Engine And Engine Cooling. Review the 73 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

58 crash reports28 fire reports38 injury reports

What owners actually said

377 reports

225,620 miles · Aug 3, 2005

Electrical System

Read full complaint

THERE WAS A RECALL ON THE ELECTRICAL SYSTEM ON MY 94 GRANDAM TOOK IT TO STUART PONTAIC IN ENID,OK TO HAVE THE RECALL FIXED THEY PUT A RELAY ON THE CAR BUT DIDN'T CHANGE THE IGNITION SWITCH ON THE CAR CAUSING THE CARE TO LOOSE POWER WHEN THE CAR WAS DRIVEN IN THE HEAT OF THE DAY CAUSING THE CAR TO LOOSE POWER AND DIE WHEN GOING OVER 40 MPH,CONTACTED PONTAIC AND THEY MADE THE DEALERSHIP REPLACE THE IGNITION SWITCH BUT WOULD NOT REPLACE THE WIRING GOING TO THE IGNITION SWITCH, WHICH IF NOT REPLACED WOULD OF CAUSED THE CAR TO CATCH ON FIRE , ON MY WAY HOME FROM WORK ON 7/30 WHILE GOING 70 MPH THE CAR DIED 9 TIMES,. I PUT THE CAR IN NEUTRAL TO START IT , AND FINALLY GOT THE CAR HOME. *NM

NHTSA ODI #10131473

176,000 miles · Jul 6, 2005

Power Train

DT: WHEN DRIVING OVER A POT HOLE THREE DAYS AGO, THE FRONT AXLE BROKE, RESULTING IN DAMAGE TO THE TIRE AND THE WHEEL. THE VEHICLE HAS NOT BEEN SEEN BY A SERVICE DEALER. THERE WAS NO PROBLEM BEFORE THE AXLE BROKE OFF. THERE WAS NO ACCIDENT, POLICE REPORT AND DAMAGE TO THE VEHICLE HAS NOT YET BEEN ASSESSED.*AK

NHTSA ODI #10127700

150,210 miles · Apr 4, 2005

Electronic Stability ControlSuspension

WHILE DRIVING A LOUD CLICKING NOISE FROM THE FRONT END WAS PRODUCED. DEALER STATED THE CONTROL ARM AND THE STABILIZER BAR BUSHINGS NEEDED TO BE REPLACED. *AK

NHTSA ODI #10117373

74,258 miles · Feb 8, 2005

Engine And Engine CoolingVisibility

Read full complaint

I REPLACED THE HEATER CORE IN MY CAR AND AN UPPER RADIATOR HOSE AND NOW I HAVE PROBLEMS WITH THE ANTIFREEZE LEAKIN OUT FROM BETWEEN THE ENGINE BLOCK AND THE INTAKE MANIFOLD WHICH INDICATES THAT I NEED A NEW INTAKE MANIFOLD GASKET AS WEEL AS VALVE COVER GASKETS DUE TO THE FACT THAT IT IS LEAKIN OUT THERE AS WELL. I SPENT $250 ON REPALCING THE HEATER CORE AND $45 ON THE UPPER RADIATOR HOSE TO BE REPAIRED FROM THE DEALER THAT I BOUGHT THE CAR FROM. I WAS TOLD BY A FRIEND THAT HER GRAND AM WAS RECALLED DUE TO A HEAD GASKET PROBLEM. PLEASE INFORM ME OF A POSSIBLE SOLOUTION.*AK

NHTSA ODI #10110141

Mileage unknown · Oct 12, 2004

Engine And Engine Cooling

WHILE DRIVING,THE VEHICLE STALLED. THE CONSUMER TRIED TO RESTART THE VEHICLE BUT WAS UNABLE TO DO SO. THE CONSUMER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE DRIVER THAT THE HEAD GASKET HAD BLEW AND NEEDED REPLACEMENT. THE DRIVER INFORMED THE MECHANIC. THIS PROBLEM HAS OCCURRED MORE THAN O…

Read full complaint

NHTSA ODI #10096644

145,200 miles · Sep 14, 2004

Engine And Engine Cooling

WAS JUST DRIVING AND IT OVERHEATED, REPLACED WATER PUMP, SENSORS, WIRES, HEATER COIL, THEMORSTAT TWICE, ALL TO NO AVAIL, TOOK IT TO 2 MECHANICS AND THEY COULDNT FIGURE OUT WHAT WAS WRONG WITH IT. CLEANED OUT THE RADITOR WITH A COMPLETE FLUSH AND RUN FINE FOR ABOUT 2 MONTHS, WE ALSO PUT 2 NEW COMPUTERS INTO IT.

NHTSA ODI #10090960

157,000 miles · Aug 6, 2004

Power TrainCrashInjury

I HAVE A 1994 PONTIAC GRAND AM SE.I WAS COMING AROUND A TURN AND THE DRIVERS REAR AXLE SNAPPED CAUSING THE WHEEL TO FALL OFF. THERE WAS NO WARNING. I COULDN'T REGAIN CONTROL OF THE VEHICLE AFTER THE WHEEL CAME OFF AND WRECKED INTO AN EMBANKMENT ROLLING AND, TOTALING THE VEHICLE.*AK

NHTSA ODI #10086291

Mileage unknown · Jun 28, 2004

Electrical SystemFire

WHILE DRIVING 50-55 MPH CONSUMER NOTICED SMOKE COMING OUT THE DRIVER'S AIR BAG. CONSUMER IMMEDIATELY PULLED OVER, TURNED THE ENGINE OFF, AND GOT OUT. WITHIN TWO MINUTES VEHICLE WAS ON FIRE. *AK

NHTSA ODI #10080048

125,000 miles · Jun 15, 2004

SteeringFire

WHILE PULLING IN A PARKING LOT, THE STEERING COLUMN CAUGHT FIRE WITHOUT WARNING. AS A RESULT THE VEHICLE WAS A TOTAL LOSS. NO INJURIES REPORTED. PLEASE PROVIDE ADDITIONAL INFORMATION. *LA

NHTSA ODI #10079272

Mileage unknown · Jun 4, 2004

Engine And Engine CoolingService Brakes, HydraulicSuspension

PROBLEMS WITH BRAKES, EXHAUST, TIRES, SHOCKS, AND SUSPENSION ON 1994 PONTIAC GRAND AM. *MR THE CONSUMER REQUESTED ASSISTANCE WITH THE REPAIRS NEEDED. THE VEHICLE ALSO NEEDED A COMPRESSOR. *SC *JB

NHTSA ODI #10075859

Official recalls

00V287000 · Electrical System:starter Assembly

Oct 2, 2000

VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE ENGINE STARTER FAILS TO ENGAGE AND THE DRIVER HOLD THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, PRODUCING HEAT THAT CAN MELT SWITCH PARTS.

Consequence & remedy

Consequence: A FIRE COULD OCCUR IN THE STEERING COLUMN AND SPREAD TO THE INTERIOR OF THE CAR.

Remedy: DEALERS WILL INSTALL A RELAY KIT AND VERIFY THAT THE VEHICLE WILL START WITH A PROPERLY CHARGED BATTERY IN GOOD OPERATING CONDITION (ADEQUATE RESERVE CAPACITY, OR COLD CRANKING AMPS). THIS CAMPAIGN DOES NOT COVER BATTERY REPLACEMENT OR UNRELATED STARTING SYSTEM OR ELECTRICAL SYSTEM REPAIRS.

94V122000 · Fuel System, Gasoline:storage:tank Assembly

Jul 1, 1994

THESE VEHICLES WERE CONSTRUCTED WITH WELDS IN THE REAR COMPARTMENT PAN ASSEMBLY THAT ARE NOT SUFFICIENT TO COMPLY WITH THE REQUIREMENTS PERTAINING TO FUEL TANK LEAKAGE IN THE EVENT OF A REAR IMPACT COLLISION. THE FUEL TANK ASSEMBLIES DO NOT COMPLY WITH FMVSS NO. 301, "FUEL SYSTEM INTEGRITY."

Consequence & remedy

Consequence: THIS CAN RESULT IN AN INCREASED RISK OF A VEHICLE FIRE IN THE EVENT OF A REAR IMPACT COLLISION.

Remedy: DEALER WILL INSTALL RIVETS ADJACENT TO THE LOCATIONS WHERE THE SUSPECT WELDS ARE LOCATED.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA00007 · Steering Column Fires

Opened Mar 3, 2000 · Closed Feb 7, 2001

Status: closed (inferred from source dates) · Electrical System

There is no summary currently available

PE99063 · Steering Column Fire

Opened Oct 7, 1999 · Closed Mar 3, 2000

Status: closed (inferred from source dates) · Steering

ODI HAS EXPANDED THE SCOPE OF ITS INVESTIGATION OF STEERING COLUMN FIRES TO INCLUDE ALL MODELS BUILT ON THE N-PLATFORM.GM HAS INDICATED IN ITS RESPONSE THAT THE SUBJECT VEHICLES ARE EQUIPPED WITH A ROTARY IGNITION SWITCH THAT HAS BEEN IN USE IN A NUMBER OF VEHICLE MODELS SINCE 1991 ON BOTH THE N AND J-PLATFORMS.HOWEVER, THE 1994-1995 N-PLATFORM IS OVER REPRESENTED ACCOUNTING FOR 83 (81%) OF THE COMBINDED TOTAL OF 102 REPORTS DESPITE BEING ONLY 14.2% OF THE COMBINED POPULATION. OF THE 10 NEW REPORTS RECEIVED SINCE OPENING EA99-063, 7 INCLUDE ALLEGATIONS OF A NO START CONDITION WHEN ATTEMPTING TO ENGAGE THE STARTER.A FIRE IS CLAIMED TO HAVE ENSUED IN THE STEERING COLUMN IMMEDIATELY THERAFTER.GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB) (NO. 433203) JULY 1994 WHIICH ADDRESSED OWNER COMPLAINTS THAT THE IGNITION SWITCH MAY NOT RETURN TO THE RUN POSITION AFTER THE VEHICLE HAS STARTED.THE TSB ADVISES THAT THE IGNITION SWITCH MOUNTING SCREWS MAY BE EXCESSIVELY TORQUED RESULTING IN DISTORTION OF THE SWITCH HOUSING.AN ENGINEERING ANALYSIS IS WARRANTED TO DETERMINE THE ROOT CAUSE(S) AND TO DETERMIN IF A SAFETY DEFECT EXISTS.