IllustrationFUEL GAUGE STOPPED WORKING/SHOWED FULL ALL THE TIME. I WAS TOLD THAT THE FUEL LEVEL SENSOR HAD GONE BAD.*AK
2001 Pontiac Aztek
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2001 Pontiac Aztek do not stand out strongly from the model-year median of 121.
About this comparison →How this year compares
Owner complaints by model year
Compare all Aztek years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
160–25K
2625–50K
3250–75K
2375–100K
16100–150K
7150K+
120 reports with mileage · 96 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports6 fire reports15 injury reports
What owners actually said
216 reportsAIR CONDITIONER STOPPED WORKING. I WAS TOLD THAT THE COMPRESSOR CASE CRACKED AND LEAKED ALL THE COOLANT.*AK
ENGINE BEGAN TO LEAK ANTIFREEZE. I WAS TOLD IT WAS A LEAKING HEAD GASKET. THE GASKET WAS CRACKED AND DEFECTIVE. THIS HAPPENED AT 80,000 MI. I HAVE THE PARTS.*AK
WHILE PULLING INTO A DRIVEWAY VEHICLE ACCELERATED. CONSUMER HAD TO APPLY THE EMERGENCY BRAKE IN ORDER TO STOP THE VEHICLE. *AK THE IGNITION WOULDN'T TURN ON, THE REAR HATCH WOULD NOT OPEN, THE COMPUTER SYSTEM HAD BLOWN OUT, THERE WERE NUMEROUS ELECTRICAL PROBLEMS, AND THE TIRE EXPLODED. *SC
I PURCHASED MY VEHICLE ON 7-23-04 AND HAVE ONLY BEEN ABLE TO DRIVE IT A TOTAL OF APPROX 2 WEEKS NOW. THE TRANSMISSION STARTED SLIPPING WHILE CHANGING GEARS FROM 2ND TO 3RD AND AFTER A COUPLE DAYS OF THIS, IT FINALLY STARTED SLIPPING REAL BAD TAKING OFF FROM A STOP SIGN OR RED LIGHT. I HAVE TAKEN IT TO A TRANSMISSION SHOP 5 TIMES…
Read full complaint
I PURCHASED MY VEHICLE ON 7-23-04 AND HAVE ONLY BEEN ABLE TO DRIVE IT A TOTAL OF APPROX 2 WEEKS NOW. THE TRANSMISSION STARTED SLIPPING WHILE CHANGING GEARS FROM 2ND TO 3RD AND AFTER A COUPLE DAYS OF THIS, IT FINALLY STARTED SLIPPING REAL BAD TAKING OFF FROM A STOP SIGN OR RED LIGHT. I HAVE TAKEN IT TO A TRANSMISSION SHOP 5 TIMES NOW AND THEY ARE NOW GOING TO JUST REPLACE THE UNIT.*AK
TRANSMISSION FAILED AT 56000 MILES NO INDICATION OF ANY PROBLEMS , JUST STARTED MAKING NOISE ALL OF A SDDEN. TOOK IT TO DEALER GOT $3900.00 ESTIMATE FOR TRANSMISSION INTAKE MANIFOLD & DRIVESHAFT. *AK
A/C CONDENSER HAS A LEAK ON THE RIGHT HAND SIDE, BOTTOM CORNER. VEHICLE HAD JUST 47,200 MILES. IT APPEARS THIS IS A FREQUENT FAILURE (6 REPLACEMENTS LISTED NHTSA COMPLAINTS AND 3 WEB SITES WITH OVER 18 IDENTICAL COMPLAINTS). ONE SOURCE STATED THAT IT APPEARED TO BE CAUSED BY MANUFACTURE PROCESS IN WHICH INSUFICENT WELD PROC…
Read full complaint
A/C CONDENSER HAS A LEAK ON THE RIGHT HAND SIDE, BOTTOM CORNER. VEHICLE HAD JUST 47,200 MILES. IT APPEARS THIS IS A FREQUENT FAILURE (6 REPLACEMENTS LISTED NHTSA COMPLAINTS AND 3 WEB SITES WITH OVER 18 IDENTICAL COMPLAINTS). ONE SOURCE STATED THAT IT APPEARED TO BE CAUSED BY MANUFACTURE PROCESS IN WHICH INSUFICENT WELD PROCESS WAS USED CAUSING FAILURE DUE TO NORMAL VIBRATION BETWEEN 42,000 AND 60,000 MILES. THIS IS LISTED AS AN ALERT FOR CANADIAN COMSUMERS AS WELL SO I AM SURE IT IS A FREQUENT PROBLEM. *AK
PURCHASED A 2001 PONTIAC AZTEK ON JUNE 19 2004 FROM A CHEVROLET DEALER..ON AUGUST 3 2004 HAD A BLOWOUT AT 65 MPH ON THE FRONT PASSENGER SIDE..THE HEADLAMP AND FOG LIGHT HAD COMPLETELY CAME OUT.HAD IT TOWED TO DEALER,,THE SERVICE DEPT. SAID IT WAS CAUSED BY WORN TIRES...WHICH WERE FIRESTONE...STILL AWAITING DEALER TO REMEDY A SIT…
Read full complaint
PURCHASED A 2001 PONTIAC AZTEK ON JUNE 19 2004 FROM A CHEVROLET DEALER..ON AUGUST 3 2004 HAD A BLOWOUT AT 65 MPH ON THE FRONT PASSENGER SIDE..THE HEADLAMP AND FOG LIGHT HAD COMPLETELY CAME OUT.HAD IT TOWED TO DEALER,,THE SERVICE DEPT. SAID IT WAS CAUSED BY WORN TIRES...WHICH WERE FIRESTONE...STILL AWAITING DEALER TO REMEDY A SITUATION THAT SHOULD NOT OF OCCURRED AFTER ONLY 45 DAYS OF OWNERSHIP.*AK
TRANSMISSION FAILED SUDDENLY AND WITHOUT PRIOR WARNING IN TRAFFIC.*AK
AIR BAG LIGHT STAYED ILLUMINATED WHILE DRIVING. VEHICLE WAS INSPECTED BY THE DEALER, AND DEALER INFORMED THE CONSUMER THAT SIDE AIR BAG MODULE NEEDED TO BE REPLACED. *AK *LA
Official recalls
507V349000 · Fuel System, Gasoline:storage
Aug 8, 2007
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Consequence & remedy
Consequence: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
03V250000 · Equipment:other:owners/service/other Manual
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
02V329000 · Air Bags:frontal
Dec 9, 2002
ON CERTAIN PASSENGER, SPORT UTILITY VEHICLES AND MINI VANS, SOME OF THESE VEHICLES HAVE A PASSENGER AIR BAG THAT WAS MANUFACTURED WITHOUT A CHECK VALVE PIN. AN AIR BAG WITHOUT THE CHECK VALVE PIN COULD PRODUCE INCREASED PRESSURE AT THE ONSET OF THE AIR BAG DEPLOYMENT AND REDUCED PRESSURE AFTERWARD.
Consequence & remedy
Consequence: THIS COULD INCREASE THE SEVERITY OF INJURY TO A PERSON WHO WAS NOT PROPERLY RESTRAINED AND WHO WAS CLOSE TO THE PASSENGER AIR BAG AT THE TIME OF DEPLOYMENT. IT COULD ALSO REDUCE THE AB8ILITY OF THE AIR BAG TO PROTECT A RESTRAINED FRONT SEAT PASSENGER.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PASSENGER AIR BAG. OWNER NOTIFICATION BEGAN DECEMBER 16, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OLDSMOBILE AT 1-800-442-6537, OR SATURN AT 1-800-553-6000, PROMPT #3.
01V383000 · Seats:front Assembly:recliner
Dec 13, 2001
VEHICLE DESCRIPTION: CERTAIN MINI VANS BUILT WITH SECOND ROW 50/50 SPLIT BENCH SEATS OR CAPTAIN'S CHAIRS, FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SEAT LATCH ANCHOR WIRE DIAMETER IS GREATER THAN 6.1 MM.
Consequence & remedy
Consequence: IF THE CONNECTOR FOR A LATCH-TYPE CHILD RESTRAINT IS NOT ATTACHED CORRECTLY TO THE ANCHORAGE POINTS, THE RESTRAINT WILL NOT PROPERLY PROTECT A CHILD IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE LATCH ANCHOR WIRES AND REPAIR THOSE WITH AN IMPROPER DIAMETER. OWNER NOTIFICATION BEGAN APRIL 10, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
01V026000 · Air Bags:frontal
Feb 1, 2001
VEHICLE DESCRIPTION: PASSENGER, SPORT UTILITY VEHICLES AND MINIVANS. THE PASSENGER AIR BAG INFLATOR MODULES WERE BUILT WITHOUT THE CORRECT AMOUNT OF GENERANT, WHICH PRODUCES THE GAS THAT FILLS THE AIR BAG. SOME WERE BUILT WITH A DOUBLE LOAD OF GENERANT AND SOME WERE BUILT WITHOUT GENERANT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, A DOUBLE LOAD OF GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANT. A MODULE WITH NO GENERANT WOULD NOT INFLATE THE AIR BAG, AND THE OCCUPANTS COULD RECEIVE MORE SEVERE INJURIES.
Remedy: DEALERS WILL REPLACE THE PASSENGER AIR BAG MODULE. TELEPHONE CALLS WERE MADE TO OWNERS ON JANUARY 29, 2001. FOLLOW UP OWNER MAILING BEGAN ON APRIL 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR SATURN AT 1-800-553-6000.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA07006 · Fuel Tank Leakage
Opened Apr 18, 2007 · Closed Sep 13, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (5)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
GM IS RECALLING (NHTSA RECALL NO. 07V-349) CERTAIN MODEL YEAR (MY) 2002-2004 BUICK RENDEZVOUS, CHEVROLET VENTURE (REGULAR WHEELBASE) AND 2001-2004 PONTIAC AZTEK AND MONTANA (REGULAR WHEELBASE) VEHICLES TO REPLACE FUEL TANKS AND CORRECT A DEFECT THAT MAY ALLOW FUEL LEAKAGE.THE VEHICLE RECALL POPULATION IS RENDEZVOUS AND AZTEK VEHICLES BUILT IN MAY 2003, VENTURE AND MONTANA VEHICLE BUILT IN JUNE THROUGH AUGUST 2002 AND CERTAIN SAME MODEL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO AND HAWAII THAT WERE BUILT THROUGH NOV/DEC 2003 (DEPENDING ON MODEL).THE TOTAL NUMBER OF VEHICLES RECALLED IS 20,594 (INCLUDES 15,196 SUBJECT AZTEK AND RENDEZVOUS VEHICLES). IN ADDITION TO THE RECALL, GM WILL EXTEND THE WARRANTY ON MY 2002-2004 RENDEZVOUS AND REGULAR WHEEL BASE VENTURE VANS AND MY 2001-2004 AZTEK AND REGULAR WHEELBASE MONTANA VANS NOT INCLUDED IN THE RECALL TO PROVIDE WARRANTY COVERAGE FOR A PERIOD OF 10 YEARS OR 150,000 MILES, WHICHEVER OCCURS FIRST.GM WILL BEGIN NOTIFYING OWNERS IN DECEMBER 2007.GM REPORTS THAT THE FUEL INLET PIPE CONTAINING THE INLET CHECK VALVE (ICV) MAY FRACTURE AND ALLOW FUEL VAPORS OR FUEL TO LEAK OUT.GM DATA REVEALED THAT ELEVATED AMBIENT TEMPERATURES, HIGHER CARBON CONTENT IN THE ICV AND VARIATION IN THE MANUFACTURING PROCESS WERE THE CONTRIBUTING FACTORS FOR POTENTIAL CRACKS IN THE ICV.BEGINNING DECEMBER 2003, GM BUILT VEHICLES WITH A REDESIGNED FUEL TANK/ICV.SUBJECT VEHICLES NOT INCLUDED IN THE RECALL OR EXTENDED WARRANTY DID NOT SHOW A FAILURE TREND SIMILAR TO THE ABOVE VEHICLES..FOR ADDITIONAL DETAILS, SEE RECALL 07V-349.THIS INVESTIGATION IS CLOSED.
RQ06009 · Fuel Tank Leakage
Opened Dec 14, 2006 · Closed Apr 18, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Additional source detail variants (4)
Fuel System, Gasoline
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.
Fuel System, Gasoline:storage:tank Assembly
CERTAIN SUBJECT VEHICLES MAY EXHIBIT LEAKAGE OF ODOR AND/OR FUELFROM THE LOWER PORTION OF THE FUEL TANK INLET FILLER PIPE (INLET CHECK VALVE).THE INLET CHECK VALVE (ICV) AND THE FUEL TANK ARE JOINED TOGETHER USING A HOT PLATE WELDING PROCESS FOR PLASTIC PARTS.GM REPORTS THAT ITS ANALYSIS OF FIELD RETURNED PARTS SHOW EVIDENCE OF PROCESS VARIATIONS FOR DIFFERENT MANUFACTURING PERIODS.THESE VARIATIONS PRODUCED SOME ICV TO FUEL TANK JOINTS WITH POOR MELT FLOW LINES.ODI'S ANALYSIS OF GM'S WARRANTY CLAIM DATA FINDS MORE FREQUENT FUEL TANK REPLACEMENTS IN THE HOTTER CLIMATE STATES.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-006) TO FURTHER ASSESS THIS MATTER.