IllustrationBRAKE FLUID LEAKS FROM THE MASTER CYLINDER RESERVOIR. DEALER REPLACED THE RESERVOIR ONCE BUT IT STILL LEAKS WHERE THE FILLER NECK MEETS THE RESERVOIR. DEALER CAN'T DO ANYTHING ELSE. MUST MAKE SURE FLUID LEVEL IS APPROX I/2 INCH BELOW 'FULL" MARKING ON RESERVOIR.*AK
2000 Plymouth Voyager
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2000 Plymouth Voyager do not stand out strongly from the model-year median of 197.
About this comparison →How this year compares
Owner complaints by model year
Compare all Voyager years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
60–25K
2325–50K
2050–75K
1675–100K
14100–150K
3150K+
82 reports with mileage · 86 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 34 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
22 crash reports5 fire reports15 injury reports
Service Brakes, Hydraulic complaints
14 reportsINTERMITTENTLY WHEN BRAKES ARE APPLIED PEDAL GOES TO THE FLOOR, CAUSING EXTENDED STOPPING DISTANCE. DEALER EXAMINED VEHICLE AND REPLACED BRAKES. HOWEVER, PROBLEM STILL EXISTS. *AK
RIGHT FRONT BRAKES DISENTEGRATED AT 11500 MILES, NOW EVERY 2000-3000 MILES, THE RIGHT FRONT BRAKES DISSOLVE, CONSUMER STATES THAT THE FRONT RIGHT ROTORS AND BRAKES NEED TO BE REPLACED, CONSUMER DOES NOT FEEL SAFE DRIVING VEHICLE. *SLC
HEARD LOUD GROWLING NOISE FROM BRAKES WHEN APPLIED,RIGHT FRONT BRAKE LOCKED WHEN BRAKES WERE APPLIED IN A PANIC STOP WAS TOLD BY DEALER THIS WAS NORMAL AS THE MEATERING DEVISE ON THE MASTER CYLINDER WOULD NOT GIVE A 50/50 AMOUNT OF PRESSURE TO THE FRONT BRAKES AT THE SAME TIME??????? I WAS SCHOCKED BY THIS STATEMENT,I FEEL AFT…
Read full complaint
HEARD LOUD GROWLING NOISE FROM BRAKES WHEN APPLIED,RIGHT FRONT BRAKE LOCKED WHEN BRAKES WERE APPLIED IN A PANIC STOP WAS TOLD BY DEALER THIS WAS NORMAL AS THE MEATERING DEVISE ON THE MASTER CYLINDER WOULD NOT GIVE A 50/50 AMOUNT OF PRESSURE TO THE FRONT BRAKES AT THE SAME TIME??????? I WAS SCHOCKED BY THIS STATEMENT,I FEEL AFTER 3 REPAIR ATTEMPTS THAT THE BRAKES FOER A 4,OOO LB VAN ARE TOO SMALL,THIS IS EVEDENT BY THE PAD SMELL AFTER DESENDING A MOUNTIAN ROAD AT A SLOW SPEED,ALSO THE BRAKE PEDAL FADES AFTER 6 STOP AND GO ATTEMPTS AT A SLOW SPEED,ALSO IN THE MORNING THE BRAKE PEDAL IS VERY HARD TO APPLY,THIS THE DEALER TOLD ME WAS DUE TO THE FACT THAT A SMALL AMOUNT OF MOISURE AND BRAKE PAD DUST WERE IN THE ROTORS AND WILL BURN OFF AFTER A FEW MILES,I HOPE NO ONE PULLS OUT IN FRONT OF ME ON MY STREET.I I HOPE YOU PEOPLE RESHEARCH THE BRAKES ON THESE VANS,YOU MIGHT BE ABLE TO SAVE A LIFE OR TWO,MY CONFIDENCE IS TOTALTY GONE IN REGARDS TO THE STOPPING OF THIS VAN. *AK
Official recalls
204V480000 · Air Bags
Oct 6, 2004
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available