Illustration1998 PONTIAC GRAND PRIX. CONSUMER WRITES IN REGARDS TO SAFETY RECALL *TGW THE CONSUMER STATED THE VEHICLE CAUGHT ON FIRE AS A RESULT OF A RECALL. *JB
1998 Pontiac Grand Prix
Owner reports · Recalls · Investigations
More warning signs than most Grand Prix years
Owner complaints for the 1998 Pontiac Grand Prix are substantially higher than the model-year median of 88.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Prix years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
40–25K
1825–50K
3450–75K
4075–100K
53100–150K
20150K+
169 reports with mileage · 330 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 90 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 90 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 89 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
19 crash reports60 fire reports16 injury reports
What owners actually said
499 reportsTL* THE CONTACT OWNS A 1998 PONTIAC GRAND PRIX. THE CONTACT STATED THAT WHILE DRIVING, THE VEHICLE CAUGHT ON FIRE FROM THE ENGINE. THE CONTACT MERGED ONTO THE SHOULDER WHERE THE FIRE WAS EXTINGUISHED. A POLICE REPORT WAS NOT FILED NOR WAS THE DEALER CONTACTED. THE MANUFACTURER DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE.…
Read full complaint
TL* THE CONTACT OWNS A 1998 PONTIAC GRAND PRIX. THE CONTACT STATED THAT WHILE DRIVING, THE VEHICLE CAUGHT ON FIRE FROM THE ENGINE. THE CONTACT MERGED ONTO THE SHOULDER WHERE THE FIRE WAS EXTINGUISHED. A POLICE REPORT WAS NOT FILED NOR WAS THE DEALER CONTACTED. THE MANUFACTURER DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 145,316.
THE GAS TANK IS NOT SEALED IN THE MIDDLE ALLOWING GAS AND FUEL VAPOR TO LEAK FROM CAR! ALL THE SWAY BAR ON THE DRIVER SIDE HAS SEPARATED DUE TO THE RACK AND PINION, CAR HAS NO SOUND WHEN TURNING TO THE RIGHT BUT IF YOU TRY AND TURN THE CAR TO THE LEFT IT IS AS IF THE POWER STEERING IS GOING OUT AND MAKE A LOUD GRINDING NOISE A…
Read full complaint
THE GAS TANK IS NOT SEALED IN THE MIDDLE ALLOWING GAS AND FUEL VAPOR TO LEAK FROM CAR! ALL THE SWAY BAR ON THE DRIVER SIDE HAS SEPARATED DUE TO THE RACK AND PINION, CAR HAS NO SOUND WHEN TURNING TO THE RIGHT BUT IF YOU TRY AND TURN THE CAR TO THE LEFT IT IS AS IF THE POWER STEERING IS GOING OUT AND MAKE A LOUD GRINDING NOISE AND IS GETTING VERY DIFFICULT TO TURN LEFT, ALSO THE WINDSHIELD WIPER DO NOT WORK PROPER AND CAUSE PROBLEMS IN THE RAIN, THE KEY GET STUCK IN THE IGNITION ALL THE TIME,FEEL AS IF MOTOR IS TWISTING OR MOVING FORWARD, WILL BE CONTACTING PONTIAC DUE TO RECALLS AND PROBLEMS ARISING. *TR
TL*THE CONTACT OWNS A 1998 PONTIAC GRAND PRIX. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT HEARD A TICKING SOUND FROM THE ENGINE. THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAG…
Read full complaint
TL*THE CONTACT OWNS A 1998 PONTIAC GRAND PRIX. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT HEARD A TICKING SOUND FROM THE ENGINE. THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 143,900.
1998 PONTIAC GRAND PRIX, 147,000 MILES. SIGNS AND SYMPTOMS OF STEERING FAILURE ARE CONSISTENT WITH GM RECALL #02049 AND NHTSA CAMPAIGN ID 02V28600. FAILURE OF THE RACK AND PINION STEERING SYSTEM. CAN BARELY TURN THE CAR LEFT ANYMORE DUE TO THE FAILURE OF THE RACK & PINION SYSTEM. SEVERAL CALLS TO GM AND PONTIAC ENDED WITH TH…
Read full complaint
1998 PONTIAC GRAND PRIX, 147,000 MILES. SIGNS AND SYMPTOMS OF STEERING FAILURE ARE CONSISTENT WITH GM RECALL #02049 AND NHTSA CAMPAIGN ID 02V28600. FAILURE OF THE RACK AND PINION STEERING SYSTEM. CAN BARELY TURN THE CAR LEFT ANYMORE DUE TO THE FAILURE OF THE RACK & PINION SYSTEM. SEVERAL CALLS TO GM AND PONTIAC ENDED WITH THEM SAYING MY VIN # IS NOT IN THE RECALL. WHEN THE CAR CAUSES A CRASH AND KILLS SOMEONE, I PLAN TO SUE BOTH PONTIAC AND GM. *TR
98 GRAND PRIX LOSES POWER STEERING WHEN TURNING LEFT AT LOW SPEED. THIS IS EXACTLY LIKE THE PROBLEM DESCRIBED IN RECALL#02V286000. THIS CAR WAS BROUGHT IN FOR THAT SERVICE RECALL BACK IN 2003 AT 39,000 MILES. THE CAR NOW HAS 95,000 MILES AND THE PROBLEM IS BACK. IT WOULD APPEAR THAT THE RECALL FIX WAS ONLY TEMPORARY. THE CARS A…
Read full complaint
98 GRAND PRIX LOSES POWER STEERING WHEN TURNING LEFT AT LOW SPEED. THIS IS EXACTLY LIKE THE PROBLEM DESCRIBED IN RECALL#02V286000. THIS CAR WAS BROUGHT IN FOR THAT SERVICE RECALL BACK IN 2003 AT 39,000 MILES. THE CAR NOW HAS 95,000 MILES AND THE PROBLEM IS BACK. IT WOULD APPEAR THAT THE RECALL FIX WAS ONLY TEMPORARY. THE CARS ARE STILL POTENTIALLY DANGEROUS TO DRIVE AFTER THE RECALL FIX HAS BEEN PERFORMED. GM WILL NOT REPAIR THE CAR AGAIN SINCE THEY CLAIM THEY ONLY HAVE TO FIX IT ONCE. THE PROBLEM HAS RETURNED, AND IF IT WAS NOT SAFE THE 1ST TIME AND HAD TO BE RECALLED, IT SHOULD BE RECALLED AGAIN UNTIL THEY GET IT RIGHT. *TR
DURING A SNOW STORM, MY CAR GOT STUCK ON MY DRIVEWAY. IN TRYING TO START THE CAR, IT WOULDN'T TURN-OVER. THE NEXT DAY, IT HAD TO BE TOWED TO A SERVICE STATION. THE STARTER HAD RUPTURED & WAS REPLACED. DURING THE DIAGNOSTICS TO VERIFY THE REPAIR, THE COOLANT DISAPPEARED FROM THE RADIATOR. DIAGNOSING THIS PROBLEM, THE MECHANIC DIS…
Read full complaint
DURING A SNOW STORM, MY CAR GOT STUCK ON MY DRIVEWAY. IN TRYING TO START THE CAR, IT WOULDN'T TURN-OVER. THE NEXT DAY, IT HAD TO BE TOWED TO A SERVICE STATION. THE STARTER HAD RUPTURED & WAS REPLACED. DURING THE DIAGNOSTICS TO VERIFY THE REPAIR, THE COOLANT DISAPPEARED FROM THE RADIATOR. DIAGNOSING THIS PROBLEM, THE MECHANIC DISCOVERED THAT THE PLASTIC INTAKE MANIFOLD HAD CRACKED, CAUSING THE COOLANT TO LEAK OUT. (THIS REMINDED ME THAT IN JAN 2005, I HAD A PROBLEM WITH SUDDEN COOLANT & OIL LOSS. I NEVER FOUND THE REASON FOR THAT OCCURRENCE, BUT NOW KNOW IT WAS RELATED TO THE CRACKED MANIFOLD.) THE PLASTIC MANIFOLD WAS REPLACED WITH ANOTHER PLASTIC MANIFOLD. PARTS ARE NOT AVAILABLE. *TR
WHILE DRIVING ON THE PARKWAY, THE STEERING SUDDENLY TIGHTENED UP, MAKING TURNING THE STEERING WHEEL DIFFICULT. THEN THE BATTERY/ALTERNATOR INDICATOR LIGHT TURNED ON ALONG WITH OTHER INDICATOR LIGHTS. SUDDENLY, THE ENGINE STALLED & THE CAR COASTED TO A STOP. OPENING THE HOOD, I NOTICED THE ACCESSORY BELT WAS MISSING (ACTUALLY, IT…
Read full complaint
WHILE DRIVING ON THE PARKWAY, THE STEERING SUDDENLY TIGHTENED UP, MAKING TURNING THE STEERING WHEEL DIFFICULT. THEN THE BATTERY/ALTERNATOR INDICATOR LIGHT TURNED ON ALONG WITH OTHER INDICATOR LIGHTS. SUDDENLY, THE ENGINE STALLED & THE CAR COASTED TO A STOP. OPENING THE HOOD, I NOTICED THE ACCESSORY BELT WAS MISSING (ACTUALLY, IT HAD COME OFF & WAS SITTING ON THE FRONT SUSPENSION). CHECKING THE BELT PULLEYS, I FOUND THAT THE ACCESSORY BELT IDLER PULLEY BEARING HAD SEIZED, CAUSING THE BELT TO COME OFF. I WAS TOWED TO A SERVICE STATION, WHERE THEY REPLACED THE ACCESSORY BELT IDLER PULLEY BEARING. THE OLD PART IS NOT AVAILABLE. *TR
1998 PONTIAC GRAND PRIX. CONSUMER STATES VEHICLE CAUGHT FIRE AND MELTED THE MOTOR *TGW THE CONSUMER RECEIVED A RECALL NOTICE AFTER THE FIRE. *JB
I RECEIVED A NOTICE IN THE MAIL FROM GM ON 5/14/2009 THAT MY VEHICLE HAD BEEN RECALLED OVER AN ISSUE INVOLVING A SAFETY RECALL 09047. THIS WAS ON THURSDAY AND THAT FOLLOWING SATURDAY MY CAR CAUGHT FIRE. I HAD NOT HAD TIME TO SCHEDULE AN APPOINTMENT WITH A DEALERSHIP. MY CAR RAN FINE AND HAD NO PROBLEMS PRIOR TO THE FIRE. THE FIR…
Read full complaint
I RECEIVED A NOTICE IN THE MAIL FROM GM ON 5/14/2009 THAT MY VEHICLE HAD BEEN RECALLED OVER AN ISSUE INVOLVING A SAFETY RECALL 09047. THIS WAS ON THURSDAY AND THAT FOLLOWING SATURDAY MY CAR CAUGHT FIRE. I HAD NOT HAD TIME TO SCHEDULE AN APPOINTMENT WITH A DEALERSHIP. MY CAR RAN FINE AND HAD NO PROBLEMS PRIOR TO THE FIRE. THE FIRE HAPPENED UNDER THE HOOD. I HAD TO CALL THE FIRE DEPARTMENT TO HAVE THE FIRE PUT OUT. *TR
Official recalls
415V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
09V116000 · Engine And Engine Cooling
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
08V118000 · Engine And Engine Cooling
Mar 12, 2008
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence & remedy
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
02V286000 · Steering:rack And Pinion
Nov 4, 2002
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
EA01014 · Air Bag Inflator
Opened Jun 11, 2001 · Closed Aug 26, 2002
Status: closed (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module
No summary supplied.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
Air Bags:frontal:driver Side:inflator Module
EA99024 · Windshield Wiper
Opened Aug 20, 1999 · Closed Jan 13, 2000
Status: closed (inferred from source dates) · Visibility
BY LETTER DATED DECEMBER 12, 1999, GM NOTIFIED NHTSA OF ITS PLANS TO CONDUCT A SAFETY RELATED DEFECT CAMPAIGN TO REMEDY 155,149 OF THE SUBJECT VEHICLES.THE VEHICLE POPULATION FOR THE CAMPAIGN INCLUDES THE 1997 BUICK REGAL/CENTURY AND PONTIAC GRAN PRIX MODELS BUILT DURING THE PERIOD FROM THE START OF PRODUCTION THROUGH MAY 1, 1997.GM DETERMINED THAT THE WIPERS INSTALLED PRIOR TO THIS DATE COULD STOP WORKING, USUALLY DURING HEAVY LOAD CONDITIONS, DUE TO SEPARATION BETWEEN THE DRIVE PIN AND THE CRESCENT IN THE WIPER CRANK ARM ASSEMBLY.EFFECTIVE MAY 1, 1997,GM CORRECTED THIS PROBLEM IN PRODUCTION BY MODIFYING THE DRIVE PIN AND STRENGTHENING THE CRESCENT.THESE SAME IMPROVED PARTS WILL BE INSTALLED IN THE VEHICLES TO BE RECALLED.THE SCOPE OF THE CAMPAIGN WILL INCLUDE ALL VEHICLES PRODUCED PRIOR TO THE MAY 1, 1997 CORRECTION (THE OLDSMOBILE INTRIQUE PRODUCTION DID NOT START UNTIL AFTER MAY 1, 1997, AND IS THEREFORE NOT INCLUDED).VEHICLES WITH THE SCOPE OF THIS INVESTIGATION AND PRODUCED AFTER MAY 1, 1997, CONTAIN THE MORE ROBUST CRESCENT AND IMPROVED PIN DESIGN AND ARE NOT INCLUDED IN THE RECALL CAMPAIGN.ODI WILL CONTINUE TO MONITOR COMPLAINT REPORTS ON THE VEHICLES PRODUCED AFTER MAY 1, 1997 AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.BASED ON GM'S RECALL ACTION (ODI 99V-348) THIS INVESTIGATION IS CLOSED.
PE99028 · Windshield Wiper
Opened Apr 16, 1999 · Closed Aug 20, 1999
Status: closed (inferred from source dates) · Visibility
INCIDENTS OF WIPER FAILURE (OWNER REPORTS AND WARRANTY) ARE VERY HIGH, AND MANY OF THE REPORTS INDICATE THAT THE FAILURES ARE STILL OCCURRING IN 1999.