SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

2004 Pontiac Sunfire

Owner reports · Recalls · Investigations

Fewer warning signs than most model years

Owner complaints for the 2004 Pontiac Sunfire are lower than the model-year median of 77.

About this comparison →
32Owner complaints

Model-year median: 77

1Recall campaigns

View recall details →

0Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
66
200182
200272
200332
200468
2005
Compare all Sunfire years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Electrical System
16Engine And Engine Cooling
4Engine
3Exterior Lighting
3Structure
3
All reported categories
Service Brakes, Hydraulic
2Unknown Or Other
2Air Bags
1Electronic Stability Control
1Equipment
1Service Brakes
1Steering
1Vehicle Speed Control
1Wheels
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

27 reports with mileage · 5 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine And Engine Cooling. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

3 crash reports1 fire reports1 injury reports

Vehicle Speed Control complaints

1 reports
Clear category filter
112,000 miles · Sep 18, 2014
Electrical SystemEngineVehicle Speed Control

BOUGHT CAR USED IN 2013. EVERYTHING SEEMED TO BE OKAY UNTIL 9/12/14 WHEN THE THEFT SYSTEM SERVICE LIGHT CAME ON AND I NOTICED THE SPEEDOMETER, RPMS, AND GAS INDICATORS WERE NOT READING - CAR BEGAN STALLING LIKE IT WAS GOING TO SHUT DOWN. I WAS TRAVELING ABOUT 50 TO 55 MPH ON A BUSY STREET. AFTER CAR IS SHUT OFF FOR A TIME IT S…

Read full complaint

BOUGHT CAR USED IN 2013. EVERYTHING SEEMED TO BE OKAY UNTIL 9/12/14 WHEN THE THEFT SYSTEM SERVICE LIGHT CAME ON AND I NOTICED THE SPEEDOMETER, RPMS, AND GAS INDICATORS WERE NOT READING - CAR BEGAN STALLING LIKE IT WAS GOING TO SHUT DOWN. I WAS TRAVELING ABOUT 50 TO 55 MPH ON A BUSY STREET. AFTER CAR IS SHUT OFF FOR A TIME IT STARTS UP OKAY AND RUNS UNTIL THE SAME THING REOCCURS AFTER GOING ABOUT 20 MILES OR SO - IF CAR SHUTS DOWN WHILE MOVING IT COULD CAUSE A SERIOUS INJURY OR DEATH. I HAVE READ NUMEROUS COMPLAINTS ABOUT THIS SAME THING ON VARIOUS WEBSITES. APPARENTLY, THE APPROXIMATE COST TO FIX IS $400.00 - I AM ON A LIMITED INCOME AND CANNOT AFFORD. PLEASE HELP. *TR

NHTSA ODI #10637233

Official recalls

1

04V300000 · Seat Belts:rear/other

Jun 23, 2004

CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, 'SEAT BELT ASSEMBLY ANCHORAGES.' THE PASSENGER-SIDE REAR SAFETY BELT MAY HAVE BEEN INSTALLED WITH AN INCORRECT NUT AND BOLT.

Consequence & remedy

Consequence: IN A SEVERE CRASH, THE UPPER SEAT BELT ANCHORAGE MAY SEPARATE. THE EFFECTIVENESS OF THE SEAT BELT COULD THEN BE REDUCED AND THE OCCUPANT COULD RECEIVE GREATER INJURIES.

Remedy: DEALERS ARE TO INSPECT THE SAFETY BELT ANCHORAGE AND INSTALL A NEW NUT AND BOLT, IF NECESSARY. THE RECALL BEGAN ON AUGUST 23, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

0

No exact-year investigations in this snapshot.