NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
11 reportsClear category filter85,416 miles · Feb 2, 2012
Engine And Engine Cooling
PORSCHE KNOWINGLY MANUFACTURED CAYENNE MODEL VEHICLES WITH PLASTIC COOLANT TUBES THAT DEGRADE AND FRACTURE CAUSING ENGINE COOLANT TO LEAK INTO THE ENGINE, POTENTIALLY LEADING TO SIGNIFICANT ENGINE DAMAGE. PORSCHE HAS KNOWN ABOUT THIS DEFECT AND FAILED TO MAKE CONSUMERS AWARE OF THE POTENTIAL FAILURE DESPITE THE RISK TO THE OWNER…
Read full complaint
PORSCHE KNOWINGLY MANUFACTURED CAYENNE MODEL VEHICLES WITH PLASTIC COOLANT TUBES THAT DEGRADE AND FRACTURE CAUSING ENGINE COOLANT TO LEAK INTO THE ENGINE, POTENTIALLY LEADING TO SIGNIFICANT ENGINE DAMAGE. PORSCHE HAS KNOWN ABOUT THIS DEFECT AND FAILED TO MAKE CONSUMERS AWARE OF THE POTENTIAL FAILURE DESPITE THE RISK TO THE OWNERS SAFETY AND POCKETBOOK. *KB
NHTSA ODI #10446282
54,500 miles · Jul 19, 2011
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2004 PORSCHE CAYENNE S. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, AN OVERHEATING INDICATOR LIGHT BEGAN TO ILLUMINATE ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN DIRECTLY TO AN INDEPENDENT REPAIR SHOP WHERE ENGINE COOLANT WAS ADDED TO THE VEHICLE. WHILE ADDING THE COOLANT, THE TECHNICIA…
Read full complaint
TL* THE CONTACT OWNS A 2004 PORSCHE CAYENNE S. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, AN OVERHEATING INDICATOR LIGHT BEGAN TO ILLUMINATE ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN DIRECTLY TO AN INDEPENDENT REPAIR SHOP WHERE ENGINE COOLANT WAS ADDED TO THE VEHICLE. WHILE ADDING THE COOLANT, THE TECHNICIANS NOTICED THAT THE COOLANT WAS LEAKING OUT THROUGH ITS PLASTIC TUBING. THE VEHICLE WAS THEN TOWED TO AN AUTHORIZED DEALER WHERE THE PLASTIC TUBING FOR THE ENGINE COOLANT WAS BEING REPLACED WITH ALUMINUM TUBING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 54,500.
NHTSA ODI #10413499
98,000 miles · May 18, 2011
Engine And Engine Cooling
COOLANT PIPE START TO FAIL FOR THE MODEL YEAR 2004-2006. THE MATERIAL FOR COOLANT PIPE WAS MADE OF PLASTIC AND IT RESULTED IN A DISINTEGRATION OF PIPE OVERTIME DUE TO TEMPERATURE CHANGES. PORSCHE TECHNICIANS IDENTIFIED THIS ISSUE AND PORSCHE ENGINEERS ALSO IDENTIFIED THIS ISSUE. THEY CAME UP WITH A REPLACEMENT PART WHICH IS M…
Read full complaint
COOLANT PIPE START TO FAIL FOR THE MODEL YEAR 2004-2006. THE MATERIAL FOR COOLANT PIPE WAS MADE OF PLASTIC AND IT RESULTED IN A DISINTEGRATION OF PIPE OVERTIME DUE TO TEMPERATURE CHANGES. PORSCHE TECHNICIANS IDENTIFIED THIS ISSUE AND PORSCHE ENGINEERS ALSO IDENTIFIED THIS ISSUE. THEY CAME UP WITH A REPLACEMENT PART WHICH IS MADE OF ALUMINUM TO MITIGATE DAMAGES TO THE ENGINE DUE TO SUDDEN FAILURE OF COOLANT PIPE. IF THE PIPE BUSTED, IT WILL CAUSE THE VEHICLE TO FAIL DURING OPERATION AND MAY RESULT IN A HAZARDOUS INCIDENT CAUSING ENVIRONMENTAL ISSUE AND POSSIBLY INJURY TO THE DRIVER AND ITS PASSENGER. IT IS HIGHLY RECOMMEND THAT PORSCHE TO RECALL THIS PRODUCT AND REPLACE IT FOR ALL DEFECT TO PREVENT FURTHER INCIDENT. ADDITIONALLY, THIS IS AN ENGINEERING FLAW SO THE COST TO REPAIR, REPLACE OR TO UPGRADE CANNOT BE THE OWNER RESPONSIBILITY. *TR
NHTSA ODI #10401458
32,419 miles · Jan 31, 2011
Engine And Engine Cooling
WATER PUMP FAILURE. ORIGINAL PART HAS PLASTIC IMPELLER AND HIGH FAILURE RATE DEALER WII REPLACE WITH UPGRADED PART BUT NO REEMBURSEMENT. *TR
NHTSA ODI #10379711
32,492 miles · Jan 31, 2011
Engine And Engine Cooling
ORIGINAL ENGINE COOLING TUBES DEFECTIVE, PLASTIC COMPOSITION.CAN FAIL WITHOUT INDICATION CAUSING OVERHEATED ENGINE AT ANY TIME. REPLACEMENT PARTS ARE UPGRADED TO METAL. NO RECALL AND MAKER WILL NOT REEMBURSE DAMAGE OR REPAIR. *TR
NHTSA ODI #10379708
77,000 miles · Nov 27, 2010
Engine And Engine Cooling
THE PORSCHE CAYENNE (AND OTHER PORSCHE MODELS) HAVE A COOLANT LEAK PROBLEM. MY VEHICLE'S "LOW COOLANT LEVEL" LIGHT CAME ON. I CHECKED THE COOLANT LEVEL AND FOUND IT TO BE SEVERELY LOW. THE PORSCHE DEALER SERVICE (AND ON-LINE FORUMS) REPORT THAT PORSCHE CAYENNE ENGINES ARE ENCOUNTERING A COOLANT LEAK PROBLEM THAT APPEARS TO AFFEC…
Read full complaint
THE PORSCHE CAYENNE (AND OTHER PORSCHE MODELS) HAVE A COOLANT LEAK PROBLEM. MY VEHICLE'S "LOW COOLANT LEVEL" LIGHT CAME ON. I CHECKED THE COOLANT LEVEL AND FOUND IT TO BE SEVERELY LOW. THE PORSCHE DEALER SERVICE (AND ON-LINE FORUMS) REPORT THAT PORSCHE CAYENNE ENGINES ARE ENCOUNTERING A COOLANT LEAK PROBLEM THAT APPEARS TO AFFECT ALL CAYENNE S, CAYENNE TURBO AND CAYENNE TURBO S ENGINES BUILT FROM 2003 TO 2006 (MY VEHICLE IS A 2004 MODEL). THE COOLANT LEAK PROBLEM IS LOCATED IN THE PLASTIC COOLANT PIPES LOCATED UNDER THE INTAKE MANIFOLD OF THE ENGINE. ACCORDING TO THE PORSCHE DEALER, THIS IS A COMMON PROBLEM DUE TO THE PLASTIC MATERIAL USED BY PORSCHE (WHICH HAS SINCE BEEN CHANGED TO A METAL MATERIAL) AND THE PLASTIC FITTINGS. THE LACK OF COOLANT CAN CAUSE THE ENGINE TO OVERHEAT, OR EVEN BLOW AN ENGINE, WHICH CAN BE EXTREMELY DANGEROUS IF THIS OCCURS WHILE DRIVING. IN ORDER TO CORRECT THE PROBLEM, PORSCHE SERVICE SAYS THAT THE COOLANT PIPES MUST BE REPLACED, WHICH IS A VERY LABOR AND PARTS INTENSIVE SERVICE COSTING WELL OVER $1,000. *TR
NHTSA ODI #10367939
77,059 miles · Feb 1, 2010
Electrical SystemEngine And Engine CoolingExterior Lighting
**UNCONTROLLED ACCELERATION** CAYENNE S ACCELERATED UNCONTROLLABLY WHILE DRIVING. WHILE DRIVING AT APPROX 60 MPH, I ENCOUNTERED TRAFFIC AHEAD AND TOOK MY FOOT OFF THE ACCELERATOR, HOWEVER THE CAR BEGAN ACCELERATING. I TRIED LIFTING THE PEDAL WITH MY FOOT, NO LUCK, APPLIED THE BRAKES AND THE CAR SLOWED, HOWEVER, WHEN I REMOVED…
Read full complaint
**UNCONTROLLED ACCELERATION** CAYENNE S ACCELERATED UNCONTROLLABLY WHILE DRIVING. WHILE DRIVING AT APPROX 60 MPH, I ENCOUNTERED TRAFFIC AHEAD AND TOOK MY FOOT OFF THE ACCELERATOR, HOWEVER THE CAR BEGAN ACCELERATING. I TRIED LIFTING THE PEDAL WITH MY FOOT, NO LUCK, APPLIED THE BRAKES AND THE CAR SLOWED, HOWEVER, WHEN I REMOVED MY FOOT FROM THE BRAKE, THE CAYENNE CONTINUED TO ACCELERATE. THE CRUISE CONTROL HAD NOT BEEN ACTIVATED AND WAS OFF. I KEPT PRESSING THE GAS PEDAL AND RELEASING IT AT LEAST A DOZEN TIMES AND FINALLY THE CAYENNE STOPPED ACCELERATING ON ITS OWN, ONLY TO LOSE ANY CONTROL TO ACCELERATE. I COASTED INTO A PARKING LOT AND STOPPED THE CAR. TURNED IT OFF AND RESTARTED - I WAS ABLE TO DRIVE, HOWEVER ACCELERATION WAS VERY SLOW AND GEAR INDICATOR ON THE DASH CLUSTER DISPLAYED A BLACK 'D' IN AN ORANGE SQUARE. THIS IS A SYMBOL THAT DOES NOT EXIST IN THE OWNERS MANUAL. THE CAR SHIFTED THROUGH GEARS NORMALLY. THE RAPID UNCONTROLLED ACCELERATION REPEATED ITSELF AND I WAS ABLE TO PULL INTO ANOTHER PARKING LOT, SLOWING AND STOPPING THE CAR THANKSTO MASSIVE 14" FRONT BRAKES WITH 6 PISTON CALIPERS AND 13"+ REAR BRAKES WITH 4 PISTON CALIPERS. I TURNED THE CAR OFF FOR A FEW MINUTES AND RESTARTED. GEAR SELECTION INDICATOR APPEARED NORMAL AND I WAS ABLE TO DRIVE OFF, HOWEVER ACCELERATION WAS STILL VERYSLOW. DROVE HOME WITH THE RAPID ACCELERATION REPEATING ITSELF AGAIN AND THEN STOPPING AFTER A FEW MILES. THE ONLY REASON THIS DID NOT CAUSE A CRASH IS THE MASSIVE BRAKING POWER OF THE CAYENNE AND ASTUTE DRIVING. I RAN DIAGNOSTIC SOFTWARE WHEN I MADE IT HOME AND THERE WAS AN "ACCELERATOR MODULE" FAILURE REPORTED. THE TAIL LIGHTS, ALARM, CENTRAL LOCKING, AND THE ABILITY TO OPEN THE TAILGATE AT ALL HAVE ALSO FAILED - "REAR LIGHTING CONTROL MODULE" FAILURE. SO WHILE DRIVING, MY TAIL LIGHTS FAILED, CAR ACCELERATED UNCONTROLLABLY AND FAILED TO ACCELERATE IN A SAFE NORMAL MANNER. THIS IS A MAJOR SAFETY ISSUE AND SHOULD BE PROMPTLY ADDRESSED! *TR
NHTSA ODI #10303704
6,000 miles · Jul 21, 2006
Engine And Engine Cooling
DT*: THE CONTACT STATED THE VEHICLE PERFORMS AS IF IT WILL STALL WHILE ACCELERATING IN TRAFFIC. THE VEHICLE HAS NEVER ACTUALLY STALLED, BUT HESITATES DURING ACCELERATION. THE HESITATION OCCURS MOSTLY WHEN VEHICLE IS MAKING TURNS. THIS IS A RECURRING INCIDENT WHICH OCCURS DAILY.
NHTSA ODI #10163129
8,200 miles · Nov 23, 2005
Engine And Engine Cooling
PORSCHE-04 CAYENNE ON OCCASIONS STALLS ON TURNING AND TOUCHING BRAKE AND TWICE ON THE FREEWAY GOING STRAIGHT BUT BRAKING AND PUSHING ON THROTTLE NO POWER FOR A FEW SECONDS. *JB
NHTSA ODI #10143572
19,000 miles · Oct 20, 2005
Air BagsEngine And Engine Cooling
DT: THE AIR BAG AND THE CHECK LIGHTS CAME ON. THE CONSUMER CONTACTED THE DEALER AND THEY SAID THEY COULD NOT SERVICE THE CAR UNTIL 10/17/2005. CALLED PORSCHE CUSTOMER SERVICE, AND THEY SAID THEY COULD HELP. THE CONSUMER BELIEVED THIS WAS A SAFETY HAZARD, AND HE DID NOT WANT TO DRIVE THE CAR.*AK *JB
NHTSA ODI #10137463
Official recalls
9Aug 30, 2022
Porsche Cars North America, Inc. (Porsche) is recalling certain 2003-2020 Porsche Macan, Cayenne, Panamera, and Cayman S, 2001-2004 Boxster, Boxster S, 2004 Boxster 50 JAHRE SPYDER 550 vehicles. Please see the recall report for a complete list of all affected models and model years. The caps that cover the low-beam headlight horizontal adjustment screws are missing, which can allow the headlights to be improperly adjusted. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Improperly adjusted headlights may not illuminate the road properly, or cause a glare to oncoming drivers, which can increase the risk of a crash.
Remedy: Dealers will inspect the headlights for sealing caps and install missing caps as necessary, free of charge. Owner notification letters were mailed October 28, 2022. Owners may contact Porsche's customer service at 1-800-767-7243. Porsche's number for this recall is ANB4.
Jun 12, 2019
Porsche Cars North America, Inc. (Porsche) is recalling certain 2003-2006 Cayenne S, Cayenne Turbo, 2004-2010 Cayenne, 2006 Cayenne Turbo S, 2010-2016 Panamera S, Panamera 4 S, Panamera Turbo, 2011-2016 Panamera, Panamera 4, 2012-2013 Panamera Turbo S, 2013-2016 Panamera 4 GTS, 2014-2016 Panamera 4 S Executive, Panamera Turbo Executive, Panamera Turbo S G1 II, Panamera Turbo S Executive, 2013 Panamera 4 Platinum Edition, Panamera Platinum Edition, 2016 Panamera 4 Edition, Panamera Edition, Panamera Turbo S Executive Luxury Sports vehicles. The bushing that attaches the gear selector lever to the gearbox may degrade over time, causing the bushing to detach. This condition could allow the driver to move the shift lever to Park and remove the ignition key, while the transmission may not be in Park, with no warning message or audible chime.
Consequence & remedy
Consequence: If the vehicle is exited without the transmission being in Park and without the parking brake being applied, the vehicle may unexpectedly move, increasing the risk of a crash.
Remedy: Porsche will notify owners, and dealers will replace the shifter cable bushing, free of charge. Owners are instructed to use the parking brake until their vehicle is repaired. The recall began August 9, 2019. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AKB1.
Sep 20, 2017
Porsche Cars North America, Inc. (Porsche) is recalling certain 2003-2006 Cayenne S and Cayenne Turbo vehicles, 2004-2006 Cayenne vehicles, and 2006 Cayenne S "Titanium" Edition vehicles. These gasoline-powered vehicles have a fuel pump flange that may crack, allowing fuel to leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Porsche will notify owners, and dealers will replace the fuel filter flanges with new filter flanges that have a protective film, free of charge. The recall began July 6, 2018. Owners may contact Porsche customer service at 1-800-767-7243. Porsche's number for this recall is AH10.
Dec 15, 2004
CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." ALL THREE REAR SEAT POSITIONS AND THE FRONT PASSENGER POSITION ARE EQUIPPED WITH SEAT BELT RETRACTORS THAT HAVE A LOCKING FEATURE WHICH CONVERTS THE RETRACTOR FROM AN EMERGENCY LOCKING RETRACTOR (ELR) MODE TO AN AUTOMATIC LOCKING RETRACTOR (ALR) MODE FOR THE PURPOSES OF CHILD RESTRAINT INSTALLATION. THE BELT MAY DEACTIVATE THE ALR MODE WITH CERTAIN CHILD RESTRAINTS.
Consequence & remedy
Consequence: WHEN INVOLVED IN A CRASH, THE CHILD RESTRAINTS MAY NOT BE PROPERLY SECURED INCREASING THE RISK OF INJURY OR DEATH TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL PERMANENTLY INSTALL A CLIP IN EITHER OF THE AFFECTED REAR OUTBOARD SEAT BELTS AND PROVIDE AN OWNER'S MANUAL INSERT. THE CLIPS WILL PREVENT UNWARRANTED CONVERSION FROM ALR TO ELR MODE WITH CHILD SEAT INSTALLATION. THE RECALL BEGAN MAY 17, 2005. OWNERS SHOULD CONTACT PORSCHE AT 1-800-545-8039.
May 17, 2004
ON CERTAIN PASSENGER VEHICLES, THE REAR SEAT BELT LATCH ATTACHMENT BOLT IS INSUFFICIENT RIVETED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSPECT THE BELT BUCKLE LATCH AND, IF NECESSARY, REPLACE THE LATCH. OWNER NOTIFICATION BEGAN ON JUNE 1, 2004. OWNERS SHOULD CONTACT PORSCHE AT 1-800-545-8039.
Feb 18, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE MAIN WIRING HARNESS WAS INCORRECTLY ROUTED. DAMAGE TO THE MAIN WIRING HARNESS CAN LEAD TO THE FAILURE OF VARIOUS ELECTRICAL SYSTEMS.
Consequence & remedy
Consequence: IN EXTREME CASES, TO A CABLE FIRE BENEATH THE INSTRUMENT PANEL IN THE PASSENGER COMPARTMENT.
Remedy: DEALERS WILL RE-ROUTE THE WIRING HARNESS. OWNER NOTIFICATION SCHEDULE BEGAN ON MARCH 29, 2004. OWNERS SHOULD CONTACT PORSCHE AT 1-800-545-8039.
Feb 18, 2004
CERTAIN SPORT UTILITY VEHICLES MAY HAVE HAD A TRANSFER CASE INSTALLED THAT COULD, DUE TO CHANGES IN THE HOUSING CASTING, RESULT IN THE OIL PUMP ROTATION. SHOULD THIS OCCUR, OIL STARVATION OF THE INTERNAL GEARS MIGHT RESULT.
Consequence & remedy
Consequence: CONTINUED OPERATION OF THE VEHICLE COULD RESULT IN A FRACTURE OF THE TRANSFER CASE HOUSING. INCORRECT TORQUE WOULD THEN BE APPLIED TO THE DRIVEN WHEELS OR OIL COULD LEAK AND CONTACT THE TIRES.
Remedy: DEALERS WILL INSPECT THE TRANSFER CASE HOUSING AND, IF NECESSARY, REPLACE THE TRANSFER CASE. OWNER NOTIFICATION BEGAN ON MAY 3, 2004. OWNERS SHOULD CONTACT PORSCHE AT 1-800-545-8039.
Feb 18, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE DRIVER'S SIDE SEAT FRAMES WERE NOT ADEQUATELY WELDED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT FRAME COULD BREAK, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE DRIVER'S SIDE SEAT FRAME. OWNER NOTIFICATION BEGAN ON MARCH 29, 2004. OWNERS SHOULD CONTACT PORSCHE AT 1-800-545-8039.
Sep 24, 2003
ON CERTAIN SPORT UTILITY VEHICLES, THE AFFECTED VEHICLES MAY BE MISSING THE GROSS VEHICLE WEIGHT RATING (GVWR) AND GROSS AXLE WEIGHT RATINGS (GAWR) ON THE CERTIFICATION LABEL AS REQUIRED BY PART 567.4(G)(3) AND (G)(4).
Consequence & remedy
Consequence: THE VEHICLE OPERATOR WILL NOT BE INFORMED OF THE VEHICLE'S GVWR AND GAWR.
Remedy: DEALERS WILL APPLY THE CORRECTED LABEL. OWNER NOTIFICATION BEGAN ON DECEMBER 22, 2003. OWNERS SHOULD CONTACT PORSCHE AT 1-800-545-8039.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA06005 · Srs Warning Light Illumination
Opened Mar 15, 2006 · Closed Mar 12, 2007
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Air Bags:side/window
PORSCHE IS INITIATING A CUSTOMER NOTIFICATION ACTION TO ADDRESS A CONDITION RELATED TO A FAULTY OR LOOSE CONNECTOR IN THE SIDE AIRBAG SYSTEM.PORSCHE'S TESTING HAS SHOWN THAT THE FAULTY CONNECTOR WILL NOT PREVENT SIDE AIRBAG DEPLOYMENT.THE FAULTY CONNECTOR WILL CAUSE THE CIRCUIT RESISTANCE TO EXCEED THE THRESHOLD FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT.PORSCHE HAS REPORTED A LARGE NUMBER OF WARRANTY CLAIMS FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT AND MANY VEHICLES HAVE BEEN SERVICED TO CORRECT THIS CONDITION AS DESCRIBED IN THE CAYENNE TECHNICAL INFORMATION BULLETIN: GROUP 6, #11/04 AIRBAG WARNING LIGHT ACTIVATED.PORSCHE WILL PERFORM THIS SERVICE TO ALL REMAINING UNCORRECTED VEHICLES UNDER A NEW PRODUCT IMPROVEMENT CAMPAIGN STARTING AT THE END OF APRIL 2007.ALL OWNERS OF A SUBJECT VEHICLE BUILT THROUGH NOVEMBER 2004 WILL BE NOTIFIED BY PORSCHE TO BRING THE VEHICLE TO A DEALER TO RECEIVE THE FREE MODIFICATION.VEHICLES BUILT AFTER NOVEMBER 2004 DO NOT CONTAIN THE SUBJECT CONNECTOR.IN ADDITION, PORSCHE REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN NOVEMBER AND DECEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIRBAG MODULE.THIS MAY ALSO PRODUCEILLUMINATION OF THE AIRBAG WARNING LIGHT THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.PORSCHE HAS NOT RECEIVED ANY REPORT OF NON-DEPLOYMENT OF THE SIDE AIRBAG.THE ACTION TAKEN BY PORSCHE IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Air Bags:frontal:sensor/control MODULE-INACTIVE
PORSCHE IS INITIATING A CUSTOMER NOTIFICATION ACTION TO ADDRESS A CONDITION RELATED TO A FAULTY OR LOOSE CONNECTOR IN THE SIDE AIRBAG SYSTEM.PORSCHE'S TESTING HAS SHOWN THAT THE FAULTY CONNECTOR WILL NOT PREVENT SIDE AIRBAG DEPLOYMENT.THE FAULTY CONNECTOR WILL CAUSE THE CIRCUIT RESISTANCE TO EXCEED THE THRESHOLD FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT.PORSCHE HAS REPORTED A LARGE NUMBER OF WARRANTY CLAIMS FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT AND MANY VEHICLES HAVE BEEN SERVICED TO CORRECT THIS CONDITION AS DESCRIBED IN THE CAYENNE TECHNICAL INFORMATION BULLETIN: GROUP 6, #11/04 AIRBAG WARNING LIGHT ACTIVATED.PORSCHE WILL PERFORM THIS SERVICE TO ALL REMAINING UNCORRECTED VEHICLES UNDER A NEW PRODUCT IMPROVEMENT CAMPAIGN STARTING AT THE END OF APRIL 2007.ALL OWNERS OF A SUBJECT VEHICLE BUILT THROUGH NOVEMBER 2004 WILL BE NOTIFIED BY PORSCHE TO BRING THE VEHICLE TO A DEALER TO RECEIVE THE FREE MODIFICATION.VEHICLES BUILT AFTER NOVEMBER 2004 DO NOT CONTAIN THE SUBJECT CONNECTOR.IN ADDITION, PORSCHE REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN NOVEMBER AND DECEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIRBAG MODULE.THIS MAY ALSO PRODUCEILLUMINATION OF THE AIRBAG WARNING LIGHT THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.PORSCHE HAS NOT RECEIVED ANY REPORT OF NON-DEPLOYMENT OF THE SIDE AIRBAG.THE ACTION TAKEN BY PORSCHE IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Air Bags
PORSCHE IS INITIATING A CUSTOMER NOTIFICATION ACTION TO ADDRESS A CONDITION RELATED TO A FAULTY OR LOOSE CONNECTOR IN THE SIDE AIRBAG SYSTEM.PORSCHE'S TESTING HAS SHOWN THAT THE FAULTY CONNECTOR WILL NOT PREVENT SIDE AIRBAG DEPLOYMENT.THE FAULTY CONNECTOR WILL CAUSE THE CIRCUIT RESISTANCE TO EXCEED THE THRESHOLD FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT.PORSCHE HAS REPORTED A LARGE NUMBER OF WARRANTY CLAIMS FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT AND MANY VEHICLES HAVE BEEN SERVICED TO CORRECT THIS CONDITION AS DESCRIBED IN THE CAYENNE TECHNICAL INFORMATION BULLETIN: GROUP 6, #11/04 AIRBAG WARNING LIGHT ACTIVATED.PORSCHE WILL PERFORM THIS SERVICE TO ALL REMAINING UNCORRECTED VEHICLES UNDER A NEW PRODUCT IMPROVEMENT CAMPAIGN STARTING AT THE END OF APRIL 2007.ALL OWNERS OF A SUBJECT VEHICLE BUILT THROUGH NOVEMBER 2004 WILL BE NOTIFIED BY PORSCHE TO BRING THE VEHICLE TO A DEALER TO RECEIVE THE FREE MODIFICATION.VEHICLES BUILT AFTER NOVEMBER 2004 DO NOT CONTAIN THE SUBJECT CONNECTOR.IN ADDITION, PORSCHE REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN NOVEMBER AND DECEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIRBAG MODULE.THIS MAY ALSO PRODUCEILLUMINATION OF THE AIRBAG WARNING LIGHT THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.PORSCHE HAS NOT RECEIVED ANY REPORT OF NON-DEPLOYMENT OF THE SIDE AIRBAG.THE ACTION TAKEN BY PORSCHE IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Air Bags:side/window
PORSCHE IS INITIATING A CUSTOMER NOTIFICATION ACTION TO ADDRESS A CONDITION RELATED TO A FAULTY OR LOOSE CONNECTOR IN THE SIDE AIRBAG SYSTEM.PORSCHE'S TESTING HAS SHOWN THAT THE FAULTY CONNECTOR WILL NOT PREVENT SIDE AIRBAG DEPLOYMENT.THE FAULTY CONNECTOR WILL CAUSE THE CIRCUIT RESISTANCE TO EXCEED THE THRESHOLD FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT.PORSCHE HAS REPORTED A LARGE NUMBER OF WARRANTY CLAIMS FOR ILLUMINATION OF THE AIR BAG WARNING LIGHT AND MANY VEHICLES HAVE BEEN SERVICED TO CORRECT THIS CONDITION AS DESCRIBED IN THE CAYENNE TECHNICAL INFORMATION BULLETIN: GROUP 6, #11/04 AIRBAG WARNING LIGHT ACTIVATED.PORSCHE WILL PERFORM THIS SERVICE TO ALL REMAINING UNCORRECTED VEHICLES UNDER A NEW PRODUCT IMPROVEMENT CAMPAIGN STARTING AT THE END OF APRIL 2007.ALL OWNERS OF A SUBJECT VEHICLE BUILT THROUGH NOVEMBER 2004 WILL BE NOTIFIED BY PORSCHE TO BRING THE VEHICLE TO A DEALER TO RECEIVE THE FREE MODIFICATION.VEHICLES BUILT AFTER NOVEMBER 2004 DO NOT CONTAIN THE SUBJECT CONNECTOR.IN ADDITION, PORSCHE REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN NOVEMBER AND DECEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIRBAG MODULE.THIS MAY ALSO PRODUCEILLUMINATION OF THE AIRBAG WARNING LIGHT THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.PORSCHE HAS NOT RECEIVED ANY REPORT OF NON-DEPLOYMENT OF THE SIDE AIRBAG.THE ACTION TAKEN BY PORSCHE IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE05060 · Srs Warning Light Illumination
Opened Nov 10, 2005 · Closed Mar 15, 2006
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Air Bags:side/window
DURING THE PRELIMINARY EVALUATION PHASE, ODI IDENTIFIED 76 OWNER COMPLAINTS AND 6,582 WARRANTY CLAIMS RELATED TO AIRBAG WARNING LIGHT ILLUMINATION FROM EITHER A FAULTY SIDE-IMPACT AIRBAG MODULE OR WIRING HARNESS.TO DATE, THERE HAS BEEN NO ALLEGATION OF CRASH, INJURY OR DEATH REPORTED.PORSCHE REPORTS THAT A BAD BATCH OF MODULES WAS PRODUCED DURING MID-NOVEMBER TO MID-DECEMBER, 2003.HOWEVER, PORSCHE?S WARRANTY DATA INDICATES THAT MOST OF THE MODULES REPLACED UNDER WARRANTY WERE ON VEHICLES BUILT BEFORE AND AFTER THIS PERIOD INDICATING THAT THE ISSUE COULD BE MORE WIDESPREAD.PORSCHE REPORTS THAT THE WIRING HARNESS MALFUNCTION IS DUE TO A FAULTY CONNECTOR LEADING TO THE AIRBAG MODULE AS A RESULT OF ENVIRONMENTAL AND MECHANICAL STRESS.IN JUNE AND NOVEMBER OF 2004, PORSCHE ADDED A PROTECTIVE COAT OF LUBRICANT GEL TO THE CONNECTOR AND REROUTED THE HARNESS TO FIX THE PROBLEM ON ALL FUTURE PRODUCTION.PORSCHE HAS NOT ISSUED A RECALL CAMPAIGN, BUT IT HAS CIRCULATED TO ITS DEALERS TWO SERVICE BULLETINS, BOTH IN SEPTEMBER 2004 TO ADDRESS THE ABOVE ISSUES.THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA06-005) AND WILL INCLUDE MY 2006 VEHICLES.
Additional source detail variants (3)
Air Bags:frontal:sensor/control MODULE-INACTIVE
DURING THE PRELIMINARY EVALUATION PHASE, ODI IDENTIFIED 76 OWNER COMPLAINTS AND 6,582 WARRANTY CLAIMS RELATED TO AIRBAG WARNING LIGHT ILLUMINATION FROM EITHER A FAULTY SIDE-IMPACT AIRBAG MODULE OR WIRING HARNESS.TO DATE, THERE HAS BEEN NO ALLEGATION OF CRASH, INJURY OR DEATH REPORTED.PORSCHE REPORTS THAT A BAD BATCH OF MODULES WAS PRODUCED DURING MID-NOVEMBER TO MID-DECEMBER, 2003.HOWEVER, PORSCHE?S WARRANTY DATA INDICATES THAT MOST OF THE MODULES REPLACED UNDER WARRANTY WERE ON VEHICLES BUILT BEFORE AND AFTER THIS PERIOD INDICATING THAT THE ISSUE COULD BE MORE WIDESPREAD.PORSCHE REPORTS THAT THE WIRING HARNESS MALFUNCTION IS DUE TO A FAULTY CONNECTOR LEADING TO THE AIRBAG MODULE AS A RESULT OF ENVIRONMENTAL AND MECHANICAL STRESS.IN JUNE AND NOVEMBER OF 2004, PORSCHE ADDED A PROTECTIVE COAT OF LUBRICANT GEL TO THE CONNECTOR AND REROUTED THE HARNESS TO FIX THE PROBLEM ON ALL FUTURE PRODUCTION.PORSCHE HAS NOT ISSUED A RECALL CAMPAIGN, BUT IT HAS CIRCULATED TO ITS DEALERS TWO SERVICE BULLETINS, BOTH IN SEPTEMBER 2004 TO ADDRESS THE ABOVE ISSUES.THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA06-005) AND WILL INCLUDE MY 2006 VEHICLES.
Air Bags
DURING THE PRELIMINARY EVALUATION PHASE, ODI IDENTIFIED 76 OWNER COMPLAINTS AND 6,582 WARRANTY CLAIMS RELATED TO AIRBAG WARNING LIGHT ILLUMINATION FROM EITHER A FAULTY SIDE-IMPACT AIRBAG MODULE OR WIRING HARNESS.TO DATE, THERE HAS BEEN NO ALLEGATION OF CRASH, INJURY OR DEATH REPORTED.PORSCHE REPORTS THAT A BAD BATCH OF MODULES WAS PRODUCED DURING MID-NOVEMBER TO MID-DECEMBER, 2003.HOWEVER, PORSCHE?S WARRANTY DATA INDICATES THAT MOST OF THE MODULES REPLACED UNDER WARRANTY WERE ON VEHICLES BUILT BEFORE AND AFTER THIS PERIOD INDICATING THAT THE ISSUE COULD BE MORE WIDESPREAD.PORSCHE REPORTS THAT THE WIRING HARNESS MALFUNCTION IS DUE TO A FAULTY CONNECTOR LEADING TO THE AIRBAG MODULE AS A RESULT OF ENVIRONMENTAL AND MECHANICAL STRESS.IN JUNE AND NOVEMBER OF 2004, PORSCHE ADDED A PROTECTIVE COAT OF LUBRICANT GEL TO THE CONNECTOR AND REROUTED THE HARNESS TO FIX THE PROBLEM ON ALL FUTURE PRODUCTION.PORSCHE HAS NOT ISSUED A RECALL CAMPAIGN, BUT IT HAS CIRCULATED TO ITS DEALERS TWO SERVICE BULLETINS, BOTH IN SEPTEMBER 2004 TO ADDRESS THE ABOVE ISSUES.THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA06-005) AND WILL INCLUDE MY 2006 VEHICLES.
Air Bags:side/window
DURING THE PRELIMINARY EVALUATION PHASE, ODI IDENTIFIED 76 OWNER COMPLAINTS AND 6,582 WARRANTY CLAIMS RELATED TO AIRBAG WARNING LIGHT ILLUMINATION FROM EITHER A FAULTY SIDE-IMPACT AIRBAG MODULE OR WIRING HARNESS.TO DATE, THERE HAS BEEN NO ALLEGATION OF CRASH, INJURY OR DEATH REPORTED.PORSCHE REPORTS THAT A BAD BATCH OF MODULES WAS PRODUCED DURING MID-NOVEMBER TO MID-DECEMBER, 2003.HOWEVER, PORSCHE?S WARRANTY DATA INDICATES THAT MOST OF THE MODULES REPLACED UNDER WARRANTY WERE ON VEHICLES BUILT BEFORE AND AFTER THIS PERIOD INDICATING THAT THE ISSUE COULD BE MORE WIDESPREAD.PORSCHE REPORTS THAT THE WIRING HARNESS MALFUNCTION IS DUE TO A FAULTY CONNECTOR LEADING TO THE AIRBAG MODULE AS A RESULT OF ENVIRONMENTAL AND MECHANICAL STRESS.IN JUNE AND NOVEMBER OF 2004, PORSCHE ADDED A PROTECTIVE COAT OF LUBRICANT GEL TO THE CONNECTOR AND REROUTED THE HARNESS TO FIX THE PROBLEM ON ALL FUTURE PRODUCTION.PORSCHE HAS NOT ISSUED A RECALL CAMPAIGN, BUT IT HAS CIRCULATED TO ITS DEALERS TWO SERVICE BULLETINS, BOTH IN SEPTEMBER 2004 TO ADDRESS THE ABOVE ISSUES.THIS INVESTIGATION IS BEING UPGRADED TO AN ENGINEERING ANALYSIS (EA06-005) AND WILL INCLUDE MY 2006 VEHICLES.
Illustration