CAR WOULD GET HORRID GAS MILEAGE, OCCASIONALLY STALL, EXHAUST SMELL UNDER HOOD, BLACK EXHAUST. THE CROSSOVER PIPE FROM EACH EXHAUST MANIFOLD HAS A COMMON CRACKING ON THE BELLOWS AND MUST BE REPLACED, THEY RUN $2500 FROM GM WHICH JUST CRACK AGAIN, OR $425 FOR JEFF M ONE THAT DOESN'T CRACK. THE PIPE CRACKS CAUSE FRESH AIR TO ENTER…
Read full complaint
CAR WOULD GET HORRID GAS MILEAGE, OCCASIONALLY STALL, EXHAUST SMELL UNDER HOOD, BLACK EXHAUST. THE CROSSOVER PIPE FROM EACH EXHAUST MANIFOLD HAS A COMMON CRACKING ON THE BELLOWS AND MUST BE REPLACED, THEY RUN $2500 FROM GM WHICH JUST CRACK AGAIN, OR $425 FOR JEFF M ONE THAT DOESN'T CRACK. THE PIPE CRACKS CAUSE FRESH AIR TO ENTER THE EXHAUST AND THE OXYGEN SENSOR THINKS THE CARS RUNNING RICH, CAUSING HORRIBLE GAS MILEAGE, OIL CONTAMINATION, AND STALLING. THE EXTRA HEAT FROM THE CAR RUNNING RICH CRACKS THE TURBO HOUSING. *NM
NHTSA ODI #10152257
65,000 miles · Dec 30, 2003
Engine And Engine Cooling
WHILE DRIVING THE ENGINE FELL. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DETERMINED THAT THE RETAINER CRADLE BROKE. CONSUMER NEVER RECEIVED A RECALL NOTICE. *NM *MR
NHTSA ODI #10052115
Mileage unknown · Dec 3, 2002
Engine And Engine Cooling
CONSUMER CALLED COMPLAINING ABOUT HAVING PROBLEM WITH THE ENGINE MOUNTS. WHICH HE REPLACED AT 115 THOUSANDS MILES AND HAS TO REPLACED AGAIN. DEALER HAS NOT BEEN NOTIFIED. PLEASE PROVIDE FIURTHER INFORMATION. TS
NHTSA ODI #8023616
Mileage unknown · Mar 12, 2001
Engine And Engine Cooling
MOTOR MOUNTS CAME LOOSE AND ENGINE FELL DOWN SOME INCHES. CURRENTLY CONSUMER IS NOT ABLE TO START VEHICLE.*AK
NHTSA ODI #882721
Mileage unknown · Nov 27, 2000
Engine And Engine Cooling
CONSUMER WAS TRAVELING ON A SIDE STREET AND WAS MAKING A LEFT TURN WHEN ENGINE HAD DROPPED, AND SHE LOST CONTROL OF VEHICLE. CONSUMER HAD THE VEHICLE TOWED INTO DEALERSHIP. *AK
NHTSA ODI #875526
Mileage unknown · Nov 30, 1999
Engine And Engine Cooling
WHILE DRIVING ABOUT 40 MPH THE ENGINE ALMOST FELL OUT DUE TO RUSTING OF THE ENGINE CRADLE. DRIVER WAS ABLE TO DRIVE THE VEHICLE SAFELY TO A MECHANIC. ENGINE CRADLE AND ENGINE MOUNTS WAS REPLACED AT A REPAIR SHOP. PLACE PROVIDE ANY FURTHER INFORMATION. *AK
NHTSA ODI #853475
Mileage unknown · Nov 7, 1999
Engine And Engine Cooling
NHTSA CAMPAIGN ID # 97V058000-ENGINE MOUNTS
NHTSA ODI #714436
Mileage unknown · Sep 30, 1999
Engine And Engine Cooling
CRACKED ENGINE BLOCK AT 95000 MILES
NHTSA ODI #712606
Mileage unknown · Aug 26, 1999
Engine And Engine Cooling
WHILE DRIVING ABOUT 35MPH HEARD A RUBBING SOUND, PULLED OVER, AND SAW SERPENTINE BELT CUTTING INTO WIRING HARNESS. BOTTOM OF FRAME WHERE THE BUSHING ON THE CRADLE MOTOR IS LOCATED, COMPLETELY DROPPED. CONTACTED DEALER TO GET VEHICLE IN FOR REPAIRS. *AK
NHTSA ODI #845910
Mileage unknown · Sep 23, 1998
Engine And Engine Cooling
REAR CRADLE BOLT RECALL WORK PERFORMED HOWEVER THE FRONT CRADLE BOLTS ROTTED OFF AND WERE NOT COVERED UNDER THE RECALL WORK.
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, WHERE ROAD SALT USE IS HEAVY. A CONDITION WHERE ONE OR BOTH FRONT ENGINE CRADLE BOLTS CAN PULL THROUGH THE RETAINERS DUE TO CORROSION OF THE RETAINERS.
Consequence & remedy
Consequence: IF BOTH BOLTS PULL THROUGH, THE FRONT OF THE CRADLE WOULD NO LONGER BE SUPPORTED AT THE MOUNTING LOCATIONS AND THE STEERING INTERMEDIATE SHAFT COULD SEPARATE FROM THE STEERING GEAR.
Remedy: DEALERS WILL REPLACE THE FRONT AND REAR FRAME/CRADLE BOLTS AND RETAINERS.
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND MINI VANS ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, ILLINOIS, INDIANA, MAINE, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT AND WISCONSIN. THE REAR CRADLE BOLTS PULL THROUGH THE RETAINERS DUE TO CORROSION OF THE RETAINER. IF BOTH BOLTS PULL THROUGH, THE REAR CRADLE WOULD NOT LONGER BE SUPPORTED AT THESE MOUNTING LOCATIONS AND THE STEERING INTERMEDIATE SHAFT CAN SEPARATE FROM THE STEERING GEAR.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, A VEHICLE CRASH COULD RESULT.
Remedy: DEALERS WILL REPLACE THE REAR CRADLE BOLTS AND RETAINERS.
CRACKS DEVELOP IN THE WHEEL MOUNTING SURFACE. IF THESE CRACKS BECOME SEVERE ENOUGH, THE WHEEL WILL COMPLETELY SEPARATE FROM THE VEHICLE.
Consequence & remedy
Consequence: IF WHEEL SEPARATION OCCURS WHILE THE VEHICLE IS IN MOTION, LOSS OF STEERING AND BRAKE CONTROL OF THE VEHICLE OCCURS, AND A VEHICLE CRASH COULD RESULT WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT THE MANUFACTURING DATE CODES STAMPED ON EACH WHEEL OF THE VEHICLE AND IF A WHEEL FALLS WITHIN THE SPECIFIED DATE CODE RANGE, THE DEALER WILL REPLACE THAT WHEEL ASSEMBLY.
CRACKS DEVELOP IN THE WHEEL MOUNTING SURFACE. IF THESE CRACKS BECOME SEVERE ENOUGH, THE WHEEL WILL COMPLETELY SEPARATE FROM THE VEHICLE.
Consequence & remedy
Consequence: IF WHEEL SEPARATION OCCURS WHILE THE VEHICLE IS IN MOTION, LOSS OF STEERING AND BRAKE CONTROL OF THE VEHICLE OCCURS, AND A VEHICLE CRASH COULD RESULT WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT THE MANUFACTURING CODES STAMPED ON EACH WHEEL OF THE VEHICLE AND IF A WHEEL FALLS WITHIN THE SPECIFIED DATE CODE RANGE, THE DEALER WILL REPLACE THAT WHEEL ASSEMBLY.
FRONT SHOULDER SAFETY BELT WEBBING MAY SEPARATE AT FRONT BELT UPPER GUIDE LOOPS ON EITHER SIDE OF THE FRONT SEAT.
Consequence & remedy
Consequence: WEBBING SEPARATION COULD OCCUR WITHOUT PRIOR WARNING ANDINCREASE THE RISK OF INJURY TO BELTED FRONT OUTBOARD OCCUPANTS IN A HIGH ENERGYCRASH.
Remedy: INSTALL A CONTROLLED ROTATION BRACKET ON DRIVER AND PASSENGER SIDE FRONT SEAT BELT GUIDE LOOPS.
BRAKE STOPLAMPS MAY NOT ILLUMINATE OR, IN SOME CASES, STOPLAMPS WILL NOT STAY ILLUMINATED ALL THE TIME WHEN BRAKES ARE APPLIED DUE TO A FAULTY STOPLAMP SWITCH. ALSO IN VEHICLES EQUIPPED WITH CRUISE CONTROL, A FAULTY STOPLAMP SWITCH CAN RESULT IN RESUMPTION OF THE CRUISE CONTROL FUNCTION UPON RELEASE OF THE BRAKE PEDAL.
Consequence & remedy
Consequence: A TRAILING VEHICLE MAY NOT RECOGNIZE A BRAKING ACTIONIN TIME TO RESPOND APPROPRIATELY. ALSO, CRUISE CONTROL WILL REENGAGE UPONRELEASE OF THE BRAKE PEDAL AND RESUME THE SET SPEED. IN EITHER CASE, IT COULDRESULT IN A CRASH WITHOUT PRIOR WARNING.
Remedy: INSTALL AN IMPROVED DESIGN STOPLAMP SWITCH.
FRONT SHOULDER BELT GUIDE LOOP ATTACHMENT FASTENER MAY PULL THROUGH DOOR MOUNTED ANCHOR PLATE.
Consequence & remedy
Consequence: SEAT BELT MAY NOT SUSTAIN LOADS REQUIRED BY FMVSS 210, AND IN A VEHICLE ACCIDENT, THE SEAT BELT MAY NOT PROPERLY RESTRAIN A PASSENGER, RESULTING IN INCREASED RISK OF GREATER INJURY TO AN OCCUPANT.
Remedy: REPLACE FRONT SHOULDER BELT GUIDE LOOP ATTACHMENT NUTS AND INSTALL NEW GUIDE COVER.
DURING A REAR END COLLISION, THE REAR EXHAUST SYSTEM HEAT SHIELD, WHICH IS WELDED TO THE TAIL PIPE ASSEMBLY, MAY PUNCTURE THE FUEL TANK.
Consequence & remedy
Consequence: IN THE PRESENCE OF AN EXTERNAL SOURCE OF IGNITION, THIS COULD RESULT IN A FIRE.
Remedy: REMOVE REAR EXHAUST SYSTEM HEAT SHIELD FROM THE PIPE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
10
RP01001 · Structure
Opened Nov 28, 2001 · Closed Jun 13, 2002
Status: closed (inferred from source dates) · Structure
There is no summary currently available
EA00011 · Engine Cradle Separation
Opened Apr 10, 2000 · Closed Jan 12, 2001
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE ENGINE CRADLE FRONT BOLTS AND/OR RETAINERS MAY FAIL, ALLOWING THE FRONT OF THE ENGINE CRADLE TO FALL, POSSIBLY SEPARATING THE STEERING INTERMEDIATE SHAFT FROM THE STEERING GEAR, WITH COMPLETE LOSS OF STEERING CONTROL
RQ97017 · Cradle Bolt Failures
Opened Oct 2, 1997 · No close date supplied
Status: open (inferred from source dates) · Structure
There is no summary currently available
PE94063 · Corroded Rear Disk Brakes
Opened Aug 12, 1994 · Closed Dec 21, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE93085 · Wheel Failures
Opened Sep 29, 1993 · Closed Feb 28, 1994
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
EA92024 · Sticking Throttle
Opened Jun 26, 1992 · Closed Jan 31, 1994
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA91049 · Jack Failure
Opened Nov 26, 1991 · Closed Oct 28, 1992
Status: closed (inferred from source dates) · Equipment
===
PE91107 · Jack Failure
Opened Aug 1, 1991 · Closed Nov 26, 1991
Status: closed (inferred from source dates) · Equipment
There is no summary currently available
PE91072 · Steering Wheel Separation
Opened May 1, 1991 · Closed Jul 8, 1991
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE90088 · Failure Stop Lamp Switch
Opened Jun 11, 1990 · Closed Oct 31, 1990
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
1990 Pontiac Grand Prix Problems, Complaints & Recalls | Skip That Year
Illustration