NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
20 reportsClear category filter156,977 miles · Jan 22, 2013
Engine And Engine CoolingService Brakes, HydraulicFire
WAS ENTERING HWY 285 NORTHBOUND WHEN FELLOW MOTORIST CAUGHT MY ATTENTION THAT FIRE WAS COMING OUT THE BOTTOM OF MY CAR. TRIED TO STOP BUT DIDNT HAVE ANY BRAKES, SO I PUT THE CAR IN PARK AND JUMPED OUT AS THE FLAMES ENGULFED THE ENGINE COMPARTMENT OF THE CAR. I FEEL THAT IT WAS DUE TO A DEFECTED RECALL PART THAT WAS SUPPOSE TO PR…
Read full complaint
WAS ENTERING HWY 285 NORTHBOUND WHEN FELLOW MOTORIST CAUGHT MY ATTENTION THAT FIRE WAS COMING OUT THE BOTTOM OF MY CAR. TRIED TO STOP BUT DIDNT HAVE ANY BRAKES, SO I PUT THE CAR IN PARK AND JUMPED OUT AS THE FLAMES ENGULFED THE ENGINE COMPARTMENT OF THE CAR. I FEEL THAT IT WAS DUE TO A DEFECTED RECALL PART THAT WAS SUPPOSE TO PREVENT WHAT HAS HAPPEN TO MY CAR. I WAS THE SECOND OWNER OF THIS CAR WHICH WAS GARAGED AND IN IMMACULATE CONDITION. *TR
NHTSA ODI #10494374
55,000 miles · Aug 16, 2011
Service Brakes, Hydraulic
TL* THE CONTACT OWNS A 2000 PONTIAC GRAND PRIX. THE CONTACT STATED THAT THE ANTI LOCK BRAKE AND TRACTION CONTROL LIGHTS WERE ILLUMINATED. THE CONTACT ALSO STATED THAT BRAKE FLUID WAS LEAKING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO DIAGNOSED THAT THE ROTORS, BRAKE PADS, BRAKE LINES, AND SENSOR NEEDED …
Read full complaint
TL* THE CONTACT OWNS A 2000 PONTIAC GRAND PRIX. THE CONTACT STATED THAT THE ANTI LOCK BRAKE AND TRACTION CONTROL LIGHTS WERE ILLUMINATED. THE CONTACT ALSO STATED THAT BRAKE FLUID WAS LEAKING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO DIAGNOSED THAT THE ROTORS, BRAKE PADS, BRAKE LINES, AND SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE CONTINUED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED A SECOND TIME. THE FAILURE MILEAGE WAS 55,000 AND THE CURRENT MILEAGE WAS 65,000.
NHTSA ODI #10419679
27,000 miles · Sep 24, 2010
Fuel System, GasolineService Brakes, Hydraulic
TL* THE CONTACT OWNS A 2000 PONTIAC GRAN PRIX GT. THE CONTACT WAS DRIVING 35 MPH AND DEPRESSING THE BRAKES BUT THERE WAS NO RESPONSE. THE CONTACT LATER DISCOVERED THAT THE TWO BRAKE LINES AND FUEL LINES THAT MERGED WERE RUSTED ENTIRELY. THE DEALER ADVISED THE VEHICLE WAS NOT UNDER RECALL AND ANY REPAIRS WOULD BE AT HIS EXPENSE. …
Read full complaint
TL* THE CONTACT OWNS A 2000 PONTIAC GRAN PRIX GT. THE CONTACT WAS DRIVING 35 MPH AND DEPRESSING THE BRAKES BUT THERE WAS NO RESPONSE. THE CONTACT LATER DISCOVERED THAT THE TWO BRAKE LINES AND FUEL LINES THAT MERGED WERE RUSTED ENTIRELY. THE DEALER ADVISED THE VEHICLE WAS NOT UNDER RECALL AND ANY REPAIRS WOULD BE AT HIS EXPENSE. THE CONTACT MADE REPAIRS TO THE VEHICLE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 27,000.
NHTSA ODI #10357302
173,000 miles · May 13, 2010
Service Brakes, Hydraulic
WE OWN A 2000 PONTIAC GRAND PRIX PURCHASED NEW. IN THE LAST 6 MONTHS THE BRAKE LINES IN THE REAR OF THIS CAR HAVE BROKEN TWICE RESULTING IN COMPLETE BRAKE FAILURE AND VERY NEAR ACCIDENTS. I AM 62 YEARS OLD AND HAVE OWNED DOZENS OF CARS. THIS IS THE FIRST TIME I HAVE EVER HAD A FAILURE LIKE THIS. IT IS OBVIOUSLY CAUSE BY DEFECT…
Read full complaint
WE OWN A 2000 PONTIAC GRAND PRIX PURCHASED NEW. IN THE LAST 6 MONTHS THE BRAKE LINES IN THE REAR OF THIS CAR HAVE BROKEN TWICE RESULTING IN COMPLETE BRAKE FAILURE AND VERY NEAR ACCIDENTS. I AM 62 YEARS OLD AND HAVE OWNED DOZENS OF CARS. THIS IS THE FIRST TIME I HAVE EVER HAD A FAILURE LIKE THIS. IT IS OBVIOUSLY CAUSE BY DEFECTIVE OR SUBSTANDARD MATERIALS. *TR
NHTSA ODI #10330244
107,000 miles · Feb 8, 2007
Service Brakes, Hydraulic
THE ABS HARNESS THAT CLIPS TO THE BACKING PLATE IS COMING UNCLIPPED ON THE BACK PLATE WHILE MAKING A SHARP LEFT HAND TURN. ITS HITTING THE LOWER A-FRAME AND COMING UNCLIPPED. I KNOW THIS BECAUSE, MY HUSBAND IS A MECHANIC, IT BECAME UNCLIPPED AND WRAPPED AROUND THE C.V SHAFT AND TORE THE CLAMP OFF THE OUTER BOOT AND GREASE WENT …
Read full complaint
THE ABS HARNESS THAT CLIPS TO THE BACKING PLATE IS COMING UNCLIPPED ON THE BACK PLATE WHILE MAKING A SHARP LEFT HAND TURN. ITS HITTING THE LOWER A-FRAME AND COMING UNCLIPPED. I KNOW THIS BECAUSE, MY HUSBAND IS A MECHANIC, IT BECAME UNCLIPPED AND WRAPPED AROUND THE C.V SHAFT AND TORE THE CLAMP OFF THE OUTER BOOT AND GREASE WENT EVERYWHERE. *JB
NHTSA ODI #10182015
Mileage unknown · Dec 9, 2005
Service Brakes, HydraulicVehicle Speed Control
DT: THE CONTACT STATED WHILE PRESSING THE BRAKE ON ICE THE VEHICLE REVVED AND THEN SLID THROUGH INTERSECTIONS. THIS OCCURS ONLY ON ICY ROADS AND CAUSED THE BRAKES TO PUMP WHEN THE ANTI LOCK BRAKES ACTIVATED. THE DEALERSHIP AND THE MANUFACTURER HAVE NOT BEEN CONTACTED. *AK
NHTSA ODI #10144866
25,800 miles · Sep 9, 2005
Service Brakes, Hydraulic
DT: THE CONTACT STATES THAT HE TOOK THE VEHICLE TO DEALER AND THE BRAKES PADS WERE FALLING APART. THE DEALER STATED ON HIS REPAIR INVOICE THAT FRONT BRAKE PADS WERE COMING OFF. THE DEALER SAID THAT THE VEHICLE NEEDED ALL NEW ROTORS BECAUSE THEY ALL WERE RUSTED.*AK *JB
NHTSA ODI #10120576
Mileage unknown · Jan 15, 2004
Service Brakes, Hydraulic
I FIRST HAD PROBLEMS WITH MY BRAKES AT 19,000 HAD TO HAVE THE FROM ROTORS TURNED AND NEW NAPA BRAKE SHOES, THIS WAS DONE AT A CERTIFIED NAPA REPAIR SHOP. THE COST WAS APPROX. 175.00. THEN ABOUT 35000 MILES I STARTED HAVING TROUBLE STOPPING SO I TOOK IT TO ANOTHER NAPA SHOP AND HE TOLD ME THE ROTORS FRONT AND REAR NEEDED TO BE…
Read full complaint
I FIRST HAD PROBLEMS WITH MY BRAKES AT 19,000 HAD TO HAVE THE FROM ROTORS TURNED AND NEW NAPA BRAKE SHOES, THIS WAS DONE AT A CERTIFIED NAPA REPAIR SHOP. THE COST WAS APPROX. 175.00. THEN ABOUT 35000 MILES I STARTED HAVING TROUBLE STOPPING SO I TOOK IT TO ANOTHER NAPA SHOP AND HE TOLD ME THE ROTORS FRONT AND REAR NEEDED TO BE REPLACED ALONG WITH NEW BRAKE SHOES ALL AROUND. I REPLACED BOTH ROTORS AND SHOES AND NOW AM EXPERIENCING THE SAME PROBLEM AT 43000 MILES. I NEED TO KNOW WHO I CAN CONTACT SINCE THIS PROBLEM IS NOT GOING TO GET BETTER AND IT IS GETTING VERY EXPENSIVE.
NHTSA ODI #10069944
Mileage unknown · Jan 15, 2004
Engine And Engine CoolingEquipmentFuel System, GasolineFire
MY CAR CAUGHT FIRE 6-5-03. GENERAL MOTORS SENT AN INVESTIGATOR OUT. ON 7-2-03 I RECEIVED A CALL FROM GM. THEY TOLD ME THE REPORT WAS MY PROBLEM THEY WOULD NOT TAKE ANY RESPONSIBILTY FOR THE FIRE. I DROVE MY CAR APROX. 15 MILES THAT MORNING TO MY KIDS DAYCARE. I PULLED UP TO THE FRONT OF THE DAYCARE AND CUT THE CAR OFF AND IT STA…
Read full complaint
MY CAR CAUGHT FIRE 6-5-03. GENERAL MOTORS SENT AN INVESTIGATOR OUT. ON 7-2-03 I RECEIVED A CALL FROM GM. THEY TOLD ME THE REPORT WAS MY PROBLEM THEY WOULD NOT TAKE ANY RESPONSIBILTY FOR THE FIRE. I DROVE MY CAR APROX. 15 MILES THAT MORNING TO MY KIDS DAYCARE. I PULLED UP TO THE FRONT OF THE DAYCARE AND CUT THE CAR OFF AND IT STARTED SMOKING AND FLAMES CAME FROM UNDER THE HOOD. EVERYTHING UNDER THE HOOD IS MELTED NO BRAKE LINES, FUEL LINE OR WIRES. I HAVE NOT DONE ANYTHING TO THE CAR BUT CHANGE THE OIL. THE OIL WAS LAST CHANGED APROX. TWO MONTHS BEFORE THAT. CARS ARE NOT DESIGNED TO JUST CATCH FIRE. I PUT MY KIDS AND A DAYCARE FULL OF KIDS IN JEOPARDY THAT DAY. JUST TO ADD A LITTLE TO MY COMPLAINT. I HAVE LEFT ABOUT 6 MESSAGES SINCE JULY 3 FOR THE GM REP, KEVIN DREW, TO CALL ME WITHOUT SUCCESS. WHEN I PURCHASED MY CAR IT ONLY HAD 51,000 MILES. I HAD TROUBLE WITH BILL HEARD DEALERSHIP FROM DAY I DROVE THE CAR OFF THE LOT IT HAD PROBLEMS. IT TOOK 4 MONTHS (1) THE PISTONS WAS MAKING AWFUL NOISE. (2) THE SECURITY LIGHT WAS FLASHING (3) THE CIG. LIGHTER HAD A BURNING SMELL WHEN PUSHED IN. I HAVE A COPY OF THE COMPLAINTS , FINDINGS AND ACTION TAKEN ON A SERVICE REPORT PROVIDED BY BILL HEARD. IN THAT REPORT IT STATES THAT THEY FOUND BURNT AND MELTED WIRE THEY REMOVED THE WIRING HARNESS AND REPLACED WIRES. I LEFT A MESSAGE FOR KEVIN DREW ASKING HIM TO CALL ME BECAUSE I KNOW FOR A FACT THAT THE WIRE GOING TO THE FUSE BOX WAS MELTED. EVERYTHING UNDER THE HOOD IS MELTED NO WIRES, BRAKE LINE OR FUEL LINE EXIST ANYMORE. THE REGION OF THE FIRE IS THE AREA OF ALL THE WIRES, COMPUTER BOX ETC. IN THE MIDDLE OF THE HOOD AT THE CENTER UP TOWARD THE TOP CLOSE TO THE WINDSHIELD.. THIS HAPPENED AT A DAYCARE. I WAS PARKED NO MORE THAN 3 FEET FROM THE BUILDING.
NHTSA ODI #10069622
50,000 miles · Nov 26, 2003
Service Brakes, Hydraulic
BRAKE PADS ON 2000 PONTIAC GRAD PRIX, PADS SEPARATED FROM METAL BACKING MAKE CAR STOP POORLY. PADS HAD ONLY 30% WEAR AT THE MOST. I STILL HAVE PARTS. *LA
NHTSA ODI #10047604
Official recalls
5Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Mar 12, 2008
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence & remedy
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Oct 21, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE PASSENGER SIDE AIR BAG MODULES HAVE AN UNDERSIZED INFLATOR ORIFICE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER SIDE AIR BAG DEPLOYMENT, THIS UNDERSIZED ORIFICE CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF AN AIR BAG INFLATOR MODULE EXPLODES, METAL AND/OR PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO THE VEHICLE OCCUPANT.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG MODULES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE07006 · Engine Compartment Fire
Opened Jan 29, 2007 · Closed Jun 12, 2007
Status: closed (inferred from source dates) · Engine And Engine Cooling
ON JANUARY 29, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED NON-CRASH FIRES ORIGINATING IN THE ENGINE COMPARTMENT IN CERTAIN MODEL YEAR (MY) 1999-2002 PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE ?L67? SUPERCHARGED VERSION OF THE GENERAL MOTORS (GM) 3800 SERIES II V6 ENGINE.TO DATE, ODI IS AWARE OF 121 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES THAT ALLEGE NON-CRASH RELATED FIRES ORIGINATING IN THE ENGINE COMPARTMENT WHILE DRIVING OR AFTER THE VEHICLE IS PARKED AND THE IGNITION SWITCHED OFF. WHILE NO SUBJECT COMPONENT HAS YET BEEN IDENTIFIED, ODI ANALYSIS OF AVAILABLE INFORMATION INDICATES THAT THE ALLEGED FIRE INCIDENT RATE AMONG THE SUBJECT VEHICLES IS SIGNIFICANTLY HIGHER THAN GM PEER VEHICLES THAT USE THE NON-SUPERCHARGED ?L36? VERSION OF THE GM 3800 SERIES II V6 ENGINE.IN SOME CASES, THE FIRE INCIDENT RATE IS TWICE AS HIGH IN THE SUBJECT VEHICLES AND UP TO AS MUCH AS AN ORDER OF MAGNITUDE GREATER THAN IN NON-SUPERCHARGED PEER VEHICLES.FOR INSTANCE, THE SUBJECT FIRE INCIDENT RATE FOR THE SUPERCHARGED MY 2000 PONTIAC GRAND PRIX GTP IS APPROXIMATELY 236 PER 100,000 VEHICLES PRODUCED (58 FIRES / 24,509 SUBJECT VEHICLES OR 0.236%) WHILE THE FIRE INCIDENT RATE FOR MY 2000 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH THE NATURALLY ASPIRATED ?L36? ENGINE IS APPROXIMATELY 18 PER 100,000 VEHICLES PRODUCED (17 FIRES / 90,338 VEHICLES OR 0.018%). THE MANUFACTURER?S INVESTIGATION INTO ALLEGED ENGINE COMPARTMENT FIRES ON THE SUBJECT VEHICLES IS ONGOING.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-008) TO FURTHER STUDY THE FREQUENCY AND SCOPE OF THE ALLEGED DEFECT. BASED ON THE INFORMATION REVIEWED IN PE07-006, THE RANGE OF SUBJECT VEHICLES UNDER INVESTIGATION WILL BE EXPANDED TO INCLUDE ALL MY 1999-2002 BUICK PARK AVENUE, REGAL, AND RIVIERA, OLDSMOBILE LSS, AND PONTIAC BONNEVILLE AND GRAND PRIX VEHICLES THAT USE THE SAME OR SUBSTANTIALLY SIMILAR TRANSVERSE MOUNTED ?L67? ENGINE.
PE07001 · Loss Of Brake Lamp Illumination
Opened Jan 17, 2007 · Closed Apr 30, 2007
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:brake Lights
THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA FOR RELEVANT BRAKE LAMP MALFUNCTIONS THAT REQUIRE REPLACEMENT OF THE MULTIFUNCTION SWITCH (MFS) MODULE.THE HAZARD WARNING SWITCH IS AN INTEGRAL PART OF THE MFS MODULE.OTHER COMPONENTS THAT AFFECT BRAKE LAMP ILLUMINATION SUCH AS WIRING, BULB SOCKETS, AND THE PLUNGER-TYPE BRAKE LAMP SWITCH, WERE NOT A PART OF THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Electrical System
THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA FOR RELEVANT BRAKE LAMP MALFUNCTIONS THAT REQUIRE REPLACEMENT OF THE MULTIFUNCTION SWITCH (MFS) MODULE.THE HAZARD WARNING SWITCH IS AN INTEGRAL PART OF THE MFS MODULE.OTHER COMPONENTS THAT AFFECT BRAKE LAMP ILLUMINATION SUCH AS WIRING, BULB SOCKETS, AND THE PLUNGER-TYPE BRAKE LAMP SWITCH, WERE NOT A PART OF THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:brake Lights
THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA FOR RELEVANT BRAKE LAMP MALFUNCTIONS THAT REQUIRE REPLACEMENT OF THE MULTIFUNCTION SWITCH (MFS) MODULE.THE HAZARD WARNING SWITCH IS AN INTEGRAL PART OF THE MFS MODULE.OTHER COMPONENTS THAT AFFECT BRAKE LAMP ILLUMINATION SUCH AS WIRING, BULB SOCKETS, AND THE PLUNGER-TYPE BRAKE LAMP SWITCH, WERE NOT A PART OF THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
EA01014 · Air Bag Inflator
Opened Jun 11, 2001 · Closed Aug 26, 2002
Status: closed (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module
No summary supplied.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
Air Bags:frontal:driver Side:inflator Module
SQ00004 · Accelerator Cable Detaches From Throttle
Opened Feb 2, 2000 · Closed Jan 19, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Illustration