Illustration04 V 480 000/AIR BAG CLOCKSPRING: AFTER THE RECALL REPAIRS WAS MADE,THE HORN FAILED TO OPERATE. THE DEALER WAS NOTIFIED. THE DEALER INFORMED THE CONSUMER THAT SOMETHING ELSE WAS CAUSING THE PROBLEM. CONSUMER IS INSISTING THAT THE HORN WAS OPERATING PROPERLY BEFORE THIS REPAIR WAS DONE. *JB
1999 Plymouth Voyager
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1999 Plymouth Voyager do not stand out strongly from the model-year median of 197.
About this comparison →How this year compares
Owner complaints by model year
Compare all Voyager years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
50–25K
1825–50K
3150–75K
2975–100K
19100–150K
7150K+
109 reports with mileage · 164 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports10 fire reports11 injury reports
What owners actually said
273 reportsI PURCHASED A USED 1999 PLYMOUTH VOYAGER 2.4L MINIVAN WITH 54,000 MILES IN APRIL 2001. SIX MONTHS AFTER PURCHASE AND AT ABOUT 58,000 MILES, THE VEHICLE BEGAN LEAKING OIL. THE OIL LEAK HAS BECOME PROGRESSIVELY WORSE OVER THE PAST 3 YEARS, TO WHERE I AM LOSING 1 QUART OF OIL PER WEEK. THE OIL IS SPRAYING THE UNDERCARRIAGE, INCLUDI…
Read full complaint
I PURCHASED A USED 1999 PLYMOUTH VOYAGER 2.4L MINIVAN WITH 54,000 MILES IN APRIL 2001. SIX MONTHS AFTER PURCHASE AND AT ABOUT 58,000 MILES, THE VEHICLE BEGAN LEAKING OIL. THE OIL LEAK HAS BECOME PROGRESSIVELY WORSE OVER THE PAST 3 YEARS, TO WHERE I AM LOSING 1 QUART OF OIL PER WEEK. THE OIL IS SPRAYING THE UNDERCARRIAGE, INCLUDING THE EXHAUST SYSTEM. THE VAN NOW HAS 88,000 MILES. I TOOK THE VAN IN RECENTLY AND THEY DIAGNOSED THE PROBLEM AS A BLOWN HEAD GASKET. THE HEAD GASKET SHOULD NOT FAIL AT SUCH LOW MILEAGE! THE HEAD GASKET IS BEING REPLACED, AT A COST OF OVER $1000!. ALTHOUGH NO DEATHS, ACCIDENTS, FIRES, DAMAGE, ETC. HAS OCCURRED, THERE WAS THE POTENTIAL FOR AN OIL FIRE FROM THE LEAK. I HAVE DONE SOME RESEARCH AND FOUND THAT THIS IS A COMMON PROBLEM WITH THE 2.4L ENGINES ON THIS MODEL!!! SOMETHING NEEDS TO BE DONE ABOUT IT!*AK
A PART HAS BEEN ORDERED FOR MY CAR SINCE OCT 2004. AT THE TIME THE ORDER WAS PLACED I WAS TOLD THERE WERE 1500 ON BACK ORDER FROM CHRYSLER. TODAY I WAS AGAIN TOLD THERE ARE STILL 1500 NATIONALLY ON BACKORDER FROM CHRYSLER. I AM TOLD BY THE DEALER THAT THIS PART IS PART OF MY EXHAUST SYSTEM AND THAT MY AUTOMOBILE WILL UNLIKELY …
Read full complaint
A PART HAS BEEN ORDERED FOR MY CAR SINCE OCT 2004. AT THE TIME THE ORDER WAS PLACED I WAS TOLD THERE WERE 1500 ON BACK ORDER FROM CHRYSLER. TODAY I WAS AGAIN TOLD THERE ARE STILL 1500 NATIONALLY ON BACKORDER FROM CHRYSLER. I AM TOLD BY THE DEALER THAT THIS PART IS PART OF MY EXHAUST SYSTEM AND THAT MY AUTOMOBILE WILL UNLIKELY PASS STATE INSPECTION AND THAT THE VEHICLE COULD ALSO BE LEAKING CARBON MONOXIDE. CHRYSLER/PLYMOUTH HAS BEEN LESS THAN HELPFUL IN ATTAINING THIS PART AND DOES NOT SEEM CONCERNED THAT THIS IS CAUSING MY AUTO TO LEAK EXHAUST AND CARBON MONOXIDE. I AM TOLD THEY ARE TRYING TO GET A NEW MANUFACTURER FOR THE PART BUT THEY HAVE NO IDEA WHEN THE PART WILL BE AVAILABLE. IF THERE IS SOME OTHER AGENCY I SHOULD CONTACT, PLEASE ADVISE. THANK YOU. *AK
WHILE DRIVING ANY SPEED, THE CONSUMER HEARD A POPPING NOISE COMING FROM THE FRONT END OF THE VEHICLE. THE DEALERSHIP INFORMED THE CONSUMER THAT THE PROBLEM WAS PERTAINING TO THE FRONT UPPER BALL JOINTS. THE PROBLEM WAS NOT RESOLVED. PLEASE PROVIDE MORE INFORMATION. *JB
THE AIR BAG LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. CONSUMER TOOK VEHICLE TO THE DEALER FOR INSPECTION. *AK *TC
WHEN APPLYING BRAKES IN A SUDDEN/EMERGENCY STOP VEHICLE EXPERIENCED EXTENDED STOPPING DISTANCE. VEHICLE HAD BEEN TO DEALER ON THREE OCCASIONS, AND THEY WERE UNABLE TO DUPLICATE THE PROBLEM.*AK
CONSUMER HAS A 1999 PLYMOUTH VOYAGER. WHEN SHE IS PARKED AND ELECTRONICALLY LOCKS THE DOORS, THERE IS A VERY LOUD BUZZING NOISE COMING FROM THE SLIDING DOOR. THIS ALSO HAPPENS EVERY TIME YOU OPEN AND CLOSE THE DOOR. AS WELL WHEN DRIVING, "DOOR OPEN" LIGHT COMES ON. *NM
HEARD A LOUD BLAST, VAN WENT UP IN THE AIR OFF THE ROAD. TOUCHED BACK DOWN ON THE ROAD I WAS ALL OVER THE ROAD. HAD NO BRAKE, NO POWER STEERING AND NO PARK. *BF THE TRANSMISSION FAILED. *SC
THE CONSUMER SMELLED GAS FUMES INSIDE THE VEHICLE. PLEASE PROVIDE MORE INFORMATION. *JB
WHILE DRIVING 30 MPH IN INCLEMENT WEATHER WINDSHIELD WIPERS FAILED. THIS CAUSED POOR VISIBILITY. HOWEVER, CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE, AND PULLED OVER. CONSUMER WILL CONTACT THE DEALER IN THE NEAR FUTURE. *AK
Official recalls
404V480000 · Air Bags
Oct 6, 2004
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. THE RECALL BEGAN ON OCTOBER 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
02V076000 · Seat Belts:rear/other
Mar 8, 2002
ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
99V116000 · Exterior Lighting:headlights
May 6, 1999
VEHICLE DESCRIPTION: MINI VANS BUILT FOR FLEET SALES ONLY. THE HEADLAMP MODULE DOES NOT IDENTIFY THE PARK LAMP AS "DRL" AS REQUIREMENT OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108.
Remedy: ALL FLEET OWNERS/OPERATORS WILL BE MAILED NON-REMOVABLE DECALS WITH THE REQUIRED "DRL" LETTERS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA04013 · Driver Air Bag Clockspring Failure
Opened Jun 4, 2004 · Closed May 25, 2005
Status: closed (inferred from source dates) · Air Bags:frontal
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.
RQ04001 · Driver Air Bag Clockspring Failure
Opened Jan 28, 2004 · Closed Jun 4, 2004
Status: closed (inferred from source dates) · Air Bags:frontal
COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF DAIMLERCHRYSLER'S RECALL OF MODEL YEAR 1996-1998.5 MINIVANS (RECALL NO. 02V-293).THIS RECALL QUERY HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-013).
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available