MY FOUR YEAR OLD CHILD CAN PULL THE SHOULDER HARNESS CLIP APART WITHOUT DISENGAGING (SQUEEZING) THE CLIP COMPENENTS TOGETHER. BOTH HARNESS CLIPS ON THE 2 INTEGRATED CHILD SEATS(FRONT BENCH) CAN BE PULLED APART. BOTH CLIPS WERE REPLACED BY DEALERSHIP ON 8/2/02, YET CONTINUE TO BE DEFECTIVE. DEALERSHIP SAID IT DOES IT WITH OTHE…
Read full complaint
MY FOUR YEAR OLD CHILD CAN PULL THE SHOULDER HARNESS CLIP APART WITHOUT DISENGAGING (SQUEEZING) THE CLIP COMPENENTS TOGETHER. BOTH HARNESS CLIPS ON THE 2 INTEGRATED CHILD SEATS(FRONT BENCH) CAN BE PULLED APART. BOTH CLIPS WERE REPLACED BY DEALERSHIP ON 8/2/02, YET CONTINUE TO BE DEFECTIVE. DEALERSHIP SAID IT DOES IT WITH OTHER CAR SEATS THAT WERE TESTED ON LOT AND DID NOT FEEL IT WAS A SAFETY CONCERN. ALYSSA DESERIS, CHILD SEAT INSPECTOR FROM BUCKS COUNTY HIGHWAY SAFETY PROGRAM INSPECTED THE SEATS AND FELT THAT THIS IS A MAJOR DEFECT AND SAFETY ISSUE. SHE CAN BE REACHED AT (215) 491-9260. THE SERVICE MANAGER REPORTED CONCERN TO CHRYSLER REPRESENTATIVE, MIKE CANTRELL. I HAVE NOT HEARD BACK FROM CHRYSLER SINCE I MADE MY COMPLAINT WITH SERVICE MANAGER ON 8/15/02. I FEEL THE HARNESS CLIP IS A CHEAP PIECE OF PLASTIC THAT WILL ONLY GET WORSE WITH WEAR AND WILL EASILY COME APART ON ITS OWN. THE HARNESS CLIPS ON OTHER NON-INTEGRATED CHILD SEATS ARE LARGER AND DO NOT DISENGAGE WITHOUT SQUEEZING CLIPS TOGETHER (IE. CENTURY AND COSTCO).*AK
NHTSA ODI #766874
Mileage unknown · May 16, 2002
Child Seat
CONSUMER STATES WHILE BUCKLING THE CHILD INTERGRATED SEAT BUCKLE, BUCKLE CAME APART. CONSUMER STATES THE PLASTIC BROKE AND THE BACK OF BUCKLE CRACKED AND SPRINGS FELL OUT. CONSUMER FEELS IF THERE IS A CAR ACCIDENT, CHILD WOULD NOT HAVE BEEN RESTRAINED. PLEASE PROVIDE ANY FURTHER INFORMATION.*JB
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
2000 Plymouth Voyager Problems, Complaints & Recalls | Skip That Year
Illustration