NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
28 reportsClear category filterMileage unknown · Feb 25, 2015
Air BagsElectrical SystemCrashInjury
LETTER FROM SENATOR BROWN ON BEHALF OF CONSTITUENTS RE GM IGNITION CLAIMS. *SMD 2006 PONTIAC SOLSTICE. THE CONSUMER STATED IN AUGUST 2006, SHE EXPERIENCED AN INCIDENT INVOLVING THE IGNITION SWITCH WHERE THE KEYS LOCKED UP IN THE AUXILIARY POSITION RENDERING WHICH CAUSED THE KEY TO BECOME STUCK IN THE IGNITION. IN JANUARY 201…
Read full complaint
LETTER FROM SENATOR BROWN ON BEHALF OF CONSTITUENTS RE GM IGNITION CLAIMS. *SMD 2006 PONTIAC SOLSTICE. THE CONSUMER STATED IN AUGUST 2006, SHE EXPERIENCED AN INCIDENT INVOLVING THE IGNITION SWITCH WHERE THE KEYS LOCKED UP IN THE AUXILIARY POSITION RENDERING WHICH CAUSED THE KEY TO BECOME STUCK IN THE IGNITION. IN JANUARY 2011, THE SAME ISSUE OCCURRED. ON OCTOBER 11, 2012, THE CONSUMERS HUSBAND WAS INVOLVED IN AN ACCIDENT WHILE DRIVING THE VEHICLE. ALSO, THE AIR BAG DID NOT DEPLOY. THE CONSUMERS HUSBAND WAS INJURED. *JB
NHTSA ODI #10690403
Mileage unknown · Oct 29, 2014
Electrical System
TL* THE CONTACT OWNS A 2006 PONTIAC SOLSTICE. THE CONTACT RECEIVED RECALL NOTIFICATIONS FOR NHTSA CAMPAIGN NUMBER: 14V171000 (ELECTRICAL SYSTEM) AND NHTSA CAMPAIGN NUMBER: 14V047000 (ELECTRICAL SYSTEM). THE CONTACT STATED THAT THE PARTS WERE NOT AVAILABLE. THE DEALER DID NOT GIVE A SPECIFIC DATE FOR WHEN THE PARTS WOULD BECOME A…
Read full complaint
TL* THE CONTACT OWNS A 2006 PONTIAC SOLSTICE. THE CONTACT RECEIVED RECALL NOTIFICATIONS FOR NHTSA CAMPAIGN NUMBER: 14V171000 (ELECTRICAL SYSTEM) AND NHTSA CAMPAIGN NUMBER: 14V047000 (ELECTRICAL SYSTEM). THE CONTACT STATED THAT THE PARTS WERE NOT AVAILABLE. THE DEALER DID NOT GIVE A SPECIFIC DATE FOR WHEN THE PARTS WOULD BECOME AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE DELAY. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10651108
23,000 miles · Oct 7, 2014
Electrical SystemSteering
TL* THE CONTACT OWNS A 2006 PONTIAC SOLSTICE. THE CONTACT STATED THAT THE WHEN THE VEHICLE WAS IN THE OFF POSITION, THE STEERING WHEEL FAILED TO LOCK. ALSO THE DOOR CHIMES FAILED TO ALERT WHEN THE KEY WAS PLACED IN THE IGNITION. THE CONTACT MENTIONED THAT THE VEHICLE WAS RECENTLY REPAIRED UNDER RECALL NHTSA CAMPAIGN NUMBER: 14E…
Read full complaint
TL* THE CONTACT OWNS A 2006 PONTIAC SOLSTICE. THE CONTACT STATED THAT THE WHEN THE VEHICLE WAS IN THE OFF POSITION, THE STEERING WHEEL FAILED TO LOCK. ALSO THE DOOR CHIMES FAILED TO ALERT WHEN THE KEY WAS PLACED IN THE IGNITION. THE CONTACT MENTIONED THAT THE VEHICLE WAS RECENTLY REPAIRED UNDER RECALL NHTSA CAMPAIGN NUMBER: 14E021000 (ELECTRICAL SYSTEM). HOWEVER, THE FAILURE PERSISTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 23,000.
NHTSA ODI #10641949
55,000 miles · Sep 12, 2014
Air BagsElectrical System
TL* THE CONTACT OWNS A 2006 PONTIAC SOLSTICE. THE CONTACT STATED THE IGNITION WAS REPAIRED DUE TO A SAFETY RECALL. THREE WEEKS LATER, THE AIR BAG INDICATOR REMAINED ILLUMINATED. THE FAILURE OCCURRED DAILY. THE DEALER STATED THAT THE AIR BAG UNIT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE RECALL NUMBER WAS UNKNOWN. …
Read full complaint
TL* THE CONTACT OWNS A 2006 PONTIAC SOLSTICE. THE CONTACT STATED THE IGNITION WAS REPAIRED DUE TO A SAFETY RECALL. THREE WEEKS LATER, THE AIR BAG INDICATOR REMAINED ILLUMINATED. THE FAILURE OCCURRED DAILY. THE DEALER STATED THAT THE AIR BAG UNIT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE RECALL NUMBER WAS UNKNOWN. THE FAILURE MILEAGE WAS 55,000. UPDATED 10/24/14*CN THE CONSUMER STATED THE REMOTE KEY DID NOT OPEN THE DOORS OR THE TRUNK. UPDATED 12/09/14*LJ THE CONSUMER FEELS THE COST OF THE REPAIRS SHOULD BE COVERED. UPDATED 05/19/2015 *JS
NHTSA ODI #10632759
Mileage unknown · Aug 20, 2014
Air BagsElectrical System
TL* THE CONTACT OWNS A 2006 PONTIAC SOLSTICE. THE CONTACT RECEIVED A NOTIFICATION FOR RECALL NHTSA CAMPAIGN ID NUMBER 14V047000 (AIR BAGS, ELECTRICAL SYSTEM). THE PARTS NEEDED TO THE REPAIRS WERE UNAVAILABLE. THE DEALER WAS CONTACTED BUT STATED THAT THEY COULD NOT REPAIR THE VEHICLE FOR FIVE MONTHS. THE MANUFACTURER WAS MADE AW…
Read full complaint
TL* THE CONTACT OWNS A 2006 PONTIAC SOLSTICE. THE CONTACT RECEIVED A NOTIFICATION FOR RECALL NHTSA CAMPAIGN ID NUMBER 14V047000 (AIR BAGS, ELECTRICAL SYSTEM). THE PARTS NEEDED TO THE REPAIRS WERE UNAVAILABLE. THE DEALER WAS CONTACTED BUT STATED THAT THEY COULD NOT REPAIR THE VEHICLE FOR FIVE MONTHS. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE.
NHTSA ODI #10626769
Mileage unknown · Aug 7, 2014
Electrical System
2006 PONTIAC SOLSTICE. COUNSEL REPRESENTING CONSUMER WRITES IN REGARDS TO IGNITION SWITCH PARTS CURRENTLY UNAVAILABLE TO COMPLETE RECALL. *SMD
NHTSA ODI #10619577
18,623 miles · Jul 31, 2014
Electrical SystemPower Train
VEHICLE WAS IN DEALERSHIP FOR IGNITION SWITCH RECALL WORK (RECALL 14063 AND 14113). WHEN VEHICLE WAS RETURNED TO ME UPON COMPLETION OF THE WORK, THE VEHICLE WOULD SOMETIMES START, AND SOMETIMES NOT. I START WITH THE TRANSMISSION IN GEAR, CLUTCH DEPRESSED. THIS MAY OR MAY NOT HAVE ANY IMPACT ON THE ISSUE, WHICH THE SERVICE TEC…
Read full complaint
VEHICLE WAS IN DEALERSHIP FOR IGNITION SWITCH RECALL WORK (RECALL 14063 AND 14113). WHEN VEHICLE WAS RETURNED TO ME UPON COMPLETION OF THE WORK, THE VEHICLE WOULD SOMETIMES START, AND SOMETIMES NOT. I START WITH THE TRANSMISSION IN GEAR, CLUTCH DEPRESSED. THIS MAY OR MAY NOT HAVE ANY IMPACT ON THE ISSUE, WHICH THE SERVICE TECHNICIAN REPORTED WAS AN ISSUE WITH THE HALL EFFECT DEVICES IN THE KEY HEAD. I AM AN EX GM ELECTRICAL ENGINEER - I UNDERSTAND NEUTRAL SAFETY. THIS IS NOT A CLUTCH/TRANSMISSION NEUTRAL SAFETY ISSUE, THIS IS A KEY SWITCH FAILURE TO ENGAGE CRANK ISSUE. THE OLD IGNITION SWITCH ALWAYS STARTED IN THIS CRANK CONFIGURATION. AT THIS TIME, I HAVE MY VEHICLE AT HOME, AND BOTH RECALL KEYS HAVE DEMONSTRATED A REFUSAL TO START THE CAR AT TIMES. TURN THE KEY, NO CRANK. GREAT, IF I DUMP THE CLUTCH AND STALL THE VEHICLE, I MAY BE IN A ROAD CONDITION THAT IS VERY DANGEROUS AND BE UNABLE TO START MY CAR. IT "COULD" BE A WALK HOME FAILURE PER THE TECHNICIANS COMMENTS IF I UNDERSTOOD HIM CORRECTLY. IN RETURNING "ONE" OF THE "TWO" SUPPLIED KEYS SO THEY COULD ORDER REPLACEMENTS, THE COMMENT WAS MADE THEY HAVE SEEN THIS ISSUE WITH HALL KEY HEADS BEFORE. EXCUSE ME, I WOULD THINK A "NO START" CONDITION IS A RECALL CONDITION -- YOU CAN GET SOMEONE HURT IN TRAFFIC. I WOULD ALSO THINK ALL KEY HEAD SHOULD BE CHECKED FOR PERFORMANCE PRIOR TO INSTALLATION IN SERVICE. HOW MANY OF THE RECALLED "FIXED" VEHICLES HAVE THESE UNSAFE KEYS IN CUSTOMERS HANDS? I CHALLENGE THIS SOLUTION AS A "FIX", AND QUESTION THE RECALL SOLUTION. *TR
NHTSA ODI #10618026
Mileage unknown · Jul 23, 2014
Air BagsElectrical System
TL* THE CONTACT OWNS A 2006 PONTIAC SOLSTICE. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V047000 (AIR BAGS, ELECTRICAL SYSTEM), BUT THE DEALER DID NOT HAVE THE PARTS TO REPAIR THE VEHICLE. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10615801
Mileage unknown · Jul 15, 2014
Air BagsElectrical System
LETTER FROM SENATOR NELSON ON BEHALF OF CONSTITUENT RE GM RECALL. *SMD 2006 PONTIAC SOLSTICE. THE CONSUMER WAS INFORMED, THE PARTS WERE NOT AVAILABLE. THE CONSUMER BACK A MONTH LATER, AND WAS INFORMED, THE PARTS WERE STILL NOT AVAILABLE. *JB
NHTSA ODI #10614428
100,000 miles · Jul 1, 2014
Electrical System
TL* THE CONTACT OWNS A 2006 PONTIAC SOLSTICE. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT WAS ALSO INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 14V047000 (AIR BAGS, ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS 1…
Read full complaint
TL* THE CONTACT OWNS A 2006 PONTIAC SOLSTICE. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT WAS ALSO INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 14V047000 (AIR BAGS, ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 108,000.
NHTSA ODI #10607555
Official recalls
4Jan 26, 2017
General Motors LLC (GM) is recalling certain 2006-2010 Pontiac Solstice and 2007-2010 Saturn Sky vehicles. The Passenger Air Bag Suppression System (PPS) sensor may become bent or damaged within the front passenger seat, possibly disabling the front passenger air bag.
Consequence & remedy
Consequence: In the event of a crash, if the front passenger air bag does not deploy as intended, the front passenger has an increased risk of injury.
Remedy: The remedy for this recall is still under development. A permanent remedy is currently under development. The recall began February 26, 2018. Owners may contact Pontiac customer service at 1-800-762-2737 or Saturn customer service at 1-800-553-6000. GM's number for this recall is 17036.
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Dec 20, 2007
ON CERTAIN PASSENGER VEHICLES, THE REAR AXLE PINION SEAL DOES NOT MEET ALL OF THE SPECIFICATIONS AND MAY EXPERIENCE A FLUID LEAK.
Consequence & remedy
Consequence: A REAR DIFFERENTIAL FAILURE MAY CAUSE LOSS OF MOTIVE POWER AND POSSIBLY LOSS OF CONTROL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE PINION SEAL FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 1, 2008. OWNERS MAY CONTACT CADILLAC AT 1-800-458-8006 OR HTTP://WWW.CADILLAC.COM; PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM; AND SATURN AT 1-800-972-8876 OR HTTP://WWW.SATURN.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP20002 · Hvac Blower Motor Connector
Opened Feb 7, 2020 · Closed Oct 27, 2022
Status: closed (inferred from source dates) · Electrical System:wiring:interior/under Dash
The Office of Defects Investigation (ODI) has completed its review of a Defect Petition received December 12, 2019 requesting an investigation into the possibility of passenger compartment fires attributed to overheating HVAC blower motor connectors in Model Years (MY) 2006-2010 Pontiac Solstice and Saturn Sky vehicles.An analysis of General Motors (GM) complaint data and information in NHTSA?s databases identified thirteen unique vehicle identification numbers (VINs) with reported incidents that could pertain to blower motor overheating, smoking, or melting in the 90,938 MY2006-2010 Saturn Sky and Pontiac Solstice vehicles produced. Two of the thirteen cited incidents reported smoke and thermal damage that may be attributed to the HVAC blower motor although neither incident was confirmed through vehicle inspection. One incident, a MY2008 Saturn Sky with substantial field exposure from a frontal collision, could not have the root cause identified. The other, a MY2007 Pontiac Solstice, did not inform the manufacturer nor take the vehicle to a dealer for evaluation.Most of the 13 incidents reported an overheated or discolored connector with attendant loss of HVAC blower fan function. GM reported 354 warranty claims with the subject components for the Sky and Solstice, none of which included a report of fire and only one report of smoke. Over a period of ten to fourteen years in service, there are two reports of smoke or thermal damage.While the subject Sky and Solstice vehicles and the recalled Hummer H3 and H3T vehicles do share common components, the Sky and Solstice vehicles have demonstrated very different behavior and their HVAC system has a lower power draw than the recalled Hummer H3 and H3T vehicles. The recalled H3 and H3T vehicles generate over triple the failure rate of the Sky and Solstice vehicles. GM suggested in its response to the ODI?s information request that this difference was due to the larger interior volume of a recalled Hummer vehicle imposing a heavier electrical load and duty cycle on its HVAC blower. The duty cycle is defined as how long it takes for the vehicle to cool down enough before the HVAC blower motor fan speed is lowered or turned off completely.Additionally, due to the size differential between the Sky and Solstice vehicles and the recalled Hummer H3 and H3T vehicles, the parts have a different power draw. The Sky and Solstice vehicles, due to their smaller size, draw less wattage, which reduces the likelihood of a thermal event. This condition in the Sky and Solstice vehicles typically leads to an inoperable HVAC blower motor as opposed to a thermal event.Despite the commonality of parts in the Sky and Solstice vehicles with those that were the basis of a safety recall, the subject vehicles have not demonstrated a safety defect trend that would likely lead to a safety recall or merit further investigation by the ODI. The subject vehicles have a low rate of reported thermal events over the ten to fourteen years they have been in service with the most recent occurring in 2017 with no confirmed fires. The HVAC blower motor was not confirmed to be the root cause for either thermal event cited above.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA?s possession, information submitted by GM in response to an information request, and the potential risks to safety implicated by the petitioner?s allegation, NHTSA does not believe that the petition warrants a formal investigation at this time. Consequently, the petition is denied.The entire petition denial can be viewed in the October 14, 2022 Federal Register under DP20-002.(https://www.f
DP16001 · Passenger Sensing System Sensor Mat
Opened May 16, 2016 · Closed Apr 24, 2017
Status: closed (inferred from source dates) · Air Bags:sensor:occupant Classification
The Office of Defects Investigation (ODI) received a petition requesting the opening of an investigation into the air bag system on model year 2006-2010 Pontiac Solstice and 2007-2010 Saturn Sky, the subject vehicles.The petitioner raised the issue of failure of the Passenger Sensing System for the front passenger seating position.On January 26, 2017, General Motors filed a defect information report recalling the subject vehicles to address the issue raised by the petition.In view of the recall, ODI considers the petition moot and is closing the action.The closing of the petition does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by future circumstances.
PE07037 · Failure Of The Rear Differential
Opened Jul 17, 2007 · Closed Dec 27, 2007
Status: closed (inferred from source dates) · Power Train:driveline:differential Unit
ODI EVALUATED TWO DIFFERENT ALLEGED DEFECTS INVOLVING REAR DRIVETRAIN COMPONENTS DURING THIS PRELIMINARY EVALUATION.GM IS CONDUCTING A RECALL TO ADDRESS ONE OF THE DEFECT CONDITIONS AND ODI HAS OPENED AN ENGINEERING ANALYSIS TO CONTINUE ITS INVESTIGATION OF THE OTHER ALLEGED DEFECT. ON DECEMBER 19, 2007, GM SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING DEFECTIVE REAR AXLE PINION SEALS IN APPROXIMATELY 275,936 MODEL YEAR (MY) 2005-07 CADILLAC CTS, STS AND SRX VEHICLES AS WELL AS MY 2006-07 PONTIAC SOLSTICE AND MY 2007 SATURN SKY VEHICLES (RECALL 07V-589).ON STS AND SRX VEHICLES WITH ALL WHEEL DRIVE, THE FRONT AXLE PINION SEAL ALSO DOES NOT MEET ALL OF GM'S SPECIFICATIONS AND MAY EXPERIENCE A FLUID LEAK.GM INDICATED THAT THE SEAL SUPPLIER MADE AN UNAUTHORIZED CHANGE TO THE PINION SEAL MATERIAL.LEAKING PINION SEALS COULD RESULT IN LOSS OF REAR DIFFERENTIAL LUBRICATION WHICH COULD RESULT IN REAR WHEEL LOCK-UP AND LOSS OF VEHICLE CONTROL. ON DECEMBER 7, 2007, ODI OPENED AN ENGINEERING ANALYSIS (EA07-017) TO INVESTIGATE COMPLAINTS OF REAR DRIVETRAIN COMPONENT FAILURE (E.G., FRACTURED REAR DIFFERENTIAL CARRIER HOUSING OR REAR AXLE HALF SHAFTS) WHILE DRIVING IN APPROXIMATELY 7,600 MY 2004 THROUGH 2006 CADILLAC CTS-V VEHICLES.THIS CONDITION MAY RESULT IN A LOSS OF MOTIVE POWER AND VEHICLE DISABLEMENT AND IS NOT ADDRESSED BY RECALL 07V-589.ODI IDENTIFIED 35 COMPLAINTS (16 TO ODI AND 19 TO GM) AND 128 WARRANTY CLAIMS POTENTIALLY RELATED TO THIS CONDITION (SEE EA07-017 OPENING RESUME).THESE COMPLAINTS ARE NOT INCLUDED IN THE FAILURE REPORT SUMMARY OF THIS CLOSING RESUME. THE COMPLAINTS AND WARRANTY FIGURES GIVEN IN THIS RESUME ARE LIMITED TO THOSE THAT (A) ARE MOST LIKELY CAUSED BY A LEAKING REAR PINION SEAL; AND (B) RESULTED IN AN ALLEGATION OF A REAR DIFFERENTIAL FAILURE WHILE DRIVING.THE DATA DO NOT INCLUDE ALL REPORTS OF SEAL LEAKAGE.
Illustration