DT*: THE CONTACT STATED WHILE DRIVING 50 MPH, THE REAR LEFT SLIDING DOOR OPENED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM. THE MANUFACTURER WAS ALSO NOTIFIED. ALSO, WHEN THE VEHICLE WAS STARTED, THE ELECTRIC STARTER MOTOR STAYED ENGAGED. THE VEHICLE HAD T…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 50 MPH, THE REAR LEFT SLIDING DOOR OPENED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM. THE MANUFACTURER WAS ALSO NOTIFIED. ALSO, WHEN THE VEHICLE WAS STARTED, THE ELECTRIC STARTER MOTOR STAYED ENGAGED. THE VEHICLE HAD TO BE SHUT OFF AND RESTARTED 4 TIMES TO MAKE THE STARTER RETURN TO NORMAL. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE STARTER WAS REPLACED, BUT THE PROBLEM PERSISTED.*AK THE WAS A NOISE COMING FROM THE FRONT OF THE VEHICLE. WHEN THE ENGINE WAS STARTED THE DOOR CHIME WOULD REMAIN ON. THE TRANSMISSION FELT AS THOUGH IT WAS SLIPPING AT TIMES. UPDATED 01/17/07. *JB
NHTSA ODI #10175476
27,000 miles · Nov 11, 2006
Latches/locks/linkages
THE DOOR OPENS BY ITSELF EVEN WHEN IT SHOULD BE LOCKED. *NM
NHTSA ODI #10173200
40,000 miles · Oct 2, 2006
Electrical SystemLatches/locks/linkages
THIS IS A SAFETY ISSUE INVOLVING ABS SYSTEM FOR MY 2005 PONTIAC SV6 MONTANA. ON OR ABOUT AUGUST 11, 2006 MY ABS LIGHT CAME ON WHILE UNDER NORMAL OPERATION OF THE VAN. THIS HAS BEEN AN INTERMITTENT PROBLEM OVER THE PAST 6 WEEKS. I TOOK IT TO A LOCAL INDEPENDENT SHOP TO HAVE IT DIAGNOSED AND THE LOCAL SHOP INFORMED ME THAT THE COD…
Read full complaint
THIS IS A SAFETY ISSUE INVOLVING ABS SYSTEM FOR MY 2005 PONTIAC SV6 MONTANA. ON OR ABOUT AUGUST 11, 2006 MY ABS LIGHT CAME ON WHILE UNDER NORMAL OPERATION OF THE VAN. THIS HAS BEEN AN INTERMITTENT PROBLEM OVER THE PAST 6 WEEKS. I TOOK IT TO A LOCAL INDEPENDENT SHOP TO HAVE IT DIAGNOSED AND THE LOCAL SHOP INFORMED ME THAT THE CODES WERE TO NEW THAT I WOULD HAVE TO TAKE IT TO A DEALERSHIP. AFTER TAKING IT TO THE DEALERSHIP THEY DIAGNOSED IT AS HAVING AN ELECTRICAL PROBLEM. THERE WERE NO FAULTY MODULES BUT THAT THIS WAS A WIRING PROBLEM. I AM THE ONLY OWNER OF AN 05 PONTIAC MONTANA THAT I KNOW. RECENTLY I HAVE HAD VARIOUS OTHER PROBLEMS WITH THE POWER SLIDING DOOR INTERMITTENTLY OPENING WHENEVER YOU ENGAGE THE TRANSMISSION INTO REVERSE (RIGHT SIDE ONLY). MY 6 YEAR OLD SITS IN THE RIGHT REAR SEAT. HOPE THIS DOESN'T HAPPEN WHILE DRIVING DOWN THE HIGHWAY. DOES THIS VEHICLE HAVE FAULTY WIRING OR DO I JUST HAVE BAD LUCK. *JB
NHTSA ODI #10169802
500 miles · Jul 10, 2006
Latches/locks/linkages
DT*: THE CONTACT STATED THE SLIDING DOOR TO THE VEHICLE WAS NOT SHUTTING PROPERLY. THE VEHICLE WAS TAKEN TO THE DEALER 3 TIMES. BOTH THE MANUFACTURER AND DEALER DETERMINED THAT THEY COULD NOT FIX THE PROBLEM WITH THE SLIDING DOOR. THERE WERE NO ACCIDENTS WHICH BEFORE THE PROBLEMS WITH THE SLIDING DOOR, BUT THE CONTACT EXPRESS…
Read full complaint
DT*: THE CONTACT STATED THE SLIDING DOOR TO THE VEHICLE WAS NOT SHUTTING PROPERLY. THE VEHICLE WAS TAKEN TO THE DEALER 3 TIMES. BOTH THE MANUFACTURER AND DEALER DETERMINED THAT THEY COULD NOT FIX THE PROBLEM WITH THE SLIDING DOOR. THERE WERE NO ACCIDENTS WHICH BEFORE THE PROBLEMS WITH THE SLIDING DOOR, BUT THE CONTACT EXPRESSED THAT THE VEHICLE IS TOO DANGEROUS TO DRIVE. ONE DOES NOT KNOW WHEN THE DOOR WILL OPEN. THE DOOR COMES OFF OF THE TRACK AT TIMES.
NHTSA ODI #10162022
3,000 miles · Apr 11, 2006
Latches/locks/linkages
GETTING READY TO LEAVE FROM A SHOPPING CENTER DURING THE MIDDLE OF A SNOW STORM, MY WIFE AND I LOADED BOTH KIDS IN THE BACK OF THE VAN (1 AND 3 YEARS) AND TRIED TO CLOSE THE DOORS. THE AUTOMATIC DOORS WOULD NOT CLOSE. WE TRIED THE KEY FOB, THE UPPER ROOF CONSOLE BUTTONS AND THE BUTTONS ON THE B-POSTS. NOTHING WORKED. WE THEN…
Read full complaint
GETTING READY TO LEAVE FROM A SHOPPING CENTER DURING THE MIDDLE OF A SNOW STORM, MY WIFE AND I LOADED BOTH KIDS IN THE BACK OF THE VAN (1 AND 3 YEARS) AND TRIED TO CLOSE THE DOORS. THE AUTOMATIC DOORS WOULD NOT CLOSE. WE TRIED THE KEY FOB, THE UPPER ROOF CONSOLE BUTTONS AND THE BUTTONS ON THE B-POSTS. NOTHING WORKED. WE THEN TRIED MANUALLY TO CLOSE THE DOORS BUT THEY WOULD NOT LATCH. WE TURNED THE IGNITION KEY ON AND OFF THE 3 TIMES AND TRIED TO USE BUTTONS AFTER EACH RESTART. FINALLY AFTER TEN MINUTES OF TRYING WE GOT THEM TO CLOSE AND LATCH BY USING THE KEY FOB. THE VEHICLE WAS TAKEN TO THE DEALER AND THE REPAIR SHEET INDICATES THEY REPLACED THE MODULE AND THE FOBS. IT HAS ONLY HAPPENED ONCE SINCE THEN, BUT I AM NOT SURE IF THE REPAIR THAT WAS DONE IS ADEQUATE SINCE IT HAS HAPPENED AGAIN SINCE THE REPAIR. *NM
NHTSA ODI #10155069
800 miles · Dec 6, 2005
Air BagsLatches/locks/linkagesService Brakes, Hydraulic
DT: THE CONTACT STATED WHEN RELEASING BRAKE PRESSURE ON AN INCLINE THE VEHICLE ROLLED BACK. THE PASSENGER'S AIR BAG LIGHT ILLUMINATED INTERMITTENTLY. ALSO, WHILE DRIVING THE REMOTE CONTROL DOORS OPEN AND CLOSE, AND POWER DOOR LOCKS LOCK AND UNLOCK. THE DEALER NOTED THIS WAS NORMAL, AND NO REPAIRS HAVE BEEN MADE. *AK …
Read full complaint
DT: THE CONTACT STATED WHEN RELEASING BRAKE PRESSURE ON AN INCLINE THE VEHICLE ROLLED BACK. THE PASSENGER'S AIR BAG LIGHT ILLUMINATED INTERMITTENTLY. ALSO, WHILE DRIVING THE REMOTE CONTROL DOORS OPEN AND CLOSE, AND POWER DOOR LOCKS LOCK AND UNLOCK. THE DEALER NOTED THIS WAS NORMAL, AND NO REPAIRS HAVE BEEN MADE. *AK
NHTSA ODI #10144582
2,000 miles · Nov 18, 2005
Latches/locks/linkagesSuspension
DT: THE CONTACT STATED WHILE DRIVING VEHICLE WOULD SWAY BACK AND FORTH REGARDLESS OF SPEED. THE VEHICLE HAS BEEN TO THE DEALER SEVERAL TIMES, BUT THEY COULD NOT FIND THE CAUSE OF THE PROBLEM. ANOTHER SAFETY CONCERN WAS THE AUTOMATIC DOOR. IT WAS NOT EQUIPPED WITH A SAFETY DEVICE TO KEEP THE DOOR FROM COMING OPEN WHEN IT …
Read full complaint
DT: THE CONTACT STATED WHILE DRIVING VEHICLE WOULD SWAY BACK AND FORTH REGARDLESS OF SPEED. THE VEHICLE HAS BEEN TO THE DEALER SEVERAL TIMES, BUT THEY COULD NOT FIND THE CAUSE OF THE PROBLEM. ANOTHER SAFETY CONCERN WAS THE AUTOMATIC DOOR. IT WAS NOT EQUIPPED WITH A SAFETY DEVICE TO KEEP THE DOOR FROM COMING OPEN WHEN IT WAS NOT INTENDED TO OPEN. FOR EXAMPLE, WHILE FUELING THE VEHICLE, IF SOMEONE ACCIDENTALLY HIT THE INSIDE HANDLE IT WILL NOT STOP UNLESS SHE MANUALLY TRIED TO CLOSE THE DOOR FROM THE OUTSIDE. THE VEHICLE HAS NOT BEEN INSPECTED TO DETERMINE WHY THIS HAPPENED.*AK
NHTSA ODI #10143089
25 miles · Sep 20, 2005
Latches/locks/linkages
DT: THE CALLER WAS HAVING PROBLEMS WITH THE PASSENGER'S SIDE SLIDING DOOR. THE MOTOR RAN EVEN AFTER THE DOOR WAS SHUT. ONCE, THE DOOR DID NOT RETRACT WHEN HER CHILD WAS GETTING OUT, AND THE DOOR TRAPPED HER. CHILD WAS NOT HURT. DEALER COULD NOT DUPLICATE THE PROBLEM. DEALER SHAVED THE DOOR ON THE INSIDE AND REPLACED THE MOTOR…
Read full complaint
DT: THE CALLER WAS HAVING PROBLEMS WITH THE PASSENGER'S SIDE SLIDING DOOR. THE MOTOR RAN EVEN AFTER THE DOOR WAS SHUT. ONCE, THE DOOR DID NOT RETRACT WHEN HER CHILD WAS GETTING OUT, AND THE DOOR TRAPPED HER. CHILD WAS NOT HURT. DEALER COULD NOT DUPLICATE THE PROBLEM. DEALER SHAVED THE DOOR ON THE INSIDE AND REPLACED THE MOTOR. THE CALLER STATED THAT THE MOTOR STILL RAN AT TIMES AFTER THE DOOR WAS CLOSED. MANUFACTURER SAID BECAUSE THEY WENT TO COURT THEY WILL HAVE TO START OVER AGAIN WITH REPORTING THE PROBLEMS WITH THE VAN. A POLICE REPORT WAS TAKEN BECAUSE THE CALLER'S PURSE WAS STOLEN OUT OF THE VAN AFTER A RECALL ON THE AUTOMATIC DOOR LOCKS. RECALL WORK WAS DONE ON THE LOCKS.*AK
NHTSA ODI #10137045
15,759 miles · Dec 28, 2004
Latches/locks/linkagesInjury
THE POWER SLIDING DOOR BEGAN TO CLOSE WITHOUT WARNING. THE PASSENGERS WRIST WAS CAUGHT IN THE HANDLE OF THE DOOR. AS A RESULT, THE PASSENGER'S RIGHT WRIST WAS BROKEN . PLEASE PROVIDE ADDITIONAL INFORMATION. *JB
THE BRAUN CORPORATION HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2005-2008 GENERAL MOTORS MOBILITY CONVERSION, HANDICAPPED ACCESSIBLE LOW FLOOR MINIVANS. DURING CONVERSION, THE DRIVER OR PASSENGER SIDE TRAILING ARM MODIFICATION MAY NOT HAVE BEEN ADEQUATELY WELDED.
Consequence & remedy
Consequence: A SQUEAKING OR CLUNKING NOISE MAY DEVELOP. THE TRAILING ARM BUSHINGS MAY PREMATURELY WEAR AND THE TRAILING ARM MAY FRACTURE OR SEPARATE, ALLOWING THE REAR AXLE TO BECOME PARTIALLY SEPARATED FROM THE CHASSIS INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND WILL HAVE A SUPPLY OF RETROFIT PARTS AVAILABLE TO REMEDY THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 4, 2010. OWNERS MAY CONTACT BRAUN AT 1-800-488-0359.
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND THE VEHICLE IN NEUTRAL (N). SOME OF THESE VEHICLES FAILED THIS TEST.
Consequence & remedy
Consequence: WHEN THE PARKING BRAKE IS RELEASED, THE DRIVER MAY NOTICE UNINTENDED BRAKING WHEN ACCELERATING, DECELERATING, OR COASTING, AND A NOISE COMING FROM THE REAR OF THE VEHICLE. UNINTENDED VEHICLE MOVEMENT COULD OCCUR INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT FOR PARKING BRAKE LEVER SLIPPAGE AT EACH REAR BRAKE CALIPER AND REPLACE THE CALIPER IF LEVER SLIPPAGE IS IDENTIFIED. THE RECALL BEGAN ON NOVEMBER 14, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR SATURN AT 1-800-972-8876.
ON CERTAIN MINIVANS, THE OUTBOARD RELEASE HANDLE ON THE IMPACT-SIDE SECOND-ROW BUCKET SEAT MAY BE ACTUATED AND THE REAR LATCHES MAY UNLATCH EARLY IN A SIDE IMPACT CRASH. THIS WAS DISCOVERED IN A SIDE IMPACT TEST RUN BY GM, UNDER CONDITIONS SIMILAR TO NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) SIDE IMPACT TEST.
Consequence & remedy
Consequence: IF THE REAR LATCHES OF THE SEAT RELEASE EARLY IN A SEVERE SIDE IMPACT, THE FRONT OUTBOARD LATCH MAY DISENGAGE AND INCREASE THE POTENTIAL FOR INJURY TO THE OCCUPANT OF THE SEAT.
Remedy: DEALERS WILL REMOVE THE SEAT LATCH RELEASE HANDLE AND INSTALL A BLACK PLASTIC CAP OVER THE EXPOSED METAL STUD TO ELIMINATE THE SIDE IMPACT SAFETY CONCERN FREE OF CHARGE. THE RECALL BEGAN ON APRIL 5, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876, CHEVROLET AT 1-800-630-2438, AND PONTIAC AT 1-800-620-7668.
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA07019 · Power Sliding Door
Opened Dec 11, 2007 · Closed Feb 23, 2009
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
PE07044 · Power Sliding Door Opening
Opened Aug 16, 2007 · Closed Dec 11, 2007
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
PE05063 · Electrical Harness Damage
Opened Nov 29, 2005 · Closed Mar 6, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:front Underhood
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
2005 Pontiac Montana Problems, Complaints & Recalls | Skip That Year
Illustration