Electrical System. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel System, Gasoline. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

15 crash reports1 fire reports6 injury reports

Engine And Engine Cooling complaints

2 reports

Clear category filter

39,099 miles · Jun 10, 2008

Engine And Engine Cooling

HAD TO REPLACE INTAKE MANIFOLD GASKET DUE TO GM DEXCOOL COOLANT CORRODING THE GASKET. IF NOT REPLACE ENGINE FAILURE WOULD OCCUR. *TR

NHTSA ODI #10230537

70,000 miles · Feb 25, 2008

Engine And Engine Cooling

Read full complaint

I HAVE A 2005 PONTIAC GRAND AM, AND EVER SINCE I GOT IT THE LIGHTS IN THE CAR AND THE HEADLIGHTS DIM, WHILE I ACCELERATE. I HAVE TAKEN IT IN TO THE GARAGE I BOUGHT IT FROM SEVERAL TIMES AND THEY NEVER FIXED IT. I AM STILL HAVING THE PROBLEM AND IT IS GETTING WORSE. THE TOLD ME THERE MAY BE A SHORT IN THE WIRING AND THEY WOULD HAVE TO TEAR THE WHOLE THING APART TO FIND IT. ANOTHER CONCERN I HAVE IS I HAVE 70,000 MILES ON MY CAR AND I HAVE HAD TO PUT HEAD GASKETS AND LIFTERS ON THIS CAR. NO ONE CAN BELIEVE THAT HAPPENS WITH SUCH LOW MILEAGE. MY SISTER WORKS WITH A GIRL WHO HAD THE SAME PROBLEM AT ABOUT THE SAME MILEAGE. (SAME YEAR). *TR

NHTSA ODI #10219123

Official recalls

14V400000 · Electrical System:ignition

Jul 3, 2014

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Consequence & remedy

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.

05V054000 · Suspension:rear

Feb 14, 2005

CERTAIN PASSENGER VEHICLES EQUIPPED WITH REAR SUSPENSION KNUCKLE BOLTS THAT ARE NOT TO SPECIFICATION AND COULD FRACTURE UNDER HIGH LOADS THAT CAN OCCUR IN SOME DRIVING CONDITIONS.

Consequence & remedy

Consequence: IF THE BOLT FRACTURE, THE REAR SUSPENSION LINKAGE COULD DETACH FROM THE KNUCKLE AND THE REAR WHEEL WOULD BE ABLE TO TURN INBOARD OR OUTBOARD. SUDDEN CHANGES IN VEHICLE HANDLING COULD OCCUR, PARTICULARLY AT HIGHER SPEEDS, AND THE DRIVER MAY NOT BE ABLE TO CONTROL THE VEHICLE AND A CRASH COULD OCCUR WITHOUT WARNING.

Remedy: DEALERS WILL REPLACE BOTH REAR SUSPENSION KNUCKLE BOLTS FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 9, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.