IllustrationPOWER STEERING PROBLEMS WITH 2006 PONTAC G6. IT DIFFICULT FOR A MECHANIC TO DETECT BECAUSE ONCE THE CAR IS TURNED OFF THE STEERING RESET. I WAS DRIVING DOWN THE HIGHWAY AN MY STEERING LOCKED. I COULD HAVE CAUSED A MAJOR ACCIDENT. I FREAKED OUT. *TR
2006 Pontiac G6
Owner reports · Recalls · Investigations
More warning signs than most G6 years
Owner complaints for the 2006 Pontiac G6 are substantially higher than the model-year median of 679.
About this comparison →How this year compares
Owner complaints by model year
Compare all G6 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1550–25K
26525–50K
36450–75K
27575–100K
346100–150K
179150K+
1,584 reports with mileage · 326 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 1,220 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 245 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 198 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
90 crash reports11 fire reports48 injury reports
Steering complaints
1,220 reportsI HAVE A 2006 PONTIAC G6 AND THE POWERSTEERING STOPS WORKING SOMETIMES. IT JUST LOCKS UP AND YOU CANT MOVE IT AT ALL. THIS USUALLY HAPPENS AT LOWER SPEEDS BUT IF IT HAPPENED ON THE FREEWAY OR SOMETHING IT WOULD NOT BE SO EASY TO CONTROL. YOU CAN NOT MOVE THE WHEEL AT ALL WHEN THIS HAPPENS. THIS NEEDS TO BE RECALLED, I CAN NOT B…
Read full complaint
I HAVE A 2006 PONTIAC G6 AND THE POWERSTEERING STOPS WORKING SOMETIMES. IT JUST LOCKS UP AND YOU CANT MOVE IT AT ALL. THIS USUALLY HAPPENS AT LOWER SPEEDS BUT IF IT HAPPENED ON THE FREEWAY OR SOMETHING IT WOULD NOT BE SO EASY TO CONTROL. YOU CAN NOT MOVE THE WHEEL AT ALL WHEN THIS HAPPENS. THIS NEEDS TO BE RECALLED, I CAN NOT BELIEVE THAT GM HAS NOT GOTTEN SUED OVER THIS. I HAVE SEEN HUNDREDS OF PEOPLE ON FORUMS THAT HAVE HAD THE SAME PROBLEM AS ME. HOW MANY PEOPLE ARE GOING TO HAVE TO DIE FOR A RECALL TO GO INTO EFFECT. *TR
MY PONTIAC G6 POWER STEERING SIGNAL WAS COMING OWN FOR REPAIR. I TOOK IT TO THE DEALERSHIP FOR REPAIR AND FOUND THAT I NEEDED A NEW MOTOR PUMP. THE MOTOR GOT REPLACED, BUT THAT SAME NIGHT I GOT THE SAME MESSAGE ON MY DASH ABOUT POWER STEERING. I TOOK MY CAR BACK TO DEALER FOR ANOTHER LOOK AT THE CAR AND THEY FOUND THAT MY STE…
Read full complaint
MY PONTIAC G6 POWER STEERING SIGNAL WAS COMING OWN FOR REPAIR. I TOOK IT TO THE DEALERSHIP FOR REPAIR AND FOUND THAT I NEEDED A NEW MOTOR PUMP. THE MOTOR GOT REPLACED, BUT THAT SAME NIGHT I GOT THE SAME MESSAGE ON MY DASH ABOUT POWER STEERING. I TOOK MY CAR BACK TO DEALER FOR ANOTHER LOOK AT THE CAR AND THEY FOUND THAT MY STEERING COLUMN NEEDS REPAIR. I COULDN'T BELIEVE THAT MY STEERING WHEEL NEEDS REPAIR CONSIDERING MY CAR IS ONLY 3 YEARS OLD. MY WARRANTY DID NOT COVER THIS SPECIFIC PROBLEM, SO I CALLED GM TO REPORT THE PROBLEM AND THEY TOLD ME THEY COULDN'T DO ANYTHING. THIS IS A FACTORY PROBLEM DUE TO THE FACT THAT THE CAR HAS ONLY 47,000 MILES AND THAT ITS NOT COMMON FOR THESE TYPE OF PROBLEMS EARLY IN THE MILEAGE. MY CAR IS NOT DRIVABLE DUE TO ACCIDENT CONCERNS, THIS COULD REALLY CAUSE DEATH BECAUSE IT POPS ON OUT OF NOWHERE AND LOCKS YOUR STEERING WHEEL. IMAGINE BEING ON THE HIGHWAY AND EVERYONE IS GOING 50-60 MPH AND YOU LOOSE CONTROL OF YOUR CAR AL OF A SUDDEN. THIS REALLY NEEDS TO BE RECALLED, AND I SEE A LOT OF PEOPLE HAS HAD THIS SAME PROBLEM EARLY IN THERE MILEAGE ON PONTIAC G6 MODELS (2006). THIS HAS TO BE TAKEN SERIOUS OR SOMEONE COULD LOOSE THERE LIFE AND THINGS COULD GET REAL BAD FOR GM. *TR
LIKE A TON OF OTHER COMPLAINTS I HAVE BEEN EXPERIENCING INTERMITTENT POWER STEERING FAILURE WITH MY 2006 PONTIAC G6 GT AT 50-53K MILES. IT USUALLY OCCURS WHEN BACKING OUT OF THE MY GARAGE OR AFTER MAKING A FEW TURNS. POWER STEERING IS DISPLAYED ON THE COMPUTER AND ASSISTED POWER STEERING GOES COMPLETELY OUT. SIMILAR TO OTHER I W…
Read full complaint
LIKE A TON OF OTHER COMPLAINTS I HAVE BEEN EXPERIENCING INTERMITTENT POWER STEERING FAILURE WITH MY 2006 PONTIAC G6 GT AT 50-53K MILES. IT USUALLY OCCURS WHEN BACKING OUT OF THE MY GARAGE OR AFTER MAKING A FEW TURNS. POWER STEERING IS DISPLAYED ON THE COMPUTER AND ASSISTED POWER STEERING GOES COMPLETELY OUT. SIMILAR TO OTHER I WOULD SHUT THE CAR OFF FOR A 10-15 MINUTES AND IT WOULD GO AWAY. WITHIN THE LAST WEEK THE POWER STEERING IS GOING OUT DAILY AND NOW IS OCCASIONALLY HAPPENING WHILE DRIVING. I HAVE TALKED TO A FEW MECHANICS AND THEY HAVE TOLD ME THEY HAVE SEEN THIS MANY TIMES ON THE 2005 AND 2006 PONTIAC G6'S BECAUSE THIS WAS PONTIAC'S FIRST ATTEMPT AT ELECTRONIC POWER STEERING VS. PUMP. *TR
STEERING 50000 MILES BALL JOINTS ARE SHOT ARE YOU KIDDING NEVER HEARD OF THIS MAYBE 100000 PLUS MILES ON ANY CAR.NEED WATCH DOGS ON THESE FOREIGN PARTS THESE FRONT STEERING PARTS MADE IN PIILPPLIES???? WE PUT ON THESE GM CARS BUY AMERICAN BUY HYUNDAI 10YR 100000 MILES WARRANTY IM TRADING MINE IN MIGHT GET CLUNKER PRICE THIS LOS…
Read full complaint
STEERING 50000 MILES BALL JOINTS ARE SHOT ARE YOU KIDDING NEVER HEARD OF THIS MAYBE 100000 PLUS MILES ON ANY CAR.NEED WATCH DOGS ON THESE FOREIGN PARTS THESE FRONT STEERING PARTS MADE IN PIILPPLIES???? WE PUT ON THESE GM CARS BUY AMERICAN BUY HYUNDAI 10YR 100000 MILES WARRANTY IM TRADING MINE IN MIGHT GET CLUNKER PRICE THIS LOST WILL BE CHEAPER IN LONG RUN THAN PAYING OUT OF MY POCKET TO KEEP THIS PONTIAC G6 SAFE. ALL THESE COMPLAINTS ON STEERING PROBLEMS NO ONE CARES??? *TR
I PURCHASED MY 2006 PONTIAC G6 IN JULY OF 2006. WHEN I RECEIVED IT HAD 300 MILES ON IT AND HAVE LOVED IT EVER SINCE. I WOULD SAY I NOTICED A SLIGHT POPPING NOISE AND I FELT IT AS WELL WHEN I MAKE TURNS. SHORTLY AFTER THAT MY BRAKES BEGAN TO SPUTTER AND CAUSE MY FRONT END TO SHAKE WHEN I APPLIED MY BRAKES EVERY SO OFTEN. FOR ABO…
Read full complaint
I PURCHASED MY 2006 PONTIAC G6 IN JULY OF 2006. WHEN I RECEIVED IT HAD 300 MILES ON IT AND HAVE LOVED IT EVER SINCE. I WOULD SAY I NOTICED A SLIGHT POPPING NOISE AND I FELT IT AS WELL WHEN I MAKE TURNS. SHORTLY AFTER THAT MY BRAKES BEGAN TO SPUTTER AND CAUSE MY FRONT END TO SHAKE WHEN I APPLIED MY BRAKES EVERY SO OFTEN. FOR ABOUT A YEAR NOW I HAVE NOTICED THAT THEY SHAKE EVERY SINGLE TIME I APPLY MY BRAKES AND IT GETS WORSE AND WORSE EACH DAY. ONE LAST ITEM OF CONCERN IS REGARDING THE STEERING OF MY CAR ON ROADS AND HIGHWAYS/ FREEWAYS. MY CAR IS UNCONTROLLABLE WHEN DRIVING CAUSING IT TO SHIFT TO THE LEFT AND RIGHT QUICKLY MAKING IT HARD TO KEEP ON THE ROAD WHICH IS HAZARDOUS TO MY SAFETY AND TO THE SAFETY OF MY PASSENGERS. I HAVE READ UP ON THESE ISSUES AND IT CAME TO MY ATTENTION THAT NUMEROUS OWNERS OF THIS VEHICLE HAVE HAD THE EXACT SAME PROBLEMS SO I KNOW THAT IT HAS NOTHING TO DO WITH THE WAY I DRIVE MY CAR. I AM SATISFIED WITH MY CAR OTHERWISE, BUT AM EXTREMELY DISAPPOINTED IN THE ISSUES I AM FACING TODAY ON A CAR THAT IS ONLY THREE YEARS OLD WITH 33,000 MILES ON IT. *TR
2006 PONTIAC G6 I JUST STARTED NOTICING THAT MY CAR AT LOW SPEEDS MADE A CLUNKING NOISE. AND IT IS DRIVING ME CRAZY ITS NOT SO BAD AT HIGHER SPEEDS BUT TODAY WHEN I WAS BACKING UP OUT OF MY DRIVEWAY MY STEERING LOCKED UP I HAD TO SHUT IT OFF AND RESTART THE CAR. I AM TRULY AFRAID TO DRIVE THIS CAR NOW. *TR
TL*THE CONTACT OWNS A 2006 PONTIAC G6. WHILE DRIVING IN REVERSE AT A LOW SPEED, THE POWER STEERING LIGHT ILLUMINATED AND THE POWER STEERING COMPLETELY FAILED. THE CONTACT TURNED OFF AND RESTARTED THE VEHICLE TO ALLOW IT TO RESET ITSELF. THE FAILURE OCCURRED AT LEAST THREE TIMES. THE CONTACT WILL SCHEDULE AN APPOINTMENT WITH …
Read full complaint
TL*THE CONTACT OWNS A 2006 PONTIAC G6. WHILE DRIVING IN REVERSE AT A LOW SPEED, THE POWER STEERING LIGHT ILLUMINATED AND THE POWER STEERING COMPLETELY FAILED. THE CONTACT TURNED OFF AND RESTARTED THE VEHICLE TO ALLOW IT TO RESET ITSELF. THE FAILURE OCCURRED AT LEAST THREE TIMES. THE CONTACT WILL SCHEDULE AN APPOINTMENT WITH THE DEALER FOR FURTHER INSPECTION. THE FAILURE MILEAGE WAS 42,000.
TL*THE CONTACT OWNS A 2006 PONTIAC G6. WHILE DRIVING APPROXIMATELY 5 MPH AND PROCEEDING TO MAKE A LEFT TURN, THE STEERING WHEEL SHOOK AND JERKED. SUDDENLY, THE POWER STEERING FAILED. THE DRIVER HAD TO EXERT GREATER EFFORT TO TURN THE STEERING WHEEL. THE DRIVER PULLED OVER TO THE SIDE OF THE ROAD AND TURNED OFF THE ENGINE. W…
Read full complaint
TL*THE CONTACT OWNS A 2006 PONTIAC G6. WHILE DRIVING APPROXIMATELY 5 MPH AND PROCEEDING TO MAKE A LEFT TURN, THE STEERING WHEEL SHOOK AND JERKED. SUDDENLY, THE POWER STEERING FAILED. THE DRIVER HAD TO EXERT GREATER EFFORT TO TURN THE STEERING WHEEL. THE DRIVER PULLED OVER TO THE SIDE OF THE ROAD AND TURNED OFF THE ENGINE. WHEN THE VEHICLE WAS RESTARTED, THE STEERING RETURNED TO NORMAL. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION AND THEY STATED THAT THE STEERING CRIMP AT THE TORQUE FAILED. THE VEHICLE WAS NOT REPAIRED. THE COST FOR REPAIR WAS ESTIMATED AT $1,450. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 50,200 AND CURRENT MILEAGE WAS 50,300.
STEERING WHEEL STARTS JERKING WHILE SITTING AT A STOP LIGHT AND STEERING WHEEL WAS SHAKING WHILE DRIVING SO BAD THAT I THOUGHT I HAD A FLAT TIRE. I HAVE NOT HAD AN ACCIDENT YET AND I HOPE THAT I DON'T, BUT I DON'T HAVE THE FUNDS TO TAKE THE CAR TO A MECHANIC. THIS ALL HAPPENED ON THE FIRST DAY OF MY POWER STEERING PROBLEMS, IT A…
Read full complaint
STEERING WHEEL STARTS JERKING WHILE SITTING AT A STOP LIGHT AND STEERING WHEEL WAS SHAKING WHILE DRIVING SO BAD THAT I THOUGHT I HAD A FLAT TIRE. I HAVE NOT HAD AN ACCIDENT YET AND I HOPE THAT I DON'T, BUT I DON'T HAVE THE FUNDS TO TAKE THE CAR TO A MECHANIC. THIS ALL HAPPENED ON THE FIRST DAY OF MY POWER STEERING PROBLEMS, IT ALSO READ POWER STEERING ACROSS MY RADIO THAT'S HOW I KNOW ITS MY POWER STEERING. AND AS I LOOK INTO THIS PROBLEM I SEE THAT MANY PEOPLE ARE HAVING THE SAME SAFETY PROBLEM. *TR
Official recalls
615V064000 · Steering:electric Power Assist System
Feb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
14V224000 · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
Apr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence & remedy
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Power Train:automatic Transmission
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
09V036000 · Exterior Lighting:brake Lights
Jan 30, 2009
GM IS RECALLING 8,012 MY 2005-2006 PONTIAC G6 VEHICLES. THE BRAKE LAMPS MAY NOT OPERATE PROPERLY BECAUSE OF CORROSION IN A WIRING CONNECTOR. CORROSION IN THE CONNECTOR COULD CAUSE THE BRAKE LAMPS TO ILLUMINATE WHEN THE BRAKE PEDAL HAS NOT BEEN DEPRESSED, OR THE LAMPS MAY NOT ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED. IN ADDITION, THE CRUISE CONTROL MAY NOT ENGAGE, AND GREATER BRAKE PEDAL FORCE MAY BE REQUIRED TO SHIFT THE VEHICLE OUT OF PARK.
Consequence & remedy
Consequence: BRAKE LAMPS THAT ARE NOT OPERATING PROPERLY MAY NOT WARN A DRIVER IN A FOLLOWING VEHICLE OF THE BRAKING STATUS AND COULD LEAD TO A CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL APPLY A DIELECTRIC LUBRICANT TO THE CONNECTOR TO PREVENT CORROSION. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 17, 2009. OWNERS MAY CONTACT PONTIAC AT 1- 800-620-7668 OR OWNER CENTER AT WWW.GMOWNERCENTER.COM.
06V417000 · Air Bags:frontal
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA13005 · Brake Light Switch/sensor Malfunction
Opened Jun 6, 2013 · Closed Jul 1, 2014
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights
On May 14, 2014 General Motors (GM) announced a recall action (14V-252) involving model year (MY) 2004-12 Chevrolet Malibu, MY 2004-07 Malibu Maxx, MY 2005-10 Pontiac G6 and MY 2007-10 Saturn Aura vehicles.An increased resistance can develop in the Body Control Module connection systems and result in voltage fluctuations in the Brake Apply Sensor (BAS, or brake light switch) circuit that can cause the brake lamps to malfunction.As a result, and according to GM, the brake lamps may illuminate when pedal application is not being applied or may not illuminate when pedal force is applied.Additionally, the cruise control may not engage or if it is engaged it may require increased pedal travel to disengage.Pedal application may not be required to move the shift lever out of PARK or additional travel may be required to move the shift lever out of PARK. Traction control, electronic stability control (ESC) and panic brake assist features may also become disabled. These failure conditions may increase the risk of a crash.The Office of Defects Investigation (ODI) opened Engineering Analysis EA13-005 on June 6, 2013 to further investigate complaints alleging that the brake lights did not operate properly on MY 2005-08 Pontiac G6 vehicles.The BAS in these vehicles produces a single analog voltage output proportional to the brake pedal's position.The BAS signal is used by various systems to determine both pedal position and rate of displacement, so a failure or inaccuracy of the signal may affect multiple systems.ODI also received similar complaints on MY 2009 Pontiac G6, MY 2004-11 Chevrolet Malibu and MY 2007-09 Saturn Aura vehicles that use the same BAS.All of these above models were included in the subject vehicle population of ODI's Information Request (IR) letter to GM.Prior to the recall announcement date, ODI received 855 reports of brake light malfunction resulting in one or several of the failure conditions.Eight (8) of the reports alleged crashes, with 1 resulting in an injury. Of these crash allegations, 2 were roll-away incidents, in which the shift interlock was moved out of PARK without pedal application and the vehicle rolled into another object.Three (3) crashes involved rear-end hits, which were believed to be due to brake light reversal.ESC/Traction Control failures were the alleged cause of 2 incidents, which resulted in unresponsive brake application and in 1 case caused the vehicle to leave the roadway.One (1) crash allegation was not counted as the circumstances of the crash were not related to any of the failure modes.ODI notes that it is difficult to determine the actual cause of incidents where brake light reversal or ESC/Traction Control failures were the alleged cause.In response to ODI's IR, GM submitted 2,268 unique reports that related to brake lamp malfunction. Combined with the data submitted during Recall Query 13-001, a total of 4,664 unique complaints were submitted.Twelve (12) of the GM reports alleged a crash, with 2 reporting minor injuries and 4 alleging property damage.Of the 12 reports, 3 involved brake light reversal allegations, 4 involved roll-away incidents and 2 involved ESC/Traction Control malfunctions. ODI did not include three (3) reports that involved allegations inconsistent with the alleged defect. This investigation is closed on the basis of GM's announcement of safety recall 14V-252.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Additional source detail variants (3)
Exterior Lighting:brake Lights
On May 14, 2014 General Motors (GM) announced a recall action (14V-252) involving model year (MY) 2004-12 Chevrolet Malibu, MY 2004-07 Malibu Maxx, MY 2005-10 Pontiac G6 and MY 2007-10 Saturn Aura vehicles.An increased resistance can develop in the Body Control Module connection systems and result in voltage fluctuations in the Brake Apply Sensor (BAS, or brake light switch) circuit that can cause the brake lamps to malfunction.As a result, and according to GM, the brake lamps may illuminate when pedal application is not being applied or may not illuminate when pedal force is applied.Additionally, the cruise control may not engage or if it is engaged it may require increased pedal travel to disengage.Pedal application may not be required to move the shift lever out of PARK or additional travel may be required to move the shift lever out of PARK. Traction control, electronic stability control (ESC) and panic brake assist features may also become disabled. These failure conditions may increase the risk of a crash.The Office of Defects Investigation (ODI) opened Engineering Analysis EA13-005 on June 6, 2013 to further investigate complaints alleging that the brake lights did not operate properly on MY 2005-08 Pontiac G6 vehicles.The BAS in these vehicles produces a single analog voltage output proportional to the brake pedal's position.The BAS signal is used by various systems to determine both pedal position and rate of displacement, so a failure or inaccuracy of the signal may affect multiple systems.ODI also received similar complaints on MY 2009 Pontiac G6, MY 2004-11 Chevrolet Malibu and MY 2007-09 Saturn Aura vehicles that use the same BAS.All of these above models were included in the subject vehicle population of ODI's Information Request (IR) letter to GM.Prior to the recall announcement date, ODI received 855 reports of brake light malfunction resulting in one or several of the failure conditions.Eight (8) of the reports alleged crashes, with 1 resulting in an injury. Of these crash allegations, 2 were roll-away incidents, in which the shift interlock was moved out of PARK without pedal application and the vehicle rolled into another object.Three (3) crashes involved rear-end hits, which were believed to be due to brake light reversal.ESC/Traction Control failures were the alleged cause of 2 incidents, which resulted in unresponsive brake application and in 1 case caused the vehicle to leave the roadway.One (1) crash allegation was not counted as the circumstances of the crash were not related to any of the failure modes.ODI notes that it is difficult to determine the actual cause of incidents where brake light reversal or ESC/Traction Control failures were the alleged cause.In response to ODI's IR, GM submitted 2,268 unique reports that related to brake lamp malfunction. Combined with the data submitted during Recall Query 13-001, a total of 4,664 unique complaints were submitted.Twelve (12) of the GM reports alleged a crash, with 2 reporting minor injuries and 4 alleging property damage.Of the 12 reports, 3 involved brake light reversal allegations, 4 involved roll-away incidents and 2 involved ESC/Traction Control malfunctions. ODI did not include three (3) reports that involved allegations inconsistent with the alleged defect. This investigation is closed on the basis of GM's announcement of safety recall 14V-252.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Exterior Lighting
On May 14, 2014 General Motors (GM) announced a recall action (14V-252) involving model year (MY) 2004-12 Chevrolet Malibu, MY 2004-07 Malibu Maxx, MY 2005-10 Pontiac G6 and MY 2007-10 Saturn Aura vehicles.An increased resistance can develop in the Body Control Module connection systems and result in voltage fluctuations in the Brake Apply Sensor (BAS, or brake light switch) circuit that can cause the brake lamps to malfunction.As a result, and according to GM, the brake lamps may illuminate when pedal application is not being applied or may not illuminate when pedal force is applied.Additionally, the cruise control may not engage or if it is engaged it may require increased pedal travel to disengage.Pedal application may not be required to move the shift lever out of PARK or additional travel may be required to move the shift lever out of PARK. Traction control, electronic stability control (ESC) and panic brake assist features may also become disabled. These failure conditions may increase the risk of a crash.The Office of Defects Investigation (ODI) opened Engineering Analysis EA13-005 on June 6, 2013 to further investigate complaints alleging that the brake lights did not operate properly on MY 2005-08 Pontiac G6 vehicles.The BAS in these vehicles produces a single analog voltage output proportional to the brake pedal's position.The BAS signal is used by various systems to determine both pedal position and rate of displacement, so a failure or inaccuracy of the signal may affect multiple systems.ODI also received similar complaints on MY 2009 Pontiac G6, MY 2004-11 Chevrolet Malibu and MY 2007-09 Saturn Aura vehicles that use the same BAS.All of these above models were included in the subject vehicle population of ODI's Information Request (IR) letter to GM.Prior to the recall announcement date, ODI received 855 reports of brake light malfunction resulting in one or several of the failure conditions.Eight (8) of the reports alleged crashes, with 1 resulting in an injury. Of these crash allegations, 2 were roll-away incidents, in which the shift interlock was moved out of PARK without pedal application and the vehicle rolled into another object.Three (3) crashes involved rear-end hits, which were believed to be due to brake light reversal.ESC/Traction Control failures were the alleged cause of 2 incidents, which resulted in unresponsive brake application and in 1 case caused the vehicle to leave the roadway.One (1) crash allegation was not counted as the circumstances of the crash were not related to any of the failure modes.ODI notes that it is difficult to determine the actual cause of incidents where brake light reversal or ESC/Traction Control failures were the alleged cause.In response to ODI's IR, GM submitted 2,268 unique reports that related to brake lamp malfunction. Combined with the data submitted during Recall Query 13-001, a total of 4,664 unique complaints were submitted.Twelve (12) of the GM reports alleged a crash, with 2 reporting minor injuries and 4 alleging property damage.Of the 12 reports, 3 involved brake light reversal allegations, 4 involved roll-away incidents and 2 involved ESC/Traction Control malfunctions. ODI did not include three (3) reports that involved allegations inconsistent with the alleged defect. This investigation is closed on the basis of GM's announcement of safety recall 14V-252.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Exterior Lighting:tail Lights
On May 14, 2014 General Motors (GM) announced a recall action (14V-252) involving model year (MY) 2004-12 Chevrolet Malibu, MY 2004-07 Malibu Maxx, MY 2005-10 Pontiac G6 and MY 2007-10 Saturn Aura vehicles.An increased resistance can develop in the Body Control Module connection systems and result in voltage fluctuations in the Brake Apply Sensor (BAS, or brake light switch) circuit that can cause the brake lamps to malfunction.As a result, and according to GM, the brake lamps may illuminate when pedal application is not being applied or may not illuminate when pedal force is applied.Additionally, the cruise control may not engage or if it is engaged it may require increased pedal travel to disengage.Pedal application may not be required to move the shift lever out of PARK or additional travel may be required to move the shift lever out of PARK. Traction control, electronic stability control (ESC) and panic brake assist features may also become disabled. These failure conditions may increase the risk of a crash.The Office of Defects Investigation (ODI) opened Engineering Analysis EA13-005 on June 6, 2013 to further investigate complaints alleging that the brake lights did not operate properly on MY 2005-08 Pontiac G6 vehicles.The BAS in these vehicles produces a single analog voltage output proportional to the brake pedal's position.The BAS signal is used by various systems to determine both pedal position and rate of displacement, so a failure or inaccuracy of the signal may affect multiple systems.ODI also received similar complaints on MY 2009 Pontiac G6, MY 2004-11 Chevrolet Malibu and MY 2007-09 Saturn Aura vehicles that use the same BAS.All of these above models were included in the subject vehicle population of ODI's Information Request (IR) letter to GM.Prior to the recall announcement date, ODI received 855 reports of brake light malfunction resulting in one or several of the failure conditions.Eight (8) of the reports alleged crashes, with 1 resulting in an injury. Of these crash allegations, 2 were roll-away incidents, in which the shift interlock was moved out of PARK without pedal application and the vehicle rolled into another object.Three (3) crashes involved rear-end hits, which were believed to be due to brake light reversal.ESC/Traction Control failures were the alleged cause of 2 incidents, which resulted in unresponsive brake application and in 1 case caused the vehicle to leave the roadway.One (1) crash allegation was not counted as the circumstances of the crash were not related to any of the failure modes.ODI notes that it is difficult to determine the actual cause of incidents where brake light reversal or ESC/Traction Control failures were the alleged cause.In response to ODI's IR, GM submitted 2,268 unique reports that related to brake lamp malfunction. Combined with the data submitted during Recall Query 13-001, a total of 4,664 unique complaints were submitted.Twelve (12) of the GM reports alleged a crash, with 2 reporting minor injuries and 4 alleging property damage.Of the 12 reports, 3 involved brake light reversal allegations, 4 involved roll-away incidents and 2 involved ESC/Traction Control malfunctions. ODI did not include three (3) reports that involved allegations inconsistent with the alleged defect. This investigation is closed on the basis of GM's announcement of safety recall 14V-252.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
RQ13001 · Brake Light Malfunction
Opened Feb 4, 2013 · Closed Jun 6, 2013
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:tail Lights
The Office of Defects Investigation (ODI) opened Recall Query RQ13-001 on February 4, 2013 in response to complaints alleging that the brake lights do not operate properly on model year (MY) 2005-2008 Pontiac G6 vehicles. Complainants allege that the brake lights illuminate when the brake pedal is not depressed, and turn off once the brake pedal is applied. In addition the driver may have difficulty shifting out of PARK, or the cruise control may not engage properly. In response to ODI?s Information Request, General Motors (GM) submitted a significant number of warranty claims and over 1, 100 reports that potentially relate to the alleged problem. ODI is continuing its analysis of this data. One of the GM reports also alleged a vehicle crash. ODI has received a total of 314 complaints, one alleging a crash.Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA13-005) to determine whether the subject vehicles present a safety related defect trend, and to further evaluate scope.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Additional source detail variants (3)
Exterior Lighting:brake Lights
The Office of Defects Investigation (ODI) opened Recall Query RQ13-001 on February 4, 2013 in response to complaints alleging that the brake lights do not operate properly on model year (MY) 2005-2008 Pontiac G6 vehicles. Complainants allege that the brake lights illuminate when the brake pedal is not depressed, and turn off once the brake pedal is applied. In addition the driver may have difficulty shifting out of PARK, or the cruise control may not engage properly. In response to ODI?s Information Request, General Motors (GM) submitted a significant number of warranty claims and over 1, 100 reports that potentially relate to the alleged problem. ODI is continuing its analysis of this data. One of the GM reports also alleged a vehicle crash. ODI has received a total of 314 complaints, one alleging a crash.Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA13-005) to determine whether the subject vehicles present a safety related defect trend, and to further evaluate scope.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Exterior Lighting
The Office of Defects Investigation (ODI) opened Recall Query RQ13-001 on February 4, 2013 in response to complaints alleging that the brake lights do not operate properly on model year (MY) 2005-2008 Pontiac G6 vehicles. Complainants allege that the brake lights illuminate when the brake pedal is not depressed, and turn off once the brake pedal is applied. In addition the driver may have difficulty shifting out of PARK, or the cruise control may not engage properly. In response to ODI?s Information Request, General Motors (GM) submitted a significant number of warranty claims and over 1, 100 reports that potentially relate to the alleged problem. ODI is continuing its analysis of this data. One of the GM reports also alleged a vehicle crash. ODI has received a total of 314 complaints, one alleging a crash.Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA13-005) to determine whether the subject vehicles present a safety related defect trend, and to further evaluate scope.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
Exterior Lighting:tail Lights
The Office of Defects Investigation (ODI) opened Recall Query RQ13-001 on February 4, 2013 in response to complaints alleging that the brake lights do not operate properly on model year (MY) 2005-2008 Pontiac G6 vehicles. Complainants allege that the brake lights illuminate when the brake pedal is not depressed, and turn off once the brake pedal is applied. In addition the driver may have difficulty shifting out of PARK, or the cruise control may not engage properly. In response to ODI?s Information Request, General Motors (GM) submitted a significant number of warranty claims and over 1, 100 reports that potentially relate to the alleged problem. ODI is continuing its analysis of this data. One of the GM reports also alleged a vehicle crash. ODI has received a total of 314 complaints, one alleging a crash.Based on the agency's current analysis, ODI has upgraded its investigation to an Engineering Analysis (EA13-005) to determine whether the subject vehicles present a safety related defect trend, and to further evaluate scope.The ODI complaints cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID, see the attached list for ODI numbers.
PE08054 · Stop Lamp Malfunction
Opened Sep 15, 2008 · Closed Jan 30, 2009
Status: closed (inferred from source dates) · Electrical System:software; Exterior Lighting:brake Lights:switch
GM NOTIFIED THE AGENCY BY LETTER DATED JANUARY 28, 2009, THAT IT WILL CONDUCT A SAFETY RECALL OF PONTIAC G6 VEHICLES BUILT FROM JANUARY 3 THROUGH JANUARY 31, 2005.VEHICLES PRODUCED DURING THIS TIME PERIOD HAVE SHOWN A HIGHLY ELEVATED INCIDENT RATE OF IMPROPER OPERATION OF THE BRAKE LAMPS. ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT CONSUMERS WOULD USE THEIR BRAKES AND DISCOVER THAT THE BRAKE LAMPS WOULD NOT ILLUMINATE.ALSO, CONSUMERS REPORT THAT THE BRAKE LAMPS WOULD ILLUMINATE WHEN THE BRAKE PEDAL WAS NOT APPLIED.ODI'S REVIEW OF THE COMPLAINT DATA FINDS THAT THE COMPLAINT RATE FOR THE JANUARY 2005 PRODUCTION IS 20 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.LIKEWISE, THE WARRANTY RATE FOR THE JANUARY 2005 PRODUCTION IS 11 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.IN ITS LETTER TO THE NHTSA, GENERAL MOTORS (GM) EXPLAINED THAT THE PRIMARY CAUSE OF THIS BRAKE CONDITION WAS FRETTING CORROSION (OXIDATION) OF THE CONNECTOR PINS ON THE BODY CONTROL MODULE (BCM) THAT CONNECT TO THE TO THE BRAKE PEDAL POSITION SENSOR (BPPS).THE CORROSION PREVENTS THE BCM FROM RECEIVING THE CORRECT SIGNAL VOLTAGE FROM THE BPPS.IN DECEMBER 2008, GM RELEASED TECHNICAL SERVICE BULLETIN (TSB) #08-05-22-009 TO PROVIDE TECHNICIANS THE CORRECT REPAIR PROCEDURES FOR SUBJECT VEHICLES THAT EXPERIENCE IMPROPER ILLUMINATION OF THE BRAKE LAMPS.THIS ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.
Additional source detail variants (2)
Electrical System:software
GM NOTIFIED THE AGENCY BY LETTER DATED JANUARY 28, 2009, THAT IT WILL CONDUCT A SAFETY RECALL OF PONTIAC G6 VEHICLES BUILT FROM JANUARY 3 THROUGH JANUARY 31, 2005.VEHICLES PRODUCED DURING THIS TIME PERIOD HAVE SHOWN A HIGHLY ELEVATED INCIDENT RATE OF IMPROPER OPERATION OF THE BRAKE LAMPS. ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT CONSUMERS WOULD USE THEIR BRAKES AND DISCOVER THAT THE BRAKE LAMPS WOULD NOT ILLUMINATE.ALSO, CONSUMERS REPORT THAT THE BRAKE LAMPS WOULD ILLUMINATE WHEN THE BRAKE PEDAL WAS NOT APPLIED.ODI'S REVIEW OF THE COMPLAINT DATA FINDS THAT THE COMPLAINT RATE FOR THE JANUARY 2005 PRODUCTION IS 20 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.LIKEWISE, THE WARRANTY RATE FOR THE JANUARY 2005 PRODUCTION IS 11 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.IN ITS LETTER TO THE NHTSA, GENERAL MOTORS (GM) EXPLAINED THAT THE PRIMARY CAUSE OF THIS BRAKE CONDITION WAS FRETTING CORROSION (OXIDATION) OF THE CONNECTOR PINS ON THE BODY CONTROL MODULE (BCM) THAT CONNECT TO THE TO THE BRAKE PEDAL POSITION SENSOR (BPPS).THE CORROSION PREVENTS THE BCM FROM RECEIVING THE CORRECT SIGNAL VOLTAGE FROM THE BPPS.IN DECEMBER 2008, GM RELEASED TECHNICAL SERVICE BULLETIN (TSB) #08-05-22-009 TO PROVIDE TECHNICIANS THE CORRECT REPAIR PROCEDURES FOR SUBJECT VEHICLES THAT EXPERIENCE IMPROPER ILLUMINATION OF THE BRAKE LAMPS.THIS ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.
Exterior Lighting:brake Lights:switch
GM NOTIFIED THE AGENCY BY LETTER DATED JANUARY 28, 2009, THAT IT WILL CONDUCT A SAFETY RECALL OF PONTIAC G6 VEHICLES BUILT FROM JANUARY 3 THROUGH JANUARY 31, 2005.VEHICLES PRODUCED DURING THIS TIME PERIOD HAVE SHOWN A HIGHLY ELEVATED INCIDENT RATE OF IMPROPER OPERATION OF THE BRAKE LAMPS. ODI OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS THAT CONSUMERS WOULD USE THEIR BRAKES AND DISCOVER THAT THE BRAKE LAMPS WOULD NOT ILLUMINATE.ALSO, CONSUMERS REPORT THAT THE BRAKE LAMPS WOULD ILLUMINATE WHEN THE BRAKE PEDAL WAS NOT APPLIED.ODI'S REVIEW OF THE COMPLAINT DATA FINDS THAT THE COMPLAINT RATE FOR THE JANUARY 2005 PRODUCTION IS 20 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.LIKEWISE, THE WARRANTY RATE FOR THE JANUARY 2005 PRODUCTION IS 11 TIMES GREATER THAN FOR THE REMAINDER OF THE SUBJECT VEHICLE POPULATION.IN ITS LETTER TO THE NHTSA, GENERAL MOTORS (GM) EXPLAINED THAT THE PRIMARY CAUSE OF THIS BRAKE CONDITION WAS FRETTING CORROSION (OXIDATION) OF THE CONNECTOR PINS ON THE BODY CONTROL MODULE (BCM) THAT CONNECT TO THE TO THE BRAKE PEDAL POSITION SENSOR (BPPS).THE CORROSION PREVENTS THE BCM FROM RECEIVING THE CORRECT SIGNAL VOLTAGE FROM THE BPPS.IN DECEMBER 2008, GM RELEASED TECHNICAL SERVICE BULLETIN (TSB) #08-05-22-009 TO PROVIDE TECHNICIANS THE CORRECT REPAIR PROCEDURES FOR SUBJECT VEHICLES THAT EXPERIENCE IMPROPER ILLUMINATION OF THE BRAKE LAMPS.THIS ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.
PE07023 · Loss Of Power Steering Assist
Opened Apr 25, 2007 · Closed Sep 25, 2007
Status: closed (inferred from source dates) · Steering:electric Power Assist System
DURING THIS INVESTIGATION, GENERAL MOTORS (GM) INDICATED THAT APPROXIMATELY 15,600 MODEL YEAR (MY) 2005 PONTIAC G6 VEHICLES BUILT FROM NOVEMBER 3, 2004 THROUGH JANUARY 5, 2005 MAY EXPERIENCE A LOSS OF POWER STEERING ASSIST DUE TO AN INSUFFICIENT CRIMP AT THE TORQUE AND POSITION SENSOR TRANSDUCER LOCATED IN THE STEERING COLUMN ASSEMBLY. GM HAS INDICATED THAT IT PLANS TO SEND LETTERS TO THE OWNERS OF THESE VEHICLES TO INFORM THEM THAT IT WILL EXTEND THE WARRANTY COVERAGE FOR THE EPS SYSTEM IN THEIR VEHICLES TO 7 YEARS OR 70,000 MILES.STATISTICAL ANALYSIS OF THE FAILURES IN THE POPULATION AFFECTED BY THE WIRING CRIMP PROBLEM INDICATE THAT THE PROBLEM IS AN EARLY LIFE FAILURE THAT SHOULD OCCUR WITHIN THE TERMS OF THE EXTENDED COVERAGE.GM'S INVESTIGATION OF EPS FAILURES IN THE SUBJECT VEHICLES IDENTIFIED A PROBLEM WITH THE CONNECTOR CRIMPS DURING THE TWO MONTH PRODUCTION RANGE COVERED BY THE WARRANTY EXTENSION.DURING THIS PERIOD THE CRIMPS MAY BE ASYMMETRICAL, RESULTING ININADEQUATE PRESSURE ON THE WIRE THAT CAN LEAD TO ELECTRICAL NOISE IN THE SIGNAL FROM THE SENSOR TO THE CONTROLLER.THE CONTROLLER MAY INTERPRET THIS ELECTRICAL NOISE AS A MALFUNCTION OF THE SYSTEM AND DEFAULT TO MANUAL MODE (I.E., TURN OFF THE EPS SYSTEM).IF THE POWER STEERING ASSIST IS LOST, THE DRIVER INFORMATION CENTER (DIC) DISPLAYS A POWER STEERING WARNING MESSAGE, A CHIME IS SOUNDED, ANDTHE SERVICE VEHICLE SOON LIGHT WILL ILLUMINATE.IN MANUAL MODE THE STEERING REQUIRES INCREASED EFFORT, ESPECIALLY AT SPEEDS LESS THAN 20 MILES PER HOUR (MPH).ODI'S ANALYSIS OF THE FAILURE DATA SHOW THAT APPROXIMATELY 30 PERCENT OF THE COMPLAINTS AND FIELD REPORTS (569 OF 1913) INVOLVE VEHICLES BUILT IN THE RANGE COVERED BY GM'S EXTENDED POLICY, WHICH ACCOUNT FOR ONLY ABOUT 7 PERCENT OF THE SUBJECT VEHICLE POPULATION.THE COMPLAINT RATE FOR THE NON-PEAK MONTHS IS RELATIVELY HIGH, AT 673 PER 100,000 VEHICLES.THE RATE FOR THE PEAK MONTHS IS 5 TIMES HIGHER AT 3,645 PER 100,000 VEHICLES.SIMILAR DIFFERENCES ARE EVIDENT IN THE WARRANTY DATA, WITH APPROXIMATELY 27 PERCENT OF THE EPS WARRANTY CLAIMS (1120 OF 4145) INVOLVING VEHICLES BUILT IN THE PEAK MONTHS.THE WARRANTY RATE FOR THE NON-PEAK MONTHS IS 1.5% AND THE RATE FOR THE PEAK MONTHS IS 7.2%.ODI IDENTIFIED 9 CRASHES THAT ARE POTENTIALLY RELATED TO EPS SYSTEM FAILURE IN THE SUBJECT VEHICLES.THE CRASHES OCCURRED AT LOW SPEEDS, SUCH AS DRIVEWAY AND PARKING LOT TYPE MANEUVERS.THE CRASHES RESULTED IN ONE ALLEGED INJURY, BUT ODI WAS UNABLE TO OBTAIN INFORMATION ABOUT THE TYPE OR SEVERITY OF THE INJURY.NONE OF THE CRASHES INVOLVE VEHICLES BUILT IN THE TWO MONTH PERIOD COVERED BY GM'S EXTENDED WARRANTY COVERAGE.THE SUBJECT VEHICLES USE THE SAME EPS SYSTEM AS THE MY 2004 CHEVROLET MALIBU VEHICLES INVESTIGATED BY ODI IN EA04-018.ALTHOUGH THE FAILURE RATES ARE HIGH IN THIS INVESTIGATION, PARTICULARLY FOR THE PEAK MONTHS, THEY ARE SIGNIFICANTLY LOWER THAN FOR THE MALIBU VEHICLES INVESTIGATED IN EA04-018.AS IN THOSE VEHICLES, THE EFFECTS ON STEERING EFFORT ARE SMALL AT SPEEDS GREATER THAN 15-20 MPH.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.