DT*: THE CONTACT STATED WHILE DRIVING 25 MPH, THE POWER FAILED AND THE VEHICLE WAS COASTED TO A STOP. WHEN THE VEHICLE WAS TAKEN TO THE SERVICE DEALER, THE PROBLEM WAS IDENTIFIED AS A FAILED PCM (POWER CONTROL MODULE, WHICH WAS REPLACED. LATER, THE AIR CONDITIONING FUSE BLEW. WHEN THE VEHICLE WAS RETURNED TO THE SERVICE DEALE…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 25 MPH, THE POWER FAILED AND THE VEHICLE WAS COASTED TO A STOP. WHEN THE VEHICLE WAS TAKEN TO THE SERVICE DEALER, THE PROBLEM WAS IDENTIFIED AS A FAILED PCM (POWER CONTROL MODULE, WHICH WAS REPLACED. LATER, THE AIR CONDITIONING FUSE BLEW. WHEN THE VEHICLE WAS RETURNED TO THE SERVICE DEALER, THE PROBLEM WAS IDENTIFIED AS WORN WIRING AT THE CONNECTION TO THE FUSE BOX. THE WIRING WAS REPAIRED, BUT THE VEHICLE LOST ALL POWER AGAIN, WHILE DRIVING 25 MPH. THE VEHICLE WAS RETURNED TO THE SERVICE DEALER WHO DETERMINED THAT THE WIRING HARNESS HAD FAILED AND NEEDED TO BE REPLACED, BEFORE FURTHER INVESTIGATIONS COULD BE MADE. THE MANUFACTURER WAS NOT ALERTED.
NHTSA ODI #10173728
13,017 miles · Feb 26, 2004
Electrical SystemStructure
DOOR STRUCTURE FAILED. *AK THE DOOR AJAR LIGHT KEPT ILLUMINATING. THE DOOR SENSOR BUTTON AN THE FUSE BOX KEPT SHORTING OUT. *NM
NHTSA ODI #10055396
Mileage unknown · May 31, 2000
Electrical System
ELECTRICAL WIRING PROBLEMS: EVERYTHING ELECTRICAL IN THE VEHICLE WILL SOMETIMES SHUT DOWN. PROBLELMS WITH VEHICLE IN THE PAST HAVE COME FROM DEFECTIVE WIRING. DEALER INSISTS THAT CONSUMER BRING VEHICLE IN WHEN HAVING ELECTRICAL WIRING PROBLEMS. *AK
NHTSA ODI #862760
Mileage unknown · Dec 7, 1999
Electrical SystemEngine And Engine CoolingTiresCrashInjury
NO SUMMARY
NHTSA ODI #715729
Mileage unknown · Sep 23, 1999
Air BagsElectrical SystemEngine And Engine Cooling
WHEN DRIVING AT 40 MPH VEHICLE IS STALLING AND CUTTING OFF. ALSO, AIR BAG LIGHT IS ON, AND THE VEHICLE WON'T TURN OFF. CONSUMER HAS TO HAVE THE VEHICLE TOWED. *AK
NHTSA ODI #848512
Mileage unknown · Jun 7, 1999
Electrical SystemEquipmentPower Train
HARD COPY OF LETTER TO CHRYSLER CORPORATION BEING FORWARED THROUGH E-MAIL. NO SAFETY DEFECT MENTIONED IN SUMMARY. *AK
NHTSA ODI #707267
Mileage unknown · Jan 13, 1999
Electrical System
CONSUMER HAS BEEN EXPERIENCING PROBLEMS WITH ELECTRICAL SYSTEM. CONSUMER WAS DISSATISFIED WITH THE WAY THE ELECTRICAL WIRING WAS UNSTALLED. THE REAR WINDOW WIPER MOTOR IS CONNECTED TO THE SAME ELECTRICAL SYSTEM AS THE AIRBAGS. WHEN WINDOW WIPER MOTOR WENT OUT, THE AIRBAG LIGHT STARTED ILLUMINATING WHEN THE AIRBAG COULD NOT DE…
Read full complaint
CONSUMER HAS BEEN EXPERIENCING PROBLEMS WITH ELECTRICAL SYSTEM. CONSUMER WAS DISSATISFIED WITH THE WAY THE ELECTRICAL WIRING WAS UNSTALLED. THE REAR WINDOW WIPER MOTOR IS CONNECTED TO THE SAME ELECTRICAL SYSTEM AS THE AIRBAGS. WHEN WINDOW WIPER MOTOR WENT OUT, THE AIRBAG LIGHT STARTED ILLUMINATING WHEN THE AIRBAG COULD NOT DEPLOY. THE MANUFACTURER HAS YET TO BE CONTACTED. *AK.ET.
NHTSA ODI #833455
Mileage unknown · May 26, 1998
Electrical System
HAZARD WARNING LIGHTS HAVE FAULTY CONNECTORS AT THE FIREWALL. POSSIBLE MANUFACTURER'S DEFECT. PROBLEM HAS NOT BEEN RESOLVED. *AK
NHTSA ODI #822307
Mileage unknown · Apr 15, 1998
Electrical System
SHORT IN ELECTRICAL WIRING, CAUSING ALL SWITCHES TO FAIL.
NHTSA ODI #543311
Mileage unknown · Apr 10, 1998
Electrical SystemEngine And Engine CoolingPower Train
TRANSMISSION/TORQUE CONVERTER/VALVE COVER GASKET/THERMOSTAT/OXYGEN SENSOR/SERPENTINE BELT FAILED, AND OXYGEN SENSOR AND WIRING HARNESS SHORTED OUT. IN ADDITION ABS BRAKES FAILED 4 TIMES, ONCE RESULTING IN AN ACCIDENT. DEALER ALSO REPLACED FRONT BRAKE PADS/ROTORS.
VEHICLE DESCRIPTION: MINI VANS. THE WIRING THAT INITIATES THE DRIVER AND/OR PASSENGER AIR BAG COULD ELECTRICALLY SHORT CIRCUIT TO GROUND. A SHORT CIRCUIT TO GROUND THAT EXISTS IMMEDIATELY AFTER TURNING THE IGNITION KEY TO THE "ON" OR "START" POSITION CAN CAUSE THE AIR BAG(S) TO INADVERTENTLY DEPLOY.
Consequence & remedy
Consequence: INADVERTENT AIR BAG DEPLOYMENT CAN INJURE A FRONT SEAT OCCUPANT.
Remedy: DEALERS WILL PERFORM AN ELECTRONIC DIAGNOSTIC CHECK. ANY SHORT CIRCUITS IDENTIFIED IN EITHER THE DRIVER'S OR PASSENGER SIDE AIR BAG INITIATOR WIRE CIRCUIT WILL BE REPAIRED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
PE97049 · Air Bag Circuit/windshield Wiper Motor
Opened Nov 18, 1997 · Closed Mar 17, 1998
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
DP96014 · Defective Air Bag Crash Sensor
Opened Nov 14, 1996 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
CFAS SENT A FOLLOW-UP LETTER ON DECEMBER 12, 1996, TO CHANGE THE INTENT OF THE PETITION TO AIRBAG AGGRESSIVITY AND DEPLOYMENT VARIABILITY.NHTSA RECEIVED THE LETTER ON 12/12/96; ACCORDINGLY, THE PETITION DUE DAY WAS CHANGED TO APRIL 12, 1997.CFAS PETITIONED THE AGENCY TO CONDUCT AN INVESTIGATION TO DETERMINE WHETHER THE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS FOR THE 1991-92 CHEVROLET CORSICA/BERETTA, 1990-92 FORD TAURUS, AND 1994-96 CHRYSLER MINIVANS ARE DEFECTIVE.CFAS ALLEGE THAT INFORMATION ON LOW SPEED CRASHES HERE OCCUPANTS HAVE SUFFERED FATAL INJURIES SUGGESTS [THAT THE ABOVE VEHICLES] HAVE DEFECTIVE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS.
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
1995 Plymouth Voyager Problems, Complaints & Recalls | Skip That Year
Illustration