IllustrationDT: AIR CONDITIONER COMPRESSOR CUTS ON AND OFF INTERMITTENTLY. HAPPENS WHEN THE CAR IS IN MOTION AND WHILE PARKED. TAKEN TO MECHANIC, AND MECHANIC STATED THAT IT WAS A MANUFACTURING DEFECT.*AK
2000 Plymouth Voyager
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2000 Plymouth Voyager do not stand out strongly from the model-year median of 197.
About this comparison →How this year compares
Owner complaints by model year
Compare all Voyager years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
60–25K
2325–50K
2050–75K
1675–100K
14100–150K
3150K+
82 reports with mileage · 86 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 34 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
22 crash reports5 fire reports15 injury reports
What owners actually said
168 reportsWHILE DRIVING 60 MPH FRONTAL AIR BAG ON THE PASSENGER SIDE INADVERTENTLY DEPLOYED. CONSUMER SUSTAINED INJURIES, BUT WAS NOT TRANSPORTED TO THE LOCAL HOSPITAL. VEHICLE WAS NOT INSPECTED AT THIS TIME.*AK *TT THE CONSUMER RECEIVED CLOCKSPRING RECALL. IT'S UNCLEAR IF THE RECALL WAS RECEIVED BEFORE OR AFTER THE AIR BAG DEPLOYED I…
Read full complaint
WHILE DRIVING 60 MPH FRONTAL AIR BAG ON THE PASSENGER SIDE INADVERTENTLY DEPLOYED. CONSUMER SUSTAINED INJURIES, BUT WAS NOT TRANSPORTED TO THE LOCAL HOSPITAL. VEHICLE WAS NOT INSPECTED AT THIS TIME.*AK *TT THE CONSUMER RECEIVED CLOCKSPRING RECALL. IT'S UNCLEAR IF THE RECALL WAS RECEIVED BEFORE OR AFTER THE AIR BAG DEPLOYED INADVERTENTLY. *NM
FROM 7/31/03 UNTIL THE PRESENT I HAVE HAD THE WINDSHIELD COWLING REPLACE MORE THAN 13 TIMES BY CHRYLER. I OWN A 2000 VOYAGER. THE RUBBER GASKET CONTINUES TO SEPERATE - AT TIMES BLOWING UP ONTO THE DRIVER SIDE WINDSHIELD.*AK
VEHICLE WAS REAR ENDED WHILE AT A COMPLETE STOP. UPON IMPACT, BOTH FRONT SEAT BACKS SNAPPED AND COLLAPSED BACKWARDS, CAUSING THE DRIVER TO FALL BACKWARDS;HIS FOOT SLIPPING OFF THE BRAKE PEDAL. VEHICLE CAREENED ACROSS THE STREET ONTO A FIELD 150 FOOT AWAY. DRIVER WAS NOT INJURED. HOWEVER, THE PASSENGER WAS TAKEN TO THE HOSPI…
Read full complaint
VEHICLE WAS REAR ENDED WHILE AT A COMPLETE STOP. UPON IMPACT, BOTH FRONT SEAT BACKS SNAPPED AND COLLAPSED BACKWARDS, CAUSING THE DRIVER TO FALL BACKWARDS;HIS FOOT SLIPPING OFF THE BRAKE PEDAL. VEHICLE CAREENED ACROSS THE STREET ONTO A FIELD 150 FOOT AWAY. DRIVER WAS NOT INJURED. HOWEVER, THE PASSENGER WAS TAKEN TO THE HOSPITAL FOR EMERGENCY TREATMENT.*AK
CONSUMER HAD TO REPLACE THE HEADLIGHT SWITCH TWICE. THE LIGHTS WENT OUT WHILE THE VEHICLE WAS BEING DRIVEN. THEY COULD GO OUT WHILE BEING IN THE DARK.*AK THE CONSUMER STATED THAT HE HAD TO REPLACE THE IGNITION SWITCH. THE HEADLIGHT IS GOING BAD AGAIN. *TC
CHRYSLER VOYAGER 2000, IMPACT OF CRASH CAUSED THE SEAT OF DRIVER TO COLLAPSE ONTO BACK SEAT. *BF *JB
'RECALL CAMPAIGN' ISSUED FOR CLOCK SPRING ASSEMBLY ON PLYMOUTH VOYAGER 2000. *BF THE VEHICLE'S CLOCK SPRING FAILED AND THE CONSUMER PAID TO HAVE IT REPLACED PRIOR TO RECEIVING RECALL NOTIFICATION. THE CONSUMER REQUEST REIMBURSEMENT. *NM
THE BOLTS ON THE TAILGATE BROKE OFF, CAUSING IT TO FALL OF THE VEHICLE. MANUFACTURER WILL BE CONTACTED BY CONSUMER.*AK
2000 PLYMOUTH VOYAGER SE STARTED EMITTING A HORRIBLE, HORRIBLE ODOR FROM AC/HEATING VENTS. *BF THE A/C WAS NOT COOLING PROPERLY. THE CONSUMER WAS INFORMED THAT THE EVAPORATOR WAS LEAKING. *SC
THE TRANSMISSION GOES INTO GEAR WITHOUT DEPRESSING THE BRAKE. THE GUIDE PLATES HAD DAMAGING SPOTS. *TC THE BRAKES HAD EXCESSIVE CLEARANCE AND DAMAGED THE TRAILING EDGE. THE VEHICLE WOULD BE IN OPERATION AT A STOP ON A SLIGHT INCLINE, THE GEAR WAS IN DRIVE, WITH THE FOOT REMOVED FROM THE BRAKE AND THE VEHICLE WOULD ROLL BA…
Read full complaint
THE TRANSMISSION GOES INTO GEAR WITHOUT DEPRESSING THE BRAKE. THE GUIDE PLATES HAD DAMAGING SPOTS. *TC THE BRAKES HAD EXCESSIVE CLEARANCE AND DAMAGED THE TRAILING EDGE. THE VEHICLE WOULD BE IN OPERATION AT A STOP ON A SLIGHT INCLINE, THE GEAR WAS IN DRIVE, WITH THE FOOT REMOVED FROM THE BRAKE AND THE VEHICLE WOULD ROLL BACKWARDS; (THE SAME FOR REVERSE), THE LENS COVERS ON THE VEHICLE HAVE YELLOWED AND OR HAD BECOME OPAQUE. IN RE: 2000 CHRYSLER VOYAGER AND A 1998 PLYMOUTH GRAND VOYAGER *SC *JB
Official recalls
204V480000 · Air Bags
Oct 6, 2004
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available