NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
129 reportsMileage unknown · Dec 20, 2006
Visibility
BOTH REAR WINDOWS ON MY PONTIAC BONNEVILLE FELL DOWN FOR NO APPARENT REASON. THE FIRST ABOUT A YEAR AGO AND THE SECOND THIS FALL. WE HAVE NO CHILDREN SO NO ONE EVER USED THE REAR WINDOWS. I WIRED THEM UP TEMPORARILY. I LIVE IN A COLD CLIMATE. IF THIS WERE TO HAPPEN TO THE FRONT WINDOWS DURING THE WINTER WHILE ON A LONG TRIP…
Read full complaint
BOTH REAR WINDOWS ON MY PONTIAC BONNEVILLE FELL DOWN FOR NO APPARENT REASON. THE FIRST ABOUT A YEAR AGO AND THE SECOND THIS FALL. WE HAVE NO CHILDREN SO NO ONE EVER USED THE REAR WINDOWS. I WIRED THEM UP TEMPORARILY. I LIVE IN A COLD CLIMATE. IF THIS WERE TO HAPPEN TO THE FRONT WINDOWS DURING THE WINTER WHILE ON A LONG TRIP WE COULD FREEZE TO DEATH. WE HAVE READ OF OTHER FAILURES OF WINDOWS WITH BONNEVILLES, I FEEL THIS IS A DEFECT WHICH THE MANUFACTURER SHOULD BE HELD ACCOUNTABLE FOR. *JB
NHTSA ODI #10176662
Mileage unknown · Nov 11, 2006
Air BagsEngine And Engine CoolingSteering
I HAVE HAD NUMEROUS PROBLEMS, AIRBAG SENSOR FRONT, STEERING NOISE 4TH TIME, AND CATALYTIC CONVERTER NOISY. *JB
NHTSA ODI #10173190
55,030 miles · Oct 17, 2006
Electrical SystemService Brakes, HydraulicStructure
2001 BONNEVILLE ABS WHEEL HUB ASSEMBLY SENSOR FAILED AND HAD TO BE REPLACED. *TS ***NAR*** THIS PART HAS BEEN REPLACED FOUR TIMES. THE CONSUMER WOULD EXPERIENCE ERRATIC BRAKING AT LOW SPEEDS. THE FIRST REPLACEMENT OF THE RIGHT FRONT ASSEMBLY WAS AT 16619 MILES AND THE MOST RECENT REPLACEMENT WAS DONE AT 55030 MILES. THE VE…
Read full complaint
2001 BONNEVILLE ABS WHEEL HUB ASSEMBLY SENSOR FAILED AND HAD TO BE REPLACED. *TS ***NAR*** THIS PART HAS BEEN REPLACED FOUR TIMES. THE CONSUMER WOULD EXPERIENCE ERRATIC BRAKING AT LOW SPEEDS. THE FIRST REPLACEMENT OF THE RIGHT FRONT ASSEMBLY WAS AT 16619 MILES AND THE MOST RECENT REPLACEMENT WAS DONE AT 55030 MILES. THE VEHICLE'S TRUNK RELEASE WAS INOPERATIVE. THE DEALER REPLACED THE COMMUNICATION LINK AND TRUNK RELEASE FUSE. THE FRONT TRANSMISSION MOUNT WAS WORN CAUSED EXCESSIVE MOVEMENT. THE DEALER REPLACED THE FRONT TRANSMISSION MOUNT. *NM
NHTSA ODI #10172233
5,000 miles · Sep 6, 2006
Electronic Stability ControlSteering
I HAVE A 2001 PONTIAC BONNEVILLE SSEI. I HAVE HAD THIS CAR IN AND OUT OF THE SHOP NUMEROUS TIMES FOR THE "CHECK STABILITY SYSTEM" WARNING AND A "CLUNKING" NOISE IN THE LEFT FRONT AREA. IT MAKES NOISE PRIMARILY IN A TURN OR GOING OVER A BUMP. I HAVE HAD THE FRONT LEFT WHEEL BEARING/ASSEMBLY REPLACED AS WELL. THE LAST MECHANI…
Read full complaint
I HAVE A 2001 PONTIAC BONNEVILLE SSEI. I HAVE HAD THIS CAR IN AND OUT OF THE SHOP NUMEROUS TIMES FOR THE "CHECK STABILITY SYSTEM" WARNING AND A "CLUNKING" NOISE IN THE LEFT FRONT AREA. IT MAKES NOISE PRIMARILY IN A TURN OR GOING OVER A BUMP. I HAVE HAD THE FRONT LEFT WHEEL BEARING/ASSEMBLY REPLACED AS WELL. THE LAST MECHANIC WAS PUZZLED AND FRUSTRATED AT THE FACT THAT HE CANNOT FIGURE OUR WHAT IS MAKING THE NOISE. I BELIEVE THAT THIS IS A DEFECT AND GM SHOULD ISSUE A RECALL AND FIX THE PROBLEM FOR THE CONSUMER. GM WONDERS WHY THEIR SALES A SLACKING....MAYBE THEY SHOULD TAKE BETTER CARE OF THEIR CUSTOMERS. MAKES ME THINK I SHOULD HAVE BOUGHT A TOYOTA..... *JB
NHTSA ODI #10167488
Mileage unknown · Aug 24, 2006
Visibility
BOTH REAR WINDOWS HAVE FALLEN DOWN (AT SEPARATE TIMES) WITHOUT OPERATION BY DRIVER/PASSENGER. APPROXIMATE COST OF REGULATOR/INSTALLATION FOR REPAIR = $350-400 EACH. FIRST INCIDENT (REAR PASSENGER SIDE) OCCURRED, AND I TAPED UP WINDOW PENDING REPAIRS. TAPE CAME LOOSE, AND WINDOW FELL DOWN AGAIN DURING RAINSTORM. I WAS ALONE I…
Read full complaint
BOTH REAR WINDOWS HAVE FALLEN DOWN (AT SEPARATE TIMES) WITHOUT OPERATION BY DRIVER/PASSENGER. APPROXIMATE COST OF REGULATOR/INSTALLATION FOR REPAIR = $350-400 EACH. FIRST INCIDENT (REAR PASSENGER SIDE) OCCURRED, AND I TAPED UP WINDOW PENDING REPAIRS. TAPE CAME LOOSE, AND WINDOW FELL DOWN AGAIN DURING RAINSTORM. I WAS ALONE IN CAR, AND HAD TO TRY TO FIND LOCATION ON HIGHWAY TO ATTEMPT TO GET WINDOW BACK UP. SAFETY ISSUE WITH BEING ON SHOULDER OF HIGHWAY DURING TORRENTIAL RAINFALL. WINDOW IS STILL TAPED BECAUSE ONCE THE SECOND WINDOW FELL, COST BECAME TOO PROHIBITIVE TO FIX AT THIS TIME. SECOND INCIDENT (REAR DRIVER SIDE) OCCURRED APPROXIMATELY 2-3 WEEKS AFTER FIRST INCIDENT. GRANDDAUGHTERS WERE IN REAR SEAT, (WINDOW LOCKS WERE ON BECAUSE 1ST WINDOW HAD ALREADY FALLEN), GRANDDAUGHTER GAVE SMALL SCREAM OF FRIGHT WHEN WINDOW FELL, SURPRISING MY HUSBAND (DRIVER), CAUSING HIM TO JERK WHEEL IN TRAFFIC BECAUSE HER SCREAM CAUGHT HIM OFF-GUARD AND HE DIDN'T KNOW WHAT HAD HAPPENED. SECOND WINDOW IS STILL TAPED. SAFETY ISSUES WITH CHILDREN IN REAR SEAT AND WINDOW DOWN, WITH NO WAY OF PUTTING IT BACK UP AT THAT TIME; PLUS, THE UNEXPECTED FRIGHT TO DRIVER. *JB
NHTSA ODI #10166419
80,000 miles · May 1, 2006
Steering
DT*: THE CONTACT STATED TWO YEARS AGO THE STEERING BEGAN TO MAKE A GRINDING NOISE WHILE DRIVING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DETERMINED THE INTERMEDIATE SHAFT HAD FAILED WHICH INTERFERED WITH THE STEERING. THE MECHANIC REPLACED THE SHAFT, AND EXPLAINED IT WAS UNUSUAL FOR THIS PART TO FAIL. THE MANUFAC…
Read full complaint
DT*: THE CONTACT STATED TWO YEARS AGO THE STEERING BEGAN TO MAKE A GRINDING NOISE WHILE DRIVING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DETERMINED THE INTERMEDIATE SHAFT HAD FAILED WHICH INTERFERED WITH THE STEERING. THE MECHANIC REPLACED THE SHAFT, AND EXPLAINED IT WAS UNUSUAL FOR THIS PART TO FAIL. THE MANUFACTURER WAS CONTACTED, AND A COMPLAINT WAS FILED. TWO YEARS AFTER THE REPLACEMENT THE SAME PART NEEDED TO BE REPLACED AGAIN. UPDATED 05/30/2006. *AK
NHTSA ODI #10156493
10,100 miles · Nov 16, 2005
Power Train
TRANSMISSION ABRUPTLY FAILED AFTER MAKING A LOUD "BANG" WHILE DRIVING AT 70 MPH ON THE INTERSTATE. THIS CAR HAD ONLY 10,100 MILES WHEN THIS OCCURRED. THE TRANSMISSION HAD TO BE REPLACED BECAUSE THE TRUSS BEARINGS BROKE APART CAUSING THE TRANSMISSION TO FAIL. THE PARTS ARE AVAILABLE FOR INSPECTION. *JB
NHTSA ODI #10142916
Mileage unknown · Oct 12, 2005
Electrical System
DAD: 2001 PONTIAC BONNEVILLE. THE IGNITION SWITCH IS COMPUTERIZED AND WORKS INTERMITTENTLY. WHEN DRIVING THE SWITCH FAILS TO RECOGNIZE THE KEY AND SHUTS THE ENGINE OFF. THIS HAPPENED THREE OR FOUR MONTHS. VEHICLE STALLED WHILE I WAS IN TRAFFIC. TOOK VEHICLE TO DEALERSHIP ON SEPTEMBER 27, 2005 AND HAD THE SWITCH CHANGED A…
Read full complaint
DAD: 2001 PONTIAC BONNEVILLE. THE IGNITION SWITCH IS COMPUTERIZED AND WORKS INTERMITTENTLY. WHEN DRIVING THE SWITCH FAILS TO RECOGNIZE THE KEY AND SHUTS THE ENGINE OFF. THIS HAPPENED THREE OR FOUR MONTHS. VEHICLE STALLED WHILE I WAS IN TRAFFIC. TOOK VEHICLE TO DEALERSHIP ON SEPTEMBER 27, 2005 AND HAD THE SWITCH CHANGED AND THE KEY REPROGRAMMED. HAVE NOT HAD ANY ACCIDENTS. THERE WERE SERVICE INFORMATION BULLETINS AND THE DOCUMENTS; 686736 AND 760683 FOR NOVEMBER 2, 2000. THE CONSUMER CALLED THE MANUFACTURER, THEY SAID THERE WAS NO RECALL, AND IT COST *AK $550 TO BE FIXED. *AK
NHTSA ODI #10139436
Mileage unknown · Oct 10, 2005
Engine And Engine CoolingSteering
WE OWN A 2001 PONTIAC BONNEVILLE. IT HAS HAD TO HAVE A NEW FAN MOTOR, NEW MANIFOLD. AND IN DEC 2003 WE HAD TO REPLACE THE RACK AND PINION, IN DEC 2004 WE HAD TO REPLACE THE RACK AND PINION. AND NOW IT IS MAKING THE SAME NOISE AGAIN. IN READING ON THE INTERNET I SEE THAT THERE ARE MANY COMPLAINTS WITH PONTIAC OVER THE RACK AN…
Read full complaint
WE OWN A 2001 PONTIAC BONNEVILLE. IT HAS HAD TO HAVE A NEW FAN MOTOR, NEW MANIFOLD. AND IN DEC 2003 WE HAD TO REPLACE THE RACK AND PINION, IN DEC 2004 WE HAD TO REPLACE THE RACK AND PINION. AND NOW IT IS MAKING THE SAME NOISE AGAIN. IN READING ON THE INTERNET I SEE THAT THERE ARE MANY COMPLAINTS WITH PONTIAC OVER THE RACK AND PINION ISSUE. THEY NEED TO MAKE CHANGES TO CORRECT THIS PROBLEM. *JB
NHTSA ODI #10139193
85,700 miles · Oct 5, 2005
Electrical System
DT: VEHICLE HAD A BATTERY LEAKAGE PROBLEM . IT WAS LEAKING FOR SOMETIME. THE BATTERY IS LOCATED UNDER THE BACK SEAT AROUND THE POSITIVE POST. THE BATTERY ACID LEAKED AND ATE THROUGH THE FLOOR PAN. THE EXHAUST IS RIGHT UNDER THE BATTERY. NOTICED THIS ON SEPTEMBER 18, 2005. WENT OUT TO START THE VEHICLE AND THAT HOW NOTICED I…
Read full complaint
DT: VEHICLE HAD A BATTERY LEAKAGE PROBLEM . IT WAS LEAKING FOR SOMETIME. THE BATTERY IS LOCATED UNDER THE BACK SEAT AROUND THE POSITIVE POST. THE BATTERY ACID LEAKED AND ATE THROUGH THE FLOOR PAN. THE EXHAUST IS RIGHT UNDER THE BATTERY. NOTICED THIS ON SEPTEMBER 18, 2005. WENT OUT TO START THE VEHICLE AND THAT HOW NOTICED IT. *AK THE CONSUMER EXPLAINED THAT THE BATTERY IN THIS CAR SITS DIRECTLY ON THE FLOOR PAN NOT ON A BATTERY TRAY. *NM
NHTSA ODI #10136896
NHTSA investigations
2EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration