NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
16 reportsClear category filter34,292 miles · Aug 30, 2011
Service Brakes, Hydraulic
COMPLETE BRAKE FAILURE OCCURRED AT A HIGH-VOLUME INTERSECTION AT LOGAN AVE., AND RT.20 IN BELVEDERE IL. WHILE APPROACHING INTERSECTION ON A YELLOW LIGHT, WITH NO ONE IN FRONT OF ME, I APPLIED THE BRAKES, HEARD A POPPING SOUND AND THE BRAKE PEDAL WENT ALL THE WAY DOWN TO THE FLOOR BOARD. I HAD ENOUGH ROOM TO APPLY THE EMERGENCY B…
Read full complaint
COMPLETE BRAKE FAILURE OCCURRED AT A HIGH-VOLUME INTERSECTION AT LOGAN AVE., AND RT.20 IN BELVEDERE IL. WHILE APPROACHING INTERSECTION ON A YELLOW LIGHT, WITH NO ONE IN FRONT OF ME, I APPLIED THE BRAKES, HEARD A POPPING SOUND AND THE BRAKE PEDAL WENT ALL THE WAY DOWN TO THE FLOOR BOARD. I HAD ENOUGH ROOM TO APPLY THE EMERGENCY BRAKES, AND CAME TO A COMPLETE STOP BEFORE ENTERING THE INTERSECTION. I HAD MY SISTER AND 92 YEAR OLD AUNT IN THE CAR. CAR WAS TOWED TO WOLF PONTIAC IN BELVEDERE, IL, MECHANIC TOLD ME THAT THE 'STEEL' BRAKE LINE HAD RUSTED OUT, AND BURST. WE HAD ALL THE BRAKE LINES REPLACED FOR APPROX $900. WE COULD HAVE HAD SERIOUS INJURY/DEATH HAD WE ENTERED THE INTERSECTION. THIS IS A SERIOUS EXAMPLE OF AN ENGINEERING DEFECT! WE LIVE IN THE SALT BELT, AND ANY DESIGN THAT WOULD LEAD TO A RUST-OUT SITUATION ON A CRITICAL PART OF THE BRAKING SYSTEM IS INEXCUSABLE. IT IS PROBABLY CHEAPER THAN PUTTING IN BRAKE LINES THAT WOULD BE RUST RESISTANT, BUT I GUESS PROFIT IS MORE IMPORTANT THAT THE SAFETY OF ITS PASSENGERS. WE WERE VERY LUCKY! I CALLED GM, AND OF COURSE THEY WERE APOLOGETIC, BUT THE SAME THING IS GOING TO HAPPEN TO OTHER DRIVERS OF THEIR TECHNOLOGY. THE OWNER OF THE CAR, IS MY AUNT, WHO WAS A PASSENGER
NHTSA ODI #10423489
145,000 miles · Aug 2, 2011
Service Brakes, Hydraulic
THE ABS SYSTEMS ENGAGES WHILE DRIVING AND NOT PRESSING THE BRAKE PEDAL. YOU CAN HEAR THE ABS SYSTEMS TRYING TO ENGAGE AND THEN THE ABS AND TRAC OFF LIGHTS COME ON IN THE DASH. THIS IS DEACTIVATING MY ABS SYSTEM. I HAVE HAD A FAULTY ABS SENSOR REPLACED AND IT FIXED THE PROBLEM FOR ABOUT THREE MONTHS. IT HAS NOW STARTED UP AGAIN. …
Read full complaint
THE ABS SYSTEMS ENGAGES WHILE DRIVING AND NOT PRESSING THE BRAKE PEDAL. YOU CAN HEAR THE ABS SYSTEMS TRYING TO ENGAGE AND THEN THE ABS AND TRAC OFF LIGHTS COME ON IN THE DASH. THIS IS DEACTIVATING MY ABS SYSTEM. I HAVE HAD A FAULTY ABS SENSOR REPLACED AND IT FIXED THE PROBLEM FOR ABOUT THREE MONTHS. IT HAS NOW STARTED UP AGAIN. I HAVE LOOKED AT NUMEROUS MESSAGE BOARDS TO FIND A FIX FOR THE PROBLEM AND WAS EXTREMELY CONCERNED TO SEE THAT THOUSANDS OF GRAND PRIX OWNERS ARE HAVING SIMILAR ISSUES AND GM IS DOING NOTHING TO FIX IT... EXCEPT CHARGE $1300 AND STILL NOT FIX THE PROBLEM.
NHTSA ODI #10417422
64,000 miles · Jun 7, 2011
Service Brakes, Hydraulic
TL* THE CONTACT OWNS A 1999 PONTIAC GRAND PRIX. THE CONTACT WAS DRIVING APPROXIMATELY 25 MPH WHEN THE BRAKE PEDAL SLOWLY TRAVELED TO THE FLOOR UPON ENGAGEMENT, WITH THE ILLUMINATION OF THE BRAKE WARNING INDICATOR. WHEN THE BRAKE PEDAL WAS APPLIED, THE VEHICLE FAILED TO REDUCE SPEED AFTER NUMEROUS ATTEMPTS. IMMEDIATELY, THE EMERG…
Read full complaint
TL* THE CONTACT OWNS A 1999 PONTIAC GRAND PRIX. THE CONTACT WAS DRIVING APPROXIMATELY 25 MPH WHEN THE BRAKE PEDAL SLOWLY TRAVELED TO THE FLOOR UPON ENGAGEMENT, WITH THE ILLUMINATION OF THE BRAKE WARNING INDICATOR. WHEN THE BRAKE PEDAL WAS APPLIED, THE VEHICLE FAILED TO REDUCE SPEED AFTER NUMEROUS ATTEMPTS. IMMEDIATELY, THE EMERGENCY BRAKE WAS ENGAGED TO STOP THE VEHICLE. THE CONTACT RESUMED OPERATION. THE VEHICLE WAS INSPECTED AND THE MASTER CYLINDER RESERVOIR WAS EMPTY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY REPLACED THE FRONT AND REAR BRAKE LINES AS A RESULT OF RUST. THE CONTACT WAS IN THE PROCESS OF NOTIFYING THE MANUFACTURER OF THE BRAKE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 64,000.
NHTSA ODI #10405387
135,533 miles · Apr 14, 2009
Electrical SystemFuel System, GasolineService Brakes, Hydraulic
TL*THE CONTACT OWNS A 1999 PONTIAC GRAND PRIX. WITHIN TWO WEEKS OF PURCHASING THE VEHICLE, THE BRAKE LINE FAILED. THE CONTACT PULLED INTO HER DRIVEWAY AND NOTICED THAT SHE WAS NO LONGER ABLE TO BRAKE. SHE TOOK THE VEHICLE BACK TO THE SALES DEALER AND THEY REPAIRED THE FAILURE, ALTHOUGH SHE NOTICED IN MARCH OF 2009 THAT THE BA…
Read full complaint
TL*THE CONTACT OWNS A 1999 PONTIAC GRAND PRIX. WITHIN TWO WEEKS OF PURCHASING THE VEHICLE, THE BRAKE LINE FAILED. THE CONTACT PULLED INTO HER DRIVEWAY AND NOTICED THAT SHE WAS NO LONGER ABLE TO BRAKE. SHE TOOK THE VEHICLE BACK TO THE SALES DEALER AND THEY REPAIRED THE FAILURE, ALTHOUGH SHE NOTICED IN MARCH OF 2009 THAT THE BATTERY FAILED. THE CONTACT PURCHASED ANOTHER BATTERY. THE SAME DAY, THE FUEL PUMP AND FUEL FILTER MALFUNCTIONED, WHICH THE CONTACT NOTICED WHEN THE VEHICLE WAS SHUT OFF. THE CONTACT HAD THE FAILURES REPLACED, BUT THE VEHICLE STILL WOULD NOT REMAIN ON. SHE HAD NOT TAKEN THE VEHICLE TO THE DEALER OR SPOKEN WITH THE MANUFACTURER. THE CURRENT MILEAGE WAS APPROXIMATELY 135,700 AND FAILURE MILEAGE WAS 135,533.
NHTSA ODI #10265343
51,000 miles · Oct 16, 2008
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 1999 PONTIAC GRAND PRIX. WHILE BACKING OUT OF THE DRIVEWAY AT APPROXIMATELY 5 MPH, THE VEHICLE FAILED TO STOP WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE SLOWED DOWN; HOWEVER, THE CONTACT HAD TO APPLY THE EMERGENCY BRAKE IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO A MECHANIC, WHO STATED TH…
Read full complaint
TL*THE CONTACT OWNS A 1999 PONTIAC GRAND PRIX. WHILE BACKING OUT OF THE DRIVEWAY AT APPROXIMATELY 5 MPH, THE VEHICLE FAILED TO STOP WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE SLOWED DOWN; HOWEVER, THE CONTACT HAD TO APPLY THE EMERGENCY BRAKE IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO A MECHANIC, WHO STATED THAT THE BRAKE LINE WAS RUSTED. THE CURRENT AND FAILURE MILEAGES WERE 51,000. UPDATED 11/12/08. *LJ UPDATED 11/14/08.*JB
NHTSA ODI #10245689
50,300 miles · Sep 21, 2006
Service Brakes, Hydraulic
THE FOLLOWING OCCURRED ON A 1999 GRAND PRIX THAT HAS 52,300 +/- MILES ON IT, LOCATED IN SOUTHEASTERN PA AND NOT GARAGED. I WENT TO START MY CAR AFTER A MEETING AND THE BRAKE PEDAL WENT TO THE FLOOR. SUBSEQUENT INVESTIGATION IN THE MEETING LOCATION PARKING LOT SHOWED THAT BRAKE FLUID WAS PUMPING OUT OF THE BRAKE LINE SYSTEM. I…
Read full complaint
THE FOLLOWING OCCURRED ON A 1999 GRAND PRIX THAT HAS 52,300 +/- MILES ON IT, LOCATED IN SOUTHEASTERN PA AND NOT GARAGED. I WENT TO START MY CAR AFTER A MEETING AND THE BRAKE PEDAL WENT TO THE FLOOR. SUBSEQUENT INVESTIGATION IN THE MEETING LOCATION PARKING LOT SHOWED THAT BRAKE FLUID WAS PUMPING OUT OF THE BRAKE LINE SYSTEM. I HAD THE CAR FLAT-BED TOWED TO THE LOCAL PONTIAC DEALER. A BRAKE LINE HAD RUSTED THROUGH IN THE ENGINE AREA. THE OTHER BRAKE LINES UP UNDER THE CHASSIS WERE ALSO RUSTED. THE PONTIAC DEALER IS REPLACING ALL OF THE BRAKE LINES WITH NEW LINES THAT HAVE TO BE BENT TO SHAPE. ONLY TWO SMALL LINES WERE AVAILABLE PRE-BENT FROM GENERAL MOTORS. *NM
NHTSA ODI #10168896
Mileage unknown · Mar 6, 2002
Service Brakes, Hydraulic
AFTER DRIVING IN THE RAIN BRAKES WILL NOT WORK EFFECTIVELY FOR 2-3 SECONDS AFTER APPLICATION. HAS OCCURRED SEVERAL TIMES SINCE NEW. WAS TOLD BY DEALER THAT THIS WAS NORMAL. IT IS A VERY DANGEROUS SITUATION TO BE EXITING AN EXPRESSWAY AFTER A 10 MILE DRIVE AND HAVE THIS OCCUR IN LIGHT RAIN. *AK
NHTSA ODI #758981
Mileage unknown · Dec 5, 2000
Service Brakes, Hydraulic
THIS COMPLAINT IS NOT NECESSARILY CONCERNING THE ABSOLUTE FAILURE OF A COMPONENT, BUT RATHER THE REPEATED NEED TO REPLACE, WHAT I CONSIDER TO BE, A CRITICAL SAFETY RELATED COMPONENT. FIRST OF ALL THE NEED TO REPLACE THE FRONT ROTORS PRIOR TO TAKING DELIVERY OF THE VEHICLE IN MARCH '99, AND THEN THE NEED TO REPLACE THE REAR ROTOR…
Read full complaint
THIS COMPLAINT IS NOT NECESSARILY CONCERNING THE ABSOLUTE FAILURE OF A COMPONENT, BUT RATHER THE REPEATED NEED TO REPLACE, WHAT I CONSIDER TO BE, A CRITICAL SAFETY RELATED COMPONENT. FIRST OF ALL THE NEED TO REPLACE THE FRONT ROTORS PRIOR TO TAKING DELIVERY OF THE VEHICLE IN MARCH '99, AND THEN THE NEED TO REPLACE THE REAR ROTORS IN OCTOBER '00, WITH A LITTLE OVER 15,000 MILES ON THE VEHICLE. NO EXPLANATION WAS GIVEN BY PONTIAC. MY CORRESPONDENCE TO PONTIAC IN RESPONSE TO A CUSTOMER SERVICE SURVEY, YIELDED MERELY A TELEPHONE MESSAGE THAT CONFIRMED BASICALLY WHAT I HAD TOLD THEM REGARDING THE TWO TIMES ROTORS WERE REPLACED, IMPLYING TO ME THAT "I CAN EXPECT TO REPLACE ROTORS ON THE VEHICLE EVERY 15,000 MILES. TO ME THAT INDICATES THAT PONTIAC ARE ESENTIALLY UNWILLING TO ADMIT TO A QUALITY, AND MORE IMPORTANTLY, CRITICAL SAFETY PROBLEM IN A COMPONENT OF THEIR PRODUCT. *AK
NHTSA ODI #737359
Mileage unknown · Nov 6, 2000
Service Brakes, Hydraulic
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #735824
Mileage unknown · Jun 13, 2000
Service Brakes, Hydraulic
DISC BRAKES ARE GRINDING - METAL TO METAL. THERE IS A PROBLEM WITH THE DISC BRAKE SYSTEM. IT IS HANGING UP ON THE INSIDE OF THE DISC BRAKES. IT IS CAUSING THE BACK SIDE OF THE DISC ON ALL FOUR WHEELS TO "GROOVE" THE ROTOR, WITH THE WORST BEING IN THE REAR OF THE VEHICLE. *AK
NHTSA ODI #723957
Official recalls
4Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Mar 12, 2008
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence & remedy
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Jan 25, 2002
ON CERTAIN PASSENGER VEHICLES AND MINI VANS, THE DRIVER'S AIR BAG INFLATOR MODULES COULD PRODUCE EXCESSIVE INTERNAL PRESSURE. IN THE EVENT OF A CRASH THAT WOULD TRIGGER A DRIVER'S AIR BAG DEPLOYMENT, THE INCREASED INTERNAL PRESSURE CAN CAUSE THE INFLATOR MODULE TO EXPLODE.
Consequence & remedy
Consequence: METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANTS.
Remedy: DEALERS WILL REPLACE THE DRIVER AIR BAG MODULE. OWNER NOTIFICATION BEGAN FEBRUARY 1, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE07006 · Engine Compartment Fire
Opened Jan 29, 2007 · Closed Jun 12, 2007
Status: closed (inferred from source dates) · Engine And Engine Cooling
ON JANUARY 29, 2007, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED NON-CRASH FIRES ORIGINATING IN THE ENGINE COMPARTMENT IN CERTAIN MODEL YEAR (MY) 1999-2002 PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE ?L67? SUPERCHARGED VERSION OF THE GENERAL MOTORS (GM) 3800 SERIES II V6 ENGINE.TO DATE, ODI IS AWARE OF 121 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES THAT ALLEGE NON-CRASH RELATED FIRES ORIGINATING IN THE ENGINE COMPARTMENT WHILE DRIVING OR AFTER THE VEHICLE IS PARKED AND THE IGNITION SWITCHED OFF. WHILE NO SUBJECT COMPONENT HAS YET BEEN IDENTIFIED, ODI ANALYSIS OF AVAILABLE INFORMATION INDICATES THAT THE ALLEGED FIRE INCIDENT RATE AMONG THE SUBJECT VEHICLES IS SIGNIFICANTLY HIGHER THAN GM PEER VEHICLES THAT USE THE NON-SUPERCHARGED ?L36? VERSION OF THE GM 3800 SERIES II V6 ENGINE.IN SOME CASES, THE FIRE INCIDENT RATE IS TWICE AS HIGH IN THE SUBJECT VEHICLES AND UP TO AS MUCH AS AN ORDER OF MAGNITUDE GREATER THAN IN NON-SUPERCHARGED PEER VEHICLES.FOR INSTANCE, THE SUBJECT FIRE INCIDENT RATE FOR THE SUPERCHARGED MY 2000 PONTIAC GRAND PRIX GTP IS APPROXIMATELY 236 PER 100,000 VEHICLES PRODUCED (58 FIRES / 24,509 SUBJECT VEHICLES OR 0.236%) WHILE THE FIRE INCIDENT RATE FOR MY 2000 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH THE NATURALLY ASPIRATED ?L36? ENGINE IS APPROXIMATELY 18 PER 100,000 VEHICLES PRODUCED (17 FIRES / 90,338 VEHICLES OR 0.018%). THE MANUFACTURER?S INVESTIGATION INTO ALLEGED ENGINE COMPARTMENT FIRES ON THE SUBJECT VEHICLES IS ONGOING.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-008) TO FURTHER STUDY THE FREQUENCY AND SCOPE OF THE ALLEGED DEFECT. BASED ON THE INFORMATION REVIEWED IN PE07-006, THE RANGE OF SUBJECT VEHICLES UNDER INVESTIGATION WILL BE EXPANDED TO INCLUDE ALL MY 1999-2002 BUICK PARK AVENUE, REGAL, AND RIVIERA, OLDSMOBILE LSS, AND PONTIAC BONNEVILLE AND GRAND PRIX VEHICLES THAT USE THE SAME OR SUBSTANTIALLY SIMILAR TRANSVERSE MOUNTED ?L67? ENGINE.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
EA01014 · Air Bag Inflator
Opened Jun 11, 2001 · Closed Aug 26, 2002
Status: closed (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module
No summary supplied.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
Air Bags:frontal:driver Side:inflator Module
PE01002 · Driver Air Bag Malfunction
Opened Jan 10, 2001 · Closed Jun 11, 2001
Status: closed (inferred from source dates) · Air Bags:frontal
ODI IS AWARE OF ONE REPORTED INCIDENT OF A DRIVER-SIDE AIR BAG INFLATOR SEPARATION IN A MODEL YEAR 1999 PONTIAC GRAND PRIX.AN INVESTIGATION OF THE INCIDENT REVEALED THAT A TWO-INCH, DISK-SHAPED FRAGMENT OF THE ALUMINUM INFLATOR ASSEMBLY RUPTURED THE AIR BAG, BROKE OFF PORTIONS OF THE AIR GAB COVER FLAPS, AND STRUCK THE DRIVER.ALSO, EVIDENCE SHOWED HOT COMBUSTION GASES/PARTICULATE ESCAPED INTO THE PASSENGER COMPARTMENT.THE DRIVER SUSTAINED NUMEROUS INJURIES FROM THE INFLATOR FRAGEMENTAND HOT GASES/PARTICULATE.A TEARDOWN OF THE FAILED INFLATOR DID NOT REVEAL ANY OBSERVABLE DEFECTS OR ROOT CAUSE OF FAILURE.GM AND ITS SUPPLIERS (DELPHI AND BREAD) ARE CURRENTLY WORKING TOGETHER TO DETERMINE THE ROOT CAUSE OF THE SINGLE REPORTED FAILURE AND THE SCOPE OF THE POTENTIAL PROBLEM CONDITION IN THE FIELD.FINALLY, GM HAS STATED THAT MODEL YEAR 1998-2000 PONTIAC GRAND PRIX VEHICLES AND MODEL YEAR 1998-2001 PONTIAC MONTANA VEHICLES HAVE IDENTICAL DRIVER-SIDE AIR BAG INFLATORS.THE ENGINEERING ANALYSIS WILL COVER THESE MODEL/MODEL YEAR VEHICLES.
Illustration