain 2020-2022 Taycan vehicles. A software error could cause the center screen (including rearview camera image) and the touch control panel remain to black directly after the ignition is activated. Also, the Real-Top-View (including rearview camera image) could display a flickering image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A malfunctioning center screen or touch control panel may obstruct the driver's view of camera assisted driving functions, increasing the risk of a crash.
Remedy: Dealers will install new software, free of charge. Owner notification letters are expected to be mailed August 5, 2022. Owners may contact Porsche's customer service at 1-800-767-7243. Porsche's number for this recall is ANA6.
Additional source detail variants (2)
Back Over Prevention: Sensing System: Camera
Porsche Cars North America, Inc. (Porsche) is recalling certain 2020-2022 Taycan vehicles. A software error could cause the center screen (including rearview camera image) and the touch control panel remain to black directly after the ignition is activated. Also, the Real-Top-View (including rearview camera image) could display a flickering image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: A malfunctioning center screen or touch control panel may obstruct the driver's view of camera assisted driving functions, increasing the risk of a crash.
Remedy: Dealers will install new software, free of charge. Owner notification letters are expected to be mailed August 5, 2022. Owners may contact Porsche's customer service at 1-800-767-7243. Porsche's number for this recall is ANA6.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Porsche Cars North America, Inc. (Porsche) is recalling certain 2020-2022 Taycan vehicles. A software error could cause the center screen (including rearview camera image) and the touch control panel remain to black directly after the ignition is activated. Also, the Real-Top-View (including rearview camera image) could display a flickering image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: A malfunctioning center screen or touch control panel may obstruct the driver's view of camera assisted driving functions, increasing the risk of a crash.
Remedy: Dealers will install new software, free of charge. Owner notification letters are expected to be mailed August 5, 2022. Owners may contact Porsche's customer service at 1-800-767-7243. Porsche's number for this recall is ANA6.
Apr 26, 2022
Porsche Cars of North America, Inc. (Porsche) is recalling certain 2020-2021 Taycan vehicles. The driver and passenger seat wire harness could become damaged during horizontal seat adjustment.
Consequence & remedy
Consequence: A damaged seat wire harness may deactivate air bags, increasing the risk of injury in a crash.
Remedy: Dealers will inspect the seat wire harness for damage, add fabric tape to secure the harness, and repair damaged wires as necessary, free of charge. Owner notification letters were mailed July 22, 2022. Owners may contact Porsche's customer service at 1-800-767-7243. Porsche's number for this recall is ANA5.
Feb 22, 2022
Porsche Cars North America, Inc. (Porsche) is recalling certain 2020-2021 Taycan vehicles equipped with an optional rear center seat. The center seat belt buckle wiring harness may obstruct access to the right rear seat lower child seat anchors, preventing a child seat from being properly secured. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 225, "Child Restraint Anchorage Systems."
Consequence & remedy
Consequence: An improperly secured child seat increases the risk of injury during a crash.
Remedy: Dealers will reroute and secure the center rear seat belt buckle wiring harness and, as necessary, replace a damaged buckle, free of charge. Owner notification letters were mailed April 7, 2022. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is ANA4.
Additional source detail variants (2)
Seat Belts:rear/other:anchorage
Porsche Cars North America, Inc. (Porsche) is recalling certain 2020-2021 Taycan vehicles equipped with an optional rear center seat. The center seat belt buckle wiring harness may obstruct access to the right rear seat lower child seat anchors, preventing a child seat from being properly secured. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 225, "Child Restraint Anchorage Systems."
Consequence: An improperly secured child seat increases the risk of injury during a crash.
Remedy: Dealers will reroute and secure the center rear seat belt buckle wiring harness and, as necessary, replace a damaged buckle, free of charge. Owner notification letters were mailed April 7, 2022. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is ANA4.
Seat Belts: Rear/other:buckle Assembly
Porsche Cars North America, Inc. (Porsche) is recalling certain 2020-2021 Taycan vehicles equipped with an optional rear center seat. The center seat belt buckle wiring harness may obstruct access to the right rear seat lower child seat anchors, preventing a child seat from being properly secured. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 225, "Child Restraint Anchorage Systems."
Consequence: An improperly secured child seat increases the risk of injury during a crash.
Remedy: Dealers will reroute and secure the center rear seat belt buckle wiring harness and, as necessary, replace a damaged buckle, free of charge. Owner notification letters were mailed April 7, 2022. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is ANA4.
Feb 2, 2022
Porsche Cars North America, Inc. (Porsche) is recalling one 2021 Taycan vehicle. The front and rear suspension may be misaligned.
Consequence & remedy
Consequence: Suspension misalignment may cause premature or uneven tire wear, increasing the risk of a crash.
Remedy: Dealers will inspect the front and rear axles, adjust the alignment as necessary, and replace any prematurely or unevenly worn tires, free of charge. The owner notification letter was mailed March 10, 2022. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is ANA2.
Additional source detail variants (2)
Tires
Porsche Cars North America, Inc. (Porsche) is recalling one 2021 Taycan vehicle. The front and rear suspension may be misaligned.
Consequence: Suspension misalignment may cause premature or uneven tire wear, increasing the risk of a crash.
Remedy: Dealers will inspect the front and rear axles, adjust the alignment as necessary, and replace any prematurely or unevenly worn tires, free of charge. The owner notification letter was mailed March 10, 2022. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is ANA2.
Suspension
Porsche Cars North America, Inc. (Porsche) is recalling one 2021 Taycan vehicle. The front and rear suspension may be misaligned.
Consequence: Suspension misalignment may cause premature or uneven tire wear, increasing the risk of a crash.
Remedy: Dealers will inspect the front and rear axles, adjust the alignment as necessary, and replace any prematurely or unevenly worn tires, free of charge. The owner notification letter was mailed March 10, 2022. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is ANA2.
Oct 13, 2021
Porsche Cars North America, Inc. (Porsche) is recalling certain 2020-2021 Taycan vehicles. The pre-collision automatic hazard lights may activate in non-emergency situations. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: An activation of hazard lights in non-emergency situations could confuse other drivers, increasing the risk of a crash.
Remedy: Dealers will reprogram the hazard lights, free of charge. Owner notification letters were mailed December 2, 2021. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AMC1.
Sep 8, 2021
Porsche Cars North America, Inc. (Porsche) is recalling certain 2020-2021 911 Carrera and Taycan vehicles. The pressure input rod connection on the brake booster may be loose and could detach.
Consequence & remedy
Consequence: A detached pressure input rod will cause the brake pedal to fail, increasing the risk of a crash.
Remedy: Dealers will repair or replace the brake booster as necessary, free of charge. Owner notification letters were mailed October 28, 2021. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AMB9.
Additional source detail variants (2)
Service Brakes, Hydraulic:critical Fasteners
Porsche Cars North America, Inc. (Porsche) is recalling certain 2020-2021 911 Carrera and Taycan vehicles. The pressure input rod connection on the brake booster may be loose and could detach.
Consequence: A detached pressure input rod will cause the brake pedal to fail, increasing the risk of a crash.
Remedy: Dealers will repair or replace the brake booster as necessary, free of charge. Owner notification letters were mailed October 28, 2021. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AMB9.
Service Brakes, Hydraulic:foundation Components
Porsche Cars North America, Inc. (Porsche) is recalling certain 2020-2021 911 Carrera and Taycan vehicles. The pressure input rod connection on the brake booster may be loose and could detach.
Consequence: A detached pressure input rod will cause the brake pedal to fail, increasing the risk of a crash.
Remedy: Dealers will repair or replace the brake booster as necessary, free of charge. Owner notification letters were mailed October 28, 2021. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AMB9.
Aug 4, 2021
Porsche Cars North America, Inc. (Porsche) is recalling certain 2021 911 Carrera Coupe, 911 Carrera S Coupe, 911 Carrera 4 Coupe, 911 Carrera 4S Coupe, 911 Turbo Coupe, 911 Turbo S Coupe, Panamera, Panamera 4 E-Hybrid, Panamera 4S, Panamera GTS, Panamera Turbo S, Taycan, Taycan 4S, Taycan Turbo, and Taycan Turbo S vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect and replace the seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed October 1, 2021. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AMB6.
Additional source detail variants (3)
Seat Belts:rear/other:retractor
Porsche Cars North America, Inc. (Porsche) is recalling certain 2021 911 Carrera Coupe, 911 Carrera S Coupe, 911 Carrera 4 Coupe, 911 Carrera 4S Coupe, 911 Turbo Coupe, 911 Turbo S Coupe, Panamera, Panamera 4 E-Hybrid, Panamera 4S, Panamera GTS, Panamera Turbo S, Taycan, Taycan 4S, Taycan Turbo, and Taycan Turbo S vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect and replace the seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed October 1, 2021. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AMB6.
Seat Belts:front:retractor
Porsche Cars North America, Inc. (Porsche) is recalling certain 2021 911 Carrera Coupe, 911 Carrera S Coupe, 911 Carrera 4 Coupe, 911 Carrera 4S Coupe, 911 Turbo Coupe, 911 Turbo S Coupe, Panamera, Panamera 4 E-Hybrid, Panamera 4S, Panamera GTS, Panamera Turbo S, Taycan, Taycan 4S, Taycan Turbo, and Taycan Turbo S vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect and replace the seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed October 1, 2021. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AMB6.
Seat Belts
Porsche Cars North America, Inc. (Porsche) is recalling certain 2021 911 Carrera Coupe, 911 Carrera S Coupe, 911 Carrera 4 Coupe, 911 Carrera 4S Coupe, 911 Turbo Coupe, 911 Turbo S Coupe, Panamera, Panamera 4 E-Hybrid, Panamera 4S, Panamera GTS, Panamera Turbo S, Taycan, Taycan 4S, Taycan Turbo, and Taycan Turbo S vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect and replace the seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed October 1, 2021. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AMB6.
Jun 29, 2021
Porsche Cars North America, Inc. (Porsche) is recalling certain 2020-2021 Taycan Turbo, Taycan Turbo S, Taycan 4S, 2021 Taycan, Taycan Cross Turismo, Taycan Turbo S Cross Turismo, Taycan 4S Cross Turismo, and Taycan Turbo Cross Turismo vehicles. The monitoring software can incorrectly detect a fault and shutdown the power train, causing a loss of motive power.
Consequence & remedy
Consequence: A loss of motive power increases the risk of a crash.
Remedy: Dealers will reprogram the power electronics and the engine control unit, free of charge. Owner notification letters were mailed July 30, 2021. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AMB5.
Additional source detail variants (2)
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
Porsche Cars North America, Inc. (Porsche) is recalling certain 2020-2021 Taycan Turbo, Taycan Turbo S, Taycan 4S, 2021 Taycan, Taycan Cross Turismo, Taycan Turbo S Cross Turismo, Taycan 4S Cross Turismo, and Taycan Turbo Cross Turismo vehicles. The monitoring software can incorrectly detect a fault and shutdown the power train, causing a loss of motive power.
Consequence: A loss of motive power increases the risk of a crash.
Remedy: Dealers will reprogram the power electronics and the engine control unit, free of charge. Owner notification letters were mailed July 30, 2021. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AMB5.
Electrical System:propulsion System:traction Motor:controller:software
Porsche Cars North America, Inc. (Porsche) is recalling certain 2020-2021 Taycan Turbo, Taycan Turbo S, Taycan 4S, 2021 Taycan, Taycan Cross Turismo, Taycan Turbo S Cross Turismo, Taycan 4S Cross Turismo, and Taycan Turbo Cross Turismo vehicles. The monitoring software can incorrectly detect a fault and shutdown the power train, causing a loss of motive power.
Consequence: A loss of motive power increases the risk of a crash.
Remedy: Dealers will reprogram the power electronics and the engine control unit, free of charge. Owner notification letters were mailed July 30, 2021. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AMB5.
May 17, 2021
Porsche Cars North America, Inc. (Porsche) is recalling certain 2021 Taycan, Panamera, Panamera Turbo S, Panamera GTS, Panamera 4, Panamera 4 Sport Turismo, Panamera 4 Executive, Panamera 4S Executive, Panamera 4S, Panamera 4S E-Hybrid, and Panamera 4 E-Hybrid vehicles. The front lower trailing arms were not forged correctly and may break.
Consequence & remedy
Consequence: A broken front lower trailing arm may cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers will replace the front lower trailing arms, free of charge. Owner notification letters were mailed October 1, 2021. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AMB2.
Mar 10, 2021
Porsche Cars North America, Inc. (Porsche) is recalling certain 2021 Porsche Taycan Turbo, Taycan Turbo S, Taycan, Taycan 4S, 911 Turbo S Coupe, Cayman, Cayman T, Cayman S, Cayman GT4, 911 Carrera Coupe, 911 Carrera S Coupe, 911 Carrera 4S Coupe, 911 Carrera 4S Targa, 911 Carrera Cabriolet, 911 Carrera S Cabriolet, 911 Carrera 4S Targa Heritage Design Edition, 911 Carrera 4S Cabriolet, 911 Turbo Coupe, 911 Turbo Cabriolet, 911 Turbo S Cabriolet, 718 Spyder, and Boxster vehicles. Certain suspension components may not have been tightened correctly and can loosen.
Consequence & remedy
Consequence: Loose suspension components may detach, causing a sudden loss of vehicle stability and control, and increasing the risk of a crash.
Remedy: Dealers will replace the affected suspension nuts and bolts. Dealers will also inspect surrounding components for damage, and replace any damaged parts as necessary. Repairs will be performed free of charge. Owner notification letters were mailed May 7, 2021. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AMA3.
Additional source detail variants (2)
Suspension:critical Fasteners
Porsche Cars North America, Inc. (Porsche) is recalling certain 2021 Porsche Taycan Turbo, Taycan Turbo S, Taycan, Taycan 4S, 911 Turbo S Coupe, Cayman, Cayman T, Cayman S, Cayman GT4, 911 Carrera Coupe, 911 Carrera S Coupe, 911 Carrera 4S Coupe, 911 Carrera 4S Targa, 911 Carrera Cabriolet, 911 Carrera S Cabriolet, 911 Carrera 4S Targa Heritage Design Edition, 911 Carrera 4S Cabriolet, 911 Turbo Coupe, 911 Turbo Cabriolet, 911 Turbo S Cabriolet, 718 Spyder, and Boxster vehicles. Certain suspension components may not have been tightened correctly and can loosen.
Consequence: Loose suspension components may detach, causing a sudden loss of vehicle stability and control, and increasing the risk of a crash.
Remedy: Dealers will replace the affected suspension nuts and bolts. Dealers will also inspect surrounding components for damage, and replace any damaged parts as necessary. Repairs will be performed free of charge. Owner notification letters were mailed May 7, 2021. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AMA3.
Suspension
Porsche Cars North America, Inc. (Porsche) is recalling certain 2021 Porsche Taycan Turbo, Taycan Turbo S, Taycan, Taycan 4S, 911 Turbo S Coupe, Cayman, Cayman T, Cayman S, Cayman GT4, 911 Carrera Coupe, 911 Carrera S Coupe, 911 Carrera 4S Coupe, 911 Carrera 4S Targa, 911 Carrera Cabriolet, 911 Carrera S Cabriolet, 911 Carrera 4S Targa Heritage Design Edition, 911 Carrera 4S Cabriolet, 911 Turbo Coupe, 911 Turbo Cabriolet, 911 Turbo S Cabriolet, 718 Spyder, and Boxster vehicles. Certain suspension components may not have been tightened correctly and can loosen.
Consequence: Loose suspension components may detach, causing a sudden loss of vehicle stability and control, and increasing the risk of a crash.
Remedy: Dealers will replace the affected suspension nuts and bolts. Dealers will also inspect surrounding components for damage, and replace any damaged parts as necessary. Repairs will be performed free of charge. Owner notification letters were mailed May 7, 2021. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AMA3.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE21013 · Loss Of Motive Power
Opened May 17, 2021 · Closed Dec 23, 2021
Status: closed (inferred from source dates) · Electrical System; Electrical System:propulsion System
In May 2021, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) of complaints received alleging a loss of motive power while in motion at any speed with no prior warning to the driver in the 2020-2021 model year (MY) Porsche Taycan electric vehicles. ODI had received 9 Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged that a loss of motive power occurred without warning and error messages about a battery fault displayed during or after the vehicle stalled.In the subject vehicles, a pulse-controlled inverter is mounted on each of the two drive modules on the front and rear axles. The software designed to continuously monitor end-to-end communication between the safety-related electronic control units (ECUs) in the vehicle can, in certain instances, incorrectly and sporadically detect a potentially faulty communication, set an error memory entry, and trigger a shutdown of the power train, resulting in loss of motive power. If this occurs, the affected vehicles display the warning message ?Motor control error. Stop vehicle in a safe place in the instrument cluster.Porsche has corrected the software malfunction in production. Further, Porsche is conducting a safety recall (21V-486) to upgrade the software on vehicles already in the field. In view of the recall action, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above can be reviewed online at nhtsa.gov under the following identification numbers: 11435775, 11433960, 11431568, 11429897, 11427688, 11426921, 11426902, 11424618, 11424613, 11424296, 11424175, 11424015, 11423458, 11423311, 11422549, 11422463, 11421593, 11421575, 11421494, 11421347, 11420845, 11420788, 11420734, 11420572, 11419756, 11419735, 11419730, 11419721, 11419422, 11418975, 11418935, 11418793, 11418705, 11418692, 11418593, 11418476, 11418405, 11418381, 11418245, 11418237, 11418153, 11418142, 11418132, 11418106, 11415110, 11414731, 11414486, 11404336, 11386164, 11383427, 11377898, 11377875, 11364083
Additional source detail variants (2)
Electrical System
In May 2021, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) of complaints received alleging a loss of motive power while in motion at any speed with no prior warning to the driver in the 2020-2021 model year (MY) Porsche Taycan electric vehicles. ODI had received 9 Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged that a loss of motive power occurred without warning and error messages about a battery fault displayed during or after the vehicle stalled.In the subject vehicles, a pulse-controlled inverter is mounted on each of the two drive modules on the front and rear axles. The software designed to continuously monitor end-to-end communication between the safety-related electronic control units (ECUs) in the vehicle can, in certain instances, incorrectly and sporadically detect a potentially faulty communication, set an error memory entry, and trigger a shutdown of the power train, resulting in loss of motive power. If this occurs, the affected vehicles display the warning message ?Motor control error. Stop vehicle in a safe place in the instrument cluster.Porsche has corrected the software malfunction in production. Further, Porsche is conducting a safety recall (21V-486) to upgrade the software on vehicles already in the field. In view of the recall action, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above can be reviewed online at nhtsa.gov under the following identification numbers: 11435775, 11433960, 11431568, 11429897, 11427688, 11426921, 11426902, 11424618, 11424613, 11424296, 11424175, 11424015, 11423458, 11423311, 11422549, 11422463, 11421593, 11421575, 11421494, 11421347, 11420845, 11420788, 11420734, 11420572, 11419756, 11419735, 11419730, 11419721, 11419422, 11418975, 11418935, 11418793, 11418705, 11418692, 11418593, 11418476, 11418405, 11418381, 11418245, 11418237, 11418153, 11418142, 11418132, 11418106, 11415110, 11414731, 11414486, 11404336, 11386164, 11383427, 11377898, 11377875, 11364083
Electrical System:propulsion System
In May 2021, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) of complaints received alleging a loss of motive power while in motion at any speed with no prior warning to the driver in the 2020-2021 model year (MY) Porsche Taycan electric vehicles. ODI had received 9 Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged that a loss of motive power occurred without warning and error messages about a battery fault displayed during or after the vehicle stalled.In the subject vehicles, a pulse-controlled inverter is mounted on each of the two drive modules on the front and rear axles. The software designed to continuously monitor end-to-end communication between the safety-related electronic control units (ECUs) in the vehicle can, in certain instances, incorrectly and sporadically detect a potentially faulty communication, set an error memory entry, and trigger a shutdown of the power train, resulting in loss of motive power. If this occurs, the affected vehicles display the warning message ?Motor control error. Stop vehicle in a safe place in the instrument cluster.Porsche has corrected the software malfunction in production. Further, Porsche is conducting a safety recall (21V-486) to upgrade the software on vehicles already in the field. In view of the recall action, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above can be reviewed online at nhtsa.gov under the following identification numbers: 11435775, 11433960, 11431568, 11429897, 11427688, 11426921, 11426902, 11424618, 11424613, 11424296, 11424175, 11424015, 11423458, 11423311, 11422549, 11422463, 11421593, 11421575, 11421494, 11421347, 11420845, 11420788, 11420734, 11420572, 11419756, 11419735, 11419730, 11419721, 11419422, 11418975, 11418935, 11418793, 11418705, 11418692, 11418593, 11418476, 11418405, 11418381, 11418245, 11418237, 11418153, 11418142, 11418132, 11418106, 11415110, 11414731, 11414486, 11404336, 11386164, 11383427, 11377898, 11377875, 11364083
Illustration