NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
34 reportsClear category filter175,000 miles · Mar 23, 2012
Fuel System, Gasoline
TL* THE CONTACT OWNS A 1997 PLYMOUTH VOYAGER. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE FUEL TANK DETACHED FROM THE VEHICLE. THE CONTACT WAS ABLE TO SAFELY STOP THE VEHICLE AND UPON EXAMINING THE VEHICLE, THE CONTACT NOTICED THAT ONE OF THE FUEL TANK STRAPS HAD FRACTURED DUE TO CORROSION. THE CONTACT APPLIED A TEMPORARY …
Read full complaint
TL* THE CONTACT OWNS A 1997 PLYMOUTH VOYAGER. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE FUEL TANK DETACHED FROM THE VEHICLE. THE CONTACT WAS ABLE TO SAFELY STOP THE VEHICLE AND UPON EXAMINING THE VEHICLE, THE CONTACT NOTICED THAT ONE OF THE FUEL TANK STRAPS HAD FRACTURED DUE TO CORROSION. THE CONTACT APPLIED A TEMPORARY STRAP AS A REMEDY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, BUT WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 175,000.
NHTSA ODI #10452772
86,000 miles · Jun 9, 2006
Engine And Engine CoolingFuel System, GasolineFire
DT*: THE CONTACT STATED WHILE DRIVING 15 MPH THERE WAS A SMELL OF FUEL AND SMOKE WAS COMING FROM THE AIR VENTS. SOMEONE BEHIND THE VEHICLE ALERTED THE DRIVER THAT THE VEHICLE WAS ON FIRE. THE DRIVER PULLED OFF OF THE ROAD AND EXITED THE VEHICLE. THE VEHICLE WAS ENGULFED IN FLAMES AND WAS TOTALED. THE FIRE DEPARTMENT AND THE…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 15 MPH THERE WAS A SMELL OF FUEL AND SMOKE WAS COMING FROM THE AIR VENTS. SOMEONE BEHIND THE VEHICLE ALERTED THE DRIVER THAT THE VEHICLE WAS ON FIRE. THE DRIVER PULLED OFF OF THE ROAD AND EXITED THE VEHICLE. THE VEHICLE WAS ENGULFED IN FLAMES AND WAS TOTALED. THE FIRE DEPARTMENT AND THE POLICE DEPARTMENT WERE NOTIFIED. THE FIRE DEPARTMENT DETERMINED THE FIRE ORIGINATED FROM THE HOOD AND SPREAD THROUGHOUT THE VEHICLE. UPDATED 07/03/06. *JB
NHTSA ODI #10159414
45,000 miles · Nov 21, 2005
Engine And Engine CoolingFuel System, GasolineVehicle Speed Control
DT: THE CONTACT STATED VEHICLE STALLS WHEN IDLING FOLLOWED BY THE ENGINE DYING. THE VEHICLE RESTARTS AFTER SEVERAL ATTEMPTS. HE TOOK THE VEHICLE TO AN INDEPENDENT REPAIR SHOP. THE REPAIR SHOP CLEANED THE THROTTLE BODY AND THE FUEL INJECTION SYSTEM. THIS DID NOT CORRECT THE PROBLEM. NO FURTHER REPAIRS HAVE BEEN MADE AT THIS T…
Read full complaint
DT: THE CONTACT STATED VEHICLE STALLS WHEN IDLING FOLLOWED BY THE ENGINE DYING. THE VEHICLE RESTARTS AFTER SEVERAL ATTEMPTS. HE TOOK THE VEHICLE TO AN INDEPENDENT REPAIR SHOP. THE REPAIR SHOP CLEANED THE THROTTLE BODY AND THE FUEL INJECTION SYSTEM. THIS DID NOT CORRECT THE PROBLEM. NO FURTHER REPAIRS HAVE BEEN MADE AT THIS TIME. *AK
NHTSA ODI #10143329
Mileage unknown · Jul 30, 2003
Fuel System, Gasoline
CONSUMER NOTICED EVIDENCE OF FUEL LEAKAGE. DEALER DIAGNOSED THAT FUEL WAS LEAKING FROM FUEL RAIL AND REPLACED IT.*AK
NHTSA ODI #10031515
Mileage unknown · May 7, 2003
Fuel System, Gasoline
THE FUEL TANK WOULD NOT TAKE MORE THAN A HALF A TANK OF FUEL. THE DEALER HAS BEEN NOTIFIED. *NLM
NHTSA ODI #10019393
98,000 miles · Mar 28, 2003
Electrical SystemFuel System, Gasoline
THE VEHICLE EXPERIENCED A FUEL LEAK. *JB THE ELECTRICAL SYSTEM HAS NOT WORKED WHILE VEHICLE WAS RUNNING. (WINDOW, BLINKERS, AND THE RADIO) RESTARTING THE VEHICLE SOLVES THE PROBLEM EACH TIME. SCC
NHTSA ODI #10014704
Mileage unknown · Jan 28, 2003
Engine And Engine CoolingFuel System, GasolinePower Train
THE CONSUMER HAS EXPERIENCE THE FOLLOWING: NOISE COMING FROM THE REAR BRAKES, NOISE WHEN STARTING THE ENGINE/UNEVEN IDLE, THE CHECK ENGINE LIGHT HAD COME ON/BURNED #5 EXHAUST VALVE-REMOVED HEAD/REPLACED VALVE/REASSEMBLED ENGINE, THE ENGINE IS KNOCKING/INTERNAL ROD KNOCKING-ENGINE HAD AN OIL LEAK/REPLACED GASKET & THE REAR MAIN …
Read full complaint
THE CONSUMER HAS EXPERIENCE THE FOLLOWING: NOISE COMING FROM THE REAR BRAKES, NOISE WHEN STARTING THE ENGINE/UNEVEN IDLE, THE CHECK ENGINE LIGHT HAD COME ON/BURNED #5 EXHAUST VALVE-REMOVED HEAD/REPLACED VALVE/REASSEMBLED ENGINE, THE ENGINE IS KNOCKING/INTERNAL ROD KNOCKING-ENGINE HAD AN OIL LEAK/REPLACED GASKET & THE REAR MAIN SEAL IS LEAKING (THE VEHICLE IS GOING THRU 2-3 QUARTS PER MONTH), AND WHEN ENGAGING IN GEAR, THE ENGINE MOVES HARD. SCC
NHTSA ODI #10001959
Mileage unknown · Jan 21, 2003
Fuel System, Gasoline
FUEL RAIL HAS A HAIR LINE CRACK ,AND IT LEAKS GAS INTO VEHICLE, CAUSING VEHICLE TO SMELL LIKE GAS. PH. *AK
NHTSA ODI #10004271
74,000 miles · Jan 8, 2003
Fuel System, GasolineInjury
THE FUEL LINE CRACKED CAUSING FUEL TO LEAK ONTO THE MANIFOLD ALLOWING FUMES TO ESCAPE INTO THE VEHICLE. FUEL LINE HAD TO BE REPLACED. *TT *NLM
NHTSA ODI #10001931
Mileage unknown · Jan 7, 2003
Electrical SystemFuel System, Gasoline
SAFETY RECALL CLOCK SPRING ASSEMBLY NAR 1/22/2003 THE AIR BAG LIGHT ILLUMINATED AND THE CONSUMER TOOK THE VEHICLE TO THE DEALER WHERE THE PROBLEM WAS DIAGNOSED AS A SHORT IN CLOCK SPRING. THE POWER DOOR LOCKS WERE NOT UNLOCKING, BUT THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM. ANOTHER RECALL REGARDING THE FUEL RAIL WAS R…
Read full complaint
SAFETY RECALL CLOCK SPRING ASSEMBLY NAR 1/22/2003 THE AIR BAG LIGHT ILLUMINATED AND THE CONSUMER TOOK THE VEHICLE TO THE DEALER WHERE THE PROBLEM WAS DIAGNOSED AS A SHORT IN CLOCK SPRING. THE POWER DOOR LOCKS WERE NOT UNLOCKING, BUT THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM. ANOTHER RECALL REGARDING THE FUEL RAIL WAS REPAIRED, HOWEVER THE CONSUMER WAS CHARGED A $50.00 DEDUCTIBLE. *JB
NHTSA ODI #10004728
Official recalls
6Nov 7, 2002
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Mar 8, 2002
ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 6, 1998
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.
Consequence & remedy
Consequence: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.
Remedy: DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED.
Nov 13, 1997
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH P215/65R15 GOODYEAR CONQUEST TIRES MOUNTED ON STEEL WHEEL. THE TIRES CAN EXPERIENCE A SUDDEN AIR PRESSURE LOSS WITHOUT WARNING.
Consequence & remedy
Consequence: SUDDEN TIRE FAILURE COULD RESULT IN A LOSS OF DRIVER CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIRES THAT WERE MOUNTED ON STEEL WHEELS.
Apr 28, 1997
THE STEEL ROAD WHEELS WERE DAMAGED BY THE EQUIPMENT USED TO MATCH MOUNT THE WHEEL TO THE TIRE.
Consequence & remedy
Consequence: A SCORE MARK WAS MADE ON THE WHEEL, AFFECTING THE DURABILITY OF THE WHEEL.
Remedy: DEALERS WILL REPLACE ALL ROAD WHEELS (AND FULL SIZE SPARE TIRES) WITH NEW WHEELS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7PE02004 · Rear Seat Belt Malfunction
Opened Jan 16, 2002 · Closed Mar 11, 2002
Status: closed (inferred from source dates) · Seat Belts:rear/other
THIS INVESTIGATION WAS OPENED JANUARY 16, 2002, BASED ON SEVEN REPORTS ALLEGING THE THIRD ROW SEAT BELT RETRACTORS FAILED ON CERTAIN 1997 AND 1998 MODEL YEAR CARAVAN AND VOYAGER VEHICLES.THE REPORTS INDICATED A TAR LIKE SUBSTANCE ENTERED THE RETRACTOR MECHANISM, THUS CAUSING THE RETRACTOR TO JAM OR BIND.IN THIS CONDITION THE SEAT BELT IS RENDERED INOPERABLE, AS THE WEBBING CANNOT RETRACT OR BE WITHDRAWN FROM THE RETRACTORS FOR USE.RECALL SCOPE:THE AFFECTED VEHICLES ARE 1997 THROUGH 1999 DODGE CARAVAN, PLYMOUTH VOYAGER, AND CHRYSLER TOWN & CONTRY BUILT ON A SHORT WHEEL BASE CHASSIS.THE INCLUSIVE DATES OF PRODUCTION ARE JUNE 1996 THROUGH OCTOBER 31, 1999.RECALL REMEDY: DAIMLERCHRYSLER DEALERS WILL REPLACE THE MASTIC SOUND BARRIER PATCHES WITH FOAM BLOCKERS, AS WELL AS, INSPECT AND REPLACE ALL THIRD ROW REAR SEAT BELT ASSEMBLIES CONTAMINATED BY THE MASTIC PATCH.
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
SQ96016 · Integrated Child Seat Belt Lockup
Opened Sep 18, 1996 · Closed Feb 4, 1997
Status: closed (inferred from source dates) · Seat Belts:integrated Child Seat
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
Illustration