TAKATA RECALL I GOT THE RECALL LETTER IN THE MAIL SUNDAY NIGHT I TOOK MY CAR TO THE NALLEY CHEVROLET DEALERSHIP IN UNION CITY GEORGIA THEY SUPPOSED HAD FIXED THE PROBLEM THE NEXT FOLLOWING DAY MY WIFE HAD TO GO TO WORK ON THE WAY DROPPING HER OFF THE CAR STARTED SMOKING MY CAR EXTREMELY BAD SO I CALLED THE NALLEY CHEVROLET PLACE…
Read full complaint
TAKATA RECALL I GOT THE RECALL LETTER IN THE MAIL SUNDAY NIGHT I TOOK MY CAR TO THE NALLEY CHEVROLET DEALERSHIP IN UNION CITY GEORGIA THEY SUPPOSED HAD FIXED THE PROBLEM THE NEXT FOLLOWING DAY MY WIFE HAD TO GO TO WORK ON THE WAY DROPPING HER OFF THE CAR STARTED SMOKING MY CAR EXTREMELY BAD SO I CALLED THE NALLEY CHEVROLET PLACE TO LET THEM KNOW AFTER I GOT OFF THE PHONE WITH THEM 30 MINUTES LATER THE CAR CAUGHT ON FIRE WHILE DRIVING BACK HOME THEY SUPPOSED OF FIXED THE PROBLEM I CAN'T GET TO WORK WITH A CAR THAT COULD POTENTIALLY BLOW UP I HAVE KIDS AND NIECES AND I CAN'T JEOPARDIZE THEY LIFE OR MINE I'M SCARED TO EVEN DRIVE AGAIN
NHTSA ODI #11118461
Mileage unknown · Aug 1, 2018
Engine
2002 PONTIAC GRAND PRIX. CONSUMER WRITES IN REGARDS TO ENGINE ISSUES. *LD THE CONSUMER STATED WHILE DRIVING, SMOKE BEGAN EMITTING FROM THE HOOD AND RADIATOR FLUID WAS LEAKING FROM THE VEHICLE. IT WAS FOUND THAT THE HEAD GASKET HAD BLOWN. THE RADIATOR HOSE HAD BEEN PATCHED TOGETHER WITH CAULKING. THE CONSUMER WAS NOT INFORMED …
Read full complaint
2002 PONTIAC GRAND PRIX. CONSUMER WRITES IN REGARDS TO ENGINE ISSUES. *LD THE CONSUMER STATED WHILE DRIVING, SMOKE BEGAN EMITTING FROM THE HOOD AND RADIATOR FLUID WAS LEAKING FROM THE VEHICLE. IT WAS FOUND THAT THE HEAD GASKET HAD BLOWN. THE RADIATOR HOSE HAD BEEN PATCHED TOGETHER WITH CAULKING. THE CONSUMER WAS NOT INFORMED OF THIS BY THE DEALERSHIP. *JS
NHTSA ODI #11112716
163,000 miles · Jul 6, 2018
EngineFire
TL* THE CONTACT OWNS A 2002 PONTIAC GRAND PRIX. WHILE THE VEHICLE WAS PARKED, SMOKE AND FLAMES WERE SEEN COMING FROM UNDERNEATH THE HOOD. THERE WERE NO INJURIES. THE FIRE DEPARTMENT WAS CALLED AND EXTINGUISHED THE FIRE. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO A LOCAL COLLISION REPAIR CENTER. THE DEALER (RUDDELL A…
Read full complaint
TL* THE CONTACT OWNS A 2002 PONTIAC GRAND PRIX. WHILE THE VEHICLE WAS PARKED, SMOKE AND FLAMES WERE SEEN COMING FROM UNDERNEATH THE HOOD. THERE WERE NO INJURIES. THE FIRE DEPARTMENT WAS CALLED AND EXTINGUISHED THE FIRE. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO A LOCAL COLLISION REPAIR CENTER. THE DEALER (RUDDELL AUTO, 110 S GOLF COURSE RD, PORT ANGELES, WA 98362, (360) 452-6822) WAS CONTACTED, BUT THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 163,000. *TT
NHTSA ODI #11109876
135,491 miles · Feb 22, 2018
EngineFire
TL* THE CONTACT OWNS A 2002 PONTIAC GRAND PRIX. AFTER PARKING THE VEHICLE, THE CONTACT NOTICED SMOKE COMING FROM THE ENGINE COMPARTMENT. THE CONTACT WAS ABLE TO CONTAIN THE FIRE. THERE WERE NO POLICE OR FIRE REPORTS FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE WI…
Read full complaint
TL* THE CONTACT OWNS A 2002 PONTIAC GRAND PRIX. AFTER PARKING THE VEHICLE, THE CONTACT NOTICED SMOKE COMING FROM THE ENGINE COMPARTMENT. THE CONTACT WAS ABLE TO CONTAIN THE FIRE. THERE WERE NO POLICE OR FIRE REPORTS FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE WIRE HARNESS FAILED. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT NOTIFIED OF THE FAILURE. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT UNDER RECALL. THE FAILURE MILEAGE WAS 135,491.
NHTSA ODI #11074323
160 miles · Aug 16, 2017
EngineFuel/propulsion System
TAKATA RECALL! AS I WAS DRIVING ON THE FREEWAY MY CAR SHUT OFF AND THE WHEEL LOCKED UP! MY DAD GOT EVERYTHING ON MY CAR REPLACE BUT IT STILL DOES THE SAME THING!
NHTSA ODI #11015734
198,000 miles · Apr 12, 2017
EngineFire
TL* THE CONTACT OWNED A 2002 PONTIAC GRAND PRIX. THE CONTACT STATED THAT THE ENGINE CAUGHT FIRE. THE DRIVER NOTICED SMOKE UNDER THE HOOD WHILE THE VEHICLE WAS PARKED. THE DRIVER RELEASED THE HOOD AND FOUND THAT THE ENGINE WAS ON FIRE. THE VEHICLE WAS DESTROYED. THE FIRE DEPARTMENT WAS PRESENT AND A FIRE REPORT WAS FILED. THE VIN…
Read full complaint
TL* THE CONTACT OWNED A 2002 PONTIAC GRAND PRIX. THE CONTACT STATED THAT THE ENGINE CAUGHT FIRE. THE DRIVER NOTICED SMOKE UNDER THE HOOD WHILE THE VEHICLE WAS PARKED. THE DRIVER RELEASED THE HOOD AND FOUND THAT THE ENGINE WAS ON FIRE. THE VEHICLE WAS DESTROYED. THE FIRE DEPARTMENT WAS PRESENT AND A FIRE REPORT WAS FILED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING); HOWEVER, THE CONTACT WAS NEVER NOTIFIED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 198,000.
NHTSA ODI #10972017
Mileage unknown · Jan 12, 2017
EngineFuel/propulsion SystemFire
TL* THE CONTACT OWNED A 2002 PONTIAC GRAND PRIX. AFTER THE CONTACT EXITED THE VEHICLE, A PASSERBY ALERTED HIM THAT A FIRE HAD ERUPTED UNDER THE HOOD OF THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. THE VEHICLE WAS DESTROYED AND TOWED TO THE CONTACT'S RESIDENCE. A POLICE REPORT WAS NOT FILED. THE CONTACT WAS NEITHER A…
Read full complaint
TL* THE CONTACT OWNED A 2002 PONTIAC GRAND PRIX. AFTER THE CONTACT EXITED THE VEHICLE, A PASSERBY ALERTED HIM THAT A FIRE HAD ERUPTED UNDER THE HOOD OF THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. THE VEHICLE WAS DESTROYED AND TOWED TO THE CONTACT'S RESIDENCE. A POLICE REPORT WAS NOT FILED. THE CONTACT WAS NEITHER AWARE NOR NOTIFIED OF NHTSA CAMPAIGN NUMBERS: 07E021000 (FUEL SYSTEM, OTHER), 08V118000 (ENGINE AND ENGINE COOLING), AND 09V116000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.
NHTSA ODI #10944638
160,000 miles · Dec 19, 2016
EngineFire
TL* THE CONTACT OWNED A 2002 PONTIAC GRAND PRIX. UPON ENTERING THE VEHICLE AND SHIFTING INTO GEAR, THE CONTACT SMELLED A BURNING ODOR AND NOTICED SMOKE. THE CONTACT EXITED THE VEHICLE AND ALERTED THE FIRE DEPARTMENT. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHICLE WAS NOT REMOVED FROM THE CONTACT'S RESIDENCE. THE VEHICLE …
Read full complaint
TL* THE CONTACT OWNED A 2002 PONTIAC GRAND PRIX. UPON ENTERING THE VEHICLE AND SHIFTING INTO GEAR, THE CONTACT SMELLED A BURNING ODOR AND NOTICED SMOKE. THE CONTACT EXITED THE VEHICLE AND ALERTED THE FIRE DEPARTMENT. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHICLE WAS NOT REMOVED FROM THE CONTACT'S RESIDENCE. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 160,000.
NHTSA ODI #10936134
Mileage unknown · Dec 15, 2016
Engine
CAR HAS RECALL. SAYS OIL MAY DRIP UNTO EXHAUST CAUSING FIRE. I CANNOT FIND A DEALER TO HELP ME GET THIS FIXED. PLEASE HELO ME
NHTSA ODI #10935555
174,000 miles · Nov 30, 2016
EngineStructureWheelsFire
ON SUNDAY NOVEMBER 20TH 2016 MY 17 YEAR OLD SON PULLED UP TO A GAS STATION IN GRAND ISLAND NE. HE WENT INSIDE TO PRE PAY FOR HIS GAS AND A MAN CAME INSIDE SAYING THERE WAS A CAR IN FIRE. MY SONS 17 YEAR OLD GIRLFRIEND WAS INSIDE VEHICLE SLEEPING AND IT HAD IGNITED UNDER FLAMES IN THE HOOD. HE HAD DRIVEN FROM LINCOLN,NE TO AURORA…
Read full complaint
ON SUNDAY NOVEMBER 20TH 2016 MY 17 YEAR OLD SON PULLED UP TO A GAS STATION IN GRAND ISLAND NE. HE WENT INSIDE TO PRE PAY FOR HIS GAS AND A MAN CAME INSIDE SAYING THERE WAS A CAR IN FIRE. MY SONS 17 YEAR OLD GIRLFRIEND WAS INSIDE VEHICLE SLEEPING AND IT HAD IGNITED UNDER FLAMES IN THE HOOD. HE HAD DRIVEN FROM LINCOLN,NE TO AURORA,NE STAYED FOR AN HOUR PLUS THEN DROVE 20 MILES TO TRUCK STOP. CAR HAD A FIRE UNDER THE HOOD AND BLEW FRONT TIRES AND IS A TOTAL LOSS. IT WAS SITTING NEXT TO A GAS PUMP WITH NO POWER.HAD A OCCUPANT IN VEHICLE SLEEPING. THE FRONT END IS GONE ALONG WITH PASSENGER SIDE OF VEHICLE. WAS WAITING FOR RECALL PARTS AT LOCAL DEALER HAD APPT FOR NEXT DAY TO FIX ISSUE!!! CONTACT FOR PHOTOS
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence & remedy
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE07006 · Engine Compartment Fire
Opened Jan 29, 2007 · Closed Jun 12, 2007
Status: closed (inferred from source dates) · Engine And Engine Cooling
ON JANUARY 29, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED NON-CRASH FIRES ORIGINATING IN THE ENGINE COMPARTMENT IN CERTAIN MODEL YEAR (MY) 1999-2002 PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE ?L67? SUPERCHARGED VERSION OF THE GENERAL MOTORS (GM) 3800 SERIES II V6 ENGINE.TO DATE, ODI IS AWARE OF 121 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES THAT ALLEGE NON-CRASH RELATED FIRES ORIGINATING IN THE ENGINE COMPARTMENT WHILE DRIVING OR AFTER THE VEHICLE IS PARKED AND THE IGNITION SWITCHED OFF. WHILE NO SUBJECT COMPONENT HAS YET BEEN IDENTIFIED, ODI ANALYSIS OF AVAILABLE INFORMATION INDICATES THAT THE ALLEGED FIRE INCIDENT RATE AMONG THE SUBJECT VEHICLES IS SIGNIFICANTLY HIGHER THAN GM PEER VEHICLES THAT USE THE NON-SUPERCHARGED ?L36? VERSION OF THE GM 3800 SERIES II V6 ENGINE.IN SOME CASES, THE FIRE INCIDENT RATE IS TWICE AS HIGH IN THE SUBJECT VEHICLES AND UP TO AS MUCH AS AN ORDER OF MAGNITUDE GREATER THAN IN NON-SUPERCHARGED PEER VEHICLES.FOR INSTANCE, THE SUBJECT FIRE INCIDENT RATE FOR THE SUPERCHARGED MY 2000 PONTIAC GRAND PRIX GTP IS APPROXIMATELY 236 PER 100,000 VEHICLES PRODUCED (58 FIRES / 24,509 SUBJECT VEHICLES OR 0.236%) WHILE THE FIRE INCIDENT RATE FOR MY 2000 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH THE NATURALLY ASPIRATED ?L36? ENGINE IS APPROXIMATELY 18 PER 100,000 VEHICLES PRODUCED (17 FIRES / 90,338 VEHICLES OR 0.018%). THE MANUFACTURER?S INVESTIGATION INTO ALLEGED ENGINE COMPARTMENT FIRES ON THE SUBJECT VEHICLES IS ONGOING.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-008) TO FURTHER STUDY THE FREQUENCY AND SCOPE OF THE ALLEGED DEFECT. BASED ON THE INFORMATION REVIEWED IN PE07-006, THE RANGE OF SUBJECT VEHICLES UNDER INVESTIGATION WILL BE EXPANDED TO INCLUDE ALL MY 1999-2002 BUICK PARK AVENUE, REGAL, AND RIVIERA, OLDSMOBILE LSS, AND PONTIAC BONNEVILLE AND GRAND PRIX VEHICLES THAT USE THE SAME OR SUBSTANTIALLY SIMILAR TRANSVERSE MOUNTED ?L67? ENGINE.
THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA FOR RELEVANT BRAKE LAMP MALFUNCTIONS THAT REQUIRE REPLACEMENT OF THE MULTIFUNCTION SWITCH (MFS) MODULE.THE HAZARD WARNING SWITCH IS AN INTEGRAL PART OF THE MFS MODULE.OTHER COMPONENTS THAT AFFECT BRAKE LAMP ILLUMINATION SUCH AS WIRING, BULB SOCKETS, AND THE PLUNGER-TYPE BRAKE LAMP SWITCH, WERE NOT A PART OF THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Electrical System
THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA FOR RELEVANT BRAKE LAMP MALFUNCTIONS THAT REQUIRE REPLACEMENT OF THE MULTIFUNCTION SWITCH (MFS) MODULE.THE HAZARD WARNING SWITCH IS AN INTEGRAL PART OF THE MFS MODULE.OTHER COMPONENTS THAT AFFECT BRAKE LAMP ILLUMINATION SUCH AS WIRING, BULB SOCKETS, AND THE PLUNGER-TYPE BRAKE LAMP SWITCH, WERE NOT A PART OF THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:brake Lights
THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA FOR RELEVANT BRAKE LAMP MALFUNCTIONS THAT REQUIRE REPLACEMENT OF THE MULTIFUNCTION SWITCH (MFS) MODULE.THE HAZARD WARNING SWITCH IS AN INTEGRAL PART OF THE MFS MODULE.OTHER COMPONENTS THAT AFFECT BRAKE LAMP ILLUMINATION SUCH AS WIRING, BULB SOCKETS, AND THE PLUNGER-TYPE BRAKE LAMP SWITCH, WERE NOT A PART OF THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
2002 Pontiac Grand Prix Problems, Complaints & Recalls | Skip That Year
Illustration