NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
188 reportsMileage unknown · Nov 14, 2010
Suspension
I AM COMPLAINING ABOUT THE CONTROL ARM BUSHINGS POPPING OUT. WE PURCHASED TWO BRAND NEW VEHICLES, BOTH G5S ON THE SAME DAY. BOTH VEHICLES HAVE CONTROL ARM BUSHING PROBLEMS! THE ONE VEHICLE WAS STILL UNDER WARRANTY AND THE CONTROL BUSHINGS WERE REPLACED BY THE DEALERSHIP. THIS VEHICLE WAS OUT OF WARRANTY AT THAT TIME AND THE …
Read full complaint
I AM COMPLAINING ABOUT THE CONTROL ARM BUSHINGS POPPING OUT. WE PURCHASED TWO BRAND NEW VEHICLES, BOTH G5S ON THE SAME DAY. BOTH VEHICLES HAVE CONTROL ARM BUSHING PROBLEMS! THE ONE VEHICLE WAS STILL UNDER WARRANTY AND THE CONTROL BUSHINGS WERE REPLACED BY THE DEALERSHIP. THIS VEHICLE WAS OUT OF WARRANTY AT THAT TIME AND THE DEALERSHIP WOULD ONLY REPLACE THEM AT OUR COST. I'M SURE AFTER READING ONLINE COMPLAINTS THAT THESE VEHICLES HAVE MAJOR ISSUES WITH CONTROL ARM BUSHINGS. I WOULD PROBABLY UNDERSTAND IF IT WERE ONE VEHICLE, BUT TO HAPPEN TO BOTH BRAND NEW VEHICLES? THERE IS A PROBLEM!
NHTSA ODI #10366208
25,000 miles · Oct 1, 2010
SteeringCrash
TL*THE CONTACT OWNS A 2007 PONTIAC G5. THE CONTACT STATED THAT ON DECEMBER 13, 2009, WHILE HER SON WAS DRIVING IN TORRENTIAL RAINY WEATHER CONDITIONS AROUND A SLIGHT CURVE, THE VEHICLE DROVE OFF OF THE ROAD AND CRASHED INTO A TREE. THE DRIVER DIED AS A RESULT OF THE CRASH. THERE WERE NO INDICATIONS OF SPEEDING OR ANY SKID MARKS.…
Read full complaint
TL*THE CONTACT OWNS A 2007 PONTIAC G5. THE CONTACT STATED THAT ON DECEMBER 13, 2009, WHILE HER SON WAS DRIVING IN TORRENTIAL RAINY WEATHER CONDITIONS AROUND A SLIGHT CURVE, THE VEHICLE DROVE OFF OF THE ROAD AND CRASHED INTO A TREE. THE DRIVER DIED AS A RESULT OF THE CRASH. THERE WERE NO INDICATIONS OF SPEEDING OR ANY SKID MARKS. THE POLICE COULD NOT DETERMINE THE CAUSE OF THE CRASH. THE CONTACT RECEIVED RECALL NOTICE 10V073000 (STEERING:ELECTRIC POWER ASSIST SYSTEM) WHICH SHE PRESUMED TO BE THE CAUSE OF THE CRASH. SHE CALLED THE DEALERSHIP WHO STATED THAT THEY HAD NO KNOWLEDGE OF THE RELATED FAILURE. SHE CALLED THE MANUFACTURER AND WAS AWAITING A CALL BACK. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 25,000.
NHTSA ODI #10358770
17,500 miles · Sep 10, 2010
Electrical SystemLatches/locks/linkages
1. WE OWN A 2007 PONTIAC G5 WITH 17,000 MILES ON IT. THE KEY STUCK IN THE IGNITION AND WE COULDN'T GET IT OUT! WE FOUND OUT THAT THERE IS A SERVICE BULLETIN FOR THIS PROBLEM (#09-02-35-005B) DATED FEBRUARY 4, 2010. HOWEVER, BECAUSE THIS IS NOT A RECALL AND THE VEHICLE IS NO LONGER UNDER WARRANTY (36 MONTH/36,000 MILES EXPIRED…
Read full complaint
1. WE OWN A 2007 PONTIAC G5 WITH 17,000 MILES ON IT. THE KEY STUCK IN THE IGNITION AND WE COULDN'T GET IT OUT! WE FOUND OUT THAT THERE IS A SERVICE BULLETIN FOR THIS PROBLEM (#09-02-35-005B) DATED FEBRUARY 4, 2010. HOWEVER, BECAUSE THIS IS NOT A RECALL AND THE VEHICLE IS NO LONGER UNDER WARRANTY (36 MONTH/36,000 MILES EXPIRED ON AUGUST 11, 2010) WE WILL BE REQUIRED TO PAY FOR THIS REPAIR OURSELVES. OUR LOCAL DEALER (NOW THE CHEVROLET DEALER IN FAYETTEVILLE, ARKANSAS) WANTS $45.00 JUST TO LOOK AT IT! 2. KEY STUCK IN THE IGNITION. ONLY OCCURRED ONCE SO FAR. 3. SINCE OTHERS HAVE HAD THIS PROBLEM WE WERE ABLE TO READ ON LINE AND FIGURE OUT HOW TO GET THE KEY OUT AND, AT LEAST TEMPORARILY, REPAIR IT OURSELVES. WE ARE SURE IT WILL HAPPEN AGAIN! *TR
NHTSA ODI #10354890
34,000 miles · Aug 8, 2010
Suspension
LEFT SIDE A ARM BUSHING REPLACED UNDER WARRANTY, AFTER WARRANTY WENT OUT AT 36,000 MILE/ 3 YEARS RIGHT SIDE IS NOW BAD. THIS MAKING THE CAR SEEM/SOUND AS IF A STRUT OR SHOCK IS BROKEN. I WAS TOLD BY DEALER THIS IS A COMMON PROBLEM ON THE CHEVY COBALTS AND PONTIAC G5. HOW DANGEROUS THIS SITUATION IS REMAINS TO BE SEEN. SEEMS TO M…
Read full complaint
LEFT SIDE A ARM BUSHING REPLACED UNDER WARRANTY, AFTER WARRANTY WENT OUT AT 36,000 MILE/ 3 YEARS RIGHT SIDE IS NOW BAD. THIS MAKING THE CAR SEEM/SOUND AS IF A STRUT OR SHOCK IS BROKEN. I WAS TOLD BY DEALER THIS IS A COMMON PROBLEM ON THE CHEVY COBALTS AND PONTIAC G5. HOW DANGEROUS THIS SITUATION IS REMAINS TO BE SEEN. SEEMS TO ME GM SHOULD HAVE TO REPLACE THESE AT THEIR EXPENSE NOT MINE, WITH A BETTER QUALITY BUSHING. A STUDY TO SEE HOW UNSAFE THIS MAKES THE SAID CARS, IS IN ORDER. *TR
NHTSA ODI #10348016
60,910 miles · Jul 21, 2010
Power TrainCrash
TL*THE CONTACT OWNS A 2007 PONTIAC G5. THE CONTACT STATED THAT WHILE DRIVING IN REVERSE THE GEARS SHIFTED FROM REVERSE TO DRIVE ON IT'S OWN CAUSING THE VEHICLE TO ACCELERATE AND CRASH INTO A BUILDING. NO ONE WAS INJURED DURING THE CRASH. THE VEHICLE WAS TOWED TO A BODY SHOP. A COMPLAINT WAS FILED WITH THE MANUFACTURER REGARDIN…
Read full complaint
TL*THE CONTACT OWNS A 2007 PONTIAC G5. THE CONTACT STATED THAT WHILE DRIVING IN REVERSE THE GEARS SHIFTED FROM REVERSE TO DRIVE ON IT'S OWN CAUSING THE VEHICLE TO ACCELERATE AND CRASH INTO A BUILDING. NO ONE WAS INJURED DURING THE CRASH. THE VEHICLE WAS TOWED TO A BODY SHOP. A COMPLAINT WAS FILED WITH THE MANUFACTURER REGARDING THE GEAR SHIFT IN 2009 AND DID NOT RECEIVE A RESPONSE OR ANY ASSISTANCE. THE CONTACT REPLACED THE GEAR SHIFT LEVER AND THE FAILURE RECURRED WHICH CAUSED THE CRASH TO OCCUR. THE FAILURE MILEAGE WAS 60,910.
NHTSA ODI #10344547
47,369 miles · Jun 23, 2010
EquipmentService Brakes, Hydraulic
THE U-SPRING HOLDING THE REAR BRAKE DRUMS TOGETHER RUSTED THROUGH AND BROKE INTO TWO PIECES. THE DEALERSHIP REPLACED BOTH OF THE REAR BRAKE DRUM KITS AT A PRICE COST TO ME OF $117.40. *TR
NHTSA ODI #10339731
32,000 miles · Jun 18, 2010
SteeringCrash
MY 2007 PONTIAC LOST POWER STEERING AND I COULDN'T TURN THE WHEEL AND HIT A BANK. GM HAD A INDEPENDENT PERSON LOOK AT IT. THEN A GM REP LOOKED AT THE REPORT AND SAID IT WASN'T THEIR FAULT. I ASK WHAT KIND OF EDUCATION SHE HAD AND SHE SAID THAT DIDN'T MATTER. THEY LOOKED AT THE CAR FOR 4 HOURS AND NO MILEAGE. *TR
NHTSA ODI #10339067
65,000 miles · Jun 11, 2010
Steering
THE POWER STEERING FAILURE LIGHT COMES ON AS WELL AS ALL THE OTHER WARNING LIGHTS AND GAUGES QUIT WORKING WHILE DRIVING WHICH MAKES IT A SAFETY CONCERN. WE HAVE RECEIVED A NOTICE FROM GM THAT THIS VEHICLE MIGHT HAVE A RECALL BECAUSE OF THE STEERING FAILURE BUT HAVE BEEN TOLD BY OUR PONTIAC DEALER AND GM THAT IT DOES NOT. THE VEH…
Read full complaint
THE POWER STEERING FAILURE LIGHT COMES ON AS WELL AS ALL THE OTHER WARNING LIGHTS AND GAUGES QUIT WORKING WHILE DRIVING WHICH MAKES IT A SAFETY CONCERN. WE HAVE RECEIVED A NOTICE FROM GM THAT THIS VEHICLE MIGHT HAVE A RECALL BECAUSE OF THE STEERING FAILURE BUT HAVE BEEN TOLD BY OUR PONTIAC DEALER AND GM THAT IT DOES NOT. THE VEHICLE HAS BEEN TO THE DEALER 3 TIMES IN THE LAST MONTH FOR THIS ISSUE. FIRST TIME, THE DEALER SAID THEY DIDN'T FIND ANYTHING. WITHIN A HALF HOUR OF LEAVING THE DEALERSHIP, THE CAR WAS BROUGHT BACK TO THE DEALER FOR THE SAME ISSUE. THE DEALER REPLACED THE ECM AND AFTER A FEW WEEKS THE ISSUE HAS RETURNED AND HAS BEEN A THE DEALER FOR A WEEK BUT THEY ARE UNABLE TO FIND PROBLEMS AND SEEM TO HAVE GIVEN UP. HAVE TALKED TO GM CUSTOMER SERVICE DURING THIS WHOLE TIME. *TR
NHTSA ODI #10335812
40,000 miles · Jun 7, 2010
Steering
TL*THE CONTACT OWNS A 2007 PONTIAC G5. WHILE DRIVING AT APPROXIMATELY 30-35 MPH, THE POWER STEERING STOPPED FUNCTIONING. THE CONTACT PULLED OVER AND SHUT THE VEHICLE OFF. WHEN HE RESTARTED IT, THE POWER STEERING STILL DID NOT FUNCTION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE STEERING COLUMN RELAY WAS REPLACED…
Read full complaint
TL*THE CONTACT OWNS A 2007 PONTIAC G5. WHILE DRIVING AT APPROXIMATELY 30-35 MPH, THE POWER STEERING STOPPED FUNCTIONING. THE CONTACT PULLED OVER AND SHUT THE VEHICLE OFF. WHEN HE RESTARTED IT, THE POWER STEERING STILL DID NOT FUNCTION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE STEERING COLUMN RELAY WAS REPLACED. WHILE DRIVING FROM THE DEALERSHIP, THE FAILURE OCCURRED AGAIN. THE DEALER THEN STATED THAT THE POWER STEERING ASSIST MOTOR NEEDED TO BE REPLACED BUT PARTS WERE UNAVAILABLE. THE VIN WAS UNAVAILABLE AT THE TIME OF THE COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 40,000.
NHTSA ODI #10335088
44,000 miles · May 16, 2010
Air BagsCrashInjury
AIR BAGS DID NOT DEPLOY ON A PONTIAC G5 2007 2D. MY 20 YR OLD COLLEGE STUDENT SON WAS DRIVING ON THE 101 FWY, WHERE THE CAR TO HIS LEFT SWITCHED LANE TO COME IN FRONT OF MY SON'S CAR, OTHER DRIVER HAD A SUDDEN BRAKE. MY SON COLLIDED INTO THE CAR IN FRONT OF HIM AT SPEED OF 40-50MPH BUT AIR BAGS DIDN'T DEPLOY. HE WAS WEARING THE …
Read full complaint
AIR BAGS DID NOT DEPLOY ON A PONTIAC G5 2007 2D. MY 20 YR OLD COLLEGE STUDENT SON WAS DRIVING ON THE 101 FWY, WHERE THE CAR TO HIS LEFT SWITCHED LANE TO COME IN FRONT OF MY SON'S CAR, OTHER DRIVER HAD A SUDDEN BRAKE. MY SON COLLIDED INTO THE CAR IN FRONT OF HIM AT SPEED OF 40-50MPH BUT AIR BAGS DIDN'T DEPLOY. HE WAS WEARING THE SEAT BELT, HOWEVER, HE IS NOW BEING TREATED FOR NECK AND BACK INJURY, CAN'T DRIVE TO SCHOOL AND THE AAA INSURANCE COMPANY DECLARED THE CAR AS TOTAL LOSS DUE TO MAJOR FRONTAL DAMAGE. *TR
NHTSA ODI #10330639
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Sep 19, 2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Consequence & remedy
Consequence: Fuel leakage in the presence of an ignition source may result in a fire.
Remedy: GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration