Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
120–25K
1525–50K
850–75K
875–100K
7100–150K
4150K+
54 reports with mileage · 35 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Steering. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Visibility. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports3 fire reports3 injury reports
What owners actually said
89 reports
145,000 miles · Jul 2, 2014
Engine And Engine Cooling
WHILE TRAVELING ON THE INTERSTATE HIGHWAY 295 IN NJ MY VEHICLE STALLED. THE STALLED AND ALMOST CAUSED A NEAR FATAL ACCIDENT WITH A SEMI. THE VEHICLE AFTER 20 MINUTES AND NUMEROUS ATTEMPTS THE VEHICLE STARTED BACK UP AND I DECIDED TO TRY AND MAKE IT HOME BY TAKING BACK ROADS AWAY FROM THE INTERSTATE. THE VEHICLE STALLED 4 MORE …
Read full complaint
WHILE TRAVELING ON THE INTERSTATE HIGHWAY 295 IN NJ MY VEHICLE STALLED. THE STALLED AND ALMOST CAUSED A NEAR FATAL ACCIDENT WITH A SEMI. THE VEHICLE AFTER 20 MINUTES AND NUMEROUS ATTEMPTS THE VEHICLE STARTED BACK UP AND I DECIDED TO TRY AND MAKE IT HOME BY TAKING BACK ROADS AWAY FROM THE INTERSTATE. THE VEHICLE STALLED 4 MORE TIMES BEFORE I COULD GET IT HOME. I WAS VISIBLY SHAKEN UPSET AND SCARED OUT OF MY MIND. *TR
NHTSA ODI #10607729
138,000 miles · Jun 12, 2014
Electrical SystemPower Train
I PUT MY CAR INTO PARK AND MY KEY WOULD NOT GO TO OFF OR START. IT WAS STUCK ON ACC AND ON. *TR
NHTSA ODI #10597791
113,019 miles · Mar 13, 2014
Engine
TL* THE CONTACT OWNS A 2002 PONTIAC BONNEVILLE. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITH OUT WARNINGS. THE CONTACT MENTIONED THAT THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER HOWEVER, THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF…
Read full complaint
TL* THE CONTACT OWNS A 2002 PONTIAC BONNEVILLE. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITH OUT WARNINGS. THE CONTACT MENTIONED THAT THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER HOWEVER, THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 113,019 AND THE CURRENT MILEAGE WAS 113,119.
NHTSA ODI #10569043
215,000 miles · Jun 17, 2013
Electrical SystemExterior Lighting
AS I WAS DRIVING, SMELLED WIRE BURNING AND SMOKE COMING FROM THE FRONT DRIVER AT THE HEADLINER THEN THE INTERIOR LIGHTS SHUT OFF, TRUNK RELEASE SWITCH INOP. I PULLED OVER ON THE HIGHWAY AND TURNED KEY OFF. THEN NOTICED TWO WEEKS AGO THAT THERE IS NO POWER TO THE OBD-II. HAVE ABLE TO REPAIR THE DAMAGES. *TR
NHTSA ODI #10520327
109,000 miles · Nov 14, 2011
Steering
TL* THE CONTACT OWNS A 2002 PONTIAC BONNEVILLE. THE CONTACT WAS DRIVING 40 MPH WHEN THE STEERING WHEEL BEGAN MAKING A CLUNKING SOUND. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE STEERING SHAFT WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VEHICLE WAS NOT REPAIR…
Read full complaint
TL* THE CONTACT OWNS A 2002 PONTIAC BONNEVILLE. THE CONTACT WAS DRIVING 40 MPH WHEN THE STEERING WHEEL BEGAN MAKING A CLUNKING SOUND. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE STEERING SHAFT WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 109,000.
NHTSA ODI #10435604
25,000 miles · May 2, 2011
Fuel System, OtherSteering
2002 PONTIAC BONNEVILLE SE 2 DEFECTS 1) "CLUNKING" OF STEERING SHAFT - HAS BEEN REPLACED MORE THAN ONCE 2) GAS GAUGE STOP WORKING AFTER 4 YEAR (2006). *TR
NHTSA ODI #10398570
85,000 miles · Jul 21, 2010
Vehicle Speed Control
I HAVE TWO GM VEHICLES THAT EXHIBIT THE SAME DANGEROUS CONDITION OF SUDDEN ACCELERATION. THIS CONDITION OCCURS EVERY TIME THE VEHICLE IS STARTED AFTER BEING TURNED OFF. UPON RE-START OF THE VEHICLE, THE ACCELERATOR PEDAL (AND /OR THROTTLE ASSEMBLY) IS STUCK AND IT REQUIRES A LARGE AMOUNT OF FORCE TO DEPRESS THE PEDAL, CAUSING …
Read full complaint
I HAVE TWO GM VEHICLES THAT EXHIBIT THE SAME DANGEROUS CONDITION OF SUDDEN ACCELERATION. THIS CONDITION OCCURS EVERY TIME THE VEHICLE IS STARTED AFTER BEING TURNED OFF. UPON RE-START OF THE VEHICLE, THE ACCELERATOR PEDAL (AND /OR THROTTLE ASSEMBLY) IS STUCK AND IT REQUIRES A LARGE AMOUNT OF FORCE TO DEPRESS THE PEDAL, CAUSING A RAPID CHANGE IN VEHICLE SPEED FROM A STOPPED CONDITION TO A VERY QUICKLY ACCELERATING VEHICLE. AFTER YOU "BREAK THROUGH" THIS FIRST "STICKING" OF THE PEDAL, THE THROTTLE ASSEMBLY FUNCTIONS FINE, UNTIL YOU TURN THE VEHICLE OFF AND RESTART AGAIN. VEHICLES AFFECTED ARE 1999 CHEVROLET ASTRO VAN AND 2002 PONTIAC BONNEVILLE. *TR
NHTSA ODI #10344489
Mileage unknown · Apr 30, 2010
Suspension
BOUGHT A 2002 PONTIAC BONNEVILLE 3 MONTHS AGO. WITHIN THE MONTH HAD TO REPLACE THE LEFT & RIGHT REAR TRAILING ARMS AT 700.00. CAR SEEMS TO HAVE A FUEL PUMP PROBLEM BECAUSE IT DOESN'T ALWAYS START-UP FEELS LIKE IT IS CHOCKING. LASTLY THIS PAST WEEK AS I TURN LEFT AND SOMETIMES RIGHT THERE IS A POPPING NOISE LIKE FRONT BEARINGS OR…
Read full complaint
BOUGHT A 2002 PONTIAC BONNEVILLE 3 MONTHS AGO. WITHIN THE MONTH HAD TO REPLACE THE LEFT & RIGHT REAR TRAILING ARMS AT 700.00. CAR SEEMS TO HAVE A FUEL PUMP PROBLEM BECAUSE IT DOESN'T ALWAYS START-UP FEELS LIKE IT IS CHOCKING. LASTLY THIS PAST WEEK AS I TURN LEFT AND SOMETIMES RIGHT THERE IS A POPPING NOISE LIKE FRONT BEARINGS OR TIE RODS. IS THERE A RECALL ON ANY INFORMATION STATED ABOVE I WOULD LIKE TO KNOW. *TR
NHTSA ODI #10328257
19,964 miles · Feb 16, 2010
Steering
STEERING INTERMEDIATE SHAFT NOISE. LOCATED ON STEERING COLUMN. THIS PROBLEM HAS NOT BE ADDRESSED. IT A FAILURE ON MORE THAN ONE MODEL OF GM CARS. ITS BEEN OCCURRING SINCE 2001 UP TO THIS DATE. SEEMS NHTSA HAS NOT NOTICED OR DONE ANYTHING TO MAKE GM CORRECT PROBLEM. GM HAS GONE ON ITS MERRY WAY COLLECTING HUNDREDS OF DOLLARS PR…
Read full complaint
STEERING INTERMEDIATE SHAFT NOISE. LOCATED ON STEERING COLUMN. THIS PROBLEM HAS NOT BE ADDRESSED. IT A FAILURE ON MORE THAN ONE MODEL OF GM CARS. ITS BEEN OCCURRING SINCE 2001 UP TO THIS DATE. SEEMS NHTSA HAS NOT NOTICED OR DONE ANYTHING TO MAKE GM CORRECT PROBLEM. GM HAS GONE ON ITS MERRY WAY COLLECTING HUNDREDS OF DOLLARS PROBABLY MILLIONS IN REPAIR FEES. LOOKS AS IF GM OR NHTSA TURN AWAY FROM HELPING THE CUSTOMERS WHO FOOT THE BILL. *TR
NHTSA ODI #10310889
Mileage unknown · Sep 1, 2009
Steering
MY 2002 PONTIAC BONNEVILLE HAS A BANGING NOISE IN THE STEERING COLUMN. I AM CONCERNED ABOUT LOSS OF CONTROL OF THE CAR. I AM TOLD THERE IS A SAFETY DEFECT BULLETIN ON THIS ISSUE BUT I DO NOT KNOW HOW TO DEAL WITH THIS. *TR
ON CERTAIN CADILLAC DEVILLE AND SEVILLE PASSENGER VEHICLES, FUNERAL COACHES, AND LIMOUSINES EQUIPPED WITH A V8 (4.6L) ENGINE, OLDSMOBILE AURORA PASSENGER VEHICLES EQUIPPED WITH A V8 (4.0L ) ENGINE, AND PONTIAC BONNEVILLE SSEI PASSENGER VEHICLES EQUIPPED WITH A SUPERCHARGED V6 (3.8L) ENGINE, THE FUEL TANK PRESSURE SENSORS ARE UNUSUALLY SUSCEPTIBLE TO MALFUNCTIONS. IF THE SENSOR MALFUNCTIONS, EXCESSIVE VACUUM CAN BE APPLIED DURING SELF-DIAGNOSTIC TESTING.
Consequence & remedy
Consequence: FUEL SYSTEM COMPONENTS CAN BE DAMAGED AND FUEL CAN LEAK FROM THE VEHICLE WHEN IT IS REFUELED. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK PRESSURE SENSOR. OWNER NOTIFICATION BEGAN ON OCTOBER 17, 2003. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
2002 Pontiac Bonneville Problems, Complaints & Recalls | Skip That Year
Illustration