NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
10 reportsClear category filter96,000 miles · May 13, 2016
Electrical SystemEngine
CAR WILL RE-START ON ITS OWN AFTER KEY IS REMOVED. AFTER PARKING AND SHUTTING OFF THE CAR, THEN REMOVING THE KEY AND OPENING THE DRIVER'S DOOR TO EXIT: IF YOU ACCIDENTALLY PRESS THE UPPER PART OF THE LOCK BUTTON ON THE DOOR (THE UNLOCK FUNCTION) INSTEAD OF PRESSING THE LOWER PART OF THE LOCK BUTTON (THE LOCK FUNCTION), THE CAR …
Read full complaint
CAR WILL RE-START ON ITS OWN AFTER KEY IS REMOVED. AFTER PARKING AND SHUTTING OFF THE CAR, THEN REMOVING THE KEY AND OPENING THE DRIVER'S DOOR TO EXIT: IF YOU ACCIDENTALLY PRESS THE UPPER PART OF THE LOCK BUTTON ON THE DOOR (THE UNLOCK FUNCTION) INSTEAD OF PRESSING THE LOWER PART OF THE LOCK BUTTON (THE LOCK FUNCTION), THE CAR WILL RE-START ITSELF. IT THEN CANNOT BE TURNED OFF BECAUSE THE IGNITION SWITCH IS ALREADY IN THE OFF POSITION. THE ONLY WAY TO SHUT OFF THE ENGINE IS TO JIGGLE THE SHIFTER.
NHTSA ODI #10864729
80,529 miles · Jun 18, 2015
Electrical System
TL* THE CONTACT OWNS A 2002 PONTIAC BONNEVILLE. THE CONTACT STATED THAT THE VEHICLE FAILED TO START WITHOUT WARNING. THE VEHICLE WAS ABLE TO BE STARTED, BUT IT TOOK SEVERAL ATTEMPTS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE IGNITION SWITCH MALFUNCTIONED AND NEEDED TO BE REPLACED. THE MANUF…
Read full complaint
TL* THE CONTACT OWNS A 2002 PONTIAC BONNEVILLE. THE CONTACT STATED THAT THE VEHICLE FAILED TO START WITHOUT WARNING. THE VEHICLE WAS ABLE TO BE STARTED, BUT IT TOOK SEVERAL ATTEMPTS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE IGNITION SWITCH MALFUNCTIONED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 80,529.
NHTSA ODI #10725928
48,502 miles · Nov 18, 2014
Electrical System
IGNITION SWITCH, ENGINE CONTROL MODULE & SECURITY/THEFT MODULE WERE ALL REPLACED BECAUSE AUTO WAS INOPERABLE DUE TO THEIR FAILURE. THE MOBILE MECHANIC CHARGED $616.22 FOR PARTS, $1215.00 FOR LABOR & $13.08 FOR A HAZARDOUS WASTE FEE, TOTAL REPAIR WAS $1844.30. PLEASE SEND EMAIL SO I CAN SCAN DETAILED INVOICE OF REPAIR.
NHTSA ODI #10734186
188,000 miles · Sep 16, 2014
Electrical SystemFuel/propulsion SystemFire
MASS AIR FLOW SENSOR AND O2 SENSOR FAILURE CONSTANT. 10/2013 SECURITY LIGHT COMES ON FREQUENTLY WHILE IN MOTION12/2013 LEAKS IN LOWER GASKET VALVE...ENGINE IS EXTREMELY HOT MOST OF THE TIME 04/2014 SERVICE ENGINE LIGHT REMAINS ON DUE TO O2 SENSOR FAILURE EVEN AFTER REPLACEMENT 7/2014 INTERIOR LIGHTS CAUGHT FIRE 05/2014. *TR
NHTSA ODI #10633472
82,000 miles · Aug 6, 2014
Electrical System
TL* THE CONTACT OWNS A 2002 PONTIAC BONNEVILLE. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOULD STALL WITHOUT WARNING. AN INDEPENDENT MECHANIC STATED THAT THE FAILURE WAS CAUSED BY THE ELECTRICAL SYSTEM. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 82,000. UPDATED 10/02/14*LJ UPDATED 3/6/2015 *JS
NHTSA ODI #10619244
138,000 miles · Jun 12, 2014
Electrical SystemPower Train
I PUT MY CAR INTO PARK AND MY KEY WOULD NOT GO TO OFF OR START. IT WAS STUCK ON ACC AND ON. *TR
NHTSA ODI #10597791
215,000 miles · Jun 17, 2013
Electrical SystemExterior Lighting
AS I WAS DRIVING, SMELLED WIRE BURNING AND SMOKE COMING FROM THE FRONT DRIVER AT THE HEADLINER THEN THE INTERIOR LIGHTS SHUT OFF, TRUNK RELEASE SWITCH INOP. I PULLED OVER ON THE HIGHWAY AND TURNED KEY OFF. THEN NOTICED TWO WEEKS AGO THAT THERE IS NO POWER TO THE OBD-II. HAVE ABLE TO REPAIR THE DAMAGES. *TR
NHTSA ODI #10520327
76,560 miles · Apr 17, 2007
Electrical System
TL*THE CONTACT OWNS A 2002 PONTIAC BONNEVILLE. THE CONTACT STATED THAT THE DEALER HAS REPLACED THE FUSES FOR THE TRUNK AND INNER DOME LIGHTS FIVE TIMES, AND THREE TIMES BY THE OWNER. THE FUSES FOR THE TAIL LIGHTS WERE REPLACED TWICE. THE TRUNK AJAR INDICATOR LIGHT ILLUMINATED WHEN THE TRUNK WAS CLOSED. THE DEALER STATED TH…
Read full complaint
TL*THE CONTACT OWNS A 2002 PONTIAC BONNEVILLE. THE CONTACT STATED THAT THE DEALER HAS REPLACED THE FUSES FOR THE TRUNK AND INNER DOME LIGHTS FIVE TIMES, AND THREE TIMES BY THE OWNER. THE FUSES FOR THE TAIL LIGHTS WERE REPLACED TWICE. THE TRUNK AJAR INDICATOR LIGHT ILLUMINATED WHEN THE TRUNK WAS CLOSED. THE DEALER STATED THAT THERE WAS A SHORT IN THE ELECTRIC SYSTEM, BUT WAS UNABLE TO DUPLICATE THE FAILURE. THE CURRENT MILEAGE WAS 78,000, AND FAILURE MILEAGE WAS 76,560. *AK
NHTSA ODI #10188122
Mileage unknown · Oct 6, 2005
Electrical System
DT: THE CONSUMER COMPLAINED ABOUT A BATTERY PROBLEM. THE POSITIVE TERMINAL CAME OUT OF THE BATTERY. THIS HAPPENED ON AUGUST 25, 2005. HAD THE VEHICLE TOWED THE DEALER BECAUSE THE VEHICLE WOULD NOT START. BATTERY ACID WAS SLIPPING OUT OF IT, AND THE BATTERY WAS IN THE BACK FLOOR BOARD. THEY NEUTRALIZED THE BATTERY ACID AND PUT …
Read full complaint
DT: THE CONSUMER COMPLAINED ABOUT A BATTERY PROBLEM. THE POSITIVE TERMINAL CAME OUT OF THE BATTERY. THIS HAPPENED ON AUGUST 25, 2005. HAD THE VEHICLE TOWED THE DEALER BECAUSE THE VEHICLE WOULD NOT START. BATTERY ACID WAS SLIPPING OUT OF IT, AND THE BATTERY WAS IN THE BACK FLOOR BOARD. THEY NEUTRALIZED THE BATTERY ACID AND PUT IN A NEW BATTERY. *AK THE CONSUMER BELIEVES THERE IS A PROBLEM WITH THE AC DELCO SIDE TERMINAL BATTERIES. THE CONSUMER'S WIFE EXPERIENCED THE SAME FAILURE IN HER VEHICLE. *NM
NHTSA ODI #10136978
Mileage unknown · Jul 13, 2004
Electrical System
VEHICLE WILL NOT START, BATTERY IS IN GOOD CONDITION, LIGHTS COME ON. I WAS TOLD IT WAS THE IGNITION SWITCH. IGNITION SWITCH HAS BEEN REPLACED AND THE IGNITION CYLINDER HAS ALSO BEEN REPLACED. VEHICLE STILL CONTINUES DO EXPERIENCE THE PROBLEM. *LA
NHTSA ODI #10081007
NHTSA investigations
2EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration