NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
11 reportsClear category filter264,000 miles · Aug 6, 2020
EngineFuel System, GasolinePower Train
TL* THE CONTACT OWNS A 2001 PONTIAC BONNEVILLE. THE CONTACT STATED THAT THE VEHICLE LEAKED OIL OUT OF THE VALVE COVER GASKET AND THE SPARK PLUG WIRE RETAINER CAUSING A MISFIRE. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED BUT FAILED TO PROPERLY ACCEL…
Read full complaint
TL* THE CONTACT OWNS A 2001 PONTIAC BONNEVILLE. THE CONTACT STATED THAT THE VEHICLE LEAKED OIL OUT OF THE VALVE COVER GASKET AND THE SPARK PLUG WIRE RETAINER CAUSING A MISFIRE. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED BUT FAILED TO PROPERLY ACCELERATE WHILE DRIVING. THE CONTACT STATED THAT THERE WERE FUMES INSIDE OF THE VEHICLE WHICH CAUSED EYE IRRITATION. THE CONTACT STATED THAT THE TPMS, CHECK ENGINE, SERVICE ENGINE, SEAT BELT, AND AIR BAGS WARNING LIGHTS WERE ILLUMINATED. ADDITIONALLY, AFTER REFUELING, THE FUEL GAUGE FAILED TO PROVIDE AN ACCURATE FUEL READING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND WAS DIAGNOSED THAT THE SPARK PLUG RETAINER AND VALVE COVER GASKET NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 03V238000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS APPROXIMATELY 264,000.
NHTSA ODI #11343664
174,000 miles · Mar 27, 2012
Fuel System, GasolineFire
TL* THE CONTACT OWNS A 2001 PONTIAC BONNEVILLE. THE CONTACT STATED THAT FUEL FUMES WOULD SEEP INTO THE VEHICLE AND THE VEHICLE WOULD EMIT A LOUD CLICKING NOISE. A LOCAL MECHANIC AND DEALER WERE UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS …
Read full complaint
TL* THE CONTACT OWNS A 2001 PONTIAC BONNEVILLE. THE CONTACT STATED THAT FUEL FUMES WOULD SEEP INTO THE VEHICLE AND THE VEHICLE WOULD EMIT A LOUD CLICKING NOISE. A LOCAL MECHANIC AND DEALER WERE UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 174,000 AND THE CURRENT MILEAGE WAS 190,000.
NHTSA ODI #10453204
120,000 miles · Apr 20, 2009
Engine And Engine CoolingFuel System, Gasoline
TL*THE CONTACT OWNS A 2001 PONTIAC BONNEVILLE. THE CONTACT STATED THAT HER VEHICLE WOULD NOT START AND THE ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. IN ADDITION, SHE SMELLED A STRONG ODOR OF GASOLINE COMING FROM THE VEHICLE. UPON FURTHER INSPECTION, SHE NOTICED THAT THE INTAKE MANIFOLD WAS RUPTURED. THE M…
Read full complaint
TL*THE CONTACT OWNS A 2001 PONTIAC BONNEVILLE. THE CONTACT STATED THAT HER VEHICLE WOULD NOT START AND THE ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. IN ADDITION, SHE SMELLED A STRONG ODOR OF GASOLINE COMING FROM THE VEHICLE. UPON FURTHER INSPECTION, SHE NOTICED THAT THE INTAKE MANIFOLD WAS RUPTURED. THE MANUFACTURER STATED THAT THEY WOULD NOT ASSUME RESPONSIBILITY FOR THE REPAIRS BECAUSE THE VIN WAS EXLCUDED FROM NHTSA CAMPAIGN ID NUMBER 04V090000 (FUEL SYSTEM, GASOLINE:DELIVERY). THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 120,000. UPDATED 5/7/09 *CN UPDATED 05/08/09.*JB
NHTSA ODI #10266049
103,000 miles · Jul 30, 2008
Fuel System, Gasoline
1. RAW SMELL OF GASOLINE INSIDE CAR INTERMITTENTLY. 2. GASOLINE LEAKING FROM PLASTIC LINE NEAR FUEL TANK ACCESS PORT ON TOP OF FUEL TANK. 3. NOT YET REPAIRED. TRYING TO FIND HOW TO REPAIR MYSELF. NO KNOWN ACCIDENT OR DAMAGE HISTORY ON THIS VEHICLE. *TR
NHTSA ODI #10236382
Mileage unknown · May 29, 2008
Fuel System, GasolineFire
ATTEMPTED TO START VEHICLE, VEHICLE WOULD NOT START. ATTEMPTED TO START VEHICLE SECOND TIME, JUMP START, VEHICLE CAUGHT FIRE. *TR
NHTSA ODI #10229219
105,367 miles · May 4, 2008
Fuel System, GasolineFire
WHILE EXITING THE INTERSTATE RAMP WHERE I LIVE (I-64/NITRO, WV) I HEARD A "POP" SOUND, THEN NOTICED AN ORANGE FLAME COMING FROM UNDER THE HOOD, AND OUT OF THE DRIVER'S SIDE FENDER. AT THIS POINT, I BRAKED TO PULL OFF ONTO THE SHOULDER, BUT LOST ALL BRAKES. (BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR) NO CARS WERE IN FRONT OF ME,…
Read full complaint
WHILE EXITING THE INTERSTATE RAMP WHERE I LIVE (I-64/NITRO, WV) I HEARD A "POP" SOUND, THEN NOTICED AN ORANGE FLAME COMING FROM UNDER THE HOOD, AND OUT OF THE DRIVER'S SIDE FENDER. AT THIS POINT, I BRAKED TO PULL OFF ONTO THE SHOULDER, BUT LOST ALL BRAKES. (BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR) NO CARS WERE IN FRONT OF ME, AND I WAS ABLE TO ROLL INTO AN INTERSECTION WHERE A TRUCK DRIVER ATTEMPTED TO PUT OUT THE FIRE WITH AN EXTINGUISHER TO NO AVAIL. THE FIRE DEPARTMENT PUT OUT THE FIRE, BUT THE CAR IS A TOTAL LOSS. THANK GOD MY CHILDREN WERE NOT IN THE CAR! *TR
NHTSA ODI #10226604
70,000 miles · Jul 2, 2007
Fuel System, GasolineFire
2001 PONTIAC BACKFIRED AND CAUGHT ON FIRE. I WAS CLEANING MY CAR WITH RADIO ON THAT KILLED MY BATTERY. I HAVE ONSTAR SO I CALLED FOR JUMP. ROADSIDE ASSISTANCE CAME OUT TO JUMP MY CAR. HE JUMPED PROPERLY. WHEN HE TURNED THE KEY VEHICLE BACKFIRED AND CAUGHT ON FIRE. ENGINE NEVER STARTED. *TR
NHTSA ODI #10195160
31 miles · Feb 8, 2007
Engine And Engine CoolingFuel System, Gasoline
I HAVE HAD A STEERING PROBLEM SINCE I PURCHASED MY 2001 BONNEVILLE SE. I HAVE A DOCUMENT ID #01-02-32-001A THAT STATES 2000-2002 PONTIAC BONNEVILLE HAS A CLUNK NOISE FROM FRONT OF STEERING WHEEL ROTATION (LUBRICATE INTERMEDIATE SHAFT). AFTER MONTHS OF GETTING A RUN-AROUND DUKE PONTIAC IN SUFFOLK VA FINALLY DIAGNOSED MY PROBLEM …
Read full complaint
I HAVE HAD A STEERING PROBLEM SINCE I PURCHASED MY 2001 BONNEVILLE SE. I HAVE A DOCUMENT ID #01-02-32-001A THAT STATES 2000-2002 PONTIAC BONNEVILLE HAS A CLUNK NOISE FROM FRONT OF STEERING WHEEL ROTATION (LUBRICATE INTERMEDIATE SHAFT). AFTER MONTHS OF GETTING A RUN-AROUND DUKE PONTIAC IN SUFFOLK VA FINALLY DIAGNOSED MY PROBLEM AND LUBRICATED THE SHAFT ON 03/01/02. THE NOISE STOPPED FOR ABOUT A YEAR OR SO AND HAS BEEN GETTING WORSE. IT NOW FEELS LIKE THE CAR HAS A SAFETY ISSUE BECAUSE IT IS HARD TO CONTROL AT LOW OR HIGHER SPEEDS. I WAS ADVISED BY PERRY BUICK -PONTIAC 10/05/06 THAT THE NOISE I'M HEARING IS FROM THE INTERMEDIATE SHAFT. I ALSO EXPERIENCED LOW FLUID LEVELS THAT WAS DETECTED ON 8-16-05 WHEN I GOT AN OIL CHANGE FROM TUNE UP PLUS. I THEN WENT TO PERRY BUICK-PONTIAC AND WAS CHARGED $376.62 TO REPLACE UPPER INTAKE MANIFOLD AND THE WORK ORDER WAS NOTED THAT THE COOLANT RESERVOIR WAS EMPTY. AFTER INVESTIGATING I FOUND THAT THERE WAS A NOTICE IN 2003 THAT PERTAINS TO ENGINE COOLANT LEAK AT THE UPPER INTAKE MANIFOLD TO THROTTLE BOBY GASKET. IT STATES THAT THE CONDITION COULD RESULT IN LOW ENGINE COOLANT LEVEL AND HIGHER ENGINE TEMPERATURE. I FEEL THAT GENERAL MOTORS SHOULD REPLACE THE INTERMEDIATE SHAFT BECAUSE I STILL OWN THE CAR AND AM HAVING THE SAME PROBLEM THAT I FEEL IS A THREAT TO MY SAFETY AND TO THOSE WHO RIDE WITH ME. I ALSO FEEL THAT GENERAL MOTORS SHOULD REIMBURSED ME THE $376.62 THAT I PAID 8-18-05 TO HAVE THE MANIFOLD REPLACED. I ALSO HAD A FUEL LEAK OCT 5,20005 AND AM NOT SURE IF THAT WAS NOT RELATED TO THE PROBLEM AFOREMENTIONED. *JB
NHTSA ODI #10182041
91,000 miles · Apr 1, 2005
Fuel System, GasolineFire
MY WIFE STARTED THE CAR TO LET IT WARM UP WHILE IT WARMED UP SHE WENT BACK INTO THE HOUSE TO GET THE KIDS AS SHE WAS COMING OUT OF THE HOUSE SHE HEARD A BOOM THINKING IT WAS A RADIATOR HOSE SHE STARTED TO OPEN THE HOOD WHEN SHE DID THAT FLAMES SHOT OUT FROM UNDER THE HOOD SO SHE CALLED THE FIRE DEPARTMENT A COUPLE OF NEIGHBORS …
Read full complaint
MY WIFE STARTED THE CAR TO LET IT WARM UP WHILE IT WARMED UP SHE WENT BACK INTO THE HOUSE TO GET THE KIDS AS SHE WAS COMING OUT OF THE HOUSE SHE HEARD A BOOM THINKING IT WAS A RADIATOR HOSE SHE STARTED TO OPEN THE HOOD WHEN SHE DID THAT FLAMES SHOT OUT FROM UNDER THE HOOD SO SHE CALLED THE FIRE DEPARTMENT A COUPLE OF NEIGHBORS CAME OUT WITH FIRE EXSTINGUISURES AND TRIED TO PUT OUT THE FIRE SHORTLY AFTER THAT THE CAR TRIED TO START IT SELF USING THE REMOTE STARTER SYSTEM AND OF COURSE THE FLAMES SHOT UP DUERING THIS ATTEMPT BY THE TIME THE FIRE DEPT GOT THIER THE FRONT OF THE CAR WAS COMPLETELY INGOLFED IN FLAMES THEY PUT OUT THE FIRE BUT NOT IN TIME TO SAVE THE CAR.*AK
NHTSA ODI #10116216
60,000 miles · Oct 25, 2004
Engine And Engine CoolingFuel System, Gasoline
WHILE DRIVING AT ANY SPEED VEHICLE STALLED WHEN GETTING READY TO STOP OR MAKE A TURN. *AK
NHTSA ODI #10097658
NHTSA investigations
2EA07008 · Engine Compartment Fire
Opened Jun 12, 2007 · Closed May 1, 2008
Status: closed (inferred from source dates) · Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (2)
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Engine And Engine Cooling
BY LETTER DATED MARCH 12, 2008, GENERAL MOTORS CORP. (GM) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (IDENTIFIED BY NHTSA RECALL NUMBER 08V-118) TO ADDRESS A DEFECT IN APPROXIMATELY 207,542 MODEL YEAR (MY) 1997-2003 BUICK REGAL GS AND PONTIAC GRAND PRIX GTP VEHICLES EQUIPPED WITH THE L67 SUPERCHARGED VERSION OF GM'S 3800 SERIES II V6 ENGINE.THE RECALLED REGAL GS VEHICLES WERE BUILT FROM AUGUST 1996 TO JUNE 2003 AND THE GRAND PRIX GTP FROM MARCH 1996 THROUGH JANUARY 2003.ACCORDING TO GM, OIL MAY ESCAPE PAST THE VALVE COVER GASKET ON THE FRONT CYLINDER BANK (CYLINDERS 1-3-5) AND DEPOSIT ONTO HOT EXHAUST SYSTEM COMPONENTS.UNDER CERTAIN CONDITIONS, IT IS POSSIBLE FOR THIS OIL TO IGNITE A SMALL PILOT FLAME, WHICH MAY SPREAD TO THE ADJACENT PLASTIC SPARK PLUG WIRE CHANNEL, THE SPARK PLUG WIRES THEMSELVES, THE PLASTIC ENGINE COVER, AND OTHER UNDER HOOD COMPONENTS.REPORTS INDICATE THIS MOST OFTEN OCCURS ON HIGHER-MILEAGE VEHICLES SHORTLY AFTER THE VEHICLE HAS BEEN DRIVEN AND THEN PARKED.TYPICALLY, THE FIRE WAS DISCOVERED WITHIN 5 TO 15 MINUTES AFTER THE VEHICLE WAS PARKED.DURING THIS TIME WINDOW, UNDER HOOD TEMPERATURES MAY BECOME ELEVATED.SUCH ELEVATED TEMPERATURES COMBINED WITH A LACK OF AIRFLOW THROUGH THE ENGINE COMPARTMENT MAY PERMIT A SMALL PILOT FLAME TO PROPAGATE AND IGNITE OTHER FUEL SOURCES.TO CORRECT THE SAFETY DEFECT, GM WILL INSTALL AN IMPROVED DESIGN FRONT VALVE COVER GASKET AND SPARK PLUG WIRE RETAINER.THIS REMEDY WILL BE SUPPLIEDFREE OF CHARGE FOR ALL RECALLED VEHICLES.UNTIL SUFFICIENT PARTS BECOME AVAILABLE TO REPAIR ALL OF THE AFFECTED VEHICLES, GM STRONGLY RECOMMENDS THAT OWNERS OBSERVE THE FOLLOWING IMPORTANT PRECAUTIONS: (1) THEY STRONGLY RECOMMEND THAT OWNERS DO NOT PARK THEIR VEHICLE IN A GARAGE, CARPORT, OR OTHER STRUCTURE; (2) IF OWNERS NOTICE A BURNING ODOR, THEY SHOULD HAVE THEIR DEALER INSPECT THE VEHICLE - THE DEALER WILL INSPECT THE VEHICLE WITHOUT CHARGE; AND (3) USE PREMIUM FUEL (91 OCTANE OR HIGHER) IN THE VEHICLE AS RECOMMENDED IN THE VEHICLE'S OWNER MANUAL.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE SUBJECT FIRE INCIDENT RATE ON THE C-, G-, AND H-PLATFORM SUBJECT VEHICLES IS LOW.THE AGENCY WILL CONTINUE TO MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration