BEGINNING AT 15K MILES THE POWER SLIDING DOORS BEGAN NOT FUNCTIONING PROPERLY. THE WOULD AUTOMATICALLY OPEN AS IF THERE WAS AN OBSTRUCTION IN THE DOORWAY. AT 18K MILES THERE WAS A COMPLETE FAILURE TO THE MOTOR DRIVE ASSEMBLY. AFTER REPAIR BOTH DOORS CONTINUED TO AUTO OPEN. DURING NORMAL DRIVING CONDITIONS AT INTERSTATE SPEED…
Read full complaint
BEGINNING AT 15K MILES THE POWER SLIDING DOORS BEGAN NOT FUNCTIONING PROPERLY. THE WOULD AUTOMATICALLY OPEN AS IF THERE WAS AN OBSTRUCTION IN THE DOORWAY. AT 18K MILES THERE WAS A COMPLETE FAILURE TO THE MOTOR DRIVE ASSEMBLY. AFTER REPAIR BOTH DOORS CONTINUED TO AUTO OPEN. DURING NORMAL DRIVING CONDITIONS AT INTERSTATE SPEED THE DOOR DID COME OPEN WITH NO PASSENGERS IN IT. WHEN THE DOORS ARE NOT FUNCTIONING PROPERLY YOU MUST DEACTIVATE LOCK OUT ROCKER SWITCH ON OVERHEAD CONSOLE, THEN MANUALLY CLOSE. IF YOU RE-ENERGIZE THE LOCK OUT SWITCH DOOR WILL AUTO OPEN. AT TIMES THE DOOR AJAR CHIME WILL SOUND WHILE THE DOORS ARE SHUT AND LOCKED AND WILL NOT TURN OFF, ONCE TO THE POINT OF RUNNING OUT THE BATTERY. WHEN DOORS DO NOT WANT TO SHUT THEY FORCE THEMSELVES OPEN REPEATEDLY. MULTIPLE OCCASIONS A MONTH SINCE 2006, I HAVE HAD IT IN FOR SERVICE NUMEROUS TIMES WITH NO SUCCESS. THE MOTOR AND CONTROL LOGIC SITS ADJACENT TO THE REAR SEATBELT MECHANISM. BOTH SEATBELTS IN THE 3RD ROW ARE NOT WORKING PROPERLY SINCE THEY HAVE ATTEMPTED TO REPAIR THIS PROBLEM. *TR
NHTSA ODI #10233500
Mileage unknown · Apr 22, 2008
Air BagsEngine And Engine CoolingLatches/locks/linkages
2005 PONTIAC MONTANA SV6 AUTOMATIC SLIDING DOOR OPENS WHILE DRIVING, BAD SENSOR AND BROKE CABLE WAS REPLACED. *CW THE CONSUMER ALSO STATED THE ENGINE FAILED, WHICH ULTIMATELY LED TO AN ENGINE REPLACEMENT. THE VEHICLE BEGAN SHAKING AND MISFIRING. A BAD PLUG AND THE STABILIZING BAR LINKS WERE REPLACED. THE UNDERCARRIAGE WAS CRA…
Read full complaint
2005 PONTIAC MONTANA SV6 AUTOMATIC SLIDING DOOR OPENS WHILE DRIVING, BAD SENSOR AND BROKE CABLE WAS REPLACED. *CW THE CONSUMER ALSO STATED THE ENGINE FAILED, WHICH ULTIMATELY LED TO AN ENGINE REPLACEMENT. THE VEHICLE BEGAN SHAKING AND MISFIRING. A BAD PLUG AND THE STABILIZING BAR LINKS WERE REPLACED. THE UNDERCARRIAGE WAS CRACKED WHICH WAS CAUSING A LOUD KNOCKING AND THUMPING SOUND UNDER THE VEHICLE. THE CONSUMER ALSO HAD THE SEATS REPLACED WITH AN AFTER MARKET LEATHER KIT BECAUSE STAINS HAD FORMED ON THE SEATS DUE TO MOISTURE. THE CONSUMER LATER DISCOVERED A RECALL HAD BEEN ISSUED BECAUSE THE AFTER MARKET KIT COULD CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. THE CONSUMER WAS INFORMED HIS VEHICLE WAS NOT INCLUDED IN THE RECALL *JB
NHTSA ODI #10226153
32,000 miles · Mar 7, 2008
Service Brakes, HydraulicStructure
BOTH SLIDING DOORS PROBLEM MALFUNCTIONING. DRIVER SLIDER WILL NOT OPEN UNTIL YOU MANUALLY UNLOCK FROM DOOR. PASSENGER DOOR WILL OPEN WITHOUT NOTICE EVEN AFTER NEW MOTOR/MECHANISM REPLACED BY DEALER. ABS SYSTEM FAILURE REPAIRED THREE TIMES IN TWO WEEKS BY DEALER. *TR
NHTSA ODI #10220352
88,032 miles · Dec 6, 2007
Structure
THE "AIR SHOCKS" THAT PROPEL AND HOLD UP THE LIFTGATE OF OUR 2005 PONTIAC MONTANA SV6 FAILED. THERE WAS NO EVIDENCE OF POSSIBLE FAILURE PRIOR TO THE ACTUAL FAILURE. THE LIFT GATE IS EXTREMELY HEAVY AND IT POSES A SAFETY HAZARD. IT DOES NOT HOLD ITSELF UP ONCE OPENED AND SHOULD IT FALL, THE HEAVY LIFTGATE DOOR WOULD SLAM SHUT …
Read full complaint
THE "AIR SHOCKS" THAT PROPEL AND HOLD UP THE LIFTGATE OF OUR 2005 PONTIAC MONTANA SV6 FAILED. THERE WAS NO EVIDENCE OF POSSIBLE FAILURE PRIOR TO THE ACTUAL FAILURE. THE LIFT GATE IS EXTREMELY HEAVY AND IT POSES A SAFETY HAZARD. IT DOES NOT HOLD ITSELF UP ONCE OPENED AND SHOULD IT FALL, THE HEAVY LIFTGATE DOOR WOULD SLAM SHUT INJURING ANYTHING OR ANYONE IN ITS WAY. WE HAVE USED IT ON THE RARE OCCASION THAT WE HAD TO, AND IT IS EXTREMELY DIFFICULT AND HEAVY TO HOLD UP AND OPEN, AND WE MUST GINGERLY CLOSE IT TO PREVENT THE BACK WINDOW FROM BREAKING SHOULD IT CLOSE TOO HARD. WE WERE FORTUNATE THAT OUR FAILURE OCCURRED WHEN WE WERE TRYING TO OPEN IT AND IT WOULDN'T OPEN AS IT SHOULD. WE FEAR THAT A SEVERE INJURY OR DEATH COULD RESULT SHOULD THE FAILURE OF THE LIFTGATE OCCUR WHILE IT IS ALREADY OPEN. *TR
NHTSA ODI #10211043
31,000 miles · Dec 1, 2007
Latches/locks/linkagesStructure
SIDE PASSENGER DOOR OPENS ON IT OWN. *TR
NHTSA ODI #10210464
16,500 miles · Jun 12, 2007
StructureInjury
TL*THE CONTACT OWNS A 2005 PONTIAC MONTANA. THE CONTACT STATED THAT WHEN THE VEHICLE WAS PARKED ON A HILL OR SMALL ANGLE, THE REAR SLIDING DOOR CLOSED WITHOUT WARNING. THE CONTACT STATED THAT THE DOOR HIT HER ON THE ELBOW AND LEFT A BAD BRUISE ON HER ARM. THE DEALER DID NOT INSPECT THE VEHICLE. THE CURRENT MILEAGE IS 17,116 …
Read full complaint
TL*THE CONTACT OWNS A 2005 PONTIAC MONTANA. THE CONTACT STATED THAT WHEN THE VEHICLE WAS PARKED ON A HILL OR SMALL ANGLE, THE REAR SLIDING DOOR CLOSED WITHOUT WARNING. THE CONTACT STATED THAT THE DOOR HIT HER ON THE ELBOW AND LEFT A BAD BRUISE ON HER ARM. THE DEALER DID NOT INSPECT THE VEHICLE. THE CURRENT MILEAGE IS 17,116 AND FAILURE MILEAGE WAS 16,500.
NHTSA ODI #10193019
600 miles · Jun 2, 2006
Exterior LightingStructure
WHISTLE NOISE FROM FRONT OF VEHICLE AROUND 60 MPH. DEALER HAS REPLACED THE FRONT WINDSHIELD SEAL, DOOR SEAL, AND A GASKET UNDER THE HOOD BUT THIS HAS NOT HELPED. THE DEALER TOLD ME THAT THEY DIDN'T HEAR THE WHISTLE UNLESS THEY DROVE IT 90 MPH!!! I WAS TOLD THAT THIS IS A PROBLEM WITH PONTIAC'S DESIGN AND IT CAN NOT BE FIXED. …
Read full complaint
WHISTLE NOISE FROM FRONT OF VEHICLE AROUND 60 MPH. DEALER HAS REPLACED THE FRONT WINDSHIELD SEAL, DOOR SEAL, AND A GASKET UNDER THE HOOD BUT THIS HAS NOT HELPED. THE DEALER TOLD ME THAT THEY DIDN'T HEAR THE WHISTLE UNLESS THEY DROVE IT 90 MPH!!! I WAS TOLD THAT THIS IS A PROBLEM WITH PONTIAC'S DESIGN AND IT CAN NOT BE FIXED. PASSENGER SIDE SLIDING DOOR DOESN'T STAY SHUT AND DOESN'T OPEN WHEN OUTSIDE HANDLE IS PULLED AND MOTOR RUNNING TOO LONG AND GRINDING AFTER DOOR HAS CLOSED. THE DOOR MOTOR HAS BEEN REPLACED YET THERE IS STILL A GRINDING NOISE WHEN THE DOOR SHUTS. HEADLIGHTS SURGING CAUSING ME TO CONSTANTLY BE BRIGHT LIGHTED BY ONCOMING TRAFFIC. THE DEALER TOLD ME THAT THIS IS NORMAL!*JB
NHTSA ODI #10158836
12,252 miles · Sep 23, 2005
Structure
PASSENGER ELECTRIC CARGO DOOR DID NOT OPEN ELECTRICALLY AFTER OUTSIDE DOOR HANDLE WAS USED TO RELEASE LATCHING MECHANISM. VEHICLE WAS DRIVEN WITH NO INDICATION THROUGH THE MONITORING/WARNING SYSTEM THAT THE DOOR WAS NOT FULLY CLOSED AND LOCKED. UNDER GM CASE# 8477192, IT WAS DECIDED TO REPLACE THE DOOR LATCH ACTUATOR FOR A VOLTA…
Read full complaint
PASSENGER ELECTRIC CARGO DOOR DID NOT OPEN ELECTRICALLY AFTER OUTSIDE DOOR HANDLE WAS USED TO RELEASE LATCHING MECHANISM. VEHICLE WAS DRIVEN WITH NO INDICATION THROUGH THE MONITORING/WARNING SYSTEM THAT THE DOOR WAS NOT FULLY CLOSED AND LOCKED. UNDER GM CASE# 8477192, IT WAS DECIDED TO REPLACE THE DOOR LATCH ACTUATOR FOR A VOLTAGE SPIKE ISSUE. *NM
NHTSA ODI #10137396
Mileage unknown · Aug 31, 2005
StructureInjury
MY 3 YEAR OLD SON PUSHED THE BUTTON TO CLOSE THE AUTOMATIC SLIDING SIDE DOOR AND THE DOOR CAUGHT HIS LEFT THUMB AND PART OF THE PALM. I TOOK HIM TO THE IMMEDIATE CARE CENTER AND HE HAD A BONE THAT WAS CHIPPED IN HIS THUMB. THEY PUT A SPLINT ON HIS THUMB AND WAS GOING TO RE X-RAY HIM IN ABOUT A WEEK. *NM
NHTSA ODI #10134973
Mileage unknown · Jun 13, 2005
Structure
I JUST WANT TO INFORM YOU THAT I WAS NOT NOTIFIED BY GM OF EITHER OF THE 2 RECALLS ON MY 2005 PONTIAC MONTANA. THE FIRST AND WORST BEING ID#: 04V597000, WHICH I KNOW FOR SURE AFFECTS MY VEHICLE. THE OTHER BEING ID#: 05V061000, WHICH MAY NOT AFFECT ME DEPENDING ON WHICH SEATS I HAVE IN THE 2ND ROW.
THE BRAUN CORPORATION HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2005-2008 GENERAL MOTORS MOBILITY CONVERSION, HANDICAPPED ACCESSIBLE LOW FLOOR MINIVANS. DURING CONVERSION, THE DRIVER OR PASSENGER SIDE TRAILING ARM MODIFICATION MAY NOT HAVE BEEN ADEQUATELY WELDED.
Consequence & remedy
Consequence: A SQUEAKING OR CLUNKING NOISE MAY DEVELOP. THE TRAILING ARM BUSHINGS MAY PREMATURELY WEAR AND THE TRAILING ARM MAY FRACTURE OR SEPARATE, ALLOWING THE REAR AXLE TO BECOME PARTIALLY SEPARATED FROM THE CHASSIS INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND WILL HAVE A SUPPLY OF RETROFIT PARTS AVAILABLE TO REMEDY THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN AT 1-800-488-0359.
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND THE VEHICLE IN NEUTRAL (N). SOME OF THESE VEHICLES FAILED THIS TEST.
Consequence & remedy
Consequence: WHEN THE PARKING BRAKE IS RELEASED, THE DRIVER MAY NOTICE UNINTENDED BRAKING WHEN ACCELERATING, DECELERATING, OR COASTING, AND A NOISE COMING FROM THE REAR OF THE VEHICLE. UNINTENDED VEHICLE MOVEMENT COULD OCCUR INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT FOR PARKING BRAKE LEVER SLIPPAGE AT EACH REAR BRAKE CALIPER AND REPLACE THE CALIPER IF LEVER SLIPPAGE IS IDENTIFIED. THE RECALL BEGAN ON NOVEMBER 14, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR SATURN AT 1-800-972-8876.
ON CERTAIN MINIVANS, THE OUTBOARD RELEASE HANDLE ON THE IMPACT-SIDE SECOND-ROW BUCKET SEAT MAY BE ACTUATED AND THE REAR LATCHES MAY UNLATCH EARLY IN A SIDE IMPACT CRASH. THIS WAS DISCOVERED IN A SIDE IMPACT TEST RUN BY GM, UNDER CONDITIONS SIMILAR TO NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) SIDE IMPACT TEST.
Consequence & remedy
Consequence: IF THE REAR LATCHES OF THE SEAT RELEASE EARLY IN A SEVERE SIDE IMPACT, THE FRONT OUTBOARD LATCH MAY DISENGAGE AND INCREASE THE POTENTIAL FOR INJURY TO THE OCCUPANT OF THE SEAT.
Remedy: DEALERS WILL REMOVE THE SEAT LATCH RELEASE HANDLE AND INSTALL A BLACK PLASTIC CAP OVER THE EXPOSED METAL STUD TO ELIMINATE THE SIDE IMPACT SAFETY CONCERN FREE OF CHARGE. THE RECALL BEGAN ON APRIL 5, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876, CHEVROLET AT 1-800-630-2438, AND PONTIAC AT 1-800-620-7668.
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA07019 · Power Sliding Door
Opened Dec 11, 2007 · Closed Feb 23, 2009
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
PE07044 · Power Sliding Door Opening
Opened Aug 16, 2007 · Closed Dec 11, 2007
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
PE05063 · Electrical Harness Damage
Opened Nov 29, 2005 · Closed Mar 6, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:front Underhood
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
2005 Pontiac Montana Problems, Complaints & Recalls | Skip That Year
Illustration