TL*THE CONTACT OWNS A 1997 PONTIAC SUNFIRE. AFTER IT RAINED FOR APPROXIMATELY 3-4 DAYS, THE CONTACT NOTICED STANDING WATER IN THE FRONT AND REAR PASSENGER SIDE OF THE VEHICLE. SHE STARTED THE VEHICLE AND NOTICED THAT ALL OF THE INSTRUMENT PANEL LIGHTS WERE ILLUMINATED. AFTER SEVERAL DAYS OF ALLOWING THE VEHICLE TO DRY OUT, EV…
Read full complaint
TL*THE CONTACT OWNS A 1997 PONTIAC SUNFIRE. AFTER IT RAINED FOR APPROXIMATELY 3-4 DAYS, THE CONTACT NOTICED STANDING WATER IN THE FRONT AND REAR PASSENGER SIDE OF THE VEHICLE. SHE STARTED THE VEHICLE AND NOTICED THAT ALL OF THE INSTRUMENT PANEL LIGHTS WERE ILLUMINATED. AFTER SEVERAL DAYS OF ALLOWING THE VEHICLE TO DRY OUT, EVERY INSTRUMENT PANEL LIGHT, WITH THE EXCEPTION OF THE AIR BAG LIGHT, DIMMED. THE DEALER STATED THAT THEY WOULD NOT INSPECT THE VEHICLE FOR LESS THAN $350. THE CONTACT NO LONGER DRIVES THE VEHICLE BECAUSE SHE FEARS FOR HER LIFE DUE TO THE DEFECT. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND CURRENT MILEAGE WAS 70,000. UPDATED 09/13/08. *LJ UPDATED 09/16/08 *JB
NHTSA ODI #10231846
125,500 miles · Feb 20, 2006
Air BagsInjury
I WAS DRIVING DOWN THE ROAD, AND THE PASSENGER AIR BAG DEPLOYED WITHOUT IMPACT OF ANY KIND, OR WARNING. *NM
NHTSA ODI #10150667
11,000 miles · May 2, 2005
Air BagsInjury
THE AIR BAG INADVERTENTLY DEPLOYED WHILE THE CONSUMER WAS DRIVING 5 MPH.
NHTSA ODI #10118824
Mileage unknown · Jun 23, 2004
Air BagsInjury
1997 PONTIAC SUNFIRE AIR BAG DEPLOYMENT.*MR WHILE DRIVING THE VEHICLE WAS INVOLVED IN AN ACCIDENT. THE VEHICLE WAS HIT ON THE REAR PASSENGER SIDE DOOR. THE FRONT AIR BAG DEPLOYED UPON IMPACT. THE CONSUMER WAS UNDER THE IMPRESSION THAT THE FRONTAL AIR BAGS WERE ONLY SUPPOSED TO DEPLOY DURING FRONTAL COLLISIONS. *NM
NHTSA ODI #10079806
Mileage unknown · Dec 10, 2003
Air Bags
BOTH FRONTAL AIR BAGS DEPLOYED WHILE CONSUMER WAS DRIVING AT 35 MPH. *AK
NHTSA ODI #10050327
Mileage unknown · Oct 18, 2002
Air Bags
CONSUMER STATES THAT WHILE MAKING A RIGHT TURN, VEHICLE MAY HAVE HIT A VERY SMALL POT HOLE, SUDDENLY BOTH THE DRIVERS AND PASSENGER SIDE AIRBAGS DEPLOYED. PLEASE PROVIDE ANY FURTHER INFORMATION. MR
NHTSA ODI #8021146
Mileage unknown · Oct 18, 2002
Air Bags
WHILE DRIVING AND MAKING A RIGHT HAND TURN CONSUMER SAYS MAY HAVE HIT A SMALL POT HOLE, AND BOTH DRIVERS AND PASSENGER SIDE AIRBAGS DEPLOYED. PLEASE PROVIDE ANY FURTHER INFORMATION. MR
NHTSA ODI #8021141
Mileage unknown · Sep 23, 2002
Air BagsCrash
AS A RESULT OF HITTING A DEER AT 55 MPH AIR BAGS DID NOT DEPLOY AT ANY TIME. PLEASE PROVIDE FURTHER INFORMATION. DEALERSHIP HAS BEEN CONTACTED.AK
NHTSA ODI #8019175
Mileage unknown · Jan 24, 2002
Air BagsSuspension
I AM LOOKING TO SEE IF THESE RECALLS HAD BEEN FIXED BY THE PREVIOUS OWNER. NO SFETY DEFEC TLISTED. *AK
NHTSA ODI #757285
Mileage unknown · Jan 31, 2001
Air BagsCrashInjury
CONSUMER WAS TRAVELING IN A VERY BAD SNOW STORM AT APPROXIMATE SPEED OF 40MPH AND COMING DOWN AN INCLINE. TRYING TO AVOID HITTING ANOTHER VEHICLE, CONSUMER CRASHED INTO A BRICK WALL. DRIVER'S AIRBAG DIDN'T DEPLOY. CAR WAS TOTALLED. SEAT BELT WAS BEING WORN AT THE TIME. CONSUMER SUFFERED CHEST INJURIES. NO RESPONSE FROM PONT…
Read full complaint
CONSUMER WAS TRAVELING IN A VERY BAD SNOW STORM AT APPROXIMATE SPEED OF 40MPH AND COMING DOWN AN INCLINE. TRYING TO AVOID HITTING ANOTHER VEHICLE, CONSUMER CRASHED INTO A BRICK WALL. DRIVER'S AIRBAG DIDN'T DEPLOY. CAR WAS TOTALLED. SEAT BELT WAS BEING WORN AT THE TIME. CONSUMER SUFFERED CHEST INJURIES. NO RESPONSE FROM PONTIAC, THEY WERE COLLECTING INFORMATION.*AK
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, BUICK AT 1-800-521-7300, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. BECAUSE OF CERTAIN CALIBRATIONS IN THE AIR BAG'S SENSING AND DIAGNOSTIC MODULE, AN INADVERTENT AIR BAG DEPLOYMENT COULD OCCUR IN A LOW SPEED CRASH OR WHEN AN OBJECT STRIKES THE FLOOR PAN.
Consequence & remedy
Consequence: AIR BAGS DEPLOY WITH GREAT FORCE AND CAN SERIOUSLY INJURE UNRESTRAINED OCCUPANTS WHO ARE TOO CLOSE TO THEM.
Remedy: DEALERS WILL RECALIBRATE THE AIR BAG SENSING AND DIAGNOSTIC MODULE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES WERE BUILT WITH MIS-LOCATED WELDS AT THE JOINT BETWEEN THE LEFT ROCKER PANEL INNER REINFORCEMENT AND THE BODY SIDE RING. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 214, "SIDE DOOR STRENGTH."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE SHEET METAL STRUCTURE WOULD NOT PERFORM AS DESIRED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSPECT THE WELDS AND, IF NECESSARY, PLACE FIVE WELDS BETWEEN THE INVOLVED PANELS AND APPLY PRIMER AND TOPCOAT FINISH MATERIALS.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE COMPACT SPARE TIRE ASSEMBLIES WERE ASSEMBLED WITH INCORRECT RIMS. IF THE SPARE TIRE IS UNDERINFLATED, THE BEAD CAN SEPARATE FROM THE RIM CAUSING A RAPID LOSS OF AIR. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: A RAPID LOSS OF AIR CAN INCREASE THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE RIM ON THE COMPACT SPARE TIRE ASSEMBLY. OWNERS ARE REQUESTED NOT TO USE THE SPARE TIRE UNTIL THE RIM HAS BEEN REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
DP03007 · Unintended Vehicle Acceleration
Opened Oct 14, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Fuel System, Other:delivery
ON SEPTEMBER 23, 2003, THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) RECEIVED A LETTER DATED SEPTEMBER 8, 2003 FROM MR. DONALD FRIEDMAN, PETITIONING THE AGENCY TO OPEN A DEFECT INVESTIGATION INTO UNINTENDED ACCELERATION INVOLVING [MODEL YEAR] 1996 AND 1997 GENERAL MOTORS J-CARS.IN SUPPORT OF HIS PETITION, MR. FRIEDMAN CITED A REPORT HE RECEIVED FOR GM SHOWING IT HAD RECEIVED FAR MORE REPORTS OF ALLEGED UNINTENDED ACCELERATION FOR THESE MODELS THAN FOR OTHERS.AFTER ASSESSING THE DATA CLAIMED BY THE PETITIONER TO JUSTIFY HIS REQUEST, ODI FOUND NO INDICATION THAT DEFECT TREND RELATED TO THE PETITIONER'S ALLEGATIONS EXISTS AT THIS TIME.THEREFORE, THERE IS NO REASONABLE POSIBILITY THAT AN ORDER CONCERNING THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT WOULD BE ISSUED AS A RESULT OF GRANTING MR. FRIEDMAN'S PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.FOR ADDITIONAL INFORMATION CONCERNING THIS ANALYSIS, PLEASE REFER TO THE ATTACHED FEDERAL REGISTER NOTICE.
PE02001 · Fire In Steering Column Area
Opened Jan 3, 2002 · Closed Mar 15, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
EA98001 · Oversensitive Air Bag Deployments
Opened Jan 23, 1998 · Closed Jul 31, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
1997 Pontiac Sunfire Problems, Complaints & Recalls | Skip That Year
Illustration