IllustrationCOOLANT ELBOW PRODUCED A CRACK. AS A RESULT, ANTI FREEZE LEAKED. THE PART WAS REPLACED TWICE. HOWEVER, THE PROBLEM RECURRED. *AK
1998 Pontiac Grand Prix
Owner reports · Recalls · Investigations
More warning signs than most Grand Prix years
Owner complaints for the 1998 Pontiac Grand Prix are substantially higher than the model-year median of 88.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Prix years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
40–25K
1825–50K
3450–75K
4075–100K
53100–150K
20150K+
169 reports with mileage · 330 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 90 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 90 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 89 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
19 crash reports60 fire reports16 injury reports
Engine And Engine Cooling complaints
90 reportsVEHICLE WAS PARKED IN A PARKING LOT WHEN FLAMES CAME FROM THE ENGINE COMPARTMENT. THE FLAMES BURNT UP THE ENTIRE ENGINE. FIRE DEPARTMENT HAD TO BURST THE DRIVER SIDE WINDOW TO LET THE SMOKE OUT OF THE CABIN . A FIRE REPORT WAS FILED. *AK *NM
WHILE DRIVING THE VEHICLE STALLS WITHOUT WARNING. THIS OCCURRED 4 TIMES IN DIFFERENT DRIVING CIRCUMSTANCE. THIS FAILURE COULD RESULT IN AN ACCIDENT. THE DEALERSHIP HAS SERVICED THE VEHICLE 5 TIMES AND PERFORMED A DIAGNOSTIC TEST, BUT NO FAILURE CODE WAS FOUND. *NM
BACK IN MAY OF 2003 I NOTICED WATER IN THE PASSENGER SIDE OF CAR IN THE WELL. I THOUGHT IT WAS A LEAK IN THE WINSHIELD BECAUSE I HAD ANOTHER CAR THAT HAD A LEAK AND IT WAS THE WINSHIELD. THE AUTOGLASS DEALER TOLD ME IT WAS THE VENT SYSTEM AND NOT THE WINSHIELD. SINCE THEN, THE AIR CONDITIONING HAS JUST STOPPED WORKING. I AM …
Read full complaint
BACK IN MAY OF 2003 I NOTICED WATER IN THE PASSENGER SIDE OF CAR IN THE WELL. I THOUGHT IT WAS A LEAK IN THE WINSHIELD BECAUSE I HAD ANOTHER CAR THAT HAD A LEAK AND IT WAS THE WINSHIELD. THE AUTOGLASS DEALER TOLD ME IT WAS THE VENT SYSTEM AND NOT THE WINSHIELD. SINCE THEN, THE AIR CONDITIONING HAS JUST STOPPED WORKING. I AM ABOUT TO TAKE THE CAR TO THE DEALER BUT I DON'T KNOW IF IT IS WORTH THE COST OF FIXING, DO YOU HAVE ANY ADVICE?
I DON'T HAVE THE EXACT DATES WITH ME. MY VEHICLE IS CURRENTLY AT DEALERSHIP FOR REPAIR. PROBLEMS: OVER THE 4 YEARS THE VEHICLE WOULD STALL FROM A STOP POSITION USUALLY WHEN AT A TRAFFIC LIGHT OUR WHEN MAKING A TURN FROM A BLVD. IN ALL CASES I'M IN A PANIC SITUATION TO RE-START THE CAR. THE CAR HAS BEEN INTO THE DEALER AND T…
Read full complaint
I DON'T HAVE THE EXACT DATES WITH ME. MY VEHICLE IS CURRENTLY AT DEALERSHIP FOR REPAIR. PROBLEMS: OVER THE 4 YEARS THE VEHICLE WOULD STALL FROM A STOP POSITION USUALLY WHEN AT A TRAFFIC LIGHT OUR WHEN MAKING A TURN FROM A BLVD. IN ALL CASES I'M IN A PANIC SITUATION TO RE-START THE CAR. THE CAR HAS BEEN INTO THE DEALER AND THEY CANT DIAGNOSE THE PROBLEM BUT CHARGED BE $80 FOR THE DIAGNOSES. THIS IS AN ONGOING ISSUE.. I FEEL VERY SERIOUS. HEADLIGHT CAPSULES FELL OFF, LEFT SIDE NOVEMBER 2001 AND JUST NOW THE RIGHT SIDE JUNE 2003. I FEEL THIS SHOULD BE CONSIDERED A RECALL ITEM. POWERWINDOW (LEFT REAR) MOTOR HAD TO BE REPALCED AND THE RIGHT REAR GOES ON AND OFF AT TIMES. WINDSHEILD SEAL LEAKS AND WATER RUNS INTO THE OVERHEAD LIGHT COUNSEL AND OVER THE PASSENGER SEAT, I'M ALSO TOLD BY THE DEALER THAT THE WEATHER GUARD IS BAD AROUND THE PASSAGER FRONT LEFT DOOR. DASH LIGHT FOR THE PERFORMANCE SHIFT DOESNT WORK, BUT DEALER INDICATES THAT THE SHIFT BOTTON WORKS. I HAVE ALL OF MY SERVICE RECORDS AND HAVE USED THE ORIGINAL SELLING DEALER FOR ALL OF MY SERVICE NEEDS SINCE I PURCHASED THE VEHICLE. I'M INTERESTED IN ADDRESSING MY MECHANICAL ISSUES. THE CURRENT MILEAGE FOR MY 1998 GP IS 47,000.
INTAKE MANIFOLD GASKET LEAK IN PONTIAC 1998 3.1 LITER ENGINE. *LA
THE ENGINE CAUGHT ON FIRE, WHILE THE VEHICLE WAS PARKED. *JB
THE CAR FOR THE PAST 2 YEARS HAS HAD AN OVERHEATING PROBLEM. FIRST IN 2000 THE WATER PUMP WAS REPLACED. 3 MONTHS LATER TROUBLE CAME BACK AND THERMOSTAT WAS REPLACED. 2 MONTHS LATER OVERHEATING AGAIN AND THIS TIME COOLANT LEAKING. THEY REPLACED A CLAMP ON THE HEAT PUMP HOSE. 6 MONTHS LATER TROUBLE IS BACK AGAIN THIS TIME IT OVERH…
Read full complaint
THE CAR FOR THE PAST 2 YEARS HAS HAD AN OVERHEATING PROBLEM. FIRST IN 2000 THE WATER PUMP WAS REPLACED. 3 MONTHS LATER TROUBLE CAME BACK AND THERMOSTAT WAS REPLACED. 2 MONTHS LATER OVERHEATING AGAIN AND THIS TIME COOLANT LEAKING. THEY REPLACED A CLAMP ON THE HEAT PUMP HOSE. 6 MONTHS LATER TROUBLE IS BACK AGAIN THIS TIME IT OVERHEATED AND BLEW THE HEATER PUMP HOSE AND COOLANT WENT EVERYWHERE. ALL IN ALL IT COST ME OUT OF POCKET $1600 BECAUSE NONE OF THE REPAIRS WERE COVERED BY ANY WARRANTY INCLUDED THE EXTENDED I HAD PURCHASED.*JB
THE ENGINE STALLED, AND THE IGNITION LOCKED UP.*JB
MY SECOND REAR MAIN SEAL LEAKING OIL WITH ONLY 61,000 MILES ON THE CAR. MY FIRST WAS FIXED UNDER WARRANTY AT 34,000 MILES AND 27,000 MILES LATER I HAVE THE EXACT SAME PROBLEM. I WAS TOLD IT WOULD COST ME 1100 DOLLARS TO FIX AND THAT THERE IS NOTHING THEY CAN DO ABOUT THIS BEING THE SECOND REPAIR IN SUCH A SHORT TIME. CUSTOMER…
Read full complaint
MY SECOND REAR MAIN SEAL LEAKING OIL WITH ONLY 61,000 MILES ON THE CAR. MY FIRST WAS FIXED UNDER WARRANTY AT 34,000 MILES AND 27,000 MILES LATER I HAVE THE EXACT SAME PROBLEM. I WAS TOLD IT WOULD COST ME 1100 DOLLARS TO FIX AND THAT THERE IS NOTHING THEY CAN DO ABOUT THIS BEING THE SECOND REPAIR IN SUCH A SHORT TIME. CUSTOMER CARE SAID ALL THEY COULD DO WAS OFFER A DISCOUNT ON A BRAND NEW VEHICLE. I THOUGHT THAT WAS LAUGHABLE. WILL THE REST OF THE PROBLEMS I'VE HAD I WILL NEVER TOUCH A GM PRODUCT AGAIN. 3 REPAIRS FIXED UNDER WARRANTY ARE NOW DOING THE SAME THING AGAIN AND NEED REPAIR. TS
Official recalls
415V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
09V116000 · Engine And Engine Cooling
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
08V118000 · Engine And Engine Cooling
Mar 12, 2008
GM IS RECALLING 207,542 MY 1997-2003 BUICK REGAL AND PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L SUPERCHARGED V-6 ENGINE. THESE VEHICLES HAVE HIGHER FRONT ROCKER COVER GASKET TEMPERATURES, CREATING THE POTENTIAL FOR EARLIER DEGRADATION OF THE FRONT ROCKER COVER GASKET AND EVENTUAL OIL SEEPAGE.
Consequence & remedy
Consequence: CERTAIN UNDERHOOD FIRES MAY BE CAUSED BY DROPS OF ENGINE OIL, FROM SEEPAGE OR SPILLAGE, BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND, IN SOME INSTANCES, THE FIRE MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, ALONG WITH THE 1-3-5 SPARK PLUG WIRE RETAINERS, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. , FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. UNTIL THE REMEDY IS COMPLETED, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS (1) THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CAR PORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE. THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL. OWNERS MAY CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
02V286000 · Steering:rack And Pinion
Nov 4, 2002
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
EA01014 · Air Bag Inflator
Opened Jun 11, 2001 · Closed Aug 26, 2002
Status: closed (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module
No summary supplied.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
Air Bags:frontal:driver Side:inflator Module
EA99024 · Windshield Wiper
Opened Aug 20, 1999 · Closed Jan 13, 2000
Status: closed (inferred from source dates) · Visibility
BY LETTER DATED DECEMBER 12, 1999, GM NOTIFIED NHTSA OF ITS PLANS TO CONDUCT A SAFETY RELATED DEFECT CAMPAIGN TO REMEDY 155,149 OF THE SUBJECT VEHICLES.THE VEHICLE POPULATION FOR THE CAMPAIGN INCLUDES THE 1997 BUICK REGAL/CENTURY AND PONTIAC GRAN PRIX MODELS BUILT DURING THE PERIOD FROM THE START OF PRODUCTION THROUGH MAY 1, 1997.GM DETERMINED THAT THE WIPERS INSTALLED PRIOR TO THIS DATE COULD STOP WORKING, USUALLY DURING HEAVY LOAD CONDITIONS, DUE TO SEPARATION BETWEEN THE DRIVE PIN AND THE CRESCENT IN THE WIPER CRANK ARM ASSEMBLY.EFFECTIVE MAY 1, 1997,GM CORRECTED THIS PROBLEM IN PRODUCTION BY MODIFYING THE DRIVE PIN AND STRENGTHENING THE CRESCENT.THESE SAME IMPROVED PARTS WILL BE INSTALLED IN THE VEHICLES TO BE RECALLED.THE SCOPE OF THE CAMPAIGN WILL INCLUDE ALL VEHICLES PRODUCED PRIOR TO THE MAY 1, 1997 CORRECTION (THE OLDSMOBILE INTRIQUE PRODUCTION DID NOT START UNTIL AFTER MAY 1, 1997, AND IS THEREFORE NOT INCLUDED).VEHICLES WITH THE SCOPE OF THIS INVESTIGATION AND PRODUCED AFTER MAY 1, 1997, CONTAIN THE MORE ROBUST CRESCENT AND IMPROVED PIN DESIGN AND ARE NOT INCLUDED IN THE RECALL CAMPAIGN.ODI WILL CONTINUE TO MONITOR COMPLAINT REPORTS ON THE VEHICLES PRODUCED AFTER MAY 1, 1997 AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.BASED ON GM'S RECALL ACTION (ODI 99V-348) THIS INVESTIGATION IS CLOSED.
PE99028 · Windshield Wiper
Opened Apr 16, 1999 · Closed Aug 20, 1999
Status: closed (inferred from source dates) · Visibility
INCIDENTS OF WIPER FAILURE (OWNER REPORTS AND WARRANTY) ARE VERY HIGH, AND MANY OF THE REPORTS INDICATE THAT THE FAILURES ARE STILL OCCURRING IN 1999.