IllustrationDURING INSPECTION OF THE FRONT SUSPENSION, NOTICED THAT THE FRONT TIRES WERE RUBBING AGAINST A METAL PLATE ON THE FRONT STRUTS. THIS CAUSED THE PAINT ON THE STRUB TO WEAR AND THE RUBBER TIRE WILL EVENTUALLY BE DAMAGED BY CONSTANTLY RUBBING AGAINST STEEL. *JB
2005 Pontiac Gto
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Pontiac Gto do not stand out strongly from the model-year median of 154.
About this comparison →How this year compares
Owner complaints by model year
Compare all Gto years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
870–25K
1925–50K
650–75K
475–100K
4100–150K
2150K+
122 reports with mileage · 32 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Tires. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports2 fire reports4 injury reports
Suspension complaints
100 reportsALIGNMENT IS BAD OUT OF THE FACTORY AND THE TIRES ARE RUBBING AGAINST THE FRONT STRUTS. COMMON PROBLEM ACCORDING TO ONLINE FORUMS. TIRES ARE WORN TO THE BELTS ON THE INSIDE. CAR ONLY HAS 17000 MILES.*AK
WHEN ROTATING MY TIRES AT 6000 MILES, I NOTICED THAT THERE WAS PAIN MISSING ON THE FRONT STRUTS BY THE TOP OF THE TIRES. ON THE PASSENGER SIDE THERE WAS ALSO A SMALL BUILD UP OF RUBBER ON THE STRUT AND VISIBLE WEAR ON THE TIRE. I LOOKED UP ON A GTO FORUM AND FOUND THAT THIS IS A COMMON PROBLEM. I TOOK THE CAR TO THE DEALER AN…
Read full complaint
WHEN ROTATING MY TIRES AT 6000 MILES, I NOTICED THAT THERE WAS PAIN MISSING ON THE FRONT STRUTS BY THE TOP OF THE TIRES. ON THE PASSENGER SIDE THERE WAS ALSO A SMALL BUILD UP OF RUBBER ON THE STRUT AND VISIBLE WEAR ON THE TIRE. I LOOKED UP ON A GTO FORUM AND FOUND THAT THIS IS A COMMON PROBLEM. I TOOK THE CAR TO THE DEALER AND INFORMED THEM OF THE INFORMATION I FOUND ON THE INTERNET. THE DEALER REALIGNED THE FRONT WHEELS BECAUSE THEY HAD TOO MUCH NEGATIVE CAMBER. THE PEOPLE ON THE FORUMS THINK THE REAL PROBLEM IS THAT THE FRONT STRUT BUSHINGS HAVE COLLAPSED FROM BEING TIED DOWN DURING TRANSPORTATION FROM AUSTRALIA. TIME WILL TELL IF THE REALIGNMENT FIXED MY PROBLEM BUT I SUSPECT THAT THE FRONT STRUT BUSHINGS WILL COLLAPSE EVEN MORE OVER TIME AND THE TIRE RUB ISSUE WILL BE BACK.*AK
CUPPING OF IN SIDE TIRE. *JB
REAR SPRINGS ARE WEAK CAUSING REAR HEIGHT TO BE 1" OUT OF SPEC CREATING ACCELERATED REAR TIRE WEAR. REQUEST NEW REAR SPRINGS TO CORRECT PROBLEM. *JB
RIGHT FRONT TIRE HAS EXCESSIVE WEAR ON INSIDE. THIS WAS NOTICED AT EACH TIRE ROTATION AND NOW THE VEHICLE HAS 18000 MILES AND IS SHOWING MORE WEAR THAN SHOULD BE. *JB
I DISCOVERED SEVERE INSIDE TIRE DAMAGE AT ONLY 17,000 MILES. RESEARCH FOUND THAT MANY OTHER 2005 PONTIAC GTO'S ARE SUFFERING FROM SIMILAR DAMAGE DUE TO THE FRONT TIRES RUBBING ON THE STRUTS. I TOOK THE CAR TO MY LOCAL DEALER, AND HE REFUSED TO DO ANY ASIDE FROM SELLING ME TWO NEW TIRES AND AN ALIGNMENT. *JB
I PURCHASED A PONTIAC GTO ONE WEEK PRIOR TO THE INCIDENT. I HAD MY TIRES REPLACED BY THE DEALER CONSISTENT WITH A WRITTEN AGREEMENT BETWEEN THE CAR DEALER AND I. THE TIRE TECH WHO REPLACED MY TIRES WANTED ME TO SEE ONE OF THE TIRES, IT WAS SLICED ON THE INSIDE , HIDDEN PART OF THE TIRE. THE TIRE DID NOT FAIL BECAUSE OF THIS, B…
Read full complaint
I PURCHASED A PONTIAC GTO ONE WEEK PRIOR TO THE INCIDENT. I HAD MY TIRES REPLACED BY THE DEALER CONSISTENT WITH A WRITTEN AGREEMENT BETWEEN THE CAR DEALER AND I. THE TIRE TECH WHO REPLACED MY TIRES WANTED ME TO SEE ONE OF THE TIRES, IT WAS SLICED ON THE INSIDE , HIDDEN PART OF THE TIRE. THE TIRE DID NOT FAIL BECAUSE OF THIS, BUT WAS VERY CLOSE TO DOING SO. COULD BE DEADLY AT FREEWAY SPEEDS IF IT HAD FAILED THERE. THEN I READ AN ONLINE ARTICLE ON THIS VERY CONDITION, AND FOLLOWED THE LINKS AT THIS POINT. I CAN'T BELIEVE THAT THE CAR MANUFACTURER HAS BEEN ALLOWED TO LET THIS HAPPEN AND NOT COME UP WITH A SOLUTION TO AN OBVIOUS MANUFACTURER DEFECT. *JB
THREE TIRE REPLACEMENTS DUE TO TIRE BLOW OUTS AT UNSAFE SPEEDS DURING THE PAST YEAR (2006-2007). MECHANICS NOTED RUBBING OF BOTH FRONT TIRES AGAINST THE STRUTS OF MY 2005 PONTIAC GTO. *JB
TL*- THE CONTACT STATED THAT ON A ROUTINE TIRE ROTATION ON THE 2005 PONTIAC GTO WITH 11700 CURRENT MILEAGE THE TIRE SHOP DISCOVERED THAT THE FRONT STRUTS WERE RUBBING AGAINST THE TIRES. AND THE TIRES WERE WORN ON THE INSIDE. THE CONTACT STATED THAT THERE WERE NO FAILURES. THE VEHICLE WAS TAKEN TO A DEALER, AND THE PROBLEM WI…
Read full complaint
TL*- THE CONTACT STATED THAT ON A ROUTINE TIRE ROTATION ON THE 2005 PONTIAC GTO WITH 11700 CURRENT MILEAGE THE TIRE SHOP DISCOVERED THAT THE FRONT STRUTS WERE RUBBING AGAINST THE TIRES. AND THE TIRES WERE WORN ON THE INSIDE. THE CONTACT STATED THAT THERE WERE NO FAILURES. THE VEHICLE WAS TAKEN TO A DEALER, AND THE PROBLEM WILL BE REPAIRED SOON. THE CONTACT WAS NOT SURE WHAT TYPE OF STRUT HE HAD, HE STATED THAT WAS PART OF THE ORIGINAL EQUIPMENT.*AK UPDATED 04/05/07.*JB
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE07010 · Front Strut To Tire Interference
Opened Feb 16, 2007 · Closed Aug 8, 2007
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:macpherson Strut; Tires; Tires:sidewall
NOTE: THE COMPLAINT AND WARRANTY COUNTS GIVEN IN THE FAILURE REPORT SUMMARY OF THIS RESUME INCLUDE ALL RECORDS RELATED TO TIRE WEAR AND WHEEL ALIGNMENT AND ARE NOT LIMITED TO TIRE-STRUT CONTACT.GENERAL MOTORS (GM) IDENTIFIED TWO CONTRIBUTORS TO PREMATURE FRONT TIRE WEAR IN THE SUBJECT VEHICLES.ONE OF THE CONTRIBUTORS CAUSING THE PREMATURE TIRE WEAR WAS OUT OF SPECIFICATION NEGATIVE CAMBER.GM STATED THAT EXCESSIVE NEGATIVE CAMBER COULD BE CAUSED BY IMPROPER CAMBER SETTINGS FROM THE FACTORY OR BENDING OF THE FRONT STRUT ASSEMBLIES DUE TO SHARP ROAD IMPACT (I.E., SEVERE POT HOLES).TO IMPROVE CAMBER SETTINGS FROM THE FACTORY, GM STATED THAT FROM FEBRUARY OF 2005 THROUGH MAY OF 2006 SEVERAL MODIFICATIONS WERE MADE TO THE CAMBER SETTING FIXTURE.GM ALSO NOTED THAT EXCESSIVE NEGATIVE CAMBER COULD RESULT IN FRONT TIRE TO STRUT CONTACT, WHICH COULD ALSO BE CAUSED BY USE OF NON-ORIGINAL EQUIPMENT (OE) TIRES AND/OR WHEELS.GM STATED THAT CONTACT OF THE FRONT TIRE AND FRONT STRUT ASSEMBLY CAN CAUSE A POLISHING ON THE TIRE SIDEWALL AND/OR STRUT ASSEMBLY; HOWEVER, THIS DOES NOT CAUSE A SUDDEN LOSS OF AIR. GENERAL MOTORS PROVIDED ODI WITH THE FINAL FACTORY FRONT CAMBER SETTINGS WHERE AVAILABLE FOR COMPLAINT AND WARRANTY CLAIM VEHICLES.APPROXIMATELY 90 PERCENT OF THESE VEHICLES HAD RIGHT WHEEL CAMBER SETTINGS THAT WERE OUT OF DESIGN SPECIFICATION.FOUR PERCENT OF THE VEHICLES HAD LEFT WHEEL CAMBER SETTINGS THAT WERE OUT OF SPECIFICATION.IN A REVIEW OF CONSUMER COMPLAINTS, MOST NOTED EXCESSIVE TIRE WEAR TO VARYING DEGREES TO BOTH FRONT TIRES.FOR COMPLAINTS INDICATING EXCESSIVE WEAR TO A SINGLE FRONT TIRE, 90 PERCENT INVOLVED THE RIGHT SIDE. ALTHOUGH IN SOME CASES THERE ARE INDICATIONS OF TIRE CONTACT WITH FRONT STRUT ASSEMBLIES IN THE SUBJECT VEHICLES, ANALYSIS OF TIRE WEAR PATTERNS IN PHOTOGRAPHS SHOWS THE GREATEST WEAR OCCURRING ON THE INBOARD TREAD SURFACE FROM ROAD WEAR AND NOT ON THE AREA OF THE TIRE ON THE UPPER SHOULDER THAT CONTACTS THE STRUT.THIS IS CONSISTENT WITH THE KNOWN TIRE WEAR PATTERNS ASSOCIATED WITH EXCESSIVE NEGATIVE CAMBER, WITH OR WITHOUT STRUT CONTACT.THIS IS MOST APPARENT IN SOME PICTURES, WHICH SHOW MINOR TIRE-STRUT CONTACT WHILE EXHIBITING SIGNIFICANT WEAR OF THE INNER TREAD SURFACE OF THE TIRES.BASED ON DATA REVIEWED DURING THE INVESTIGATION, WHILE EXCESSIVE NEGATIVE CAMBER IS AN APPARENT ISSUE, THE PREMATURE TIRE WEAR APPEARS TO BE PRIMARILY CAUSED BY TIRE TO ROAD SURFACE CONTACT AS OPPOSED TO CONTACT OF THE FRONT TIRES TO THE FRONT STRUT ASSEMBLIES.ODI REVIEWED APPROXIMATELY 1,400 TOTAL COMPLAINTS AND WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT.VIRTUALLY ALL OF THE REPORTS RELATE TO UNEVEN/EXCESSIVE TIRE WEAR OR SOME AWARENESS OF THE TIRE-STRUT CONTACT ISSUE.ODI WAS ABLE TO IDENTIFY 9 TIRE AIR LOSS INCIDENTS ALLEGED TO BE CAUSED BY TIRE-STRUT CONTACT, WITH5 OF THESE DESCRIBING A SLOW AIR LOSS.WHILE THERE WAS EVIDENCE OF TIRE-STRUT CONTACT IN SOME OF THESE VEHICLES, ODI'S ANALYSIS DID NOT FIND THAT THIS CONTACT WAS THE CAUSE OF THE AIR LOSS BUT RATHER A SECONDARY SYMPTOM OF THE EXCESSIVE NEGATIVE CAMBER CONDITION THAT RESULTS IN RAPID ROAD WEAR ON THE INBOARD TREAD SURFACE. ODI IS AWARE OF ONE CRASH ALLEGED TO BE CAUSED BY CONTACT OF THE FRONT STRUT TO FRONT TIRE.HOWEVER, ANALYSIS OF THE INFORMATION PROVIDED BY THE CONSUMER, GM AND A THIRD PARTY INVESTIGATOR DOES NOT INDICATE THAT TIRE-STRUT CONTACT WAS A FACTOR IN THE CRASH.ODI IS UNAWARE OF ANY INJURIES OR FATALITIES ATTRIBUTED TO THE ALLEGED DEFECT. ODI HAS NOT IDENTIFIED A SAFETY RELATED DEFECT TREND IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF TH
Additional source detail variants (5)
Suspension:front
NOTE: THE COMPLAINT AND WARRANTY COUNTS GIVEN IN THE FAILURE REPORT SUMMARY OF THIS RESUME INCLUDE ALL RECORDS RELATED TO TIRE WEAR AND WHEEL ALIGNMENT AND ARE NOT LIMITED TO TIRE-STRUT CONTACT.GENERAL MOTORS (GM) IDENTIFIED TWO CONTRIBUTORS TO PREMATURE FRONT TIRE WEAR IN THE SUBJECT VEHICLES.ONE OF THE CONTRIBUTORS CAUSING THE PREMATURE TIRE WEAR WAS OUT OF SPECIFICATION NEGATIVE CAMBER.GM STATED THAT EXCESSIVE NEGATIVE CAMBER COULD BE CAUSED BY IMPROPER CAMBER SETTINGS FROM THE FACTORY OR BENDING OF THE FRONT STRUT ASSEMBLIES DUE TO SHARP ROAD IMPACT (I.E., SEVERE POT HOLES).TO IMPROVE CAMBER SETTINGS FROM THE FACTORY, GM STATED THAT FROM FEBRUARY OF 2005 THROUGH MAY OF 2006 SEVERAL MODIFICATIONS WERE MADE TO THE CAMBER SETTING FIXTURE.GM ALSO NOTED THAT EXCESSIVE NEGATIVE CAMBER COULD RESULT IN FRONT TIRE TO STRUT CONTACT, WHICH COULD ALSO BE CAUSED BY USE OF NON-ORIGINAL EQUIPMENT (OE) TIRES AND/OR WHEELS.GM STATED THAT CONTACT OF THE FRONT TIRE AND FRONT STRUT ASSEMBLY CAN CAUSE A POLISHING ON THE TIRE SIDEWALL AND/OR STRUT ASSEMBLY; HOWEVER, THIS DOES NOT CAUSE A SUDDEN LOSS OF AIR. GENERAL MOTORS PROVIDED ODI WITH THE FINAL FACTORY FRONT CAMBER SETTINGS WHERE AVAILABLE FOR COMPLAINT AND WARRANTY CLAIM VEHICLES.APPROXIMATELY 90 PERCENT OF THESE VEHICLES HAD RIGHT WHEEL CAMBER SETTINGS THAT WERE OUT OF DESIGN SPECIFICATION.FOUR PERCENT OF THE VEHICLES HAD LEFT WHEEL CAMBER SETTINGS THAT WERE OUT OF SPECIFICATION.IN A REVIEW OF CONSUMER COMPLAINTS, MOST NOTED EXCESSIVE TIRE WEAR TO VARYING DEGREES TO BOTH FRONT TIRES.FOR COMPLAINTS INDICATING EXCESSIVE WEAR TO A SINGLE FRONT TIRE, 90 PERCENT INVOLVED THE RIGHT SIDE. ALTHOUGH IN SOME CASES THERE ARE INDICATIONS OF TIRE CONTACT WITH FRONT STRUT ASSEMBLIES IN THE SUBJECT VEHICLES, ANALYSIS OF TIRE WEAR PATTERNS IN PHOTOGRAPHS SHOWS THE GREATEST WEAR OCCURRING ON THE INBOARD TREAD SURFACE FROM ROAD WEAR AND NOT ON THE AREA OF THE TIRE ON THE UPPER SHOULDER THAT CONTACTS THE STRUT.THIS IS CONSISTENT WITH THE KNOWN TIRE WEAR PATTERNS ASSOCIATED WITH EXCESSIVE NEGATIVE CAMBER, WITH OR WITHOUT STRUT CONTACT.THIS IS MOST APPARENT IN SOME PICTURES, WHICH SHOW MINOR TIRE-STRUT CONTACT WHILE EXHIBITING SIGNIFICANT WEAR OF THE INNER TREAD SURFACE OF THE TIRES.BASED ON DATA REVIEWED DURING THE INVESTIGATION, WHILE EXCESSIVE NEGATIVE CAMBER IS AN APPARENT ISSUE, THE PREMATURE TIRE WEAR APPEARS TO BE PRIMARILY CAUSED BY TIRE TO ROAD SURFACE CONTACT AS OPPOSED TO CONTACT OF THE FRONT TIRES TO THE FRONT STRUT ASSEMBLIES.ODI REVIEWED APPROXIMATELY 1,400 TOTAL COMPLAINTS AND WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT.VIRTUALLY ALL OF THE REPORTS RELATE TO UNEVEN/EXCESSIVE TIRE WEAR OR SOME AWARENESS OF THE TIRE-STRUT CONTACT ISSUE.ODI WAS ABLE TO IDENTIFY 9 TIRE AIR LOSS INCIDENTS ALLEGED TO BE CAUSED BY TIRE-STRUT CONTACT, WITH5 OF THESE DESCRIBING A SLOW AIR LOSS.WHILE THERE WAS EVIDENCE OF TIRE-STRUT CONTACT IN SOME OF THESE VEHICLES, ODI'S ANALYSIS DID NOT FIND THAT THIS CONTACT WAS THE CAUSE OF THE AIR LOSS BUT RATHER A SECONDARY SYMPTOM OF THE EXCESSIVE NEGATIVE CAMBER CONDITION THAT RESULTS IN RAPID ROAD WEAR ON THE INBOARD TREAD SURFACE. ODI IS AWARE OF ONE CRASH ALLEGED TO BE CAUSED BY CONTACT OF THE FRONT STRUT TO FRONT TIRE.HOWEVER, ANALYSIS OF THE INFORMATION PROVIDED BY THE CONSUMER, GM AND A THIRD PARTY INVESTIGATOR DOES NOT INDICATE THAT TIRE-STRUT CONTACT WAS A FACTOR IN THE CRASH.ODI IS UNAWARE OF ANY INJURIES OR FATALITIES ATTRIBUTED TO THE ALLEGED DEFECT. ODI HAS NOT IDENTIFIED A SAFETY RELATED DEFECT TREND IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF TH
Suspension:front:macpherson Strut
NOTE: THE COMPLAINT AND WARRANTY COUNTS GIVEN IN THE FAILURE REPORT SUMMARY OF THIS RESUME INCLUDE ALL RECORDS RELATED TO TIRE WEAR AND WHEEL ALIGNMENT AND ARE NOT LIMITED TO TIRE-STRUT CONTACT.GENERAL MOTORS (GM) IDENTIFIED TWO CONTRIBUTORS TO PREMATURE FRONT TIRE WEAR IN THE SUBJECT VEHICLES.ONE OF THE CONTRIBUTORS CAUSING THE PREMATURE TIRE WEAR WAS OUT OF SPECIFICATION NEGATIVE CAMBER.GM STATED THAT EXCESSIVE NEGATIVE CAMBER COULD BE CAUSED BY IMPROPER CAMBER SETTINGS FROM THE FACTORY OR BENDING OF THE FRONT STRUT ASSEMBLIES DUE TO SHARP ROAD IMPACT (I.E., SEVERE POT HOLES).TO IMPROVE CAMBER SETTINGS FROM THE FACTORY, GM STATED THAT FROM FEBRUARY OF 2005 THROUGH MAY OF 2006 SEVERAL MODIFICATIONS WERE MADE TO THE CAMBER SETTING FIXTURE.GM ALSO NOTED THAT EXCESSIVE NEGATIVE CAMBER COULD RESULT IN FRONT TIRE TO STRUT CONTACT, WHICH COULD ALSO BE CAUSED BY USE OF NON-ORIGINAL EQUIPMENT (OE) TIRES AND/OR WHEELS.GM STATED THAT CONTACT OF THE FRONT TIRE AND FRONT STRUT ASSEMBLY CAN CAUSE A POLISHING ON THE TIRE SIDEWALL AND/OR STRUT ASSEMBLY; HOWEVER, THIS DOES NOT CAUSE A SUDDEN LOSS OF AIR. GENERAL MOTORS PROVIDED ODI WITH THE FINAL FACTORY FRONT CAMBER SETTINGS WHERE AVAILABLE FOR COMPLAINT AND WARRANTY CLAIM VEHICLES.APPROXIMATELY 90 PERCENT OF THESE VEHICLES HAD RIGHT WHEEL CAMBER SETTINGS THAT WERE OUT OF DESIGN SPECIFICATION.FOUR PERCENT OF THE VEHICLES HAD LEFT WHEEL CAMBER SETTINGS THAT WERE OUT OF SPECIFICATION.IN A REVIEW OF CONSUMER COMPLAINTS, MOST NOTED EXCESSIVE TIRE WEAR TO VARYING DEGREES TO BOTH FRONT TIRES.FOR COMPLAINTS INDICATING EXCESSIVE WEAR TO A SINGLE FRONT TIRE, 90 PERCENT INVOLVED THE RIGHT SIDE. ALTHOUGH IN SOME CASES THERE ARE INDICATIONS OF TIRE CONTACT WITH FRONT STRUT ASSEMBLIES IN THE SUBJECT VEHICLES, ANALYSIS OF TIRE WEAR PATTERNS IN PHOTOGRAPHS SHOWS THE GREATEST WEAR OCCURRING ON THE INBOARD TREAD SURFACE FROM ROAD WEAR AND NOT ON THE AREA OF THE TIRE ON THE UPPER SHOULDER THAT CONTACTS THE STRUT.THIS IS CONSISTENT WITH THE KNOWN TIRE WEAR PATTERNS ASSOCIATED WITH EXCESSIVE NEGATIVE CAMBER, WITH OR WITHOUT STRUT CONTACT.THIS IS MOST APPARENT IN SOME PICTURES, WHICH SHOW MINOR TIRE-STRUT CONTACT WHILE EXHIBITING SIGNIFICANT WEAR OF THE INNER TREAD SURFACE OF THE TIRES.BASED ON DATA REVIEWED DURING THE INVESTIGATION, WHILE EXCESSIVE NEGATIVE CAMBER IS AN APPARENT ISSUE, THE PREMATURE TIRE WEAR APPEARS TO BE PRIMARILY CAUSED BY TIRE TO ROAD SURFACE CONTACT AS OPPOSED TO CONTACT OF THE FRONT TIRES TO THE FRONT STRUT ASSEMBLIES.ODI REVIEWED APPROXIMATELY 1,400 TOTAL COMPLAINTS AND WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT.VIRTUALLY ALL OF THE REPORTS RELATE TO UNEVEN/EXCESSIVE TIRE WEAR OR SOME AWARENESS OF THE TIRE-STRUT CONTACT ISSUE.ODI WAS ABLE TO IDENTIFY 9 TIRE AIR LOSS INCIDENTS ALLEGED TO BE CAUSED BY TIRE-STRUT CONTACT, WITH5 OF THESE DESCRIBING A SLOW AIR LOSS.WHILE THERE WAS EVIDENCE OF TIRE-STRUT CONTACT IN SOME OF THESE VEHICLES, ODI'S ANALYSIS DID NOT FIND THAT THIS CONTACT WAS THE CAUSE OF THE AIR LOSS BUT RATHER A SECONDARY SYMPTOM OF THE EXCESSIVE NEGATIVE CAMBER CONDITION THAT RESULTS IN RAPID ROAD WEAR ON THE INBOARD TREAD SURFACE. ODI IS AWARE OF ONE CRASH ALLEGED TO BE CAUSED BY CONTACT OF THE FRONT STRUT TO FRONT TIRE.HOWEVER, ANALYSIS OF THE INFORMATION PROVIDED BY THE CONSUMER, GM AND A THIRD PARTY INVESTIGATOR DOES NOT INDICATE THAT TIRE-STRUT CONTACT WAS A FACTOR IN THE CRASH.ODI IS UNAWARE OF ANY INJURIES OR FATALITIES ATTRIBUTED TO THE ALLEGED DEFECT. ODI HAS NOT IDENTIFIED A SAFETY RELATED DEFECT TREND IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF TH
Suspension
NOTE: THE COMPLAINT AND WARRANTY COUNTS GIVEN IN THE FAILURE REPORT SUMMARY OF THIS RESUME INCLUDE ALL RECORDS RELATED TO TIRE WEAR AND WHEEL ALIGNMENT AND ARE NOT LIMITED TO TIRE-STRUT CONTACT.GENERAL MOTORS (GM) IDENTIFIED TWO CONTRIBUTORS TO PREMATURE FRONT TIRE WEAR IN THE SUBJECT VEHICLES.ONE OF THE CONTRIBUTORS CAUSING THE PREMATURE TIRE WEAR WAS OUT OF SPECIFICATION NEGATIVE CAMBER.GM STATED THAT EXCESSIVE NEGATIVE CAMBER COULD BE CAUSED BY IMPROPER CAMBER SETTINGS FROM THE FACTORY OR BENDING OF THE FRONT STRUT ASSEMBLIES DUE TO SHARP ROAD IMPACT (I.E., SEVERE POT HOLES).TO IMPROVE CAMBER SETTINGS FROM THE FACTORY, GM STATED THAT FROM FEBRUARY OF 2005 THROUGH MAY OF 2006 SEVERAL MODIFICATIONS WERE MADE TO THE CAMBER SETTING FIXTURE.GM ALSO NOTED THAT EXCESSIVE NEGATIVE CAMBER COULD RESULT IN FRONT TIRE TO STRUT CONTACT, WHICH COULD ALSO BE CAUSED BY USE OF NON-ORIGINAL EQUIPMENT (OE) TIRES AND/OR WHEELS.GM STATED THAT CONTACT OF THE FRONT TIRE AND FRONT STRUT ASSEMBLY CAN CAUSE A POLISHING ON THE TIRE SIDEWALL AND/OR STRUT ASSEMBLY; HOWEVER, THIS DOES NOT CAUSE A SUDDEN LOSS OF AIR. GENERAL MOTORS PROVIDED ODI WITH THE FINAL FACTORY FRONT CAMBER SETTINGS WHERE AVAILABLE FOR COMPLAINT AND WARRANTY CLAIM VEHICLES.APPROXIMATELY 90 PERCENT OF THESE VEHICLES HAD RIGHT WHEEL CAMBER SETTINGS THAT WERE OUT OF DESIGN SPECIFICATION.FOUR PERCENT OF THE VEHICLES HAD LEFT WHEEL CAMBER SETTINGS THAT WERE OUT OF SPECIFICATION.IN A REVIEW OF CONSUMER COMPLAINTS, MOST NOTED EXCESSIVE TIRE WEAR TO VARYING DEGREES TO BOTH FRONT TIRES.FOR COMPLAINTS INDICATING EXCESSIVE WEAR TO A SINGLE FRONT TIRE, 90 PERCENT INVOLVED THE RIGHT SIDE. ALTHOUGH IN SOME CASES THERE ARE INDICATIONS OF TIRE CONTACT WITH FRONT STRUT ASSEMBLIES IN THE SUBJECT VEHICLES, ANALYSIS OF TIRE WEAR PATTERNS IN PHOTOGRAPHS SHOWS THE GREATEST WEAR OCCURRING ON THE INBOARD TREAD SURFACE FROM ROAD WEAR AND NOT ON THE AREA OF THE TIRE ON THE UPPER SHOULDER THAT CONTACTS THE STRUT.THIS IS CONSISTENT WITH THE KNOWN TIRE WEAR PATTERNS ASSOCIATED WITH EXCESSIVE NEGATIVE CAMBER, WITH OR WITHOUT STRUT CONTACT.THIS IS MOST APPARENT IN SOME PICTURES, WHICH SHOW MINOR TIRE-STRUT CONTACT WHILE EXHIBITING SIGNIFICANT WEAR OF THE INNER TREAD SURFACE OF THE TIRES.BASED ON DATA REVIEWED DURING THE INVESTIGATION, WHILE EXCESSIVE NEGATIVE CAMBER IS AN APPARENT ISSUE, THE PREMATURE TIRE WEAR APPEARS TO BE PRIMARILY CAUSED BY TIRE TO ROAD SURFACE CONTACT AS OPPOSED TO CONTACT OF THE FRONT TIRES TO THE FRONT STRUT ASSEMBLIES.ODI REVIEWED APPROXIMATELY 1,400 TOTAL COMPLAINTS AND WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT.VIRTUALLY ALL OF THE REPORTS RELATE TO UNEVEN/EXCESSIVE TIRE WEAR OR SOME AWARENESS OF THE TIRE-STRUT CONTACT ISSUE.ODI WAS ABLE TO IDENTIFY 9 TIRE AIR LOSS INCIDENTS ALLEGED TO BE CAUSED BY TIRE-STRUT CONTACT, WITH5 OF THESE DESCRIBING A SLOW AIR LOSS.WHILE THERE WAS EVIDENCE OF TIRE-STRUT CONTACT IN SOME OF THESE VEHICLES, ODI'S ANALYSIS DID NOT FIND THAT THIS CONTACT WAS THE CAUSE OF THE AIR LOSS BUT RATHER A SECONDARY SYMPTOM OF THE EXCESSIVE NEGATIVE CAMBER CONDITION THAT RESULTS IN RAPID ROAD WEAR ON THE INBOARD TREAD SURFACE. ODI IS AWARE OF ONE CRASH ALLEGED TO BE CAUSED BY CONTACT OF THE FRONT STRUT TO FRONT TIRE.HOWEVER, ANALYSIS OF THE INFORMATION PROVIDED BY THE CONSUMER, GM AND A THIRD PARTY INVESTIGATOR DOES NOT INDICATE THAT TIRE-STRUT CONTACT WAS A FACTOR IN THE CRASH.ODI IS UNAWARE OF ANY INJURIES OR FATALITIES ATTRIBUTED TO THE ALLEGED DEFECT. ODI HAS NOT IDENTIFIED A SAFETY RELATED DEFECT TREND IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF TH
Tires
NOTE: THE COMPLAINT AND WARRANTY COUNTS GIVEN IN THE FAILURE REPORT SUMMARY OF THIS RESUME INCLUDE ALL RECORDS RELATED TO TIRE WEAR AND WHEEL ALIGNMENT AND ARE NOT LIMITED TO TIRE-STRUT CONTACT.GENERAL MOTORS (GM) IDENTIFIED TWO CONTRIBUTORS TO PREMATURE FRONT TIRE WEAR IN THE SUBJECT VEHICLES.ONE OF THE CONTRIBUTORS CAUSING THE PREMATURE TIRE WEAR WAS OUT OF SPECIFICATION NEGATIVE CAMBER.GM STATED THAT EXCESSIVE NEGATIVE CAMBER COULD BE CAUSED BY IMPROPER CAMBER SETTINGS FROM THE FACTORY OR BENDING OF THE FRONT STRUT ASSEMBLIES DUE TO SHARP ROAD IMPACT (I.E., SEVERE POT HOLES).TO IMPROVE CAMBER SETTINGS FROM THE FACTORY, GM STATED THAT FROM FEBRUARY OF 2005 THROUGH MAY OF 2006 SEVERAL MODIFICATIONS WERE MADE TO THE CAMBER SETTING FIXTURE.GM ALSO NOTED THAT EXCESSIVE NEGATIVE CAMBER COULD RESULT IN FRONT TIRE TO STRUT CONTACT, WHICH COULD ALSO BE CAUSED BY USE OF NON-ORIGINAL EQUIPMENT (OE) TIRES AND/OR WHEELS.GM STATED THAT CONTACT OF THE FRONT TIRE AND FRONT STRUT ASSEMBLY CAN CAUSE A POLISHING ON THE TIRE SIDEWALL AND/OR STRUT ASSEMBLY; HOWEVER, THIS DOES NOT CAUSE A SUDDEN LOSS OF AIR. GENERAL MOTORS PROVIDED ODI WITH THE FINAL FACTORY FRONT CAMBER SETTINGS WHERE AVAILABLE FOR COMPLAINT AND WARRANTY CLAIM VEHICLES.APPROXIMATELY 90 PERCENT OF THESE VEHICLES HAD RIGHT WHEEL CAMBER SETTINGS THAT WERE OUT OF DESIGN SPECIFICATION.FOUR PERCENT OF THE VEHICLES HAD LEFT WHEEL CAMBER SETTINGS THAT WERE OUT OF SPECIFICATION.IN A REVIEW OF CONSUMER COMPLAINTS, MOST NOTED EXCESSIVE TIRE WEAR TO VARYING DEGREES TO BOTH FRONT TIRES.FOR COMPLAINTS INDICATING EXCESSIVE WEAR TO A SINGLE FRONT TIRE, 90 PERCENT INVOLVED THE RIGHT SIDE. ALTHOUGH IN SOME CASES THERE ARE INDICATIONS OF TIRE CONTACT WITH FRONT STRUT ASSEMBLIES IN THE SUBJECT VEHICLES, ANALYSIS OF TIRE WEAR PATTERNS IN PHOTOGRAPHS SHOWS THE GREATEST WEAR OCCURRING ON THE INBOARD TREAD SURFACE FROM ROAD WEAR AND NOT ON THE AREA OF THE TIRE ON THE UPPER SHOULDER THAT CONTACTS THE STRUT.THIS IS CONSISTENT WITH THE KNOWN TIRE WEAR PATTERNS ASSOCIATED WITH EXCESSIVE NEGATIVE CAMBER, WITH OR WITHOUT STRUT CONTACT.THIS IS MOST APPARENT IN SOME PICTURES, WHICH SHOW MINOR TIRE-STRUT CONTACT WHILE EXHIBITING SIGNIFICANT WEAR OF THE INNER TREAD SURFACE OF THE TIRES.BASED ON DATA REVIEWED DURING THE INVESTIGATION, WHILE EXCESSIVE NEGATIVE CAMBER IS AN APPARENT ISSUE, THE PREMATURE TIRE WEAR APPEARS TO BE PRIMARILY CAUSED BY TIRE TO ROAD SURFACE CONTACT AS OPPOSED TO CONTACT OF THE FRONT TIRES TO THE FRONT STRUT ASSEMBLIES.ODI REVIEWED APPROXIMATELY 1,400 TOTAL COMPLAINTS AND WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT.VIRTUALLY ALL OF THE REPORTS RELATE TO UNEVEN/EXCESSIVE TIRE WEAR OR SOME AWARENESS OF THE TIRE-STRUT CONTACT ISSUE.ODI WAS ABLE TO IDENTIFY 9 TIRE AIR LOSS INCIDENTS ALLEGED TO BE CAUSED BY TIRE-STRUT CONTACT, WITH5 OF THESE DESCRIBING A SLOW AIR LOSS.WHILE THERE WAS EVIDENCE OF TIRE-STRUT CONTACT IN SOME OF THESE VEHICLES, ODI'S ANALYSIS DID NOT FIND THAT THIS CONTACT WAS THE CAUSE OF THE AIR LOSS BUT RATHER A SECONDARY SYMPTOM OF THE EXCESSIVE NEGATIVE CAMBER CONDITION THAT RESULTS IN RAPID ROAD WEAR ON THE INBOARD TREAD SURFACE. ODI IS AWARE OF ONE CRASH ALLEGED TO BE CAUSED BY CONTACT OF THE FRONT STRUT TO FRONT TIRE.HOWEVER, ANALYSIS OF THE INFORMATION PROVIDED BY THE CONSUMER, GM AND A THIRD PARTY INVESTIGATOR DOES NOT INDICATE THAT TIRE-STRUT CONTACT WAS A FACTOR IN THE CRASH.ODI IS UNAWARE OF ANY INJURIES OR FATALITIES ATTRIBUTED TO THE ALLEGED DEFECT. ODI HAS NOT IDENTIFIED A SAFETY RELATED DEFECT TREND IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF TH
Tires:sidewall
NOTE: THE COMPLAINT AND WARRANTY COUNTS GIVEN IN THE FAILURE REPORT SUMMARY OF THIS RESUME INCLUDE ALL RECORDS RELATED TO TIRE WEAR AND WHEEL ALIGNMENT AND ARE NOT LIMITED TO TIRE-STRUT CONTACT.GENERAL MOTORS (GM) IDENTIFIED TWO CONTRIBUTORS TO PREMATURE FRONT TIRE WEAR IN THE SUBJECT VEHICLES.ONE OF THE CONTRIBUTORS CAUSING THE PREMATURE TIRE WEAR WAS OUT OF SPECIFICATION NEGATIVE CAMBER.GM STATED THAT EXCESSIVE NEGATIVE CAMBER COULD BE CAUSED BY IMPROPER CAMBER SETTINGS FROM THE FACTORY OR BENDING OF THE FRONT STRUT ASSEMBLIES DUE TO SHARP ROAD IMPACT (I.E., SEVERE POT HOLES).TO IMPROVE CAMBER SETTINGS FROM THE FACTORY, GM STATED THAT FROM FEBRUARY OF 2005 THROUGH MAY OF 2006 SEVERAL MODIFICATIONS WERE MADE TO THE CAMBER SETTING FIXTURE.GM ALSO NOTED THAT EXCESSIVE NEGATIVE CAMBER COULD RESULT IN FRONT TIRE TO STRUT CONTACT, WHICH COULD ALSO BE CAUSED BY USE OF NON-ORIGINAL EQUIPMENT (OE) TIRES AND/OR WHEELS.GM STATED THAT CONTACT OF THE FRONT TIRE AND FRONT STRUT ASSEMBLY CAN CAUSE A POLISHING ON THE TIRE SIDEWALL AND/OR STRUT ASSEMBLY; HOWEVER, THIS DOES NOT CAUSE A SUDDEN LOSS OF AIR. GENERAL MOTORS PROVIDED ODI WITH THE FINAL FACTORY FRONT CAMBER SETTINGS WHERE AVAILABLE FOR COMPLAINT AND WARRANTY CLAIM VEHICLES.APPROXIMATELY 90 PERCENT OF THESE VEHICLES HAD RIGHT WHEEL CAMBER SETTINGS THAT WERE OUT OF DESIGN SPECIFICATION.FOUR PERCENT OF THE VEHICLES HAD LEFT WHEEL CAMBER SETTINGS THAT WERE OUT OF SPECIFICATION.IN A REVIEW OF CONSUMER COMPLAINTS, MOST NOTED EXCESSIVE TIRE WEAR TO VARYING DEGREES TO BOTH FRONT TIRES.FOR COMPLAINTS INDICATING EXCESSIVE WEAR TO A SINGLE FRONT TIRE, 90 PERCENT INVOLVED THE RIGHT SIDE. ALTHOUGH IN SOME CASES THERE ARE INDICATIONS OF TIRE CONTACT WITH FRONT STRUT ASSEMBLIES IN THE SUBJECT VEHICLES, ANALYSIS OF TIRE WEAR PATTERNS IN PHOTOGRAPHS SHOWS THE GREATEST WEAR OCCURRING ON THE INBOARD TREAD SURFACE FROM ROAD WEAR AND NOT ON THE AREA OF THE TIRE ON THE UPPER SHOULDER THAT CONTACTS THE STRUT.THIS IS CONSISTENT WITH THE KNOWN TIRE WEAR PATTERNS ASSOCIATED WITH EXCESSIVE NEGATIVE CAMBER, WITH OR WITHOUT STRUT CONTACT.THIS IS MOST APPARENT IN SOME PICTURES, WHICH SHOW MINOR TIRE-STRUT CONTACT WHILE EXHIBITING SIGNIFICANT WEAR OF THE INNER TREAD SURFACE OF THE TIRES.BASED ON DATA REVIEWED DURING THE INVESTIGATION, WHILE EXCESSIVE NEGATIVE CAMBER IS AN APPARENT ISSUE, THE PREMATURE TIRE WEAR APPEARS TO BE PRIMARILY CAUSED BY TIRE TO ROAD SURFACE CONTACT AS OPPOSED TO CONTACT OF THE FRONT TIRES TO THE FRONT STRUT ASSEMBLIES.ODI REVIEWED APPROXIMATELY 1,400 TOTAL COMPLAINTS AND WARRANTY CLAIMS POTENTIALLY RELATED TO THE ALLEGED DEFECT.VIRTUALLY ALL OF THE REPORTS RELATE TO UNEVEN/EXCESSIVE TIRE WEAR OR SOME AWARENESS OF THE TIRE-STRUT CONTACT ISSUE.ODI WAS ABLE TO IDENTIFY 9 TIRE AIR LOSS INCIDENTS ALLEGED TO BE CAUSED BY TIRE-STRUT CONTACT, WITH5 OF THESE DESCRIBING A SLOW AIR LOSS.WHILE THERE WAS EVIDENCE OF TIRE-STRUT CONTACT IN SOME OF THESE VEHICLES, ODI'S ANALYSIS DID NOT FIND THAT THIS CONTACT WAS THE CAUSE OF THE AIR LOSS BUT RATHER A SECONDARY SYMPTOM OF THE EXCESSIVE NEGATIVE CAMBER CONDITION THAT RESULTS IN RAPID ROAD WEAR ON THE INBOARD TREAD SURFACE. ODI IS AWARE OF ONE CRASH ALLEGED TO BE CAUSED BY CONTACT OF THE FRONT STRUT TO FRONT TIRE.HOWEVER, ANALYSIS OF THE INFORMATION PROVIDED BY THE CONSUMER, GM AND A THIRD PARTY INVESTIGATOR DOES NOT INDICATE THAT TIRE-STRUT CONTACT WAS A FACTOR IN THE CRASH.ODI IS UNAWARE OF ANY INJURIES OR FATALITIES ATTRIBUTED TO THE ALLEGED DEFECT. ODI HAS NOT IDENTIFIED A SAFETY RELATED DEFECT TREND IN THE SUBJECT VEHICLES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF TH