NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
22 reportsClear category filter109,000 miles · Mar 2, 2013
EnginePower TrainFire
AFTER HAVING THE TRANSMISSION REPLACED 2 TIMES BY DEALERSHIP, WE HAD TO REPLACE IT AT 99,000 MILES AGAIN OUT OF OUR POCKETS. THE INTAKE MANIFOLD EXPLODED IN MY HUSBANDS FACE IN 2012! WE ALSO HAD THAT FIXED FOR $480.00 OUT OF OUR POCKETS. THEN ON FEBRUARY 22,2013 AFTER PARKING THE VEHICLE , THE ENGINE CAUGHT FIRE WITHIN MINUTES A…
Read full complaint
AFTER HAVING THE TRANSMISSION REPLACED 2 TIMES BY DEALERSHIP, WE HAD TO REPLACE IT AT 99,000 MILES AGAIN OUT OF OUR POCKETS. THE INTAKE MANIFOLD EXPLODED IN MY HUSBANDS FACE IN 2012! WE ALSO HAD THAT FIXED FOR $480.00 OUT OF OUR POCKETS. THEN ON FEBRUARY 22,2013 AFTER PARKING THE VEHICLE , THE ENGINE CAUGHT FIRE WITHIN MINUTES AND COMPLETELY ENGULFED THE CAR!( WE HAD TAKEN IT IN FOR THE ENGINE COMPARTMENT FIRE RECALL AT OUR PONTIAC DEALERSHIP PREVIOUSLY TO BE FIXED.) FIRE WAS SO SEVERE IT WENT UNDER THE CAR AND DOWN THE STREET. WE HAVE 4 CHILDREN AND THIS HAS BEEN NOT ONLY A CONSTANT INCONVENIENCE FOR US, BUT A DANGER TO MY FAMILY! IT IS TIME THAT THIS BE TAKEN SERIOUSLY. *TR
NHTSA ODI #10501021
20,000 miles · Jul 15, 2010
Power Train
I BOUGHT MY PONTIAC GRAND PRIX GT (3.8L) IN LATE '01, I MOSTLY SERVICED EVERYTHING WITH MY ORIGINAL DEALERSHIP WHERE I BOUGHT THE VEHICLE. AFTER ABOUT 3 YEARS (UNDER THE MFG WARRANTY) THE CAR BEGAN HESITATING WHEN ACCELERATING UPHILL & UNDER LOAD AT ABOUT 50-60 MPH, I BROUGHT THE CAR TO THE SERVICE DEPARTMENT (AT THE DEALERSHI…
Read full complaint
I BOUGHT MY PONTIAC GRAND PRIX GT (3.8L) IN LATE '01, I MOSTLY SERVICED EVERYTHING WITH MY ORIGINAL DEALERSHIP WHERE I BOUGHT THE VEHICLE. AFTER ABOUT 3 YEARS (UNDER THE MFG WARRANTY) THE CAR BEGAN HESITATING WHEN ACCELERATING UPHILL & UNDER LOAD AT ABOUT 50-60 MPH, I BROUGHT THE CAR TO THE SERVICE DEPARTMENT (AT THE DEALERSHIP) THE TOOK ME FOR A ROAD TEST WHERE THE PROBLEM WAS DUPLICATED THEN THEY DID SOME DIAGNOSTICS (CHARGED ME FOR IT) BUT THEY COULD NOT FIND ANY SPECIFIC PROBLEM (NO CODES EITHER). MY FATHER HAS A CHEVY IMPALA LS '00 AND HE HAS THE EXACT SAME ISSUE, SO I DECIDED THERE MUST BE SOME KIND OF ISSUE WITH THESE CARS THAT GM SERVICE PEOPLE SHOULD KNOW ABOUT. SO I CALLED THE GM SERVICE CENTER, LEFT A MESSAGE & A TECHNICIAN CALLED ME BACK ONLY TO TELL ME THAT THERE'S ABSOLUTELY "NOTHING" HE CAN TELL ME MORE ABOUT IT AND THERE'S NO KNOW ISSUE / HE HAS NO IDEA WHY BOTH OF OUR CARS (SIMILAR MAKES) HAVE DEVELOPED THE SAME ISSUE. I WENT ALL OVER THE PLACE TO MANY DIFFERENT & INDEPENDENT MECHANIC SHOPS TO NO AVAILABILITY. I FINALLY WAS TOLD THAT THERE'S A KNOWN (& CONFIRMED) ISSUE WITH THESE VEHICLES (THIS WAS AN ISSUE FROM '99 TO '01) AND THAT THE PROBLEM WAS A FAULTY PCM (POWERTRAIN CONTROL MODULE). SO I CALLED UP MY LOCAL DEALERSHIP TO FIND OUT THE PRICE, WHICH THEY TOLD ME WOULD BE OVER "$900.00" FOR THE PART PLUS LABOR CHARGES... I THOUGHT THAT IT WOULD BE NICE OF GM TO OFFER ME SOME REPAIR FOR THIS FAULTY PART THAT HAS DRIVEN ME NUTS FOR YEARS, BUT THEY REFUSED TO DO ANYTHING EVEN A REQUEST TO SIMPLY UPDATE THE PCM SOFTWARE FREE OF CHARGE WAS DENIED TO ME. SO I CHECKED IN TO A DEALRSHIP & ORDERED THE PCM SOFTWARE UPDATED, THE PROBLEM WAS RESOLVED! SO AFTER GOING THRU ALL THE SUGGESTIONS & ELIMINATING PART AFTER PART MYSELF, I FINALLY FIGURED IT OUT! THE PROBLEM WAS FAULTY SOFTWARE ON THE PCM (POWER CONTROL MANAGEMENT) CHIP THAT WAS REFLASHED & NOW WORKS FLAWLESSLY. SHOULDN'T GM AT LEAST REIMBURSE ME FOR THIS? *TR
NHTSA ODI #10343441
67,000 miles · May 19, 2010
Power TrainService Brakes, Hydraulic
TL*THE CONTACT OWNS A 2001 PONTIAC GRAND PRIX. THE CONTACT STATED THAT SHE HAD RECURRING FAILURE WITH HER ANTI-LOCK BRAKES. WHILE BRAKING, THE ABS AND TRACTION SERVICE LIGHTS ILLUMINATED ON THE DASHBOARD AND A "GRUMBLING" SOUND CAN BE HEARD COMING FROM THE BRAKES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO INFORMED THE…
Read full complaint
TL*THE CONTACT OWNS A 2001 PONTIAC GRAND PRIX. THE CONTACT STATED THAT SHE HAD RECURRING FAILURE WITH HER ANTI-LOCK BRAKES. WHILE BRAKING, THE ABS AND TRACTION SERVICE LIGHTS ILLUMINATED ON THE DASHBOARD AND A "GRUMBLING" SOUND CAN BE HEARD COMING FROM THE BRAKES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO INFORMED THE CONTACT THAT THE HUBS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED INDEPENDENTLY. THE FAILURE CONTINUED TO OCCUR. THE FAILURE MILEAGE WAS APPROXIMATELY 67,000. THE CURRENT MILEAGE WAS APPROXIMATELY 72,200. UPDATED 12/21/10*BF UPDATED 12/23/10*JB
NHTSA ODI #10331145
60,000 miles · Feb 18, 2010
Power TrainTraction Control System
OIL LEAKAGE FROM VALVE COVERS, TRANSMISSION FAILURE, HUB ASSEMBLY FAILURE,TRACTION SYSTEM FAILURE. PROBLEMS WITH ONLY 60,000 MILES GM WILL NOT ACKNOWLEDGE RESPONSIBILITY OR ASSIST IN PAYING FOR REPAIRS. FOUND MANY SIMILAR COMPLAINTS. SHOULD NOT HAVE THESE PROBLEMS WITH LOW MILEAGE ON THIS VEHICLE WHICH WAS PURCHASED NEW AND WELL…
Read full complaint
OIL LEAKAGE FROM VALVE COVERS, TRANSMISSION FAILURE, HUB ASSEMBLY FAILURE,TRACTION SYSTEM FAILURE. PROBLEMS WITH ONLY 60,000 MILES GM WILL NOT ACKNOWLEDGE RESPONSIBILITY OR ASSIST IN PAYING FOR REPAIRS. FOUND MANY SIMILAR COMPLAINTS. SHOULD NOT HAVE THESE PROBLEMS WITH LOW MILEAGE ON THIS VEHICLE WHICH WAS PURCHASED NEW AND WELL MAINTAINED. TOLD BY CERTIFIED MECHANICS THAT THESE PROBLEMS SHOULD NOT HAVE HAPPENED. *TR
NHTSA ODI #10311904
7,000 miles · Feb 11, 2010
Power TrainCrash
PONTIAC GRAND PRIX 2001: WAS HIT BY ANOTHER CAR IN THE LEFT REAR WHILE CAR WAS AT RED STOP LIGHT WAITING FOR GREEN LIGHT, SPINNED, WENT ON TO "AUTOMATIC" DRIVE AND HIT FIRE HYDRANT ON THE RIGHT SIDE FENDER. THE IMPACT MAY HAVE BEEN TOO GREAT TO CAUSE THE VEHICLE TO MOVE PASSED MEDIAN AND STILL HIT A FIRE HYDRANT AND STOP SIGN …
Read full complaint
PONTIAC GRAND PRIX 2001: WAS HIT BY ANOTHER CAR IN THE LEFT REAR WHILE CAR WAS AT RED STOP LIGHT WAITING FOR GREEN LIGHT, SPINNED, WENT ON TO "AUTOMATIC" DRIVE AND HIT FIRE HYDRANT ON THE RIGHT SIDE FENDER. THE IMPACT MAY HAVE BEEN TOO GREAT TO CAUSE THE VEHICLE TO MOVE PASSED MEDIAN AND STILL HIT A FIRE HYDRANT AND STOP SIGN AT THE INTERSECTION. MY WIFE SUFFERED MULTIPLE INJURIES, I.E., BROKEN RIBS, NECK WOUNDS, ORGAN BURST, ETC., THAT KILLED HER AT THE SCENE. I HAVE SEEN A CAR THAT WENT ON "CRAZY SPIN" AFTER RUNNING OVER A PIECE OF TIRE ON THE ROAD. I HAVE BEEN BOTHERED BY THAT INCIDENT WHICH HAPPENED JUST A MONTH AFTER MY WIFE'S DEATH AND BEGAN TO QUESTION THE DESIGN OF FRONT WHEEL DRIVEN CARS THAT GO ON TO "AUTOMATIC" DRIVE AFTER ANY DISTURBANCE. THE OTHER CAR THAT HIT MY WIFE'S CAR IS SMALLER AND IT MUST HAVE BEEN MOVING OVER THE SPEED LIMIT OF 35 MPH TO HAVE TO CAUSE THE GRAND PRIX TO DEVELOP THAT MUCH MOTION AND MOVE AT RANDOM.. AND IT MUST BE THE MECHANISM OR TRANSMISSION THAT TRIGGERED IT TO MOVE. THEORIZE THAT THE GRAND PRIX WAS AT STOP AND BRAKES APPLIED, CAR WOULD NOT MOVE THE DISTANCE IT HAD IF NOT UNDERGONE "AUTOMATIC". THERE WERE PREVIOUS REPORTS ABOUT FRONT WHEEL CARS/ENGINES BEFORE THEY BECAME COMMON. THE GRAND PRIX'S ON-STAR DID NOT ACTIVATE OR FUNCTION, ALSO THE AIR BAG DID NOT DEPLOY. IT WAS NOT PHYSICALLY POSSIBLE FOR THE GRAND PRIX TO MOVE THAT MUCH DISTANCES IF ATTRIBUTED ONLY TO OTHER VEHICLE HITTING IT. THE GRAND PRIX PRO-PERFORMANCE CLAIM WAS SOMETHING THAT HAVE BEEN PUT TOGETHER WITHOUT SAFETY CHECKS. NON-DEPLOYMENT OF THE AIR BAG ALSO HAD DELAYED RESCUE AND THE "ON STAR" CLAIM OF IMMEDIATE ALERT DID NOT WORK. HOW SAFE ARE THE FRONT WHEEL CARS NOW? I HAVE TO READ BACK POPULAR MECHANICS MAGAZINE 1978'S BACK ISSUES TO FIND THE ARTICLE ON THE FRONT WHEEL DRIVE CARS. I FEEL THAT THE SPEED OF THE OTHER CAR WAS NOT THE FACTOR THAT MADE THE GRAND PRIX GO ON RANDOM MOTION. THERE MUST BE FUEL INJECTION MECHANISM/COMPONENT PROBLEM. *TR
NHTSA ODI #10308647
94,500 miles · May 4, 2008
Power Train
ON A COLD START THE CAR WILL NOT GO INTO GEAR UNTIL IT WARMS UP. HAPPENS EVERYTIME AS LONG AS THE CAR HAS SAT FOR A FEW HOURS. *TR
NHTSA ODI #10226612
Mileage unknown · Apr 22, 2008
Electrical SystemEngine And Engine CoolingEquipment
2001 PONTIAC GRAND PRIX ENGINE OIL LEAK, INTERIOR WATER LEAK AT PASSENGER DOOR *CW THE DEALER INFORMED THE CONSUMER THAT THE WATER LEAK MAY HAVE BEEN A RESULT OF THE DOOR BEING MISALIGNED. THE VEHICLE PULLED TO THE LEFT. THE CONSUMER WAS THEN INFORMED THE REASON FOR THE PULLING OF THE VEHICLE WAS DUE TO THE INFERIOR TIRES ON TH…
Read full complaint
2001 PONTIAC GRAND PRIX ENGINE OIL LEAK, INTERIOR WATER LEAK AT PASSENGER DOOR *CW THE DEALER INFORMED THE CONSUMER THAT THE WATER LEAK MAY HAVE BEEN A RESULT OF THE DOOR BEING MISALIGNED. THE VEHICLE PULLED TO THE LEFT. THE CONSUMER WAS THEN INFORMED THE REASON FOR THE PULLING OF THE VEHICLE WAS DUE TO THE INFERIOR TIRES ON THE VEHICLE. THE STICKER IN THE TRUNK SPECIFIED H RATED TIRES, HOWEVER THE TIRES THE DEALER SOLD ON THE VEHICLE WERE GOODYEAR EAGLE LS TIRES. THE CD PLAYER WAS INOPERATIVE. THE ENGINE LIGHT ILLUMINATED. THE EGR VALVE AND GASKET WERE REPLACED. THE SUNROOF WAS LEAKING AND THE ALTERNATOR WAS REPLACED. THE LEFT FRONT CV BOOT WAS LEAKING AND THE LEFT FRONT HUB BEARING WAS NOISY. THE IGNITION CYLINDER, PARKING BRAKE, POWER STEERING HOSE, PUMP SEAL, RACK AND PINION AND OUTER TIE ROD WERE REPLACED. *JB
NHTSA ODI #10226154
74,000 miles · Mar 25, 2008
Power Train
PURCHASED USED 2001 PONTIAC GRAND PRIX IN JUNE, 2007. COMPLAINED TO AUTO DEALER THAT CARS TRANSMISSION WAS SLIPPING. THEY TEST DROVE VEHICLE AND STATED IT WAS OK. HAD VEHICLE S TRANSMISSION TESTED A FEW MONTHS LATER - IT IS BAD PER TRANSMISSION PLACE. AUTO DEALER STATES HE WILL PUT IN TRANNY AT COST OF 1,700 TO 1800. TRANSM…
Read full complaint
PURCHASED USED 2001 PONTIAC GRAND PRIX IN JUNE, 2007. COMPLAINED TO AUTO DEALER THAT CARS TRANSMISSION WAS SLIPPING. THEY TEST DROVE VEHICLE AND STATED IT WAS OK. HAD VEHICLE S TRANSMISSION TESTED A FEW MONTHS LATER - IT IS BAD PER TRANSMISSION PLACE. AUTO DEALER STATES HE WILL PUT IN TRANNY AT COST OF 1,700 TO 1800. TRANSMISSION CENTER OFFERED TO PUT IN TRANNY FOR 1200. HE WILL NOT MATCH THE COST NOR PAY FOR IT. I FEEL HE IS PARTIALLY LIABLE FOR THIS AS HE SOLD IT LIKE THAT. PLEASE ADVISE ME OF WHAT LEGAL RIGHTS I HAVE AS A CONSUMER. *TR
NHTSA ODI #10222251
60,000 miles · Apr 3, 2007
Engine And Engine CoolingEquipmentPower Train
PURCHASED THIS CAR USED, IT WAS 2 YEARS OLD WITH ABOUT 21K MILES. KEPT UP WITH ALL MAINTENANCE. DEALER EXTENDED WARRANTY FOR 3 MONTHS. BUT DID NOT NOTIFY ME WHEN THE ORIGINAL MANUFACTURERS WARRANTY EXPIRED SO I WAS UNABLE TO EXTEND. PURCHASED A PLATINUM WARRANTY FROM AAA. TRANSMISSION "BLEW UP" AT 48K MILES. HAD IT REPLACED PER …
Read full complaint
PURCHASED THIS CAR USED, IT WAS 2 YEARS OLD WITH ABOUT 21K MILES. KEPT UP WITH ALL MAINTENANCE. DEALER EXTENDED WARRANTY FOR 3 MONTHS. BUT DID NOT NOTIFY ME WHEN THE ORIGINAL MANUFACTURERS WARRANTY EXPIRED SO I WAS UNABLE TO EXTEND. PURCHASED A PLATINUM WARRANTY FROM AAA. TRANSMISSION "BLEW UP" AT 48K MILES. HAD IT REPLACED PER WARRANTY W/A USED TRANSMISSION AS WARRANTY WOULD NOT PAY FOR NEW ONE. DROVE THE CAR FOR 19 MOS AND 12K MILES AND TRANSMISSION BLEW UP AGAIN! DEALER SAID WARRANTY WAS ONLY GOOD ON TRANSMISSION FOR 1 YEAR AND THEY ARE MAKING INQUIRIES AS TO WHETHER I HAVE TO PAY FOR ANOTHER ONE EVEN THOUGH MY CONTRACT W/AAA WARRANTY CO IS GOOD TO 8/10/08 OR 83,894 MILES. WHY IS MY CAR EATING TRANSMISSIONS??? HELP! *JB
NHTSA ODI #10186893
36,000 miles · Sep 14, 2005
Electrical SystemExterior LightingPower Train
I BOUGHT THE CAR OCT 2003 IT HAD 23000 MILES ON IT AND THEN WHEN IT HIT 30000 MILES THAT'S WHEN TROUBLE STARTED MY HUSBAND WENT TO CHECK ON HIS BROTHER AND TURNED THE CAR OFF AND WAS OFF FOR 1 HOUR AND WENT TO START THE CAR AND IT WOULDN'T STAY RUNNING TOOK IT TO THE LOCAL REPAIR MAN AND HE WORKED ON IT AND NOTHING 250.00 DOLLAR…
Read full complaint
I BOUGHT THE CAR OCT 2003 IT HAD 23000 MILES ON IT AND THEN WHEN IT HIT 30000 MILES THAT'S WHEN TROUBLE STARTED MY HUSBAND WENT TO CHECK ON HIS BROTHER AND TURNED THE CAR OFF AND WAS OFF FOR 1 HOUR AND WENT TO START THE CAR AND IT WOULDN'T STAY RUNNING TOOK IT TO THE LOCAL REPAIR MAN AND HE WORKED ON IT AND NOTHING 250.00 DOLLARS LATER HE HAULED IT THE GM DEALER IN INDEPENDENCE KS. WHERE THEY SAID IT WAS THE ANTI THEFT DEVICE HAD ME LOCKED OUT AND THE HAD TO REPLACE THE MODULE. 480.00 LATER. NOW WHEN I DRIVE A DISTANCE MY CHECK ENGINE LIGHT COMES ON AND MY CAR ACTS LIKE IT TRIES TO CUT OUT AND SHIFTS HARD AND JERKS. AND MY TRACT OFF LIGHT STAYS ON NOW ALL THE TIME. MY LAST GRAND PRIX HAD 160000 MILES ON IT BEFORE IT STARTED ACTING UP. MY LOCAL REPAIR MAN SAID THAT I NEED TO REPLACE THE BRAIN MODULE AND ALL MY PROBLEMS WELL STOP. AND NOW WHEN IT RAINS MY CAR FEEL UP WITH WATER ON THE PASSENGER SIDE FLOOR BOARD 2 INCHES RIGHT NOW SO IF THERE IS A RECALL ON THIS CAR IT NEEDS TO BE THE WHOLE CAR. RIGHT NOW THE CAR HAS 51000 MILES. *JB
NHTSA ODI #10136472
Official recalls
6Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Mar 12, 2008
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence & remedy
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Dec 9, 2002
ON CERTAIN PASSENGER, SPORT UTILITY VEHICLES AND MINI VANS, SOME OF THESE VEHICLES HAVE A PASSENGER AIR BAG THAT WAS MANUFACTURED WITHOUT A CHECK VALVE PIN. AN AIR BAG WITHOUT THE CHECK VALVE PIN COULD PRODUCE INCREASED PRESSURE AT THE ONSET OF THE AIR BAG DEPLOYMENT AND REDUCED PRESSURE AFTERWARD.
Consequence & remedy
Consequence: THIS COULD INCREASE THE SEVERITY OF INJURY TO A PERSON WHO WAS NOT PROPERLY RESTRAINED AND WHO WAS CLOSE TO THE PASSENGER AIR BAG AT THE TIME OF DEPLOYMENT. IT COULD ALSO REDUCE THE AB8ILITY OF THE AIR BAG TO PROTECT A RESTRAINED FRONT SEAT PASSENGER.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PASSENGER AIR BAG. OWNER NOTIFICATION BEGAN DECEMBER 16, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OLDSMOBILE AT 1-800-442-6537, OR SATURN AT 1-800-553-6000, PROMPT #3.
Feb 1, 2001
VEHICLE DESCRIPTION: PASSENGER, SPORT UTILITY VEHICLES AND MINIVANS. THE PASSENGER AIR BAG INFLATOR MODULES WERE BUILT WITHOUT THE CORRECT AMOUNT OF GENERANT, WHICH PRODUCES THE GAS THAT FILLS THE AIR BAG. SOME WERE BUILT WITH A DOUBLE LOAD OF GENERANT AND SOME WERE BUILT WITHOUT GENERANT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, A DOUBLE LOAD OF GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANT. A MODULE WITH NO GENERANT WOULD NOT INFLATE THE AIR BAG, AND THE OCCUPANTS COULD RECEIVE MORE SEVERE INJURIES.
Remedy: DEALERS WILL REPLACE THE PASSENGER AIR BAG MODULE. TELEPHONE CALLS WERE MADE TO OWNERS ON JANUARY 29, 2001. FOLLOW UP OWNER MAILING BEGAN ON APRIL 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR SATURN AT 1-800-553-6000.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE07006 · Engine Compartment Fire
Opened Jan 29, 2007 · Closed Jun 12, 2007
Status: closed (inferred from source dates) · Engine And Engine Cooling
ON JANUARY 29, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED NON-CRASH FIRES ORIGINATING IN THE ENGINE COMPARTMENT IN CERTAIN MODEL YEAR (MY) 1999-2002 PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE ?L67? SUPERCHARGED VERSION OF THE GENERAL MOTORS (GM) 3800 SERIES II V6 ENGINE.TO DATE, ODI IS AWARE OF 121 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES THAT ALLEGE NON-CRASH RELATED FIRES ORIGINATING IN THE ENGINE COMPARTMENT WHILE DRIVING OR AFTER THE VEHICLE IS PARKED AND THE IGNITION SWITCHED OFF. WHILE NO SUBJECT COMPONENT HAS YET BEEN IDENTIFIED, ODI ANALYSIS OF AVAILABLE INFORMATION INDICATES THAT THE ALLEGED FIRE INCIDENT RATE AMONG THE SUBJECT VEHICLES IS SIGNIFICANTLY HIGHER THAN GM PEER VEHICLES THAT USE THE NON-SUPERCHARGED ?L36? VERSION OF THE GM 3800 SERIES II V6 ENGINE.IN SOME CASES, THE FIRE INCIDENT RATE IS TWICE AS HIGH IN THE SUBJECT VEHICLES AND UP TO AS MUCH AS AN ORDER OF MAGNITUDE GREATER THAN IN NON-SUPERCHARGED PEER VEHICLES.FOR INSTANCE, THE SUBJECT FIRE INCIDENT RATE FOR THE SUPERCHARGED MY 2000 PONTIAC GRAND PRIX GTP IS APPROXIMATELY 236 PER 100,000 VEHICLES PRODUCED (58 FIRES / 24,509 SUBJECT VEHICLES OR 0.236%) WHILE THE FIRE INCIDENT RATE FOR MY 2000 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH THE NATURALLY ASPIRATED ?L36? ENGINE IS APPROXIMATELY 18 PER 100,000 VEHICLES PRODUCED (17 FIRES / 90,338 VEHICLES OR 0.018%). THE MANUFACTURER?S INVESTIGATION INTO ALLEGED ENGINE COMPARTMENT FIRES ON THE SUBJECT VEHICLES IS ONGOING.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-008) TO FURTHER STUDY THE FREQUENCY AND SCOPE OF THE ALLEGED DEFECT. BASED ON THE INFORMATION REVIEWED IN PE07-006, THE RANGE OF SUBJECT VEHICLES UNDER INVESTIGATION WILL BE EXPANDED TO INCLUDE ALL MY 1999-2002 BUICK PARK AVENUE, REGAL, AND RIVIERA, OLDSMOBILE LSS, AND PONTIAC BONNEVILLE AND GRAND PRIX VEHICLES THAT USE THE SAME OR SUBSTANTIALLY SIMILAR TRANSVERSE MOUNTED ?L67? ENGINE.
PE07001 · Loss Of Brake Lamp Illumination
Opened Jan 17, 2007 · Closed Apr 30, 2007
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:brake Lights
THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA FOR RELEVANT BRAKE LAMP MALFUNCTIONS THAT REQUIRE REPLACEMENT OF THE MULTIFUNCTION SWITCH (MFS) MODULE.THE HAZARD WARNING SWITCH IS AN INTEGRAL PART OF THE MFS MODULE.OTHER COMPONENTS THAT AFFECT BRAKE LAMP ILLUMINATION SUCH AS WIRING, BULB SOCKETS, AND THE PLUNGER-TYPE BRAKE LAMP SWITCH, WERE NOT A PART OF THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Electrical System
THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA FOR RELEVANT BRAKE LAMP MALFUNCTIONS THAT REQUIRE REPLACEMENT OF THE MULTIFUNCTION SWITCH (MFS) MODULE.THE HAZARD WARNING SWITCH IS AN INTEGRAL PART OF THE MFS MODULE.OTHER COMPONENTS THAT AFFECT BRAKE LAMP ILLUMINATION SUCH AS WIRING, BULB SOCKETS, AND THE PLUNGER-TYPE BRAKE LAMP SWITCH, WERE NOT A PART OF THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:brake Lights
THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA FOR RELEVANT BRAKE LAMP MALFUNCTIONS THAT REQUIRE REPLACEMENT OF THE MULTIFUNCTION SWITCH (MFS) MODULE.THE HAZARD WARNING SWITCH IS AN INTEGRAL PART OF THE MFS MODULE.OTHER COMPONENTS THAT AFFECT BRAKE LAMP ILLUMINATION SUCH AS WIRING, BULB SOCKETS, AND THE PLUNGER-TYPE BRAKE LAMP SWITCH, WERE NOT A PART OF THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration