NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
81 reports78,900 miles · Mar 30, 2011
Air BagsCrashInjury
TL* THE CONTACT OWNS A 2005 PONTIAC MONTANA. THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH AND CRASHED INTO A DEER. THE AIR BAGS DID NOT DEPLOY AND THERE WAS DAMAGE TO THE HOOD, HEAD LIGHTS, FENDER AND PASSENGER SIDE DOOR. THE CONTACT SUSTAINED A BRUISED EYE AND INJURIES TO THE LIPS. THE PASSENGER SUSTAINED A BROKEN FINGER AND WR…
Read full complaint
TL* THE CONTACT OWNS A 2005 PONTIAC MONTANA. THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH AND CRASHED INTO A DEER. THE AIR BAGS DID NOT DEPLOY AND THERE WAS DAMAGE TO THE HOOD, HEAD LIGHTS, FENDER AND PASSENGER SIDE DOOR. THE CONTACT SUSTAINED A BRUISED EYE AND INJURIES TO THE LIPS. THE PASSENGER SUSTAINED A BROKEN FINGER AND WRIST AND THE REAR PASSENGER SUSTAINED A PUNCTURE WOUND TO THE FOREHEAD. THE CONTACT STATED THAT THE AIR BAG AND CHECK ENGINE WARNING LIGHTS WERE ILLUMINATED AND THE TAIL LIGHTS BECAME INOPERABLE IMMEDIATELY AFTER THE CRASH. THE BRAKE LIGHTS WOULD OPERATE ERRATICALLY. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE FROM THE SCENE OF THE CRASH. THE MANUFACTURER WAS CONTACTED AND SENT AN INSPECTOR TO INSPECT THE VEHICLE WHO CONFIRMED THAT THE AIR BAGS WERE DEFECTIVE. THE CONTACT REFERENCED THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 06V417000 (AIR BAGS: FRONTAL) BUT THE VIN WAS NOT INCLUDED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 78,900.
NHTSA ODI #10393742
64,000 miles · Jan 2, 2011
Electrical SystemTraction Control System
SINCE PURCHASING NEARLY 2 YRS AGO FROM A LOCAL DEALERSHIP, IT HAS HAD NUMEROUS MINOR ISSUES AND SOME DANGEROUS PROBLEMS AS WELL. MY MAIN CONCERN IS THAT THE DRIVERS SIDE AUTOMATIC SLIDING DOOR DOESN'T FUNCTION PROPERLY. WE HAD THE VAN LOOKED AT BY A MECHANIC FROM THE DEALERSHIP AND HE WAS UNABLE TO REMEDY THE PROBLEMS WITH THE D…
Read full complaint
SINCE PURCHASING NEARLY 2 YRS AGO FROM A LOCAL DEALERSHIP, IT HAS HAD NUMEROUS MINOR ISSUES AND SOME DANGEROUS PROBLEMS AS WELL. MY MAIN CONCERN IS THAT THE DRIVERS SIDE AUTOMATIC SLIDING DOOR DOESN'T FUNCTION PROPERLY. WE HAD THE VAN LOOKED AT BY A MECHANIC FROM THE DEALERSHIP AND HE WAS UNABLE TO REMEDY THE PROBLEMS WITH THE DOOR. THE SLIDER DOOR OPENS RANDOMLY, WON'T SHUT, OR JUST KEEPS OPENING AND SHUTTING FOR NO PARTICULAR REASON. WE'VE TRIED TURNING THE SWITCH OFF ON THE CONSOLE, WHICH FOR THE MOST PART KEEPS THE DOOR SHUT~ BUT THEN THAT DOOR IS UNUSABLE. NOW FOR THE MOST SERIOUS OF MY CONCERNS WITH THE CONSOLE SWITCH OFF, THE DOOR HAS ON OCCASION OPENED ON ITS OWN WHEN THE VAN IS GOING DOWN THE ROAD. ALSO, AT LEAST 3 TIMES IN THE LAST 6 MONTHS, THE DOOR HAS OPENED ON ITS OWN IN THE NIGHT AND STAYED OPEN~ CAUSING MY BATTERY TO BE DEAD IN THE MORNING. ANOTHER PROBLEM WE HAVE HAS IS THE ABS AND THE TRACTION CONTROL LIGHTS COME ON RANDOMLY, WE HAD THE VAN SERVICED AND STILL IT DOESN'T SEEM LIKE THOSE SYSTEMS ARE WORKING PROPERLY. *TR
NHTSA ODI #10373776
65,000 miles · Dec 6, 2010
Equipment Adaptive/mobilityFuel System, Gasoline
I HAVE ONLY 2005 PONTIAC MONTANA ENTERVAN FROM BRAUN, AND IT IS ABOUT TO GET ITS FIFTH FUEL TANK. TWO OTHER TANKS WERE DELIVERED BUT NOT INSTALLED BECAUSE THEY WERE DEFECTIVE. I ONCE MET A GUY WITH A VEHICLE LIKE MINE AND HE ALSO HAD A FUEL TANK LEAK. I BELIEVE THAT THIS SHOULD BE INVESTIGATED. WHILE THE POPULATION OF VEHICL…
Read full complaint
I HAVE ONLY 2005 PONTIAC MONTANA ENTERVAN FROM BRAUN, AND IT IS ABOUT TO GET ITS FIFTH FUEL TANK. TWO OTHER TANKS WERE DELIVERED BUT NOT INSTALLED BECAUSE THEY WERE DEFECTIVE. I ONCE MET A GUY WITH A VEHICLE LIKE MINE AND HE ALSO HAD A FUEL TANK LEAK. I BELIEVE THAT THIS SHOULD BE INVESTIGATED. WHILE THE POPULATION OF VEHICLES IS SMALL, THE HANDICAPPED PEOPLE IN THEM ARE MOST VULNERABLE. THIS IS ESPECIALLY TRUE IF THE WHEELCHAIR RAMP WILL NOT GO DOWN OR THERE'S A FIRE IN THE AREA OF THE RAMP. THE CONTACT WANTED TO FILE THE COMPLAINT THAT HE SENT VIA EMAIL. THE CURRENT MILES WERE 65,000. THE VIN WAS NOT AVAILABLE. BL
NHTSA ODI #10369323
110,131 miles · Nov 16, 2010
Structure
TL*THE CONTACT OWNS A 2005 PONTIAC MONTANA SV6. WHILE DRIVING APPROXIMATELY 15 MPH THE REAR SLIDING DOOR OPENED AND THE CHILD SAFETY LOCK WAS ON. THE CONTACT STATED THAT SHE NOTICED ON SEVERAL OCCASION THE DOOR DIDN'T LOCK PROPERLY. THE MANUFACTURER WILL BE NOTIFIED. THE VEHICLE WILL BE TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING…
Read full complaint
TL*THE CONTACT OWNS A 2005 PONTIAC MONTANA SV6. WHILE DRIVING APPROXIMATELY 15 MPH THE REAR SLIDING DOOR OPENED AND THE CHILD SAFETY LOCK WAS ON. THE CONTACT STATED THAT SHE NOTICED ON SEVERAL OCCASION THE DOOR DIDN'T LOCK PROPERLY. THE MANUFACTURER WILL BE NOTIFIED. THE VEHICLE WILL BE TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE FAILURE AND CURRENT MILEAGES WERE 110,131.
NHTSA ODI #10365917
Mileage unknown · Oct 27, 2010
Electrical SystemStructure
I HAVE A HANDICAP ACCESSIBLE VAN MADE BY M.C. MOBILITY AND GM. MY AUTOMATIC SLIDING DOOR OPENS ITSELF AND EXECUTES THE RAMP AT DIFFERENT TIMES. ONCE I WAS AT THE DRIVE THRU AND PUT MY CAR IN PARK AND IT OPENED THE DOOR AND EXECUTED THE RAMP. OTHER TIMES IT HAS OPENED AND CLOSED BY ITSELF. ONE TIME DURING AN OUTDOOR EVENT SOM…
Read full complaint
I HAVE A HANDICAP ACCESSIBLE VAN MADE BY M.C. MOBILITY AND GM. MY AUTOMATIC SLIDING DOOR OPENS ITSELF AND EXECUTES THE RAMP AT DIFFERENT TIMES. ONCE I WAS AT THE DRIVE THRU AND PUT MY CAR IN PARK AND IT OPENED THE DOOR AND EXECUTED THE RAMP. OTHER TIMES IT HAS OPENED AND CLOSED BY ITSELF. ONE TIME DURING AN OUTDOOR EVENT SOME FOLKS WATCHED MY CAR FOR ENTERTAINMENT FOR 4 HOURS AND DURING THAT TIME PERIOD IT OPENED AND CLOSED ITSELF 14 TIMES. WE HAVE HAD THE DOOR WORKED ON MANY TIMES AND IT IS WELL DOCUMENTED AND I WOULD BE HAPPY TO SHARE THE DOCUMENTATION. THE WHEELS ON MY DOOR HAVE BEEN CHANGED SEVERAL TIMES I HAVE REPLACED MY CAR BATTERY AND THE BATTERIES OF BOTH KEY FOBS. RIGHT NOW IT HAS BEEN WORKING CORRECTLY FOR ABOUT 60 DAYS
NHTSA ODI #10364668
Mileage unknown · Oct 23, 2010
Latches/locks/linkagesStructure
THE DRIVER SIDE SLIDING DOOR CONTINUES TO OPEN AND WHEN YOU LOCK IT MANUALLY IT CHIMES WHILE YOU ARE DRIVING. THE SENSORS HAVE BEEN REPLACED AND THE LOCK BUT NOTHING IS WORKING RIGHT. *TR
NHTSA ODI #10361882
70,000 miles · Jul 23, 2010
Vehicle Speed Control
WHILE DRIVING THE VEHICLE THE SPEEDOMETER GAUGE, GAS GAUGE AND/OR TEMPERATURE GAUGE WILL BEGIN MOVING ERRATICALLY. IN THE EVENT IT IS THE SPEEDOMETER - IT WILL APPEAR THE VEHICLE IS TRAVELING AT 110MPH WHEN IT IS REALLY GOING ABOUT 30MPG. IT HAPPENS ONE OR TWICE A MONTH AND THERE IS NO WAY TO REPAIR IT THAT I AM AWARE OF. IT …
Read full complaint
WHILE DRIVING THE VEHICLE THE SPEEDOMETER GAUGE, GAS GAUGE AND/OR TEMPERATURE GAUGE WILL BEGIN MOVING ERRATICALLY. IN THE EVENT IT IS THE SPEEDOMETER - IT WILL APPEAR THE VEHICLE IS TRAVELING AT 110MPH WHEN IT IS REALLY GOING ABOUT 30MPG. IT HAPPENS ONE OR TWICE A MONTH AND THERE IS NO WAY TO REPAIR IT THAT I AM AWARE OF. IT IS VERY DANGEROUS BECAUSE THE SUDDEN CHANGE IN SPEEDOMETER CAN CAUSE A WRECK OR CRASH. *TR
NHTSA ODI #10344991
Mileage unknown · Jun 16, 2010
Structure
2005 PONTIAC MONTANA. CONSUMER STATES PROBLEM WITH FRONT PASSENGER DOOR *TGW THE CONSUMER STATED THE FRONT PASSENGER DOOR HAD TO BE REPAIRED TWICE IN LESS THAN ONE YEAR AT A COST OF $117.69. THE SECOND TIME, THE CONSUMER HAD TO PAY $ 109.82. THE DEALER REPLACED THE DOOR PANEL CLIPS AND DOOR HANDLE. *JB
NHTSA ODI #10336966
130,000 miles · Mar 2, 2010
Electrical SystemFire
FOR SEVERAL DAYS WE NOTICED AS STRONG CHEMICAL LIKE SMELL IN THE CAR AND THEN NOTICED THAT THE MIRROR CONTROL NO LONGER WORKED. I TOOK OFF THE DRIVER'S SIDE DOOR SWITCH PANEL TO INVESTIGATE THE MIRROR PROBLEM AND FOUND THE MIRROR CONTROL HAD BEEN SMOLDERING FOR DAYS. THE ASSEMBLY WAS COMPLETELY CHARRED AND MATING CONNECTOR HAD…
Read full complaint
FOR SEVERAL DAYS WE NOTICED AS STRONG CHEMICAL LIKE SMELL IN THE CAR AND THEN NOTICED THAT THE MIRROR CONTROL NO LONGER WORKED. I TOOK OFF THE DRIVER'S SIDE DOOR SWITCH PANEL TO INVESTIGATE THE MIRROR PROBLEM AND FOUND THE MIRROR CONTROL HAD BEEN SMOLDERING FOR DAYS. THE ASSEMBLY WAS COMPLETELY CHARRED AND MATING CONNECTOR HAD ALSO MELTED. *TR
NHTSA ODI #10315619
Mileage unknown · Sep 16, 2009
Latches/locks/linkages
THE DRIVER SIDE BACK DOOR WILL NOT CLOSE AND STAY CLOSED. IF I PUSH THE BUTTON TO CLOSE IT AUTOMATICALLY, IT COMES RIGHT BACK OPEN. IF I USE THE OVERRIDE AND CLOSE IT MANUALLY, THEN THE DOOR CHIMES AS I AM DRIVING TELLING ME THAT THE DOOR IS AJAR. I ALSO HAVE ISSUES WITH THE PASSENGER SIDE BACK DOOR. IF I GO OVER A BUMP OR P…
Read full complaint
THE DRIVER SIDE BACK DOOR WILL NOT CLOSE AND STAY CLOSED. IF I PUSH THE BUTTON TO CLOSE IT AUTOMATICALLY, IT COMES RIGHT BACK OPEN. IF I USE THE OVERRIDE AND CLOSE IT MANUALLY, THEN THE DOOR CHIMES AS I AM DRIVING TELLING ME THAT THE DOOR IS AJAR. I ALSO HAVE ISSUES WITH THE PASSENGER SIDE BACK DOOR. IF I GO OVER A BUMP OR POT HOLE, THEN THE CHIME STARTS AND THE ONLY WAY TO STOP IT IS TO OPEN THE DOOR AND RE-CLOSE IT. *TR
NHTSA ODI #10284209
Official recalls
5Mar 19, 2010
THE BRAUN CORPORATION HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2005-2008 GENERAL MOTORS MOBILITY CONVERSION, HANDICAPPED ACCESSIBLE LOW FLOOR MINIVANS. DURING CONVERSION, THE DRIVER OR PASSENGER SIDE TRAILING ARM MODIFICATION MAY NOT HAVE BEEN ADEQUATELY WELDED.
Consequence & remedy
Consequence: A SQUEAKING OR CLUNKING NOISE MAY DEVELOP. THE TRAILING ARM BUSHINGS MAY PREMATURELY WEAR AND THE TRAILING ARM MAY FRACTURE OR SEPARATE, ALLOWING THE REAR AXLE TO BECOME PARTIALLY SEPARATED FROM THE CHASSIS INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND WILL HAVE A SUPPLY OF RETROFIT PARTS AVAILABLE TO REMEDY THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN AT 1-800-488-0359.
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Jun 20, 2005
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND THE VEHICLE IN NEUTRAL (N). SOME OF THESE VEHICLES FAILED THIS TEST.
Consequence & remedy
Consequence: WHEN THE PARKING BRAKE IS RELEASED, THE DRIVER MAY NOTICE UNINTENDED BRAKING WHEN ACCELERATING, DECELERATING, OR COASTING, AND A NOISE COMING FROM THE REAR OF THE VEHICLE. UNINTENDED VEHICLE MOVEMENT COULD OCCUR INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT FOR PARKING BRAKE LEVER SLIPPAGE AT EACH REAR BRAKE CALIPER AND REPLACE THE CALIPER IF LEVER SLIPPAGE IS IDENTIFIED. THE RECALL BEGAN ON NOVEMBER 14, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR SATURN AT 1-800-972-8876.
Feb 18, 2005
ON CERTAIN MINIVANS, THE OUTBOARD RELEASE HANDLE ON THE IMPACT-SIDE SECOND-ROW BUCKET SEAT MAY BE ACTUATED AND THE REAR LATCHES MAY UNLATCH EARLY IN A SIDE IMPACT CRASH. THIS WAS DISCOVERED IN A SIDE IMPACT TEST RUN BY GM, UNDER CONDITIONS SIMILAR TO NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) SIDE IMPACT TEST.
Consequence & remedy
Consequence: IF THE REAR LATCHES OF THE SEAT RELEASE EARLY IN A SEVERE SIDE IMPACT, THE FRONT OUTBOARD LATCH MAY DISENGAGE AND INCREASE THE POTENTIAL FOR INJURY TO THE OCCUPANT OF THE SEAT.
Remedy: DEALERS WILL REMOVE THE SEAT LATCH RELEASE HANDLE AND INSTALL A BLACK PLASTIC CAP OVER THE EXPOSED METAL STUD TO ELIMINATE THE SIDE IMPACT SAFETY CONCERN FREE OF CHARGE. THE RECALL BEGAN ON APRIL 5, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876, CHEVROLET AT 1-800-630-2438, AND PONTIAC AT 1-800-620-7668.
Dec 22, 2004
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA07019 · Power Sliding Door
Opened Dec 11, 2007 · Closed Feb 23, 2009
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
PE07044 · Power Sliding Door Opening
Opened Aug 16, 2007 · Closed Dec 11, 2007
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
PE05063 · Electrical Harness Damage
Opened Nov 29, 2005 · Closed Mar 6, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:front Underhood
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration