Steering. Review the 295 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 190 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 178 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

25 crash reports20 fire reports17 injury reports

What owners actually said

712 reports

168,750 miles · Jan 4, 2015

Steering

I WAS DRIVING HOME FROM WORK ON THE HIGHWAY AND WENT TO CHANGE LANES AND MY VEHICLE WAS DIFFICULT TO STEER. I HAD TO PULL OVER AND HAVE MY CAR HAULED HOME. I HAD A MECHANIC LOOK AT IT AND HE INFORMED ME ABOUT A RECALL FOR THE ELECTRONIC POWER STEERING ASSIST. I CONTACTED DEALERSHIP WHERE I PURCHASED IT AND THEY SAID IT WASN'T PA…

Read full complaint

NHTSA ODI #10670000

138,000 miles · Jan 1, 2015

Steering

I WAS PULLING INTO A PARKING SPOT AND MY POWER STEERING WENT OUT. RESTARTED THE CAR SEEMED TO RESOLVE IT FOR A DAY OR TWO. NOW IT HAPPENS SEVERAL TIMES. WHEN CONTACTED DEALER ABOUT A RECALL, I WAS TOLD MINE WAS NOT COVERED UNDER RECALL AND THEY COULD FIX IT FOR $800. WHEN IT OR IF IT BECOMES A RECALL I COULD BE REIMBURSED. AT TH…

Read full complaint

NHTSA ODI #10669518

26,000 miles · Jan 1, 2015

Electrical SystemExterior Lighting

Read full complaint

HEAD LIGHTS KEEP GOING OUT...THE WIRES CONNECTED WITH THE LOW BEAM LIGHTS ARE BURNT AND CORRODED. I HAVE REPLACE THESE PARTS 20 TIMES SINCE 2009. THIS TIME ON JANUARY 1, 2015 THE WIRES AND CONNECTORS ARE TO BURNT TO REPAIR AND THE DEALER SHIP SAID I WILL HAVE TO BUY THE WHOLE HARNESS KIT ASSEMBLY INSTEAD OF JUST THE WIRES. WHY SHOULD I, THIS PROBLEMS IS FAR AND WIDE ON THE INTERNET WITH THE PONTIAC G6. I TRAVEL WITH MY JOB AND I HAVE EXPERIENCED MULTIPLE TIMES BOTH HEADLIGHTS GOING OUT ON ME AND I HAD TO USE THE HIGH BEAM JUST TO GET HOME. PLEASE LET GM KNOW AND ISSUE SOME KIND OF RECALL BEFORE I DIE ON THE HIGHWAY DUE TO THESE FAULTY HEADLIGHT WIRES. *JS

NHTSA ODI #10669450

94,000 miles · Dec 31, 2014

Electrical System

THE DRIVERS SIDE, LOW BEAM HEADLIGHT HAS BEEN REPLACED SEVERAL TIMES. THE WIRING HARNESS MELTS! THIS SEEMS TO BE A COMMON COMPLAINT WITH G6 OWNERS. *JS

NHTSA ODI #10669351

Mileage unknown · Dec 27, 2014

Exterior Lighting

DRIVER SIDE HIGHLIGHT NOT WORKING. FURTHER INSPECTION SHOWS THAT THE HEADLIGHT WIRE IS CORRODED & BURNT. THIS IS A COMMON ISSUE WITH THIS CAR & SEVERAL OTHERS, YET GENERAL MOTORS REFUSES TO ISSUE A RECALL WHICH CAN LEAD TO A DANGEROUS SITUATION. *TR

NHTSA ODI #10668499

88,000 miles · Dec 23, 2014

Engine And Engine CoolingTires

Read full complaint

TL* THE CONTACT OWNS A 2009 PONTIAC G6. THE CONTACT STATED THAT AFTER THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL), THE COOLING FANS ACTIVATED INDEPENDENTLY CAUSING THE AIR CONDITIONER TO FAIL. IN ADDITION, THE TIRE PRESSURE WARNING LIGHT ILLUMINATED, BUT THE TIRES DID NOT NEED AIR. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TEMPERATURE GAUGE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE PERSISTED. THE FAILURE MILEAGE WAS 88,000. THE VIN WAS UNAVAILABLE.

NHTSA ODI #10667885

83,350 miles · Dec 22, 2014

Steering

Read full complaint

MULTIPLE INSTANCES OF LOSS OF POWER STEERING. IN ALL CASES VEHICLE WAS DRIVEN OUT OF THE TRAFFIC LANES, PARKED AND ENGINE SHUT OFF. POWER STEERING WAS EVENTUALLY RESTORED ON RESTART. THERE WAS NO OBVIOUS PATTERN TO THE LOSS OF POWER STEERING. VEHICLE WAS TAKEN TO AUTHORIZED GM SERVICE CENTER FOR REPAIR. DIAGNOSTICS TROUBLE CODE C0545 STEERING WHEEL TORQUE INPUT RESULTED IN REPLACEMENT OF A FAULTY STEERING COLUMN, REPROGRAMMING AND SETUP AT A COST OF $741.00. SIMILAR POWER STEERING ISSUES ARE MENTIONED IN NHTSA CAMPAIGN ID NUMBER 14V153000 BUT THE VIN OF MY VEHICLE IS NOT INCLUDED IN THAT RECALL. *TR

NHTSA ODI #10667598

97,000 miles · Dec 22, 2014

Steering

Read full complaint

FAULTY STEERING TORQUE SENSOR. RECALL ON YEAR,MAKE,MODEL BUT DOESNT INCLUDE MY VIN NHTSA RECALL # 14V-153, GM BULLETIN 14116. WHILE MY WIFE WAS DRIVING THE CAR IT MADE AN ALARM NOISE, THEN THE STEERING BECAME ALMOST IMPOSSIBLE TO TURN. SHE WAS ABLE TO BRING MY CAR TO A STOP ON THE SHOULDER WITHOUT HITTING ANYTHING. AFTER STARING AND STOPPING THE CAR MULTIPLE TIMES, AROUND 10 MINUTES LATER, THE STEERING RETURNED. I CONTACTED GM AND THEY OPENED A CASE # [XXX]. THEY SAID TO BRING TO THE DEALER AND HAVE IT DIAGNOSED. AFTER PAYING $93 THEY SAID IT WAS THE STEERING TORQUE SENSOR, WHICH WAS A RECALLED ITEM ON A 2009 G6, BUT NOT MY PARTICULAR CAR. THE DEALER WANTED OVER $750 TO FIX THE PROBLEM. I DISPUTED THIS TO THE DEALER AND THEY CONTACTED GM WHO AGREED TO LOWER THE COST TO $250 WHICH I DISPUTED. NOW THE CAR HAS NO POWER STEERING AT ALL. AFTER TRYING TO DISCUSS THIS FURTHER WITH GM DIRECTLY, THE SENIOR ADVISER TOLD ME MY CASE WAS CLOSED. I WAS TOLD I AGREED TO THE COST ASSISTANCE WHICH I DIDN'T. I AM WAITING TO HEAR BACK FROM A HIGHER LEVEL GM ADVISER TO SOLVE THIS PROBLEM. AFTER READING THE NHTSA COMPLAINTS ABOUT OTHER 2009 G6 NON RECALLED STEERING PROBLEMS WHICH ARE EXACTLY THE SAME PROBLEM AS THE RECALLED ONES I FEEL THIS PROBLEM SHOULD BE RECALLED AND FIXED BEFORE SOMEONE GET HURT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI #10667559

76,004 miles · Dec 21, 2014

Exterior Lighting

LEFT LOW BEAM NOT WORKING. REPLACED WITH NEW BULB TWICE IN A MONTH. BACK IN 2013, A MONTH AFTER PURCHASING USED VEHICLE, I HAD THE SAME PROBLEM. I REPLACES THE LEFT LOW BEAM LIGHT THREE TIMES IN ONE MONTH AND THEN TOOK TO DEALER WHO SAD THE HARNESS HAD MELTED. THIS NEEDS TO BE RECALLED. THIS IS SERIOUSLY DANGEROUS! *TR

NHTSA ODI #10667522

81,000 miles · Dec 17, 2014

Electrical SystemExterior Lighting

Read full complaint

2009 PONTIAC G6 PASSENGER SIDE HEADLIGHT WOULD INTERMITTENTLY GO OFF AND FINALLY STAYED OFF. AFTER REMOVING THE HEADLIGHT ASSEMBLY, I FOUND A MELTED CONNECT TO THE LIGHT BULB ITSELF. I FOUND A REPLACEMENT CONNECTOR AT NAPA AUTO PARTS AND REPLACED IT. IT WORKED FOR 3 WEEKS AND WENT OUT AGAIN. UPON OPENING UP THE LIGHT, I FOUND THE NEW CONNECTOR MELTED AGAIN. THERE IS A WIRING PROBLEM CAUSING THIS CONNECTOR TO OVERHEAT. SAFETY CONCERN IS IF BOTH FAIL OVER TIME, THE DRIVER WILL NOT HAVE ANY HEADLIGHTS FOR NIGHTTIME DRIVING. ALSO, THE HEADLIGHTS ARE PART OF THE DAYTIME DRIVING LIGHTS. *TR

NHTSA ODI #10664816

Official recalls

14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control

May 14, 2014

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Consequence & remedy

Consequence: Any of the above failure conditions increases the risk of a crash.

Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

Additional source detail variants (5)

Electronic Stability Control (esc)