IllustrationCONSUMER IS UPSET BECAUSE MANUFACTURER WILL NOT HAVE PARTS AVAILABLE UNTIL MARCH, AND DEALER WILL NOT BE ABLE TO PERFORM NHTSA RECALL 00V287000/MANUFACTURER'S RECALL P00079S REPAIRS CONCERNING ENGINE STARTER. CONSUMER FEELS RECALL IS NOT DONE IN TIMELY MANNER. AK
1994 Pontiac Grand Am
Owner reports · Recalls · Investigations
More warning signs than most Grand Am years
Owner complaints for the 1994 Pontiac Grand Am are substantially higher than the model-year median of 82.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Am years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 27 of 377 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 73 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
58 crash reports28 fire reports38 injury reports
Electrical System complaints
71 reportsINTERMITTENTLY WHILE DRIVING VEHICLE WILL STALL UNEXPECTEDLY WHICH MAY CAUSE A CRASH. OCCUPANT HAS TO PLACE VEHICLE IN "NEUTRAL" POSITION IN ORDER TO RESTART VEHICLE. THERE IS A TSB TO REPROGRAM THE COMPUTER. VEHICLE'S COMPUTER HAVE BEEN REPROGRAMMED 12 TIMES. PROBLEM STILL OCCURRING. *AK *ML
CONSUMER EXPERIENCED A NO START CONDITION. NOTICED SMOKE COMING FROM STEERING COLUMN,AND WITHIN MINUTES, VEHICLE WAS ENGULFED WITH FLAMES FROM STEERING COLUMN TO THE REAR OF VEHICLE, CAUSING TOTAL LOSS OF VEHICLE. *AK
THE VEHICLE CAUGHT FIRE CAUSING DAMAGE TO THE STEERING WHEEL / THE DASHBOARD & THE SUNROOF. *YC
A SHORT IN THE WIRING HARNESS CAUSED A FIRE, BURNING THE HOME AND ANOTHER VEHICLE. THIS VEHICLE WAS TOTALED. MANUFACTURER HAS BEEN NOTIFIED. *AK
THE STARTER IN MY CAR APPARENTLY SHORTED OUT, RESULTING IN A FIRE AND A COMPLETE AND TOTAL LOSS OF MY VEHICLE AND ALL ITS CONTENTS. MY INSURANCE COMPANY IS NOT HELPING SO I AM DOING ALL I CAN TO FIND SOME ASSISTANCE. HAVE THERE BEEN RECALLS FOR THIS PROBLEM? IS THERE ANYTHING ELSE I CAN DO? *AK
WHILE DRIVING AT 70 MPH VEHICLE FILLED UP WITH SMOKE, CAUSING CONSUMER TO PULL OVER TO THE SIDE OF THE ROAD. VEHICLE HAS BEEN IN REPAIR SHOP FOUR TIMES, AND DEALER HAS REPLACES THE WIRING HARNESS. *AK
WHILE DRIVING AT 50 MPH, NOTICED VEHICLE STARTED TO LOSE POWER. ALSO, THE AUTOMATIC LOCKS WILL LOCK ONLY WITH VEHICLE IS PUT INTO MOTION; AND WHEN TRYING TO USE THE SWITCH ON THE DOOR, IT DOESN'T WORK. WHEN PUTTING ON HIGH HIGH BEAMS THEY WILL WORK, BUT WHEN CUTTING THE HIGH BEAM OFF, THE REGULAR LIGHTS WON'T WORK. IT T…
Read full complaint
WHILE DRIVING AT 50 MPH, NOTICED VEHICLE STARTED TO LOSE POWER. ALSO, THE AUTOMATIC LOCKS WILL LOCK ONLY WITH VEHICLE IS PUT INTO MOTION; AND WHEN TRYING TO USE THE SWITCH ON THE DOOR, IT DOESN'T WORK. WHEN PUTTING ON HIGH HIGH BEAMS THEY WILL WORK, BUT WHEN CUTTING THE HIGH BEAM OFF, THE REGULAR LIGHTS WON'T WORK. IT TAKES ALONG TIME FOR THE CONSUMER TO GET THE LIGHTS TO WORK. *AK
WHILE ATTEMPTING TO START ENGINE, SMOKE CAME FROM THE IGNITION SWITCH. A SMALL FIRE OCCURED UNDER THE CENTER PARK PLUG WIRE.
INTERMITTENTLY WHILE DRIVING THE VEHICLE STALLS WITHOUT PRIOR WARNING WHICH ALMOST CAUSED AN ACCIDENT. THE DEFECTIVE ENGINE WIRES WERE "TOO SHORT", CAUSING THE VEHICLE TO STALL. *AK DEALER STATED THAT THE WIRES IN THE WIRING HARNESS NEAR THE TRANSMISSION WERE STRETCHED TIGHTLY AND HAD CHAFED AND WORN OFF THE INSULATION, CAU…
Read full complaint
INTERMITTENTLY WHILE DRIVING THE VEHICLE STALLS WITHOUT PRIOR WARNING WHICH ALMOST CAUSED AN ACCIDENT. THE DEFECTIVE ENGINE WIRES WERE "TOO SHORT", CAUSING THE VEHICLE TO STALL. *AK DEALER STATED THAT THE WIRES IN THE WIRING HARNESS NEAR THE TRANSMISSION WERE STRETCHED TIGHTLY AND HAD CHAFED AND WORN OFF THE INSULATION, CAUSING A SHORT WHICH IN TURN WOULD CAUSE THE VEHICLE TO STALL. *SLC
Official recalls
200V287000 · Electrical System:starter Assembly
Oct 2, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE ENGINE STARTER FAILS TO ENGAGE AND THE DRIVER HOLD THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, PRODUCING HEAT THAT CAN MELT SWITCH PARTS.
Consequence & remedy
Consequence: A FIRE COULD OCCUR IN THE STEERING COLUMN AND SPREAD TO THE INTERIOR OF THE CAR.
Remedy: DEALERS WILL INSTALL A RELAY KIT AND VERIFY THAT THE VEHICLE WILL START WITH A PROPERLY CHARGED BATTERY IN GOOD OPERATING CONDITION (ADEQUATE RESERVE CAPACITY, OR COLD CRANKING AMPS). THIS CAMPAIGN DOES NOT COVER BATTERY REPLACEMENT OR UNRELATED STARTING SYSTEM OR ELECTRICAL SYSTEM REPAIRS.
94V122000 · Fuel System, Gasoline:storage:tank Assembly
Jul 1, 1994
THESE VEHICLES WERE CONSTRUCTED WITH WELDS IN THE REAR COMPARTMENT PAN ASSEMBLY THAT ARE NOT SUFFICIENT TO COMPLY WITH THE REQUIREMENTS PERTAINING TO FUEL TANK LEAKAGE IN THE EVENT OF A REAR IMPACT COLLISION. THE FUEL TANK ASSEMBLIES DO NOT COMPLY WITH FMVSS NO. 301, "FUEL SYSTEM INTEGRITY."
Consequence & remedy
Consequence: THIS CAN RESULT IN AN INCREASED RISK OF A VEHICLE FIRE IN THE EVENT OF A REAR IMPACT COLLISION.
Remedy: DEALER WILL INSTALL RIVETS ADJACENT TO THE LOCATIONS WHERE THE SUSPECT WELDS ARE LOCATED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA00007 · Steering Column Fires
Opened Mar 3, 2000 · Closed Feb 7, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE99063 · Steering Column Fire
Opened Oct 7, 1999 · Closed Mar 3, 2000
Status: closed (inferred from source dates) · Steering
ODI HAS EXPANDED THE SCOPE OF ITS INVESTIGATION OF STEERING COLUMN FIRES TO INCLUDE ALL MODELS BUILT ON THE N-PLATFORM.GM HAS INDICATED IN ITS RESPONSE THAT THE SUBJECT VEHICLES ARE EQUIPPED WITH A ROTARY IGNITION SWITCH THAT HAS BEEN IN USE IN A NUMBER OF VEHICLE MODELS SINCE 1991 ON BOTH THE N AND J-PLATFORMS.HOWEVER, THE 1994-1995 N-PLATFORM IS OVER REPRESENTED ACCOUNTING FOR 83 (81%) OF THE COMBINDED TOTAL OF 102 REPORTS DESPITE BEING ONLY 14.2% OF THE COMBINED POPULATION. OF THE 10 NEW REPORTS RECEIVED SINCE OPENING EA99-063, 7 INCLUDE ALLEGATIONS OF A NO START CONDITION WHEN ATTEMPTING TO ENGAGE THE STARTER.A FIRE IS CLAIMED TO HAVE ENSUED IN THE STEERING COLUMN IMMEDIATELY THERAFTER.GM ISSUED A TECHNICAL SERVICE BULLETIN (TSB) (NO. 433203) JULY 1994 WHIICH ADDRESSED OWNER COMPLAINTS THAT THE IGNITION SWITCH MAY NOT RETURN TO THE RUN POSITION AFTER THE VEHICLE HAS STARTED.THE TSB ADVISES THAT THE IGNITION SWITCH MOUNTING SCREWS MAY BE EXCESSIVELY TORQUED RESULTING IN DISTORTION OF THE SWITCH HOUSING.AN ENGINEERING ANALYSIS IS WARRANTED TO DETERMINE THE ROOT CAUSE(S) AND TO DETERMIN IF A SAFETY DEFECT EXISTS.