NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
107 reportsClear category filter24,000 miles · Nov 17, 2014
Electrical System
TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. UPON ATTEMPTING TO START THE VEHICLE, THE KEY WOULD NOT TURN OVER INTO THE ON POSITION. THE CONTACT MADE MULTIPLE ATTEMPTS TO START THE VEHICLE. THE FAILURE BEGAN AFTER THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE VEHICLE WAS TOWED TO THE…
Read full complaint
TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. UPON ATTEMPTING TO START THE VEHICLE, THE KEY WOULD NOT TURN OVER INTO THE ON POSITION. THE CONTACT MADE MULTIPLE ATTEMPTS TO START THE VEHICLE. THE FAILURE BEGAN AFTER THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 24,000.
NHTSA ODI #10658677
156,000 miles · Nov 17, 2014
Air BagsElectrical SystemInjury
TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. WHILE DRIVING 35 MPH, THE IGNITION SWITCH MOVED INDEPENDENTLY FROM THE RUN POSITION WITHOUT WARNING. AS A RESULT, THE VEHICLE STRUCK A CURB AND THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED A NECK INJURY THAT DID NOT REQUIRE MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. …
Read full complaint
TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. WHILE DRIVING 35 MPH, THE IGNITION SWITCH MOVED INDEPENDENTLY FROM THE RUN POSITION WITHOUT WARNING. AS A RESULT, THE VEHICLE STRUCK A CURB AND THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED A NECK INJURY THAT DID NOT REQUIRE MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS 156,000.
NHTSA ODI #10655363
Mileage unknown · Oct 23, 2014
Electrical SystemEngineEngine And Engine CoolingFire
2004 PONTIAC GT GRAND PRIX. CONSUMER WRITES IN REGARDS TO RECEIVING RECALL NOTICE AND ELECTRICAL ISSUES. *TGW THE CONSUMER STATED HE EXPERIENCED ELECTRICAL ISSUES, OVER THE YEARS. THE INSTRUMENT PANEL WOULD GO OUT. THE A/C FAN MOTOR, AND TAIL LIGHTS FAILED. THE VEHICLE WOULD SHUT OFF AT ANY TIME. THE IGNITION SWITCH WAS EVENT…
Read full complaint
2004 PONTIAC GT GRAND PRIX. CONSUMER WRITES IN REGARDS TO RECEIVING RECALL NOTICE AND ELECTRICAL ISSUES. *TGW THE CONSUMER STATED HE EXPERIENCED ELECTRICAL ISSUES, OVER THE YEARS. THE INSTRUMENT PANEL WOULD GO OUT. THE A/C FAN MOTOR, AND TAIL LIGHTS FAILED. THE VEHICLE WOULD SHUT OFF AT ANY TIME. THE IGNITION SWITCH WAS EVENTUALLY REPLACED. ALSO, THE ENGINE OVERHEATED. *JB THE CONSUMER STATED A FIRE DEVELOPED UNDER THE HOOD WHILE DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED NO FIRE OCCURRED. *JS
NHTSA ODI #10644083
Mileage unknown · Oct 22, 2014
Electrical SystemEngineFire
I HAD JUST ARRIVED AT WORK TO BEGIN MY SHIFT..AS I ENTERED THE BUILDING TO GO CLOCK IN WITHIN SEVERAL MINUTES I NOTICED SEVERAL EMPLOYEES EXITING THE BUILDING AND GATHERING OUTSIDE IN THE PARKING LOT..IN THE MIDDLE OF ME ASKN AN EMPLOYEE WHAT WAS GOING ON OUTSIDE ANOTHER EMPLOYEE NOTIFIED ME THAT MY VECHICLE WAS ON FIRE. *TR
NHTSA ODI #10649302
Mileage unknown · Oct 15, 2014
Electrical System
TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). HOWEVER, THE CONTACT WAS DISPLEASED WITH THE SCHEDULE OF WHEN THE DEALER WOULD PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAIL…
Read full complaint
TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). HOWEVER, THE CONTACT WAS DISPLEASED WITH THE SCHEDULE OF WHEN THE DEALER WOULD PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10644876
Mileage unknown · Oct 15, 2014
Air BagsElectrical SystemCrashInjury
2004 PONTIAC GRAND PRIX. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL AND AIRBAGS DID NOT DEPLOY DURING ACCIDENT. *SMD THE CONSUMER STATED SHE SLAMMED ON THE BRAKE, TO AVOID HITTING SOME TIRES, THAT WERE ON THE HIGHWAY. HER VEHICLE STOPPED MOVING COMPLETELY AND EVERYTHING WENT DARK ON THE INSIDE. AS A RESULT, SHE WAS …
Read full complaint
2004 PONTIAC GRAND PRIX. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL AND AIRBAGS DID NOT DEPLOY DURING ACCIDENT. *SMD THE CONSUMER STATED SHE SLAMMED ON THE BRAKE, TO AVOID HITTING SOME TIRES, THAT WERE ON THE HIGHWAY. HER VEHICLE STOPPED MOVING COMPLETELY AND EVERYTHING WENT DARK ON THE INSIDE. AS A RESULT, SHE WAS REAR ENDED. THE CONSUMER WAS INJURED IN THE ACCIDENT. *JB UPDATED 10/29/15.*JB
NHTSA ODI #10642024
124,000 miles · Sep 30, 2014
Electrical SystemFire
TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. THE CONTACT STATED THAT AFTER PARKING THE VEHICLE, IT CAUGHT ON FIRE. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE. A POLICE/FIRE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A IMPOUND LOT. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL…
Read full complaint
TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. THE CONTACT STATED THAT AFTER PARKING THE VEHICLE, IT CAUGHT ON FIRE. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE. A POLICE/FIRE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A IMPOUND LOT. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 124,000.
NHTSA ODI #10640136
Mileage unknown · Sep 29, 2014
Electrical SystemCrashInjury
WHILE EXITING OFF OF LINWOOD TO J .C. LODGE SOUTHBOUND. THERE WAS A VAN THAT STOPPED AT THE END OF THE RAMP. SOMEONE HAD THROWN TIRES ON TO THE EXPRESS WAY. AFTER HE PULLED OFF I SAW THE TIRES AND SLAMMED ON MY BRAKES.I WAS UNABLE TO MOVE MY CAR IT HAD CUT OFF. THERE WAS NO MUSIC OR LIGHTS ON IN MY CAR. 30 -40 SECONDS LATER I W…
Read full complaint
WHILE EXITING OFF OF LINWOOD TO J .C. LODGE SOUTHBOUND. THERE WAS A VAN THAT STOPPED AT THE END OF THE RAMP. SOMEONE HAD THROWN TIRES ON TO THE EXPRESS WAY. AFTER HE PULLED OFF I SAW THE TIRES AND SLAMMED ON MY BRAKES.I WAS UNABLE TO MOVE MY CAR IT HAD CUT OFF. THERE WAS NO MUSIC OR LIGHTS ON IN MY CAR. 30 -40 SECONDS LATER I WAS REAR- ENDED. MY TRUNK WAS PUSHED INTO THE BACKSEAT.WHILE AT THE SCENE THE DRIVER WHO HIT ME BECAME VERY BELLIGERENT AND CONTINUOUSLY ASKED ' WHY WAS I JUST SITTING THERE?. I WAS TAKEN BY AN AMBULANCE TO HENRY FORD HOSPITAL ON W. GRAND BLVD. THE OFFICER AT THE SCENE CAME TO THE HOSPITAL. HE ASKED ME QUESTIONS ABOUT THE CRASH. I TOLD HIM "IT GOT DARK AND QUIET". IT WAS MY IGNITION SWITCH. BOTH ROTATOR CUFFS WERE TORN, DISC IN MY BACK WAS DISPLACED,BROKE MY TOE ON MY LEFT FOOT, SPRAINED MY ANKLE, SURGERY RECOMMENDED FOR BOTH KNEES AND ROTATOR CUFFS. I ALSO HAVE EXTREME JOINT PAIN AND SWELLING ALL OVER MY BODY. HAD SURGERY ON MY LEFT ROTATOR CUFF. I KNOW WALK WITH A CANE. I CANNOT SIT OR STAND FOR LONG PERIODS OF TIME. MONTHS AND MONTHS OF PHYSICAL THERAPY AND PAIN MEDICATION. IT KILLED MINES AND MY FAMILY'S LIFE AS WE ONCE KNEW IT. *TR
NHTSA ODI #10639838
100,000 miles · Sep 25, 2014
Air BagsElectrical SystemCrash
TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. WHILE DRIVING 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. AS A RESULT, THE VEHICLE CRASHED INTO A WALL BARRIER. THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO INJURIES REPORTED AND A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE CONTACT REFERENCE…
Read full complaint
TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. WHILE DRIVING 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. AS A RESULT, THE VEHICLE CRASHED INTO A WALL BARRIER. THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO INJURIES REPORTED AND A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM), BUT IT WAS NOT CONFIRMED IF THE VEHICLE WAS INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #10638903
Mileage unknown · Sep 25, 2014
Electrical System
TL* THE CONTACT OWNS A 2004 PONTIAC GRAND PRIX. THE CONTACT STATED THAT THE KEY BECAME LODGED IN THE IGNITION SWITCH. THE DEALER STATED THAT THE FAILURE WAS NOT RELATED TO NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10638899
Official recalls
7Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Apr 6, 2015
General Motors LLC (GM) notified the agency on April 2, 2015, that they are is recalling certain model year 2004 Buick Regal vehicles manufactured April 9, 2003, to June 1, 2003, 2004 Chevrolet Impala vehicles manufactured April 8, 2003, to June 23, 2003, and 2004 Chevrolet Monte Carlo vehicles manufactured April 7, 2003, to June 23, 2003. On May 18, 2015, GM expanded the recall to cover an additional 49,751 2004 Pontiac Grand Prix vehicles manufactured January 6, 2003, to June 25, 2004. In the affected vehicles, the valve cover gasket may leak.
Consequence & remedy
Consequence: The leaking engine oil can drip onto the hot surface of the exhaust manifold, increasing the risk of a fire.
Remedy: GM will notify owners, and dealers will remove the plastic cover and plastic oil fill tube extension and replace the front valve cover and gasket. These repairs will be done free of charge. The recall began on April 24, 2015. Owners may contact Buick customer service at 1-800-521-7300, Pontiac customer service at 1-800-762-2737 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14574.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Feb 9, 2005
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, 'ACCELERATOR CONTROL SYSTEMS.' IF ONE OF THE TWO ACCELERATOR PEDAL RETURN SPRINGS FAILS AND THE TEMPERATURE IS -22 DEGREES F TO -40 DEGREES F, THE ENGINE MAY NOT RETURN TO IDLE WITHIN THREE SECONDS, AS REQUIRED.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR, GREATER BRAKE PEDAL FORCE AND A LONGER DISTANCE MAY BE REQUIRED TO STOP THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE ACCELERATOR PEDAL ASSEMBLY. THIS RECALL BEGAN ON MARCH 8, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339 OR PONTIAC AT 1-800-620-7668.
Jun 23, 2004
CERTAIN PASSENGER VEHICLES WERE PRODUCED WITH LOWER THAN SPECIFIED TORQUE ON BOTH FRONT BRAKE CALIPER TO STEERING KNUCKLE ATTACHMENT BOLTS. WITH IMPROPER TORQUE, THE CLAMP LOAD AT THE JOINT MAY NOT BE ADEQUATE TO PREVENT MOVEMENT BETWEEN THE CALIPER BRACKET AND KNUCKLE.
Consequence & remedy
Consequence: DEPENDING ON WHETHER ONE OR BOTH BOLTS BACKS OUT OR FRACTURES, THE RESULT CAN BE LOCKING OF THE AFFECTED WHEEL DURING BRAKING AND AN ABRUPT STEERING INPUT IN THE DIRECTION OF THE LOCKED WHEEL, REDUCED BRAKING AND NOISE FROM THE AFFECTED WHEEL, OR SEVERING OF A BRAKE HOSE, INCREASED BRAKE PEDAL TRAVEL, AND REDUCED STEERING CONTROL. REDUCED BRAKING OR STEERING CONTROL COULD CAUSE A CRASH.
Remedy: DEALERS ARE TO TIGHTEN BOTH BOLTS TO THE SPECIFIED TORQUE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT CHEVROLET 1-800-630-2438 OR PONTIAC 1-800-620-7668.
Jun 23, 2004
CERTAIN PASSENGER VEHICLES HAVE A CONDITION WHERE THE FRONT FRAME REAR BODY MOUNT BRACKET MAY FRACTURE.
Consequence & remedy
Consequence: IF IGNORED, THE BRACKET WOULD FRACTURE AND DEGRADE TO THE POINT WHERE THE INTERMEDIATE STEERING SHAFT COULD SEPARATE, RESULTING IN LOSS OF STEERING CONTROL AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE FRONT FRAME ASSEMBLY AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 16, 2004. OWNERS SHOULD CONTACT PONTIAC AT 1-800-620-7668.
Sep 12, 2003
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, "PASSENGER CAR BRAKING SYSTEMS." ON SOME OF THESE VEHICLES, THE RIGHT REAR BRAKE HOSE FITTING MAY NOT BE TIGHTENED PROPERLY, AND A BRAKE FLUID LEAK COULD OCCUR.
Consequence & remedy
Consequence: IF ENOUGH FLUID LEAKS, THE BRAKE PEDAL WILL BE LOWER THAN NORMAL, AND STOPPING DISTANCES WILL BE LONGER. IF THIS OCCURS WHEN STOPPING DISTANCE IS LIMITED, A CRASH COULD OCCUR.
Remedy: DEALERS WILL TIGHTEN THE RIGHT REAR BRAKE HOSE FITTING TO THE PROPER TORQUE SPECIFICATION, AND ADD BRAKE FLUID IF NECESSARY. OWNER NOTIFICATION BEGAN AUGUST 28, 2003. OWNERS SHOULD CONTACT PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration