← New search

2004 Pontiac Grand Prix

Owner reports · Recalls · Investigations

More warning signs than most Grand Prix years

Owner complaints for the 2004 Pontiac Grand Prix are substantially higher than the model-year median of 88.

About this comparison →

When problems were reported

Mileage at the reported incident

314 reports with mileage · 140 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 107 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 98 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Steering. Review the 64 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

46 crash reports58 fire reports33 injury reports

Engine complaints

98 reports
Clear category filter
Mileage unknown · Jan 19, 2016
Engine

TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V201000 (ENGINE); HOWEVER, THE PART FOR THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE C…

Read full complaint

TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V201000 (ENGINE); HOWEVER, THE PART FOR THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ODI #10821129

Mileage unknown · Jan 19, 2016
Engine

TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V201000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWAR…

Read full complaint

TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V201000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

NHTSA ODI #10820986

Mileage unknown · Jan 15, 2016
Engine

TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V201000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER W…

Read full complaint

TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V201000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ODI #10820514

118,000 miles · Jan 13, 2016
Engine

TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN: 15V201000 (ENGINE AND ENGINE COOLING) HOWEVER, THE PART FOR THE RECALL REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER H…

Read full complaint

TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN: 15V201000 (ENGINE AND ENGINE COOLING) HOWEVER, THE PART FOR THE RECALL REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 118,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ODI #10820070

Mileage unknown · Jan 13, 2016
Engine

TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V201000 (ENGINE AND ENGINE COOLING) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF T…

Read full complaint

TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V201000 (ENGINE AND ENGINE COOLING) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS UNAVAILABLE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ODI #10819965

130,000 miles · Jan 13, 2016
EngineFire

TL* THE CONTACT OWNED A 2004 PONTIAC GRAND PRIX. WHILE PARKED, THE UNOCCUPIED VEHCILE IGNITED INTO LARGE FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND STATED THAT THE FIRE ORIGINATED IN THE ENGINE COMPARTMENT. THE VEHICLE WAS DESTROYED AND TOWED TO A SALVAGE FACILITY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APP…

Read full complaint

TL* THE CONTACT OWNED A 2004 PONTIAC GRAND PRIX. WHILE PARKED, THE UNOCCUPIED VEHCILE IGNITED INTO LARGE FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND STATED THAT THE FIRE ORIGINATED IN THE ENGINE COMPARTMENT. THE VEHICLE WAS DESTROYED AND TOWED TO A SALVAGE FACILITY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

NHTSA ODI #10819950

158,000 miles · Jan 13, 2016
EngineFire

TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. THE CONTACT STATED THAT FIVE MINUTES AFTER THE VEHICLE WAS PARKED, THE FRONT END OF THE VEHICLE CAUGHT ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A FIRE REPORT WAS FILED AND THERE WERE NO INJURIES SUSTAINED THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS NOT DIAGNOSED OR…

Read full complaint

TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. THE CONTACT STATED THAT FIVE MINUTES AFTER THE VEHICLE WAS PARKED, THE FRONT END OF THE VEHICLE CAUGHT ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A FIRE REPORT WAS FILED AND THERE WERE NO INJURIES SUSTAINED THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND THE CONTACT WAS NOTIFIED OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE FAILURE MILEAGE WAS 158,000.

NHTSA ODI #10819918

72,975 miles · Jan 11, 2016
EngineFire

WHILE PARKED AND ADDING ENGINE OIL, OIL AND ENGINE CAUGHT ON FIRE.

NHTSA ODI #10819282

158,853 miles · Jan 7, 2016
Electrical SystemEngine

TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. THE VEHICLE LEAKED OIL FROM THE FRONT END OF THE VEHICLE AND THERE WAS AN ABNORMAL ODOR. THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT THE VEHICLE SPUTTERED WHEN DRIVING UPHILL. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC WHO DIAGNOSED THAT THERE WAS …

Read full complaint

TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. THE VEHICLE LEAKED OIL FROM THE FRONT END OF THE VEHICLE AND THERE WAS AN ABNORMAL ODOR. THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT THE VEHICLE SPUTTERED WHEN DRIVING UPHILL. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC WHO DIAGNOSED THAT THERE WAS AN ELECTRICAL SHORT WITH THE VEHICLE; HOWEVER, THE FAILURE WAS NOT SPECIFIED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 158,853.

NHTSA ODI #10818709

120,000 miles · Dec 31, 2015
Engine

TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. WHILE DRIVING 30 MPH, THE CONTACT OBSERVED A PUDDLE OF OIL UNDERNEATH THE FRONT OF THE VEHICLE AND AN UNKNOWN WARNING LIGHT ILLUMINATED. THE FAILURE WAS PERSISTENT. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE VALVE RING FRACTURED AND NEEDED TO BE REPLACED. THE…

Read full complaint

TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. WHILE DRIVING 30 MPH, THE CONTACT OBSERVED A PUDDLE OF OIL UNDERNEATH THE FRONT OF THE VEHICLE AND AN UNKNOWN WARNING LIGHT ILLUMINATED. THE FAILURE WAS PERSISTENT. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE VALVE RING FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000.

NHTSA ODI #10817184

Official recalls

7

15V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

Oct 26, 2015

General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.

Consequence & remedy

Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engine’s front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.

Additional source detail variants (2)

Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.

Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engine’s front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.

Engine And Engine Cooling:engine

General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.

Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engine’s front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.

15V201000 · Engine And Engine Cooling:engine

Apr 6, 2015

General Motors LLC (GM) notified the agency on April 2, 2015, that they are is recalling certain model year 2004 Buick Regal vehicles manufactured April 9, 2003, to June 1, 2003, 2004 Chevrolet Impala vehicles manufactured April 8, 2003, to June 23, 2003, and 2004 Chevrolet Monte Carlo vehicles manufactured April 7, 2003, to June 23, 2003. On May 18, 2015, GM expanded the recall to cover an additional 49,751 2004 Pontiac Grand Prix vehicles manufactured January 6, 2003, to June 25, 2004. In the affected vehicles, the valve cover gasket may leak.

Consequence & remedy

Consequence: The leaking engine oil can drip onto the hot surface of the exhaust manifold, increasing the risk of a fire.

Remedy: GM will notify owners, and dealers will remove the plastic cover and plastic oil fill tube extension and replace the front valve cover and gasket. These repairs will be done free of charge. The recall began on April 24, 2015. Owners may contact Buick customer service at 1-800-521-7300, Pontiac customer service at 1-800-762-2737 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14574.

14V400000 · Electrical System:ignition

Jul 3, 2014

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Consequence & remedy

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.

05V046000 · Vehicle Speed Control:accelerator Pedal

Feb 9, 2005

CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, 'ACCELERATOR CONTROL SYSTEMS.' IF ONE OF THE TWO ACCELERATOR PEDAL RETURN SPRINGS FAILS AND THE TEMPERATURE IS -22 DEGREES F TO -40 DEGREES F, THE ENGINE MAY NOT RETURN TO IDLE WITHIN THREE SECONDS, AS REQUIRED.

Consequence & remedy

Consequence: IF THIS WERE TO OCCUR, GREATER BRAKE PEDAL FORCE AND A LONGER DISTANCE MAY BE REQUIRED TO STOP THE VEHICLE.

Remedy: DEALERS WILL REPLACE THE ACCELERATOR PEDAL ASSEMBLY. THIS RECALL BEGAN ON MARCH 8, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339 OR PONTIAC AT 1-800-620-7668.

04V287000 · Service Brakes, Hydraulic

Jun 23, 2004

CERTAIN PASSENGER VEHICLES WERE PRODUCED WITH LOWER THAN SPECIFIED TORQUE ON BOTH FRONT BRAKE CALIPER TO STEERING KNUCKLE ATTACHMENT BOLTS. WITH IMPROPER TORQUE, THE CLAMP LOAD AT THE JOINT MAY NOT BE ADEQUATE TO PREVENT MOVEMENT BETWEEN THE CALIPER BRACKET AND KNUCKLE.

Consequence & remedy

Consequence: DEPENDING ON WHETHER ONE OR BOTH BOLTS BACKS OUT OR FRACTURES, THE RESULT CAN BE LOCKING OF THE AFFECTED WHEEL DURING BRAKING AND AN ABRUPT STEERING INPUT IN THE DIRECTION OF THE LOCKED WHEEL, REDUCED BRAKING AND NOISE FROM THE AFFECTED WHEEL, OR SEVERING OF A BRAKE HOSE, INCREASED BRAKE PEDAL TRAVEL, AND REDUCED STEERING CONTROL. REDUCED BRAKING OR STEERING CONTROL COULD CAUSE A CRASH.

Remedy: DEALERS ARE TO TIGHTEN BOTH BOLTS TO THE SPECIFIED TORQUE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT CHEVROLET 1-800-630-2438 OR PONTIAC 1-800-620-7668.

04V299000 · Structure:frame And Members

Jun 23, 2004

CERTAIN PASSENGER VEHICLES HAVE A CONDITION WHERE THE FRONT FRAME REAR BODY MOUNT BRACKET MAY FRACTURE.

Consequence & remedy

Consequence: IF IGNORED, THE BRACKET WOULD FRACTURE AND DEGRADE TO THE POINT WHERE THE INTERMEDIATE STEERING SHAFT COULD SEPARATE, RESULTING IN LOSS OF STEERING CONTROL AND A CRASH COULD OCCUR.

Remedy: DEALERS WILL INSPECT THE FRONT FRAME ASSEMBLY AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 16, 2004. OWNERS SHOULD CONTACT PONTIAC AT 1-800-620-7668.

03V331000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings

Sep 12, 2003

CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, "PASSENGER CAR BRAKING SYSTEMS." ON SOME OF THESE VEHICLES, THE RIGHT REAR BRAKE HOSE FITTING MAY NOT BE TIGHTENED PROPERLY, AND A BRAKE FLUID LEAK COULD OCCUR.

Consequence & remedy

Consequence: IF ENOUGH FLUID LEAKS, THE BRAKE PEDAL WILL BE LOWER THAN NORMAL, AND STOPPING DISTANCES WILL BE LONGER. IF THIS OCCURS WHEN STOPPING DISTANCE IS LIMITED, A CRASH COULD OCCUR.

Remedy: DEALERS WILL TIGHTEN THE RIGHT REAR BRAKE HOSE FITTING TO THE PROPER TORQUE SPECIFICATION, AND ADD BRAKE FLUID IF NECESSARY. OWNER NOTIFICATION BEGAN AUGUST 28, 2003. OWNERS SHOULD CONTACT PONTIAC AT 1-800-620-7668.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

DP05010 · Unstable Headlamps

Opened Dec 21, 2005 · Closed Apr 10, 2006

Status: closed (inferred from source dates) · Exterior Lighting:headlights

ODI RECEIVED A PETITION FROM MR. BRAD LAMB OF THE NORTH CAROLINA CONSUMERS COUNCIL, REQUESTING INVESTIGATION OF AN ALLEGED DEFECT EVIDENCED BY SHAKE OR BOUNCE OF THE HEADLAMPS ON MODEL YEAR 2004 PONTIAC GRAND PRIX VEHICLES.ODI'S PREVIOUS REVIEW OF THIS ISSUE IN OCTOBER 2003, DETERMINED THAT IT DID NOT WARRANT INVESTIGATION.ODI'S CURRENT ANALYSIS IDENTIFIED 36 COMPLAINTS IN THE CONSUMER COMPLAINT DATABASE; AND A DECLINING TREND OF REPORTS WAS EVIDENT.A FEW FIELD REPORTS OF SIMILAR NATURE WERE ALSO SUBMITTED BY THE MANUFACTURER IN ITS EARLY WARNING REPORTING DATA.A SERVICE BULLETIN AND A REVISED HEADLAMP RETAINING BRACKET WERE ISSUED IN NOVEMBER 2004, AND THESE ACTIONS ARE SEEN AS APPROPRIATE IN ADDRESSING THE PROBLEM WHILE ALL OF THE SUBJECT VEHICLES ARE STILL COVERED BY THE NEW VEHICLE WARRANTY.COMPROMISE TO SAFE VEHICLE OPERATION AS A RESULT OF THIS ISSUE WAS NOT IDENTIFIED.IT IS UNLIKELY THAT INVESTIGATION WOULD RESULT IN A NHTSA ORDER FOR THE RECALL AND REMEDY OF THIS PROBLEM.