IllustrationVEHICLE'S PASSENGER FRONT WHEEL CAME OFF DAMAGING THE FRONT FENDER AND DOOR.*MR WHILE DRIVING THE PASSENGER SIDE FRONT TIRE TO CAME OFF DUE TO BROKEN STUDS. THE VEHICLE SUSTAINED DAMAGE TO THE PASSENGER SIDE FENDER AND DOOR (OHIO TRAFFIC CRASH REPORT). *NM
1997 Pontiac Bonneville
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Bonneville years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
20–25K
325–50K
750–75K
875–100K
14100–150K
3150K+
37 reports with mileage · 110 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 50 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports16 fire reports6 injury reports
What owners actually said
147 reportsVEHICLE FAILED TO START. UPON OPENING HOOD CONSUMER NOTICED THAT THE BATTERY TERMINAL POST CAME OFF, AND ACID WAS LEAKING OUT.*AK
WHILE DRIVING AT NORMAL SPEED DRIVER BEGAN TO SEE SMOKE COMING FROM THE VEHICLE. DRIVER PROCEEDED TO DRIVE HOME, AND PARKED VEHICLE. A MECHANIC STATED THAT THERE WAS A WHOLE IN THE PLENUM THAT ALLOWED WATER TO LEAK AND WARP THE HEADS. *AK
THE VEHICLE STALLED ON SEVERAL OCCASIONS, THE VEHICLE WAS TAKEN TO THREE DIFFERENT DEALERS AND THEY ALL STATED THE COMPUTER SHOWED NO ERRORS. *JB *SCC *JB
A BLOCK FROM HOME OUR ENGINE SHUT DOWN. THE UPPER MANIFOLD HAD A HOLE IN IT DUE TO THE MANIFOLD BEING PLASTIC, AND CRYSTALIZING OVER A PERIOD OF TIME. IT COST US $729.00 TO GET IT FIXED. LUCKILY OUR ENGINE WASN'T HOT OR WE WOULD HAVE HAD MORE SERIOUS PROBLEMS.*AK
CONSUMER STATED WHILE DRIVING VEHICLE AT 25 MPH SUDDENLY ALL ELECTRICAL COMPONENTS DIED. NO BRAKES/ NO POWER STEERING. TOOK VEHICLE TO DEALER, DEALER POPPED HOOD, AND NOTICED BATTERY ACID ALL OVER THE ENGINE COMPARTMENT, AND BATTERY CABLES WERE LOOSE. DEALER REPLACED CABLES, AND PUT JELLY AROUND THEM. FIVE DAYS LATER, CABLES W…
Read full complaint
CONSUMER STATED WHILE DRIVING VEHICLE AT 25 MPH SUDDENLY ALL ELECTRICAL COMPONENTS DIED. NO BRAKES/ NO POWER STEERING. TOOK VEHICLE TO DEALER, DEALER POPPED HOOD, AND NOTICED BATTERY ACID ALL OVER THE ENGINE COMPARTMENT, AND BATTERY CABLES WERE LOOSE. DEALER REPLACED CABLES, AND PUT JELLY AROUND THEM. FIVE DAYS LATER, CABLES WERE LOOSE AGAIN. CAUSE UNKNOWN. THE CABLE HAS LOOSEN AGAIN AND VEHICLE STALLED AND LOST ALL POWER. CONSUMER WAS LEFT STRANDED. *AK
WHILE DRIVING A 100 MILES FROM HOME THE CAR OVERHEATED & HAD TO BE TOWED. WE FOUND THAT THE PROBLEM WAS DUE TO A HOLE IN THE AIR PLENUM IN THE UPPER INTAKE MANIFOLD. WE HAVE FOUND THAT THERE ARE OVER 20 SUCH CASES IN OUR SMALL COMMUNITY ALONE. ALL ON 3800 MOTORS IN PONTIAC'S. THIS IS A FOUR HUNDRED DOLLAR REPAIR BILL THAT OCC…
Read full complaint
WHILE DRIVING A 100 MILES FROM HOME THE CAR OVERHEATED & HAD TO BE TOWED. WE FOUND THAT THE PROBLEM WAS DUE TO A HOLE IN THE AIR PLENUM IN THE UPPER INTAKE MANIFOLD. WE HAVE FOUND THAT THERE ARE OVER 20 SUCH CASES IN OUR SMALL COMMUNITY ALONE. ALL ON 3800 MOTORS IN PONTIAC'S. THIS IS A FOUR HUNDRED DOLLAR REPAIR BILL THAT OCCURRED ONLY BECAUSE PONTIAC DECIDED TO USE PLASTIC IN THEIR PART WHICH IN TURN MELTED & CAUSED OUR MOTOR TO OVERHEAT. I HOPE THAT PONTIAC WILL RECALL THESE PLENUMS & REIMBURSE US FOR THE COST OF REPAIRING & TOWING OUR CAR. IF PONTIAC WOULD CALL THEIR DEALERS THEY WOULD FIND OUT JUST HOW MANY OF THESE PARTS HAVE MALFUNCTIONED. *JB
WHILE ROTATING MY TIRES, I NOTICED THAT THE RIGHT SIDE STABILIZER BAR WAS NOT CONNECTED TO THE LOWER CONTROL ARM. THE LINK BOLT AND BUSHING WERE MISSING. I PURCHASED A NEW ASSEMBLY FROM PONTIAC DEALER AND INSTALLED. *TT
TRANSMISSION BUMPS AND JERKS AT SPEEDS OVER 30 MPH. USUALLY WHEN CLIMBING A HILL. SOLUTION...LET OFF THE GAS FOR A SECOND AND RE APPLY TO STOP THE BUCKING TEMPORARILY. ALSO HAPPENED TO MY 92 BONNEVILLE WHICH HAD THE ORIGINAL TRANSMISSION THAT NEVER FAILED WITH OVER 180,000 MILES ON IT, BESIDES THE BUCKING. *NLM
LOSS OF COOLANT. PLASTIC AIR INTAKE MOUNTED ON TOP OF INTAKE MANIFOLD FAILED LEAKING COOLANT UNDER PRESSURE INTO COMBUSTION CHAMBER. TALKED TO SEVERAL LICENSED TECHNICIANS IN THE AREA AND THEY STATE THAT THIS IS A COMMON PROBLEM. REQUIRES REPLACEMENT OF AIR INTAKE. $275 & LABOR. *NLM
Official recalls
196V196000 · Seats
Oct 8, 1996
THE SEAT COVER TRIM MATERIAL DOES NOT MEET THE FLAMMABILITY REQUIREMENTS OF FMVSS NO. 302, "FLAMMABILITY OF INTERIOR MATERIALS."
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WERE PRESENT, A VEHICLE INTERIOR FIRE CAN OCCUR.
Remedy: DEALERS WILL REPLACE THE COVERS ON THE FRONT SEAT BACKS, REAR SEAT CUSHION AND REAR SEAT BACK ASSEMBLIES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.