I FOUND THAT I EXPERIENCE A SIMILAR PROBLEM WITH DOOR HINGE CRAKING RESULTING IN DOOR NOT CLOSING PROPERLY. MY FATHER WAS ABLE TO FIX WITH SIMPLE WELDING., BUT NOW I FIND I AM NOT THE ONLY PERSON TO EXPERIENCE THIS. MY FRIEND HAS A SIMILAR 95 DODGE CARAVAN WITH THIS SAME PROBLEM ON BOTH DOOR. I HAD IT ONLY ON ONE. NOW LOOKING…
Read full complaint
I FOUND THAT I EXPERIENCE A SIMILAR PROBLEM WITH DOOR HINGE CRAKING RESULTING IN DOOR NOT CLOSING PROPERLY. MY FATHER WAS ABLE TO FIX WITH SIMPLE WELDING., BUT NOW I FIND I AM NOT THE ONLY PERSON TO EXPERIENCE THIS. MY FRIEND HAS A SIMILAR 95 DODGE CARAVAN WITH THIS SAME PROBLEM ON BOTH DOOR. I HAD IT ONLY ON ONE. NOW LOOKING THROUGH THE COMPLAINTS I'M WODERING IF IT MAY BE A STRUTUAL PROBLEM INTEAD OF JUST WEAR AND TEAR ON THE VEHICLE. DATE IS NOT ACCURAT ALL I REMEMBER WAS THAT IT WAS LAST YEAR. THE COMPUTER WOULDN'T LET ME PROCEED WITH OUT A FULL DATE INPUT.
NHTSA ODI #10185413
136,000 miles · Aug 27, 2004
Latches/locks/linkages
CONSUMER STATED DOORS WERE DEFECTIVE. THE FRAME WHERE THE HINGES WERE ATTACHED CRACKED. THIS WAS HAPPENING AROUND DRIVER'S SIDE AS WELL AS THE PASSENGER' SIDE DOORS. BECAUSE OF THE CRACKS DOORS WOULD NOT LOCK, AND COULD BE OPENED INVOLUNTARILY. *AK
NHTSA ODI #10089937
Mileage unknown · Jan 21, 2004
Latches/locks/linkages
WHEN DRIVING BOTH SLIDING DOORS UNLATCHED, CAUSING THE DOORS TO OPEN. *AK
NHTSA ODI #10055467
Mileage unknown · Jan 20, 2004
Air BagsEngine And Engine CoolingLatches/locks/linkagesCrash
ACCIDENTS INVOLVING PLYMOUTH VOYAGER'S, THE AIR BAGS DIDN'T DEPLOY. *PH (NAR) THE CONSUMER ALSO EXPERIENCED PROBLEMS WITH THE ENGINE HEAD GASKETS AND THE TAIL GATE LIGHT COMING ON. *CB
NHTSA ODI #10055474
10,400 miles · Aug 27, 2003
Latches/locks/linkagesStructure
CONSUMER CALLED COMPLAINING ABOUT STRUCTURE PROBLEMS. THE HINGES ON THE DOOR WERE NOT STRONG ENOUGH TO HOLD THE DOOR, AND THERE WAS A CRACK. DEALER AND MANUFACTURE WERE CONTACTED, AND STATED THAT THEY WERE NOT RESPONSIBLE FOR IT. ALSO, LATCH ON THE DOOR WAS NOT WORKING PROPERLY TO THE POINT THAT WHEN THEY MADE A SHARP CURVE T…
Read full complaint
CONSUMER CALLED COMPLAINING ABOUT STRUCTURE PROBLEMS. THE HINGES ON THE DOOR WERE NOT STRONG ENOUGH TO HOLD THE DOOR, AND THERE WAS A CRACK. DEALER AND MANUFACTURE WERE CONTACTED, AND STATED THAT THEY WERE NOT RESPONSIBLE FOR IT. ALSO, LATCH ON THE DOOR WAS NOT WORKING PROPERLY TO THE POINT THAT WHEN THEY MADE A SHARP CURVE THE DOOR CAME OPEN. *AK
NHTSA ODI #10037753
70,000 miles · Feb 6, 2003
Latches/locks/linkages
THE HOOD RELEASE HANDLE BROKE OFF IN HAND WHILE ATTEMPTING TO OPEN HOOD. PLEASE PROVIDE ANY FURTHER INFORMATION. PH
NHTSA ODI #10006726
Mileage unknown · Jul 13, 2000
Latches/locks/linkages
WHEN THE DOOR MECHANISM FAILED I TOOK IT TO TIMBERLINE AND THEY COULD NOT FIX IT AND SAID THAT I WOULD HAVE TO HAVE IT FIXED AT A BODY SHOP. WHEN I TOOK IT TO THE BODY SHOP THEY TOLD ME THAT THEY HAVE HAD TO REPLACE APPROX. 6 OF THESE MECHANISM ON THE SAME MODEL OF VAN AS MINE IN THE PAST YEAR. THEY SAID THAT WHEN IT WAS BUILT…
Read full complaint
WHEN THE DOOR MECHANISM FAILED I TOOK IT TO TIMBERLINE AND THEY COULD NOT FIX IT AND SAID THAT I WOULD HAVE TO HAVE IT FIXED AT A BODY SHOP. WHEN I TOOK IT TO THE BODY SHOP THEY TOLD ME THAT THEY HAVE HAD TO REPLACE APPROX. 6 OF THESE MECHANISM ON THE SAME MODEL OF VAN AS MINE IN THE PAST YEAR. THEY SAID THAT WHEN IT WAS BUILT THE MECHANISM SHOULD HAVE HAD STEEL FRAMEWORK TO ADHERE TO AND THERE WAS ONLY A VERY LIGHT METAL USED TO BUILD IT WITH. WHAT WOULD HAVE HAPPENED IT ONE OF MY CHILDREN WOULD HAVE HAD THE DOOR COME OPEN OR MYSELF BECAUSE THE LATCH AND LOCK FAILED. *AK
NHTSA ODI #725372
Mileage unknown · May 16, 2000
Latches/locks/linkages
HAD THE LATCH ON THE HATCHBACK SERVICED ABOUT A YEAR PRIOR AS PER THE RECALL. ALL OF THE SCREWS CAME LOOSE AND THE LATCH FELL OFF THE HATCH. THE DEALER APPARENTLY NEGLECTED TO TIGHTEN THE SCREWS WHEN REPLACING THE UNIT AS PER THE RECALL! LUCKY NO ONE WAS HURT! *AK
NHTSA ODI #722791
Mileage unknown · May 9, 2000
Latches/locks/linkages
WHILE DRIVING 35 MPH HOOD LATCH RELEASED, CAUSING THE HOOD TO FLY UP, BLOCKING VISIBILITY. PLEASE GIVE ANY FURTHER DETAILS. *AK
NHTSA ODI #861629
Mileage unknown · Dec 30, 1999
Latches/locks/linkages
THE SLIDING DOOR LATCH BROKE, CAUSING THE VEHICLE'S DOOR TO NOT SHUT ALL THE WAY. DEALER HAS PUT A CORD ON THE DOOR TO KEEP IT FROM OPENING. *AK
VEHICLE DESCRIPTION: MINI VANS. THE WIRING THAT INITIATES THE DRIVER AND/OR PASSENGER AIR BAG COULD ELECTRICALLY SHORT CIRCUIT TO GROUND. A SHORT CIRCUIT TO GROUND THAT EXISTS IMMEDIATELY AFTER TURNING THE IGNITION KEY TO THE "ON" OR "START" POSITION CAN CAUSE THE AIR BAG(S) TO INADVERTENTLY DEPLOY.
Consequence & remedy
Consequence: INADVERTENT AIR BAG DEPLOYMENT CAN INJURE A FRONT SEAT OCCUPANT.
Remedy: DEALERS WILL PERFORM AN ELECTRONIC DIAGNOSTIC CHECK. ANY SHORT CIRCUITS IDENTIFIED IN EITHER THE DRIVER'S OR PASSENGER SIDE AIR BAG INITIATOR WIRE CIRCUIT WILL BE REPAIRED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
PE97049 · Air Bag Circuit/windshield Wiper Motor
Opened Nov 18, 1997 · Closed Mar 17, 1998
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
DP96014 · Defective Air Bag Crash Sensor
Opened Nov 14, 1996 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
CFAS SENT A FOLLOW-UP LETTER ON DECEMBER 12, 1996, TO CHANGE THE INTENT OF THE PETITION TO AIRBAG AGGRESSIVITY AND DEPLOYMENT VARIABILITY.NHTSA RECEIVED THE LETTER ON 12/12/96; ACCORDINGLY, THE PETITION DUE DAY WAS CHANGED TO APRIL 12, 1997.CFAS PETITIONED THE AGENCY TO CONDUCT AN INVESTIGATION TO DETERMINE WHETHER THE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS FOR THE 1991-92 CHEVROLET CORSICA/BERETTA, 1990-92 FORD TAURUS, AND 1994-96 CHRYSLER MINIVANS ARE DEFECTIVE.CFAS ALLEGE THAT INFORMATION ON LOW SPEED CRASHES HERE OCCUPANTS HAVE SUFFERED FATAL INJURIES SUGGESTS [THAT THE ABOVE VEHICLES] HAVE DEFECTIVE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS.
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
1995 Plymouth Voyager Problems, Complaints & Recalls | Skip That Year
Illustration