Illustration5/04 CONDENSER REPLACED UNDER WARRANTY 7/05 CONDENSER AGAIN RIPPED NOT UNDER WARRANTY 5 TIMES MY HUB WAS REPLACED THAT HOLDS THE BEARINGS IN THE WHEELS. *NM
2002 Pontiac Aztek
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Pontiac Aztek do not stand out strongly from the model-year median of 121.
About this comparison →How this year compares
Owner complaints by model year
Compare all Aztek years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
1925–50K
1950–75K
1575–100K
12100–150K
5150K+
85 reports with mileage · 36 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports1 fire reports2 injury reports
What owners actually said
121 reportsTHE HEADLIGHTS HAVE SUDDENLY STOPPED WORKING WHEN THE STEERING WHEEL TILT IS IN THE LOWEST 2 POSITIONS. I CALLED GM TO SEE IF THERE WAS A SERVICE ADVISORY FOR THIS AND THEY SAID NO. THEY ADVISED I TAKE IT TO THE DEALERSHIP FOR DIAGNOSIS WHICH WILL COST AT LEAST $90. *JB
DT: THE VEHICLE WAS OVERHEATING TO THE POINT TO WHERE CONSUMER ACTUALLY HAD TO PULL OFF THE ROAD. THE DEALER TOLD HER THAT THERE WAS A INTERNAL LEAK IN THE INTAKE MANIFOLD GASKET. SHE HAS DONE RESEARCH AND FOUND THAT THIS IS WAS COMMON PROBLEM FOR THE TYPE OF ENGINE AND MODEL THAT SHE OWNED. ALSO, WHILE DOING RESEARCH SHE LEA…
Read full complaint
DT: THE VEHICLE WAS OVERHEATING TO THE POINT TO WHERE CONSUMER ACTUALLY HAD TO PULL OFF THE ROAD. THE DEALER TOLD HER THAT THERE WAS A INTERNAL LEAK IN THE INTAKE MANIFOLD GASKET. SHE HAS DONE RESEARCH AND FOUND THAT THIS IS WAS COMMON PROBLEM FOR THE TYPE OF ENGINE AND MODEL THAT SHE OWNED. ALSO, WHILE DOING RESEARCH SHE LEARNED THAT THIS PROBLEM WAS OCCURRING BETWEEN 60,000-80,000 MILES. SHE FOUND TWO WEBSITES WITH COMPLAINTS FROM OTHER AZTEK OWNERS.*AK IN ADDITION, WHEN COMING TO A STOP, THE HEAT STOPPED COMING FROM THE DASH VENTS. DEALERSHIP PURGED AN AIR POCKET FOUND IN THE COOLING SYSTEM. THE CONSUMER AND MANUFACTURER WAS ABLE TO COME TO SOME SORT OF COMPROMISE REGARDING THE COST OF REPLACING THE INTAKE MANIFOLD GASKET.*TT *SB
THE PROBLEM WAS WITH THE DRIVERS SIDE REAR KNUCKLE ON THE 2002 AZTEC. THE CONSUMER HEARD CLUNKING COMING FROM REAR WHEN HITTING BUMPS. THE VEHICLE WAS TAKEN TO THE DEALER, WHO ADVISED THE CONSUMER THAT THERE WAS A BUSHING FAILURE. THIS CAUSED A FORWARD/BACKWARD MOVEMENT OF THE DRIVER'S SIDE REAR TIRE 1 1/2-3 INCHES. AFTER FU…
Read full complaint
THE PROBLEM WAS WITH THE DRIVERS SIDE REAR KNUCKLE ON THE 2002 AZTEC. THE CONSUMER HEARD CLUNKING COMING FROM REAR WHEN HITTING BUMPS. THE VEHICLE WAS TAKEN TO THE DEALER, WHO ADVISED THE CONSUMER THAT THERE WAS A BUSHING FAILURE. THIS CAUSED A FORWARD/BACKWARD MOVEMENT OF THE DRIVER'S SIDE REAR TIRE 1 1/2-3 INCHES. AFTER FURTHER DISCUSSION, THE DEALER WOULD NOT COOPERATE IN THE PURCHASE OF THE PART/LABOR. THE PROBLEM IS PROGRESSIVE. THE VEHICLE IS REGULARLY MAINTAINED AND SERVICE RECORDS ARE AVAILABLE. *AK *SC *JB
DT: CONSUMER SAYS BODY MODULE HAS BLOWN THREE TIMES ON VEHICLE. CONSUMER WAS ON PARKWAY WHEN BODY MODULE BLEW OUT, AND VEHICLE AND EVERYTHING ON CAR SHUT DOWN. ENGINE STOPPED, ALL LIGHTS STARTED BLINKING, THE HATCH POPPED. THE BODY MODULE BLEW AT 7000 MILES/AT 17000 MILES, AND AGAIN AT 27000 MILES. VEHICLE WAS TAKEN TO DEALER …
Read full complaint
DT: CONSUMER SAYS BODY MODULE HAS BLOWN THREE TIMES ON VEHICLE. CONSUMER WAS ON PARKWAY WHEN BODY MODULE BLEW OUT, AND VEHICLE AND EVERYTHING ON CAR SHUT DOWN. ENGINE STOPPED, ALL LIGHTS STARTED BLINKING, THE HATCH POPPED. THE BODY MODULE BLEW AT 7000 MILES/AT 17000 MILES, AND AGAIN AT 27000 MILES. VEHICLE WAS TAKEN TO DEALER THREE TIMES AND BODY MODULE WAS REPLACED. FIRST TWO TIMES MODULE BLEW WAS AT NIGHT, THE THIRD WAS DURING THE DAY. ALSO, CONSUMER SAYS THAT SHE IS HAVING PROBLEM WITH FUEL TANK POPPING. TANK IS CONTRACTING OR EXPANDING, AND NOTHING IS RELIEVING THE PRESSURE SLOWLY. SO WHEN THE PRESSURE CHANGES QUICKLY IT CAUSED NOISE. CONSUMER SAYS THIS IS DANGEROUS AND CAN CAUSE AN EXPLOSION. *AK
MY VEHICLE HAS REPEATEDLY OVER HEATED SO THAT I HAVE TO PULL OVER ON THE INTERSTATE, AFTER HAVING THE THERMOSTAT REPLACED, THE VEHICLE CONTINUED TO OVER HEAT SO THEREFORE I TOOK IT TO THE DEALERSHIP WHERE PURCHASE. I WAS TOLD I HAVE A LEAK IN THE MANIFOLD GASGET. WHILE ONLINE RESEARCHING THIS PROBLEM I CAME UPON A WEBSITE THAT …
Read full complaint
MY VEHICLE HAS REPEATEDLY OVER HEATED SO THAT I HAVE TO PULL OVER ON THE INTERSTATE, AFTER HAVING THE THERMOSTAT REPLACED, THE VEHICLE CONTINUED TO OVER HEAT SO THEREFORE I TOOK IT TO THE DEALERSHIP WHERE PURCHASE. I WAS TOLD I HAVE A LEAK IN THE MANIFOLD GASGET. WHILE ONLINE RESEARCHING THIS PROBLEM I CAME UPON A WEBSITE THAT INDICATED THAT A LEAKING MANIFOLD GASGET IS A COMMOM PROBLEM WITH MY TYPE OF VEHICLE ALONG WITH OTHER TYPES MADE BY GM
ANTILOCK BRAKE SYSTEM FAILS AT LOW SPEEDS AND STOPING DISTANCE IS LONGER THAN WHEN OPERATING. NO ACCIDENT YET AND AFTER 2 REPAIR ATTEMPTS ITS GETTING WORSE
DT: THE RIGHT AIR CONDITIONER CONDENSOR, NEAR THE BOTTOM, IS CRACKED ALONG THE BOTTOM. TOOK TO THE DEALER AND HE HAS SEEN OTHER ONES SIMILAR ON THE AZTEC AND THE MONTERO.*AK
RIGHT FRONT HUB FAILURE. HAD TO BE REPLACED BY DEALER AS NON WARRANTY, VEHICLE STARTED MAKING LOUD WHINNING NOISES THAT WOULD GO UP AND DOWN WHEN CAR WAS GOING OVER 25 MPH. DEALER SAID THIS WAS COMMON FOR THIS CAR. *AK
TWO WHEEL BEARINGS HAVE FAILED ON MY 2002 PONTIAC AZTEK BEFORE 50,000 MILES. FORTUNATELY I RECOGNIZED THE NOISE BEFORE ANYTHING TRAGIC HAPPENED. PONTIAC REPLACED THE FIRST ONE UNDER WARRANTY, BUT DECLINED TO OFFER ANY ASSISTANCE WITH THE BEARING NOT UNDER WARRANTY. HOW OFTEN WILL THESE GO BAD AND SHOULD I TRUST THEM?*AK
Official recalls
207V349000 · Fuel System, Gasoline:storage
Aug 8, 2007
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Consequence & remedy
Consequence: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
03V250000 · Equipment:other:owners/service/other Manual
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA07006 · Fuel Tank Leakage
Opened Apr 18, 2007 · Closed Sep 13, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (5)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
RQ06009 · Fuel Tank Leakage
Opened Dec 14, 2006 · Closed Apr 18, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Additional source detail variants (4)
Fuel System, Gasoline
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage:tank Assembly
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.