2003 Porsche Boxster S

MY ENGINE FAILED DUE TO A PART CALLED THE INTERMEDIATE SHAFT. THE CAR IS A 2003 PORSCHE, BOXSTER S WITH 47,000. THIS PROBLEM IS WELL DOCUMENTED ON LINE AND APPEARS TO BE A MANUFACTURING PROBLEM. THE DEALERSHIP I WENT TO, KNEW RIGHT AWAY ABOUT THE FAILURE AS THEY SEE AT LEAST 1 PER MONTH. WHEN THIS PART FAILS, THE REMEDY IS A NEW (OR USED ENGINE). THERE IS NO WAY TO KNOW OF THIS FAILURE UNTIL IT HAPPENS. I REPLACED MY ENGINE AND IT COST $12,000. THIS WEBSITE PROVIDES A LOT OF INFORMATION ABOUT THIS PORSCHE PROBLEM AND IT SHOWS SOME OF THE RESEARCH CONDUCTED BY THEIR ENGINEER, HTTP://WWW.LNENGINEERING.COM/IMS.HTML. THEIR RESEARCH INDICATES THAT PORSCHE KNOWS OF THE PROBLEM AND THINKS IT HAS TO DO WITH PARTICULAR VIN NUMBER CARS (ONE OF WHICH IS MINE) AND FIXES IT WHEN IT HAPPENS DURING WARRANTY. I ASKED THEM TO HELP COVER THE COST AND THEY SAID NO, AS MY CAR WAS OUT OF WARRANTY. IT IS MY OPINION THAT A CAR (PORSCHE OR NOT) SHOULD NOT FAIL LIKE THIS ESPECIALLY WITH NO WARNING. AS AN FYI, IT APPEARS PORSCHE FINALLY REDESIGNED THIS PART IN 2006. I HOPE YOU CAN HELP ME CAPTURE SOME OF MY OUT OF POCKET EXPENSE AS WELL AS MAKE OTHER USERS AWARE WITH A POSSIBLE RECALL. *TR

I HAVE A 2003 PORSCHE BOXSTER S WITH 32,000MI ON IT. ON THE 8TH OF MARCH, THE ENGINE FAILED WITH AN INTERMEDIATE SHAFT BEARING FAILURE REQUIRING THE REPLACEMENT OF THE ENGINE. PORSCHE CARS NORTH AMERICA ARE NOT HELPFUL. SUCH A CATASTROPHIC FAILURE OF THE ENGINE IN MY OPINION IS DANGEROUS AND SHOULD BE TAKEN MORE SERIOUSLY BY PCNA CONSIDERING THE NUMBER OF CASES THAT ARE OUT THERE. *TR

ON SATURDAY, MAY 16TH THIS BOXSTER SUFFERED ENGINE FAILURE WHILE TRAVELING AT ~ 30 MPH. THE ENGINE FAILED WITH NO PRIOR WARNING. THE INITIAL INDICATION WAS A LOUD AND DISTRACTING FLAPPING NOISE THAT SOUNDED LIKE SOMETHING HAD BEEN PICKED UP ON THE CAR'S UNDERCARRIAGE. THIS WAS FOLLOWED WITHIN A MOMENT BY SHUTDOWN OF THE ENGINE AND LOSS OF POWER STEERING. WE FEEL FORTUNATE THAT THIS ENGINE FAILED AT RELATIVELY LOW SPEED IN LIGHT TRAFFIC, SO THAT NO ACCIDENT OR INJURIES OCCURRED. HAD THE FAILURE OCCURRED EARLIER IN THE DAY WHILE WE WERE DRIVING AT HIGHWAY SPEED ON CURVING ROADS, WE BELIEVE WE WOULD HAVE BEEN INVOLVED IN A SERIOUS ACCIDENT. PROPERTY DAMAGE WAS LIMITED TO LOSS OF THE ENGINE ITSELF - INSTALLATION OF A REMANUFACTURED ENGINE IS ESTIMATED AT $14,000 TO $15,000. WE PURCHASED THE VEHICLE THIS PAST JANUARY FOR $20,000 SO THAT THIS ENGINE FAILURE REPRESENTS A NEAR TOTAL, UNINSURED LOSS. THE ENGINE FAILURE HAS BEEN DIAGNOSED AS AN INTERMEDIATE ENGINE SHAFT (IMS) FAILURE BY A LOCAL MECHANIC SPECIALIZING IN PORSCHE MAINTENANCE AND REPAIR (THE CLOSEST PORSCHE DEALERSHIP IS OVER 100 MILES AWAY). OUR SUBSEQUENT INTERNET RESEARCH INDICATES THAT IMS FAILURE IS A COMMON PROBLEM FOR PORSCHE AUTOMOBILES WITH THE M96 ENGINE, WITH SOME ESTIMATES THAT GREATER THAN 25% OF THESE VEHICLES WILL SUFFER ENGINE FAILURE PRIOR TO REACHING 100,000 MILES. UNFORTUNATELY, THE TRUE STATISTICS ARE NOT AVAILABLE TO CONSUMERS. PORSCHE HAS NOT ADMITTED THAT THIS FAILURE MODE RESULTS FROM A BEARING DESIGN FLAW, HOWEVER THAT IS THE GENERALLY ACCEPTED ROOT CAUSE. PORSCHE CARS NORTH AMERICA DECLINES TO ASSIST WITH REPAIR. WE RECOMMEND THAT YOU OPEN AN INVESTIGATION INTO THE FAILURE RATE AND SAFETY ASPECTS OF THE PORSCHE M96 ENGINE. WE FURTHER SUGGEST THAT IT IS LIKELY THAT FATAL ACCIDENTS INVOLVING PORSCHES WITH THESE ENGINES HAVE BEEN IMPROPERLY ASSIGNED TO DRIVER ERROR. WE BELIEVE THAT PORSCHE SHOULD BE HELD RESPONSIBLE FOR IMS FAILURES OF M96 ENGINES THROUGH A SAFETY RECALL. *TR

I HAVE HAD MANY PROBLEMS WITH A 2003 BOXSTER S I PURCHASED IN MAY 2003 FROM MCKENNA PORSCHE IN NORWALK, CA. SOME OF THE MAJOR PROBLEMS IN THE LAST 2 YEARS INCLUDE: 1) CONDENSATION IN OIL FILLER AREA; 2) OIL LEAKS IN 2 LOCATIONS; 3) WORN DRIVE BELT; 4) CLUTCH CAUSING GRINDING NOISE; 5) IGINITION SWITCH & KEY DIDN'T WORK; AIR CONDITIONING UNIT DIDN'T COOL; 6) STEREO SYSTEM DIDN'T WORK. MCKENNA HAS REPAIRED/REPLACED ALL ITEMS TO DATE EXCEPT THE CLUTCH. MCKENNA ADVISED CLUCTH PROBLEM IS MY RESPONSIBILITY DUE TO WEAR AND COST IS $1700. THE VEHILCE HAS 19000 MILES. THE INCIDENT DATE BELOW IS DATE I PICKED UP THE VEHILCE FROM MCKENNA. I HAVE HAD PROBLEMS WITH THE VEHICLE STARTING WITH THE FIRST DAY I PICKED UP THE VEHICLE FROM MCKENNA.