I WAS DRIVING ON THE EXPRESSWAY AND AS I WAS EXITING I NOTICED SMOKE COMING FROM UNDER THE HOOD. AS I PULLED OVER TO A SIDE STREET THE POWER STEERING WENT OUT, BATTERY LIGHT AND CHECK OIL LIGHTS WENT ON AND THE CAR COMPLETELY DIED. WHEN I LOOKED UNDER THE HOOD THERE WAS A FIRE. I HAVE NOT HAD ANY PROBLEMS WITH THE VEHICLE PRIOR …
Read full complaint
I WAS DRIVING ON THE EXPRESSWAY AND AS I WAS EXITING I NOTICED SMOKE COMING FROM UNDER THE HOOD. AS I PULLED OVER TO A SIDE STREET THE POWER STEERING WENT OUT, BATTERY LIGHT AND CHECK OIL LIGHTS WENT ON AND THE CAR COMPLETELY DIED. WHEN I LOOKED UNDER THE HOOD THERE WAS A FIRE. I HAVE NOT HAD ANY PROBLEMS WITH THE VEHICLE PRIOR BUT DID TAKE THE CAR IN A FEW MONTHS AGO FOR GM RECALL 15757.
NHTSA ODI #10893838
130,000 miles · Jul 2, 2016
EngineFire
OUR CAR BURNED UP ALMOST COMPLETELY, STARTING IN THE ENGINE AREA. THE FIRE APPEARED AFTER DRIVING AND PARKING THE CAR. POLICEMEN AND FIREMEN CAME TO EXTINGUISH AND SAID CAR WAS SO DESTROYED ANY FURTHER INVESTIGATION WOULD BE POSSIBLE. WE HAVE PHOTOS OF THE CAR AND OTHER WITNESSES. AFTER WE HAD IT TOWED AND CRUSHED, GM RECAL…
Read full complaint
OUR CAR BURNED UP ALMOST COMPLETELY, STARTING IN THE ENGINE AREA. THE FIRE APPEARED AFTER DRIVING AND PARKING THE CAR. POLICEMEN AND FIREMEN CAME TO EXTINGUISH AND SAID CAR WAS SO DESTROYED ANY FURTHER INVESTIGATION WOULD BE POSSIBLE. WE HAVE PHOTOS OF THE CAR AND OTHER WITNESSES. AFTER WE HAD IT TOWED AND CRUSHED, GM RECALL 15757 CAME OUT. HOWEVER THEY ARE NOT APPLYING THIS RECALL TO OUR CAR. DO WE HAVE ANY RIGHTS?
NHTSA ODI #10882257
Mileage unknown · May 23, 2016
Engine
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND PRIX. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART TO DO THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIE…
Read full complaint
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND PRIX. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART TO DO THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #10870346
186,000 miles · Apr 21, 2016
EngineFuel/propulsion System
I STARTED SMELLING A STRONG GASOLINE SMELL - SO OPENED THE HOOD TO CHECK WHAT WAS THE CAUSE. I TOOK OFF THE ENGINE COVER AND DISCOVERED THAT THE 3/8" QUICK CONNECTOR AT FUEL RAIL WAS DRIPPING FUEL ALL OVER THE INTAKE MANIFOLD. YIKES!!! THE POTENTIAL FOR A FIRE IS/WAS HUGE. I DO NOT KNOW HOW LONG THIS HAS BEEN HAPPENING.
NHTSA ODI #10860749
110,000 miles · Apr 20, 2016
EngineFire
I RECENTLY RECEIVED A RECALL NOTICE FROM GM, RECALL# 15757, FIRST WEEK OF MARCH 2016 REGARDING THE ENGINE'S FRONT VALVE COVER AND GASKET TO BE REPLACED WITH NEW PARTS DUE TO DROPS OF ENGINE OIL THAT MAY DEPOSIT ON THE EXHAUST MANIFOLD WHICH COULD CAUSE AN ENGINE FIRE. I CALLED DEALERSHIP AND WAS TOLD PARTS WERE STILL NOT AVAILA…
Read full complaint
I RECENTLY RECEIVED A RECALL NOTICE FROM GM, RECALL# 15757, FIRST WEEK OF MARCH 2016 REGARDING THE ENGINE'S FRONT VALVE COVER AND GASKET TO BE REPLACED WITH NEW PARTS DUE TO DROPS OF ENGINE OIL THAT MAY DEPOSIT ON THE EXHAUST MANIFOLD WHICH COULD CAUSE AN ENGINE FIRE. I CALLED DEALERSHIP AND WAS TOLD PARTS WERE STILL NOT AVAILABLE AND I WAS PLACED ON A WAITING LIST. ON APRIL 9, 2016, MY CAR STARTED ON FIRE DUE TO OIL LEAK. THE CAR WAS PARKED FOR 5 MINUTES BEFORE SMOKE AND FIRE STARTED TO COME FROM UNDER THE HOOD. THE FIRE DEPT. DID COME OUT AND PUT THE FIRE OUT, HOWEVER, THE ENTIRE ENGINE COMPARTMENT IS TOTALED. I CONTACTED THE DEALERSHIP ON APRIL 11TH, IN WHICH THE DEALERSHIP STILL DID NOT HAVE THE RECALL PARTS AVAILABLE. I WAS GIVEN GENERAL MOTOR'S PHONE#, CONTACTED THEM AND EXPLAINED THE SITUATION, IN WHICH WE WERE TOLD THAT SOMEONE WOULD COME OUT IN 48 HRS TO ASSESS DAMAGE. HOWEVER, ON APRIL 13TH, I RECEIVED A PHONE CALL FROM AN ADVISOR STATING THAT FURTHER INFORMATION IS NEEDED FROM ME. NO ONE HAS COME OUT TO ASSESS DAMAGE AS ORIGINALLY STATED, AS WELL, I HAD TO EMAIL SEVERAL PICTURES AND PAPERWORK THAT WAS REQUESTED. WHEN I ATTEMPT TO CONTACT THE ADVISOR THROUGH EMAIL OR PHONE, SHE DOES NOT RESPOND TO ANY OF MY INQUIRIES. I EXPLAINED WE ARE IN NEED OF A RENTAL SINCE I'M OUT A VEHICLE, HOWEVER, I WAS TOLD THAT IS NOT THEIR CONCERN, AS WELL, IT COULD TAKE 20-30 BUSINESS DAYS TO DETERMINE ANYTHING. I'M NOT SURE IF I SHOULD ENTRUST GM TO TAKE CARE OF THIS SITUATION OR GET LEGAL ADVICE. I ALSO HAVE PICTURES AVAILABLE FROM MY PHONE, HOWEVER, THE FORM WOULD NOT ALLOW ME TO UPLOAD DUE TO THE SIZE.
NHTSA ODI #10860552
Mileage unknown · Apr 18, 2016
Engine
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND PRIX. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE); HOWEVER, THE PART FOR THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE…
Read full complaint
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND PRIX. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE); HOWEVER, THE PART FOR THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10860117
50,000 miles · Apr 12, 2016
Engine
WE RECEIVED A GM RECALL NOTICE #15757 IN DECEMBER 2015 AND AGAIN IN FEBRUARY 2016, WE CONTACTED THE LOCAL DUBLIN CA DEALER IN MID MARCH AND WAS TOLD PARTS ARE ON BACK ORDER AND WE WOULD GET A CALL WHEN IT. TODAY ON APRIL 12 I CALLED AGAIN AND "THERE'S A PART PROBLEM" AND THE PARTS ARE STILL ON THE WAY. I FIND THIS HARD PUT TO …
Read full complaint
WE RECEIVED A GM RECALL NOTICE #15757 IN DECEMBER 2015 AND AGAIN IN FEBRUARY 2016, WE CONTACTED THE LOCAL DUBLIN CA DEALER IN MID MARCH AND WAS TOLD PARTS ARE ON BACK ORDER AND WE WOULD GET A CALL WHEN IT. TODAY ON APRIL 12 I CALLED AGAIN AND "THERE'S A PART PROBLEM" AND THE PARTS ARE STILL ON THE WAY. I FIND THIS HARD PUT TO BELIEVE SINCE THE ORIGINAL DECEMBER RECALL NOTICE. ARE WE GETTING THE STALL AROUND?
NHTSA ODI #10855163
Mileage unknown · Apr 4, 2016
Engine
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND PRIX. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 15V7001000 (ENGINE AND ENGINE COOLING). THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISC…
Read full complaint
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND PRIX. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 15V7001000 (ENGINE AND ENGINE COOLING). THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #10853364
150,000 miles · Mar 28, 2016
EngineFire
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND PRIX. THE CONTACT STATED THAT WHILE PARKED, A STRONG ODOR OF BURNING OIL WAS NOTICED AND FUMES OF SMOKE WERE SEEN COMING FROM UNDER THE HOOD. THE CONTACT FURTHER OBSERVED THE VEHICLE BY LOOKING INTO THE ENGINE AND NOTICED EXCESSIVE OIL. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAI…
Read full complaint
TL* THE CONTACT OWNS A 2001 PONTIAC GRAND PRIX. THE CONTACT STATED THAT WHILE PARKED, A STRONG ODOR OF BURNING OIL WAS NOTICED AND FUMES OF SMOKE WERE SEEN COMING FROM UNDER THE HOOD. THE CONTACT FURTHER OBSERVED THE VEHICLE BY LOOKING INTO THE ENGINE AND NOTICED EXCESSIVE OIL. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING) HOWEVER, THE PARTS FOR THE RECALL WERE NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #10851901
Mileage unknown · Mar 3, 2016
EngineFire
TL* THE CONTACT OWNED A 2001 PONTIAC GRAND PRIX. THE CONTACT STATED THAT IT WAS INFORMED THAT THERE WAS SMOKE COMING FROM THE VEHICLE. THE HOOD OF THE VEHICLE WAS OPENED AND THERE WERE FLAMES. THE INFANT OCCUPANT WAS REMOVED FROM THE VEHICLE AND THE FIRE DEPARTMENT WAS ALTERED. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHI…
Read full complaint
TL* THE CONTACT OWNED A 2001 PONTIAC GRAND PRIX. THE CONTACT STATED THAT IT WAS INFORMED THAT THERE WAS SMOKE COMING FROM THE VEHICLE. THE HOOD OF THE VEHICLE WAS OPENED AND THERE WERE FLAMES. THE INFANT OCCUPANT WAS REMOVED FROM THE VEHICLE AND THE FIRE DEPARTMENT WAS ALTERED. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHICLE WAS TOWED TO A IMPOUND LOT WHERE IT WAS DEEMED DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE MEDICAL ATTENTION WAS REQUIRED FOR THE INFANT OCCUPANT. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE FAILURE MILEAGE WAS NOT AVAILABLE.
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence & remedy
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
ON CERTAIN PASSENGER, SPORT UTILITY VEHICLES AND MINI VANS, SOME OF THESE VEHICLES HAVE A PASSENGER AIR BAG THAT WAS MANUFACTURED WITHOUT A CHECK VALVE PIN. AN AIR BAG WITHOUT THE CHECK VALVE PIN COULD PRODUCE INCREASED PRESSURE AT THE ONSET OF THE AIR BAG DEPLOYMENT AND REDUCED PRESSURE AFTERWARD.
Consequence & remedy
Consequence: THIS COULD INCREASE THE SEVERITY OF INJURY TO A PERSON WHO WAS NOT PROPERLY RESTRAINED AND WHO WAS CLOSE TO THE PASSENGER AIR BAG AT THE TIME OF DEPLOYMENT. IT COULD ALSO REDUCE THE AB8ILITY OF THE AIR BAG TO PROTECT A RESTRAINED FRONT SEAT PASSENGER.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PASSENGER AIR BAG. OWNER NOTIFICATION BEGAN DECEMBER 16, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OLDSMOBILE AT 1-800-442-6537, OR SATURN AT 1-800-553-6000, PROMPT #3.
VEHICLE DESCRIPTION: PASSENGER, SPORT UTILITY VEHICLES AND MINIVANS. THE PASSENGER AIR BAG INFLATOR MODULES WERE BUILT WITHOUT THE CORRECT AMOUNT OF GENERANT, WHICH PRODUCES THE GAS THAT FILLS THE AIR BAG. SOME WERE BUILT WITH A DOUBLE LOAD OF GENERANT AND SOME WERE BUILT WITHOUT GENERANT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, A DOUBLE LOAD OF GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANT. A MODULE WITH NO GENERANT WOULD NOT INFLATE THE AIR BAG, AND THE OCCUPANTS COULD RECEIVE MORE SEVERE INJURIES.
Remedy: DEALERS WILL REPLACE THE PASSENGER AIR BAG MODULE. TELEPHONE CALLS WERE MADE TO OWNERS ON JANUARY 29, 2001. FOLLOW UP OWNER MAILING BEGAN ON APRIL 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR SATURN AT 1-800-553-6000.
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE07006 · Engine Compartment Fire
Opened Jan 29, 2007 · Closed Jun 12, 2007
Status: closed (inferred from source dates) · Engine And Engine Cooling
ON JANUARY 29, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED NON-CRASH FIRES ORIGINATING IN THE ENGINE COMPARTMENT IN CERTAIN MODEL YEAR (MY) 1999-2002 PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE ?L67? SUPERCHARGED VERSION OF THE GENERAL MOTORS (GM) 3800 SERIES II V6 ENGINE.TO DATE, ODI IS AWARE OF 121 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES THAT ALLEGE NON-CRASH RELATED FIRES ORIGINATING IN THE ENGINE COMPARTMENT WHILE DRIVING OR AFTER THE VEHICLE IS PARKED AND THE IGNITION SWITCHED OFF. WHILE NO SUBJECT COMPONENT HAS YET BEEN IDENTIFIED, ODI ANALYSIS OF AVAILABLE INFORMATION INDICATES THAT THE ALLEGED FIRE INCIDENT RATE AMONG THE SUBJECT VEHICLES IS SIGNIFICANTLY HIGHER THAN GM PEER VEHICLES THAT USE THE NON-SUPERCHARGED ?L36? VERSION OF THE GM 3800 SERIES II V6 ENGINE.IN SOME CASES, THE FIRE INCIDENT RATE IS TWICE AS HIGH IN THE SUBJECT VEHICLES AND UP TO AS MUCH AS AN ORDER OF MAGNITUDE GREATER THAN IN NON-SUPERCHARGED PEER VEHICLES.FOR INSTANCE, THE SUBJECT FIRE INCIDENT RATE FOR THE SUPERCHARGED MY 2000 PONTIAC GRAND PRIX GTP IS APPROXIMATELY 236 PER 100,000 VEHICLES PRODUCED (58 FIRES / 24,509 SUBJECT VEHICLES OR 0.236%) WHILE THE FIRE INCIDENT RATE FOR MY 2000 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH THE NATURALLY ASPIRATED ?L36? ENGINE IS APPROXIMATELY 18 PER 100,000 VEHICLES PRODUCED (17 FIRES / 90,338 VEHICLES OR 0.018%). THE MANUFACTURER?S INVESTIGATION INTO ALLEGED ENGINE COMPARTMENT FIRES ON THE SUBJECT VEHICLES IS ONGOING.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-008) TO FURTHER STUDY THE FREQUENCY AND SCOPE OF THE ALLEGED DEFECT. BASED ON THE INFORMATION REVIEWED IN PE07-006, THE RANGE OF SUBJECT VEHICLES UNDER INVESTIGATION WILL BE EXPANDED TO INCLUDE ALL MY 1999-2002 BUICK PARK AVENUE, REGAL, AND RIVIERA, OLDSMOBILE LSS, AND PONTIAC BONNEVILLE AND GRAND PRIX VEHICLES THAT USE THE SAME OR SUBSTANTIALLY SIMILAR TRANSVERSE MOUNTED ?L67? ENGINE.
THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA FOR RELEVANT BRAKE LAMP MALFUNCTIONS THAT REQUIRE REPLACEMENT OF THE MULTIFUNCTION SWITCH (MFS) MODULE.THE HAZARD WARNING SWITCH IS AN INTEGRAL PART OF THE MFS MODULE.OTHER COMPONENTS THAT AFFECT BRAKE LAMP ILLUMINATION SUCH AS WIRING, BULB SOCKETS, AND THE PLUNGER-TYPE BRAKE LAMP SWITCH, WERE NOT A PART OF THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Electrical System
THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA FOR RELEVANT BRAKE LAMP MALFUNCTIONS THAT REQUIRE REPLACEMENT OF THE MULTIFUNCTION SWITCH (MFS) MODULE.THE HAZARD WARNING SWITCH IS AN INTEGRAL PART OF THE MFS MODULE.OTHER COMPONENTS THAT AFFECT BRAKE LAMP ILLUMINATION SUCH AS WIRING, BULB SOCKETS, AND THE PLUNGER-TYPE BRAKE LAMP SWITCH, WERE NOT A PART OF THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:brake Lights
THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA FOR RELEVANT BRAKE LAMP MALFUNCTIONS THAT REQUIRE REPLACEMENT OF THE MULTIFUNCTION SWITCH (MFS) MODULE.THE HAZARD WARNING SWITCH IS AN INTEGRAL PART OF THE MFS MODULE.OTHER COMPONENTS THAT AFFECT BRAKE LAMP ILLUMINATION SUCH AS WIRING, BULB SOCKETS, AND THE PLUNGER-TYPE BRAKE LAMP SWITCH, WERE NOT A PART OF THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
2001 Pontiac Grand Prix Problems, Complaints & Recalls | Skip That Year
Illustration