IllustrationDT*: THE CONTACT STATED A LEAK IN THE BRAKE LINE WAS DISCOVERED AND RESULTED IN THE VEHICLE BEING TAKEN TO AN INDEPENDENT MECHANIC. AFTER FURTHER INSPECTION IT WAS DETERMINED THE BRAKE AND FUEL LINES WERE RUSTED AND REQUIRED REPLACEMENT. *NM UPDATED 02/21/06. *JB
1996 Pontiac Bonneville
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Bonneville years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
20–25K
325–50K
750–75K
1175–100K
26100–150K
14150K+
63 reports with mileage · 87 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports7 fire reports14 injury reports
Service Brakes, Hydraulic complaints
7 reportsBRAKE LINES ON 1996 PONTIAC BONNIVILLE ARE RUSTED THROUGH AND ALLOWED THE FLUID TO LEAK OUT CAUSING CATASTROFIC LOSS OF BRAKING OF AUTOMOBILE.*AK
ABS LIGHT CAME ON, WHEN APPLYING BRAKES VEHICLE DID NOT STOP ON WET PAVEMENT. TOOK VEHICLE TO DEALER WHO INDICATED THAT ABS COMPUTER MALFUNCTIONED.*AKSENSOR FAILED ALSO. *JG
IMPROPERLY INSTALLED TRANSMISSION CABLE TORE THROUGH THE BRAKE LINE CAUSING LOSS OF FLUID.
COMING DOWN A HILL AT APPROX 5 MPH , STARTED TO APPLY PRESSURE ON BRAKES, SMELLED GAS FUMES AND NOTICED SMOKE. TIRE WERE ALSO EXTREMELY HOT. *AK
ABS BRAKE SYSTEM , APPLIED THE BRAKES AND THE PEDAL WENT THE FLOOR, IMPACT 12:00 POSITION, SPEED 35 MPH, APPLIED THE BRAKES ON WET SURFACE, COMPLETE LOSS OF BRAKES. HIT ONE VEHICLE AND KNOCKED INTO ANOTHER ONE. *AK
ANTILOCK BRAKES FAILED 6 TIMES.
Official recalls
296V116000 · Fuel System, Gasoline:fuel Injection System
Jul 1, 1996
A BACKFIRE DURING ENGINE STARTING CAN CAUSE BREAKAGE OF THE UPPER INTAKE MANIFOLD.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A NO-START CONDITION AND POSSIBLY AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL UPDATE THE POWERTRAIN CONTROL MODULE PROGRAMMING. UNTIL THE CAMPAIGN REPAIR IS MADE, THE VEHICLE HOOD SHOULD BE SHUT WHENEVER STARTING THE VEHICLE TO REDUCE THE CHANCE OF PERSONAL INJURY.
95V204000 · Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module
Oct 23, 1995
THESE VEHICLES WERE ASSEMBLED WITH A MALFUNCTION ALARM, LIGHTING AND LOCKING (MALL) MODULE THAT CAN CONTAIN A DAMAGED CAPACITOR. IF THE CAPACITOR IS DAMAGED, THE "KEY IN THE IGNITION" WARNING CHIME AND THE DRIVER SEAT BELT UNBUCKLED WARNING CHIME AND INDICATOR LAMP MAY NOT WORK. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION" AND FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." IN ADDITION, OTHER CHIME REMINDER FUNCTIONS, INTERIOR LIGHTING CONTROLS, AND POWER DOOR LOCKING FEATURES ARE ALSO AFFECTED.
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE; THE DRIVER MAY NOT BE AWARE THAT THE KEY WAS LEFT IN THE IGNITION OR THAT THE SAFETY BELT WAS NOT BUCKLED.
Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, REPLACE THE MALL MODULE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE02050 · Engine Compartment Fires
Opened Jun 13, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.