NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
73 reportsClear category filter140,000 miles · Oct 27, 2015
EngineExterior LightingPower Train
THERE ARE MANY SAFETY CONCERNS ON THIS VEHICLE. THE FIRST CONCERN IS THE SMOKE THAT COMES FROM UNDER THE HOOD BECAUSE OF THE OIL LEAKING ON THE ENGINE WHILE IN MOTION. TO THE POINT I HAVE HAD TO USE A HOSE TO COOL DOWN THE MOTOR. OIL POURED OUT WITH THE WATER. I HAVE HAD THE PRIOR RECALLS DONE AND STILL HAD LEAKING AFTER THE SO …
Read full complaint
THERE ARE MANY SAFETY CONCERNS ON THIS VEHICLE. THE FIRST CONCERN IS THE SMOKE THAT COMES FROM UNDER THE HOOD BECAUSE OF THE OIL LEAKING ON THE ENGINE WHILE IN MOTION. TO THE POINT I HAVE HAD TO USE A HOSE TO COOL DOWN THE MOTOR. OIL POURED OUT WITH THE WATER. I HAVE HAD THE PRIOR RECALLS DONE AND STILL HAD LEAKING AFTER THE SO CALLED RECALL WAS DONE IN 2010. I WAS TOLD BY CASTLE PONTIAC (NORTH RIVERSIDE, IL) THERE WAS NO FURTHER REPAIRS THEY COULD OFFER. EVEN THOUGH I SHOWED THEM THE OIL CONTINUING TO LEAK AFTER THE SO CALLED RECALL WAS COMPLETED. THE SECOND CONCERN IS THE HEAD LAMP ASSEMBLY THAT IS FOGGY LOOKING CAUSING THE VEHICLE TO HAVE POOR LIGHTING. THE NEXT CONCERN IS THE SUSPENSION THAT IS LITERALLY FALLING APART. I HAVE ALSO HAD TO HAVE THE HEAD GASKET CHANGED ON THIS VEHICLE AND THE TRANSMISSION HAD TO BE REBUILT. ALSO THE TAIL LAMPS RETAIN WATER EVERY TIME IT RAINS & THE PASSENGER & DRIVERS SIDE DOORS FILL WITH RAIN. LIKE I SAID THERE ARE MANY SAFETY CONCERNS ON THIS VEHICLE. I CAN PROVIDE PHOTOS TO THE CORRECT PARTIES & WOULD BE WILLING TO CONSIDER MY VEHICLE BEING USED TO BE INVESTIGATED TO CREATE REMEDIES FOR THESE SAFETY CONCERNS AS MY SMALL CHILD & MYSELF TRAVEL IN THIS VEHICLE. WHEN I TALKED TO GM CUSTOMER SERVICE TODAY I WAS TOLD THE VEHICLE IS SAFE TO DRIVE YET I AM SURE IF THE OWNER OF GM HAD THIS VEHICLE THEY WOULD NOT DEEM THIS VEHICLE SAFE. THANK YOU IN ADVANCE FOR TAKING TIME TO READ MY CONCERNS. *TR
NHTSA ODI #10786463
152,000 miles · Oct 24, 2015
EngineFire
WE PURCHASED THIS 2000 GRAND PRIX GT FROM ANOTHER INDIVIDUAL IN JULY 2015. ENGINE CAUGHT FIRE ON 10/20/2015 WHILE PARKED IN THE DRIVEWAY AT OUR RESIDENCE. NEIGHBORS ALERTED US (5-10 MINUTES AFTER RETURNING HOME FROM A FIVE MILE DRIVE TO ENJOY A 35 MINUTE MEAL) THAT THE CAR WAS ON FIRE. FLAMES WERE EVIDENT BELOW THE ENGINE. W…
Read full complaint
WE PURCHASED THIS 2000 GRAND PRIX GT FROM ANOTHER INDIVIDUAL IN JULY 2015. ENGINE CAUGHT FIRE ON 10/20/2015 WHILE PARKED IN THE DRIVEWAY AT OUR RESIDENCE. NEIGHBORS ALERTED US (5-10 MINUTES AFTER RETURNING HOME FROM A FIVE MILE DRIVE TO ENJOY A 35 MINUTE MEAL) THAT THE CAR WAS ON FIRE. FLAMES WERE EVIDENT BELOW THE ENGINE. WE WERE ABLE TO CONTROL THE FIRE WITH HELP FROM OUR NEIGHBOR, USING TWO HOME EXTINGUISHERS. THE TROY, OH FIRE DEPT RESPONDED; ENSURED THE FIRE WAS COMPLETELY OUT AND CAR WAS SAFE TO LEAVE (CUT WIRES ON BATTERY). DISCOVERED GM RECALL NO. 09047 & GM RECALL NO. 07035 AS WELL AS NHTSA RECALL #07E-21 INDICATING ISSUES WHICH MAY RESULT IN AN ENGINE FIRE.
NHTSA ODI #10785800
Mileage unknown · Sep 17, 2015
EngineFire
ENGINE COMPARTMENT FIRE SHORTLY AFTER SHUTDOWN. INCIDENT 2015-00005488
NHTSA ODI #10764476
160,000 miles · Jul 2, 2015
EngineFire
TL* THE CONTACT OWNED A 2000 PONTIAC GRAND PRIX. AFTER THE VEHICLE WAS PARKED FOR A SHORT PERIOD OF TIME, IT CAUGHT FIRE WITHOUT WARNING. THERE WERE NO ISSUES OR WARNING SIGNS PRIOR TO THE FIRE. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FIRE, BUT DID NOT DETERMINE THE CAUSE OF THE FAILURE. THERE WERE NO INJURIES AND A POLIC…
Read full complaint
TL* THE CONTACT OWNED A 2000 PONTIAC GRAND PRIX. AFTER THE VEHICLE WAS PARKED FOR A SHORT PERIOD OF TIME, IT CAUGHT FIRE WITHOUT WARNING. THERE WERE NO ISSUES OR WARNING SIGNS PRIOR TO THE FIRE. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FIRE, BUT DID NOT DETERMINE THE CAUSE OF THE FAILURE. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V116000 (ENGINE AND ENGINE COOLING). THE FAILURE MILEAGE WAS 160,000.
NHTSA ODI #10731716
183,000 miles · May 29, 2015
Engine
TL* THE CONTACT OWNS A 2000 PONTIAC GRAND PRIX. WHILE DRIVING AT APPROXIMATELY 40 MPH, THE CONTACT OBSERVED SMOKE UNDER THE HOOD OF THE VEHICLE. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBE…
Read full complaint
TL* THE CONTACT OWNS A 2000 PONTIAC GRAND PRIX. WHILE DRIVING AT APPROXIMATELY 40 MPH, THE CONTACT OBSERVED SMOKE UNDER THE HOOD OF THE VEHICLE. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V116000 (ENGINE AND ENGINE COOLING). THE FAILURE MILEAGE WAS APPROXIMATELY 183,000.
NHTSA ODI #10722195
291,494 miles · Apr 17, 2015
EngineFire
TL* THE CONTACT OWNED A 2000 PONTIAC GRAND PRIX. WHILE THE VEHICLE WAS IN PARK, THE CONTACT NOTICED THAT THE FRONT OF THE VEHICLE CAUGHT FIRE. THE FIRE DESTROYED THE SIDING OF THE CONTACT'S RESIDENCE. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FIRE. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER W…
Read full complaint
TL* THE CONTACT OWNED A 2000 PONTIAC GRAND PRIX. WHILE THE VEHICLE WAS IN PARK, THE CONTACT NOTICED THAT THE FRONT OF THE VEHICLE CAUGHT FIRE. THE FIRE DESTROYED THE SIDING OF THE CONTACT'S RESIDENCE. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FIRE. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 291,494.
NHTSA ODI #10706362
99,000 miles · Dec 29, 2014
EngineFire
TL* THE CONTACT OWNED A 2000 PONTIAC GRAND PRIX. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE CAUGHT FIRE. THE FIRE WAS EXTINGUISHED, BUT THE SPECIFICS WERE UNKNOWN. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. A POLICE AND A FIRE REPORT WERE NOT FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS MADE AWARE OF THE …
Read full complaint
TL* THE CONTACT OWNED A 2000 PONTIAC GRAND PRIX. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE CAUGHT FIRE. THE FIRE WAS EXTINGUISHED, BUT THE SPECIFICS WERE UNKNOWN. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. A POLICE AND A FIRE REPORT WERE NOT FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 99,000.
NHTSA ODI #10668849
200,000 miles · Nov 18, 2014
EngineFire
TL* THE CONTACT OWNED A 2000 PONTIAC GRAND PRIX. AFTER PARKING THE VEHICLE, IT IGNITED INTO FLAMES. THE VEHICLE WAS UNOCCUPIED AT THE TIME OF THE FIRE. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS DESTROYED. THE CONTACT DID NOT RECEIVE A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 08V118000 (ENGINE AND ENGINE COOLING). HOWEVER, T…
Read full complaint
TL* THE CONTACT OWNED A 2000 PONTIAC GRAND PRIX. AFTER PARKING THE VEHICLE, IT IGNITED INTO FLAMES. THE VEHICLE WAS UNOCCUPIED AT THE TIME OF THE FIRE. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS DESTROYED. THE CONTACT DID NOT RECEIVE A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 08V118000 (ENGINE AND ENGINE COOLING). HOWEVER, THE CONTACT BELIEVED THE FAILURE WAS RELATED TO THE RECALL. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.
NHTSA ODI #10658820
173,000 miles · Oct 2, 2014
EngineUnknown Or OtherFire
TL* THE CONTACT OWNS A 2000 PONTIAC GRAND PRIX. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE BECAME ENGULFED IN FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND WAS UNABLE TO DETECT WHERE THE FIRE ORIGINATED. A POLICE/FIRE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGN…
Read full complaint
TL* THE CONTACT OWNS A 2000 PONTIAC GRAND PRIX. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE BECAME ENGULFED IN FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND WAS UNABLE TO DETECT WHERE THE FIRE ORIGINATED. A POLICE/FIRE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 173,000.
NHTSA ODI #10640960
126,818 miles · Aug 10, 2014
Electrical SystemEngineFuel System, Gasoline
I WAS DRIVING ALONG,AND SUDDENLY WITHOUT WARNING,THE ENGINE DIED...NATURALLY THE POWER STEERING AND POWER BRAKES DIDN'T WORK, BUT I MANAGED TO GET THE CAR OVER TO THE CURB. I TRIED TO START IT AND IT STARTED JUST FINE, SO I TOOK IT HOME, I WAS NERVOUS AFTER THAT DRIVING IT ! BECAUSE AFTER THAT IT CONTINUED TO STALL SEVERAL …
Read full complaint
I WAS DRIVING ALONG,AND SUDDENLY WITHOUT WARNING,THE ENGINE DIED...NATURALLY THE POWER STEERING AND POWER BRAKES DIDN'T WORK, BUT I MANAGED TO GET THE CAR OVER TO THE CURB. I TRIED TO START IT AND IT STARTED JUST FINE, SO I TOOK IT HOME, I WAS NERVOUS AFTER THAT DRIVING IT ! BECAUSE AFTER THAT IT CONTINUED TO STALL SEVERAL MORE TIMES WHEN I WAS DRIVING IT, I NEVER KNEW WHEN IT WOULD HAPPEN. SO I COULDN'T GO OUT OF TOWN IN IT THAT'S FOR SURE ! I SPENT QUITE A BIT OF MONEY FOR MECHANICS TO WORK ON IT, BUT SINCE IT DIDN'T SHOW A CODE OF ANY KIND, NO ONE COULD FIX IT FOR ME. I LOVED THE CAR, BUT I TRADED IT OFF BECAUSE NO BODY COULD FIX IT. I JUST CAN'T BELIEVE THAT IT WAS NOT INCLUDED IN THAT RECALL FOR THE IGNITION SWITCH. JUST THOUGHT I WOULD LET YOU KNOW ABOUT THIS...THANKS *TR
NHTSA ODI #10621272
Official recalls
5Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Mar 12, 2008
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence & remedy
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Oct 21, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE PASSENGER SIDE AIR BAG MODULES HAVE AN UNDERSIZED INFLATOR ORIFICE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER SIDE AIR BAG DEPLOYMENT, THIS UNDERSIZED ORIFICE CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF AN AIR BAG INFLATOR MODULE EXPLODES, METAL AND/OR PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO THE VEHICLE OCCUPANT.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE AIR BAG MODULES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE07006 · Engine Compartment Fire
Opened Jan 29, 2007 · Closed Jun 12, 2007
Status: closed (inferred from source dates) · Engine And Engine Cooling
ON JANUARY 29, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED NON-CRASH FIRES ORIGINATING IN THE ENGINE COMPARTMENT IN CERTAIN MODEL YEAR (MY) 1999-2002 PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE ?L67? SUPERCHARGED VERSION OF THE GENERAL MOTORS (GM) 3800 SERIES II V6 ENGINE.TO DATE, ODI IS AWARE OF 121 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES THAT ALLEGE NON-CRASH RELATED FIRES ORIGINATING IN THE ENGINE COMPARTMENT WHILE DRIVING OR AFTER THE VEHICLE IS PARKED AND THE IGNITION SWITCHED OFF. WHILE NO SUBJECT COMPONENT HAS YET BEEN IDENTIFIED, ODI ANALYSIS OF AVAILABLE INFORMATION INDICATES THAT THE ALLEGED FIRE INCIDENT RATE AMONG THE SUBJECT VEHICLES IS SIGNIFICANTLY HIGHER THAN GM PEER VEHICLES THAT USE THE NON-SUPERCHARGED ?L36? VERSION OF THE GM 3800 SERIES II V6 ENGINE.IN SOME CASES, THE FIRE INCIDENT RATE IS TWICE AS HIGH IN THE SUBJECT VEHICLES AND UP TO AS MUCH AS AN ORDER OF MAGNITUDE GREATER THAN IN NON-SUPERCHARGED PEER VEHICLES.FOR INSTANCE, THE SUBJECT FIRE INCIDENT RATE FOR THE SUPERCHARGED MY 2000 PONTIAC GRAND PRIX GTP IS APPROXIMATELY 236 PER 100,000 VEHICLES PRODUCED (58 FIRES / 24,509 SUBJECT VEHICLES OR 0.236%) WHILE THE FIRE INCIDENT RATE FOR MY 2000 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH THE NATURALLY ASPIRATED ?L36? ENGINE IS APPROXIMATELY 18 PER 100,000 VEHICLES PRODUCED (17 FIRES / 90,338 VEHICLES OR 0.018%). THE MANUFACTURER?S INVESTIGATION INTO ALLEGED ENGINE COMPARTMENT FIRES ON THE SUBJECT VEHICLES IS ONGOING.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-008) TO FURTHER STUDY THE FREQUENCY AND SCOPE OF THE ALLEGED DEFECT. BASED ON THE INFORMATION REVIEWED IN PE07-006, THE RANGE OF SUBJECT VEHICLES UNDER INVESTIGATION WILL BE EXPANDED TO INCLUDE ALL MY 1999-2002 BUICK PARK AVENUE, REGAL, AND RIVIERA, OLDSMOBILE LSS, AND PONTIAC BONNEVILLE AND GRAND PRIX VEHICLES THAT USE THE SAME OR SUBSTANTIALLY SIMILAR TRANSVERSE MOUNTED ?L67? ENGINE.
PE07001 · Loss Of Brake Lamp Illumination
Opened Jan 17, 2007 · Closed Apr 30, 2007
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:brake Lights
THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA FOR RELEVANT BRAKE LAMP MALFUNCTIONS THAT REQUIRE REPLACEMENT OF THE MULTIFUNCTION SWITCH (MFS) MODULE.THE HAZARD WARNING SWITCH IS AN INTEGRAL PART OF THE MFS MODULE.OTHER COMPONENTS THAT AFFECT BRAKE LAMP ILLUMINATION SUCH AS WIRING, BULB SOCKETS, AND THE PLUNGER-TYPE BRAKE LAMP SWITCH, WERE NOT A PART OF THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Electrical System
THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA FOR RELEVANT BRAKE LAMP MALFUNCTIONS THAT REQUIRE REPLACEMENT OF THE MULTIFUNCTION SWITCH (MFS) MODULE.THE HAZARD WARNING SWITCH IS AN INTEGRAL PART OF THE MFS MODULE.OTHER COMPONENTS THAT AFFECT BRAKE LAMP ILLUMINATION SUCH AS WIRING, BULB SOCKETS, AND THE PLUNGER-TYPE BRAKE LAMP SWITCH, WERE NOT A PART OF THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:brake Lights
THE AGENCY'S ANALYSIS OF GM'S COMPLAINT AND WARRANTY DATA FOR THE SUBJECT VEHICLES, INCLUDING A COMPARISON WITH OTHER AGENCY AND MANUFACTURER DATA PERTAINING TO OTHER VEHICLE BRAKE LAMP INVESTIGATIONS, INDICATED A LOW FAILURE HISTORY FOR THE SUBJECT VEHICLES.THIS INVESTIGATION INCLUDED A REVIEW AND ANALYSIS OF DATA FOR RELEVANT BRAKE LAMP MALFUNCTIONS THAT REQUIRE REPLACEMENT OF THE MULTIFUNCTION SWITCH (MFS) MODULE.THE HAZARD WARNING SWITCH IS AN INTEGRAL PART OF THE MFS MODULE.OTHER COMPONENTS THAT AFFECT BRAKE LAMP ILLUMINATION SUCH AS WIRING, BULB SOCKETS, AND THE PLUNGER-TYPE BRAKE LAMP SWITCH, WERE NOT A PART OF THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
EA01014 · Air Bag Inflator
Opened Jun 11, 2001 · Closed Aug 26, 2002
Status: closed (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module
No summary supplied.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
Air Bags:frontal:driver Side:inflator Module
SQ00004 · Accelerator Cable Detaches From Throttle
Opened Feb 2, 2000 · Closed Jan 19, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Illustration