IllustrationTHE INNER IGNITION LOCK NEEDS TO BE CHANGED ABOUT EVERY 60,000 MILES. YOU CAN'T TURN THE KEY OVER AT ALL SO OBVIOUSLY YOU CAN'T START YOUR CAR. THIS SHOULD BE A RECALL, ALOT OF OTHER PEOPLE HAVE THE SAME PROBLEM.
2004 Pontiac Sunfire
Owner reports · Recalls · Investigations
Fewer warning signs than most model years
Owner complaints for the 2004 Pontiac Sunfire are lower than the model-year median of 77.
Counts are not adjusted for sales, age, mileage exposure or reporting. A lower count does not establish that a car is problem-free.
About this comparison →32Owner complaints
Model-year median: 77
1Recall campaignsView recall details →
0InvestigationsView investigation details →
Check a VIN with NHTSA ↗ Model-level counts do not show whether a particular VIN is affected or repaired.
Inspection summary
2004 Pontiac Sunfire
NHTSA snapshot: September 18, 2026. 32 owner complaints · 1 recall campaigns · 0 investigations.
Counts are not failure probabilities and are not adjusted for sales, age, mileage exposure or reporting. One report may name several categories. Comparison method and limitations.
Top reported categories (up to 5)
- Electrical System: 16 reports
- Engine And Engine Cooling: 4 reports
- Engine: 3 reports
- Exterior Lighting: 3 reports
- Structure: 3 reports
Full reported-category list and vehicle report
Recall links
Check a VIN with NHTSA. Model-level history does not establish whether a particular VIN is affected or repaired.
Print the top reported categories, recall links, snapshot date and comparison limits.
How this year compares
Owner complaints by model year
Compare all Sunfire years →Counts vary with age, sales, mileage exposure and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
90–25K
525–50K
650–75K
275–100K
4100–150K
1150K+
27 reports with mileage · 5 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports1 fire reports1 injury reports
Unknown Or Other complaints
2 reportsIN JANUARY OF 2006 THE TACHOMETER GAUGE STARTED JUMPING AROUND NOT READING CORRECT, BY CLICKING THE IGNITION ON AND OFF WITH THE CAR NOT RUNNING IT WOULD RE-SET. IN THE FALL OF 2012 THE TEMPERATURE GAUGE STARTED AND CONTINUES TO READ WRONG. APRIL 1ST 2013, NOW THE FUEL GAUGE HAS STARED TURNING COUNTER CLOCKWISE AND NO LONGER WOR…
Read full complaint
IN JANUARY OF 2006 THE TACHOMETER GAUGE STARTED JUMPING AROUND NOT READING CORRECT, BY CLICKING THE IGNITION ON AND OFF WITH THE CAR NOT RUNNING IT WOULD RE-SET. IN THE FALL OF 2012 THE TEMPERATURE GAUGE STARTED AND CONTINUES TO READ WRONG. APRIL 1ST 2013, NOW THE FUEL GAUGE HAS STARED TURNING COUNTER CLOCKWISE AND NO LONGER WORKS.
Recall campaigns
104V300000 · Seat Belts:rear/other
Jun 23, 2004
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, 'SEAT BELT ASSEMBLY ANCHORAGES.' THE PASSENGER-SIDE REAR SAFETY BELT MAY HAVE BEEN INSTALLED WITH AN INCORRECT NUT AND BOLT.
Consequence & remedy
Consequence: IN A SEVERE CRASH, THE UPPER SEAT BELT ANCHORAGE MAY SEPARATE. THE EFFECTIVENESS OF THE SEAT BELT COULD THEN BE REDUCED AND THE OCCUPANT COULD RECEIVE GREATER INJURIES.
Remedy: DEALERS ARE TO INSPECT THE SAFETY BELT ANCHORAGE AND INSTALL A NEW NUT AND BOLT, IF NECESSARY. THE RECALL BEGAN ON AUGUST 23, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Defect investigations
0No exact-year investigations in this snapshot.
An investigation is not a finding of a defect, and closure does not prove a vehicle is problem-free.