NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
56 reportsClear category filter92,000 miles · Nov 8, 2006
Electrical System
THE KEY IS STUCK IN THE IGNITION. I AM UNABLE TO TAKE IT OUT EVEN WHEN ALL GEARS HAVE BEEN SWITCHED TO PARK. THE WERE NO EVENTS THAT GAVE ME WARNING ANY THING WAS WRONG WITH THE IGNITION. AT THIS POINT THIS IS THE 3RD PONTIAC GRAND PRIX RANGING IN YEARS 2001-2003 THAT I HAVE KNOWN THIS TO HAPPEN TO. THE KEY IS STILL STUCK IN THE…
Read full complaint
THE KEY IS STUCK IN THE IGNITION. I AM UNABLE TO TAKE IT OUT EVEN WHEN ALL GEARS HAVE BEEN SWITCHED TO PARK. THE WERE NO EVENTS THAT GAVE ME WARNING ANY THING WAS WRONG WITH THE IGNITION. AT THIS POINT THIS IS THE 3RD PONTIAC GRAND PRIX RANGING IN YEARS 2001-2003 THAT I HAVE KNOWN THIS TO HAPPEN TO. THE KEY IS STILL STUCK IN THERE. PRICE QUOTES I HAVE GOT RANGE FROM $1,000.00- $2,000.00 DEPENDING ON IF THEY HAVE TO RESET THE AIRBAG. *NM
NHTSA ODI #10172983
Mileage unknown · Oct 16, 2006
Electrical SystemExterior Lighting
2002 PONTIAC GRAND PRIX GT. AFTER ENGAGING HAZARD WARNING SWITCH TO ON, THEN TO OFF, BRAKE LIGHTS FAIL TO WORK. HAVE TO WIGGLE HAZARD SWITCH TO GET BRAKES WORKING AGAIN. ALL BRAKE LIGHTS GO OUT AFTER HAZARD SWITCH IS TURNED OFF. FAULTY TURN SIGNAL-HAZARD SWITCH MODULE. UNCERTAIN IF BRAKE LIGHTS ARE WORKING UNLESS CONSTANT CHE…
Read full complaint
2002 PONTIAC GRAND PRIX GT. AFTER ENGAGING HAZARD WARNING SWITCH TO ON, THEN TO OFF, BRAKE LIGHTS FAIL TO WORK. HAVE TO WIGGLE HAZARD SWITCH TO GET BRAKES WORKING AGAIN. ALL BRAKE LIGHTS GO OUT AFTER HAZARD SWITCH IS TURNED OFF. FAULTY TURN SIGNAL-HAZARD SWITCH MODULE. UNCERTAIN IF BRAKE LIGHTS ARE WORKING UNLESS CONSTANT CHECKING. HAVE TO CONTINUE TO WIGGLE HAZARD SWITCH BUTTON TO GET THEM TO FUNCTION AGAIN. VERY DANGEROUS. *NM
NHTSA ODI #10170902
50,000 miles · Oct 4, 2006
Electrical System
1) NONE 2) WHEN PARKING MY 2002 GRAND PRIX SE IT MORE OFTEN THAN NOT, WILL NOT RELEASE THE KEY. THE ENGINE WILL TURN OFF HOWEVER, THE SWITCH WILL NOT TURN BACK COMPLETELY TO RELEASE THE KEY. 3) THE ONLY SOLUTIONS THAT ONLY SOMETIMES WORK ARE TO A) MOVE TO A DIFFERENT PARKING SPOT AND TRY TURNING THE CAR OFF AGAIN WHICH RAR…
Read full complaint
1) NONE 2) WHEN PARKING MY 2002 GRAND PRIX SE IT MORE OFTEN THAN NOT, WILL NOT RELEASE THE KEY. THE ENGINE WILL TURN OFF HOWEVER, THE SWITCH WILL NOT TURN BACK COMPLETELY TO RELEASE THE KEY. 3) THE ONLY SOLUTIONS THAT ONLY SOMETIMES WORK ARE TO A) MOVE TO A DIFFERENT PARKING SPOT AND TRY TURNING THE CAR OFF AGAIN WHICH RARELY WORKS, B) TURNING THE STEERING WHEEL BACK AND FORTH UNTIL A "CLICK" IS HEARD THEN KEY CAN BE TAKEN OUT, OR C)SOMETIMES JUST MOVING THE SHIFTER FROM PARK DOWN THROUGH ALL GEARS AND BACK TO PARK AGAIN SOMETIMES WORKS. AND D) JUST LETTING THE CAR SIT FOR OVER 5 MINUTES OR SO WITH NO ACTION BEING TAKEN AND THEN A "CLICK" IS HEARD AND THE KEY CAN THEN BE RELEASED. SEE WWW.AUTOMOTIVEFORUMS.COM AND SEARCH "KEY STUCK IGNITION SWITCH" FOR NUMEROUS COMPLAINTS EXACTLY LIKE THIS FOR ALL YEARS OF PONTIAC GRAND PRIX'S. *JB
NHTSA ODI #10169956
90,000 miles · Jun 7, 2006
Electrical SystemEngine And Engine CoolingPower TrainFire
I WAS DRIVING THE 2002 PONTIAC GRAND PRIX GTP ON A HIGHWAY WITH 45-55 MPH SPEED LIMIT FOR APPROX. 45 MIN. THE CAR SHUT OFF 15 SEC. AFTER I HEARD THE ENGINE BACKFIRE. THE SPEEDOMETER WENT FROM 0 ALL THE WAY UP, AND BACK TO 0. I PULLED INTO THE NEAREST PARKING LOT AND POPPED THE HOOD. I DISCOVERED A FIRE NEAR THE INTAKE AND …
Read full complaint
I WAS DRIVING THE 2002 PONTIAC GRAND PRIX GTP ON A HIGHWAY WITH 45-55 MPH SPEED LIMIT FOR APPROX. 45 MIN. THE CAR SHUT OFF 15 SEC. AFTER I HEARD THE ENGINE BACKFIRE. THE SPEEDOMETER WENT FROM 0 ALL THE WAY UP, AND BACK TO 0. I PULLED INTO THE NEAREST PARKING LOT AND POPPED THE HOOD. I DISCOVERED A FIRE NEAR THE INTAKE AND THE LOWER RIGHT SIDE OF THE VALVE COVER. THE CAR WAS TOWED TO A PONTIAC DEALER. THEY REPLACED THE FUEL INJECTORS, THE LOWER INTAKE, VALVE COVER, SPARK PLUG WIRES, ELECTRICAL HARNESS AND MUCH MOTOR THE COST WAS APPROX. $5000. AFTER SAYING IT WOULD TAKE 2 WEEKS, IT TOOK THE SHOP 6 OR 7 WEEKS TO FIX, SO MY CAR RENTAL BILL WAS THOUSANDS MORE THAN INSURANCE WOULD COVER THE CAR WASN'T NEARLY AS RESPONSIVE AND HAD TROUBLE GOING UP EVEN THE SMALLEST INCLINES. ALSO, THE SHIFT-PARK INTERLINK STOPPED WORKING SO THE CAR WOULD NOT SHIFT OUT OF PARK AFTER THE FIRE. AND MY SUNROOF HASN'T WORKED SINCE. AND MY FAN FOR THE A/C AND HEATER ONLY WORKS WITH THE FAN ON 5. ALSO I HAVE NOTICED A WEIRD SOUND COMING FROM THE SPEAKERS ON OCCASION. ABOUT A WEEK OR TWO LATER THE CAR WAS IN THE SHOP BECAUSE THEY HAD NOT REPLACED THE SPARK PLUGS; ONE OF THEM WAS CRACKED AND WAS MOST LIKELY CRACKED WHEN I GOT THE CAR BACK. THE CAR HAD ABOUT 90,000 MILES WHEN IT HAD CAUGHT FIRE. THEN ON JUNE 3, 2006-AFTER LESS THAN 2000 MILES, THE ENGINE LOCKED UP. THE DEALER SAID THE ONLY OPTION THEY CAN DO TO FIX IT IS PUT A NEW ENGINE IN--THE INITIAL ESTIMATE IS $5200. ALSO, I'M GOING TO BE OUT OF A CAR AGAIN AND WILL HAVE THE BURDEN OF RENTAL CAR COSTS AGAIN. FROM WHAT I HAVE READ, THERE HAVE BEEN NUMEROUS FIRES INVOLVING THE GM 3.8. SOMETHING NEEDS TO BE DONE. *NM
NHTSA ODI #10159167
60,000 miles · May 30, 2006
Electrical System
MY VEHICLE STALLED WHILE I WAS DRIVING ON A BUSY 5 LANE ROAD (2 LANES GOING EACH WAY - AND A TURN LANE). I COULD TELL THAT IT WAS ABOUT TO STALL AND WAS ABOUT TO TURN INTO A BUSINESS PARKING LOT. MY VEHICLE COMPLETELY STALLED IN THE TURN LANE. I WAS FORTUNATE THAT I WAS NOT HURT AND THAT THERE WAS NO ACCIDENT. I WAS ABLE TO …
Read full complaint
MY VEHICLE STALLED WHILE I WAS DRIVING ON A BUSY 5 LANE ROAD (2 LANES GOING EACH WAY - AND A TURN LANE). I COULD TELL THAT IT WAS ABOUT TO STALL AND WAS ABOUT TO TURN INTO A BUSINESS PARKING LOT. MY VEHICLE COMPLETELY STALLED IN THE TURN LANE. I WAS FORTUNATE THAT I WAS NOT HURT AND THAT THERE WAS NO ACCIDENT. I WAS ABLE TO PUT THE HAZARD LIGHTS ON AS SOON AS MY CAR WAS DEAD. FORTUNATELY, I HAD A CELL PHONE AND I WAS ABLE TO CALL ROADSIDE ASSISTANCE. *JB
NHTSA ODI #10158556
40,600 miles · May 12, 2006
Electrical SystemFire
10/31/05 CAR CLEANED AT CAR WASH. 11/01/05 NOTICED A WINDOW CLEANER SMELL, WHILE DRIVING COMING THROUGH THE AIR VENTS FOR A MINUTE. 11/12/05, 12:45 P.M. DROVE THE CAR 6 MINUTES TO A HAIR SALON. 1:45 P.M. STARTED FOR HOME, PARKED AT CONVENIENCE STORE, LEFT CAR RUNNING WITH MY PERMANENTLY DISABLED HUSBAND INSIDE. PROCEEDED HOM…
Read full complaint
10/31/05 CAR CLEANED AT CAR WASH. 11/01/05 NOTICED A WINDOW CLEANER SMELL, WHILE DRIVING COMING THROUGH THE AIR VENTS FOR A MINUTE. 11/12/05, 12:45 P.M. DROVE THE CAR 6 MINUTES TO A HAIR SALON. 1:45 P.M. STARTED FOR HOME, PARKED AT CONVENIENCE STORE, LEFT CAR RUNNING WITH MY PERMANENTLY DISABLED HUSBAND INSIDE. PROCEEDED HOME NOTICED THE WINDOW CLEANER SMELL AGAIN. 1:58 P.M. PARKED IN CONDOMINIUM PARKING LOT. 2:20 P.M. OUR NEIGHBOR TOLD ME OUR CAR IS ON FIRE. THERE WERE FLAMES 10' HIGH COMING OFF THE FRONT OF MY CAR. A LOUD EXPLOSION OCCURRED AND THE POLICE AND FIREMEN WERE SHOUTING TO GET BACK DOWN THE HILL AND GET THE CHILDREN ALL THE WAY DOWN THE HILL! I TOLD THE OFFICER THAT I WAS THE OWNER OF THE BURNING CAR. OUR NEIGHBOR TOLD ME HER TOYOTA WAS PARKED ON THE RIGHT OF MINE AND IT WAS ON FIRE TOO. WHEN THE FIRE WAS OUT, THE POLICE OFFICER TOLD ME THE HONDA CR-V ON THE LEFT OF MY CAR WAS ALSO BURNED, AND THEY WOULD NOTIFY THE OWNER. 2:35 P.M. A FIREMAN GOT THE REGISTRATION AND PERSONAL BELONGINGS OUT FOR ME. BEFORE MY CAR WAS TOWED AWAY, I TOOK PICTURES AND ASKED THE TOW TRUCK OWNER, IF HE COULD GIVE A REASON MY CAR BURNED UP. HE SAID IT LOOKS ELECTRICAL TO ME. SUNDAY, 11/13/05, 3:00 P.M. OUR SON-IN-LAW, A FIRE INSPECTOR FOR THE CLIFTON FIRE DEPARTMENT CAME TO THE UNOFFICIAL CONCLUSION THAT, IT LOOKS ELECTRICAL DUE TO THE BURN PATTERN. I REPORTED THE FIRE TO MY INSURANCE CARRIER AND GENERAL MOTORS CORPORATION. I WAS CONTACTED BY ESIS FOR GMC, AND SUPPLIED ALL THE DETAILS, PICTURES AND COPIES OF REPAIR ORDERS. THIS IS A POTENTIAL FOR FATALITIES AND MANY MORE OF THESE ENGINE FIRES WILL OCCUR IF THE CAUSE IS NOT FOUND. *JB
NHTSA ODI #10157414
49,000 miles · Nov 2, 2005
Electrical System
(1) NO EVENTS (2) IGNITION SWITCH KEY WON'T COME OUT (3) NOTHING DONE SO FAR AS DEALER CAN NOT GIVE DEFINITE ANSWER ON WHAT NEEDS REPAIR OR REPLACEMENT...EITHER THEY HAVE NO IDEA AS TO THE SOURCE OF THE PROBLEM OR THEY ARE RUNNING A SCAM TO BLEED MY BANK ACCOUNT........ OTHERS HAVE POSTED SIMILAR MESSAGES ON FORUMS WITH NEGAT…
Read full complaint
(1) NO EVENTS (2) IGNITION SWITCH KEY WON'T COME OUT (3) NOTHING DONE SO FAR AS DEALER CAN NOT GIVE DEFINITE ANSWER ON WHAT NEEDS REPAIR OR REPLACEMENT...EITHER THEY HAVE NO IDEA AS TO THE SOURCE OF THE PROBLEM OR THEY ARE RUNNING A SCAM TO BLEED MY BANK ACCOUNT........ OTHERS HAVE POSTED SIMILAR MESSAGES ON FORUMS WITH NEGATIVE RESULTS AND HUNDREDS OR THOUSANDS OF DOLLARS IN REPAIRS WITHOUT SOLVING THE PROBLEM....... MOST LIKELY RESPONSE FOUND WAS REPLACE THE PARKING LOCK RELAY. *NM
NHTSA ODI #10141539
17,000 miles · Oct 18, 2005
Electrical System
DT: THE CONTACT OWNS A 2002 PONTIAC GRAND PRIX. THE SECURITY SYSTEM IS TOO SENSITIVE BECAUSE THE CAR WILL LOCK AND HE HAS TO WAIT FOR 20 MINUTES TO MOVE THE VEHICLE. THIS WILL OCCUR IF THE KEY IS DIRTY OR ANYTHING THAT WILL TRIGGER THE ANTI-THEFT SYSTEM. HE DOES NOT MIND THAT THE CAR HAS THIS FEATURE. BUT THE FEATURE IS TOO S…
Read full complaint
DT: THE CONTACT OWNS A 2002 PONTIAC GRAND PRIX. THE SECURITY SYSTEM IS TOO SENSITIVE BECAUSE THE CAR WILL LOCK AND HE HAS TO WAIT FOR 20 MINUTES TO MOVE THE VEHICLE. THIS WILL OCCUR IF THE KEY IS DIRTY OR ANYTHING THAT WILL TRIGGER THE ANTI-THEFT SYSTEM. HE DOES NOT MIND THAT THE CAR HAS THIS FEATURE. BUT THE FEATURE IS TOO SENSITIVE. THIS OCCURRED A LOT HERE LATELY. THE CONTACT CONTACTED THE MANUFACTURER, AND THEY TOLD HIM THAT THEY COULD NOT RESET THE SYSTEM, AND THERE WAS NOTHING THEY COULD DO ABOUT THIS VEHICLE BECAUSE THIS WAS SIMPLY THE WAY IT WAS MADE. *AK *JB
NHTSA ODI #10136994
57,000 miles · Jun 26, 2005
Electrical System
UNABLE TO EXTRACT KEY FROM THE IGNITION AFTER PUTTING THE CAR IN PARK. IN MOST FAILURES, I HAVE HAD TO RESTART THE CAR AND GO BACK THROUGH ALL OF THE GEARS AND PUT IT BACK INTO PARK THEN REMOVE THE KEY. I WORK WITH AN INDIVIDUAL WITH THE SAME YEAR CAR AND SHE RECENTLY HAD THE SAME ISSUE. HER CAR WAS UNDER THE EXTENDED WARRA…
Read full complaint
UNABLE TO EXTRACT KEY FROM THE IGNITION AFTER PUTTING THE CAR IN PARK. IN MOST FAILURES, I HAVE HAD TO RESTART THE CAR AND GO BACK THROUGH ALL OF THE GEARS AND PUT IT BACK INTO PARK THEN REMOVE THE KEY. I WORK WITH AN INDIVIDUAL WITH THE SAME YEAR CAR AND SHE RECENTLY HAD THE SAME ISSUE. HER CAR WAS UNDER THE EXTENDED WARRANTY, BUT TO REPAIR THE PROBLEM IT WOULD HAVE COST OVER $1000 IF SHE HAD NOT HAD THE WARRANTY. I BELIEVE THE ISSUE RELATES TO THE TRANSMISSION NOT SHIFTING FULLING INTO PARK.
NHTSA ODI #10126625
Mileage unknown · Jan 7, 2004
Electrical SystemExterior Lighting
HEADLIGHT AND DASHBOARD LIGHTS FLASH INTERMITTENTLY, APPROXIMATLEY EVERY 2 SECONDS. HAD IT LOOKED AT TWICE BY AW GOLDEN PONTIAC IN READING PA AND WAS TOLD MY CAR "WAS KNOWN TO DO THAT, AND IT CAN'T BE FIXED." ALSO, I CAN LEAVE IT THERE "FOR THE MECHANIC TO DRIVE IT HOME AT NIGHT, SO HE CAN SEE WHAT I'M TALKING ABOUT." MY CAR DO…
Read full complaint
HEADLIGHT AND DASHBOARD LIGHTS FLASH INTERMITTENTLY, APPROXIMATLEY EVERY 2 SECONDS. HAD IT LOOKED AT TWICE BY AW GOLDEN PONTIAC IN READING PA AND WAS TOLD MY CAR "WAS KNOWN TO DO THAT, AND IT CAN'T BE FIXED." ALSO, I CAN LEAVE IT THERE "FOR THE MECHANIC TO DRIVE IT HOME AT NIGHT, SO HE CAN SEE WHAT I'M TALKING ABOUT." MY CAR DOES NOT HAVE THIS PROBLEM EVERYTIME I DRIVE AT NIGHT, MAYBE EVERY OTHER NIGHT, BUT IT IS NO-STOP WHEN IT STARTS. DRIVERS IN FRONT OF ME HIT THEIR BRAKES, BECAUSE THEY THINK I'M FLASHING THEM. I CAN SEE THIS CAUSING A PROBLEM IF I HAVE TO DEAL WITH A PERSON HAVING ROAD RAGE.*AK
NHTSA ODI #10052601
Official recalls
3Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Mar 12, 2008
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence & remedy
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE07006 · Engine Compartment Fire
Opened Jan 29, 2007 · Closed Jun 12, 2007
Status: closed (inferred from source dates) · Engine And Engine Cooling
ON JANUARY 29, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED NON-CRASH FIRES ORIGINATING IN THE ENGINE COMPARTMENT IN CERTAIN MODEL YEAR (MY) 1999-2002 PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE ?L67? SUPERCHARGED VERSION OF THE GENERAL MOTORS (GM) 3800 SERIES II V6 ENGINE.TO DATE, ODI IS AWARE OF 121 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES THAT ALLEGE NON-CRASH RELATED FIRES ORIGINATING IN THE ENGINE COMPARTMENT WHILE DRIVING OR AFTER THE VEHICLE IS PARKED AND THE IGNITION SWITCHED OFF. WHILE NO SUBJECT COMPONENT HAS YET BEEN IDENTIFIED, ODI ANALYSIS OF AVAILABLE INFORMATION INDICATES THAT THE ALLEGED FIRE INCIDENT RATE AMONG THE SUBJECT VEHICLES IS SIGNIFICANTLY HIGHER THAN GM PEER VEHICLES THAT USE THE NON-SUPERCHARGED ?L36? VERSION OF THE GM 3800 SERIES II V6 ENGINE.IN SOME CASES, THE FIRE INCIDENT RATE IS TWICE AS HIGH IN THE SUBJECT VEHICLES AND UP TO AS MUCH AS AN ORDER OF MAGNITUDE GREATER THAN IN NON-SUPERCHARGED PEER VEHICLES.FOR INSTANCE, THE SUBJECT FIRE INCIDENT RATE FOR THE SUPERCHARGED MY 2000 PONTIAC GRAND PRIX GTP IS APPROXIMATELY 236 PER 100,000 VEHICLES PRODUCED (58 FIRES / 24,509 SUBJECT VEHICLES OR 0.236%) WHILE THE FIRE INCIDENT RATE FOR MY 2000 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH THE NATURALLY ASPIRATED ?L36? ENGINE IS APPROXIMATELY 18 PER 100,000 VEHICLES PRODUCED (17 FIRES / 90,338 VEHICLES OR 0.018%). THE MANUFACTURER?S INVESTIGATION INTO ALLEGED ENGINE COMPARTMENT FIRES ON THE SUBJECT VEHICLES IS ONGOING.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-008) TO FURTHER STUDY THE FREQUENCY AND SCOPE OF THE ALLEGED DEFECT. BASED ON THE INFORMATION REVIEWED IN PE07-006, THE RANGE OF SUBJECT VEHICLES UNDER INVESTIGATION WILL BE EXPANDED TO INCLUDE ALL MY 1999-2002 BUICK PARK AVENUE, REGAL, AND RIVIERA, OLDSMOBILE LSS, AND PONTIAC BONNEVILLE AND GRAND PRIX VEHICLES THAT USE THE SAME OR SUBSTANTIALLY SIMILAR TRANSVERSE MOUNTED ?L67? ENGINE.
PE07001 · Loss Of Brake Lamp Illumination
Opened Jan 17, 2007 · Closed Apr 30, 2007
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:brake Lights
THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA FOR RELEVANT BRAKE LAMP MALFUNCTIONS THAT REQUIRE REPLACEMENT OF THE MULTIFUNCTION SWITCH (MFS) MODULE.THE HAZARD WARNING SWITCH IS AN INTEGRAL PART OF THE MFS MODULE.OTHER COMPONENTS THAT AFFECT BRAKE LAMP ILLUMINATION SUCH AS WIRING, BULB SOCKETS, AND THE PLUNGER-TYPE BRAKE LAMP SWITCH, WERE NOT A PART OF THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Electrical System
THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA FOR RELEVANT BRAKE LAMP MALFUNCTIONS THAT REQUIRE REPLACEMENT OF THE MULTIFUNCTION SWITCH (MFS) MODULE.THE HAZARD WARNING SWITCH IS AN INTEGRAL PART OF THE MFS MODULE.OTHER COMPONENTS THAT AFFECT BRAKE LAMP ILLUMINATION SUCH AS WIRING, BULB SOCKETS, AND THE PLUNGER-TYPE BRAKE LAMP SWITCH, WERE NOT A PART OF THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:brake Lights
THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA FOR RELEVANT BRAKE LAMP MALFUNCTIONS THAT REQUIRE REPLACEMENT OF THE MULTIFUNCTION SWITCH (MFS) MODULE.THE HAZARD WARNING SWITCH IS AN INTEGRAL PART OF THE MFS MODULE.OTHER COMPONENTS THAT AFFECT BRAKE LAMP ILLUMINATION SUCH AS WIRING, BULB SOCKETS, AND THE PLUNGER-TYPE BRAKE LAMP SWITCH, WERE NOT A PART OF THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration