NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
159 reportsClear category filterMileage unknown · Feb 5, 1999
Electrical SystemEngine And Engine CoolingPower Train
ABS BRAKES CONTROL UNIT REPLACED IN SEPTEMBER 94/IN OCTOBER, 96, AND ABS MODULE CHANGED IN JULY, 94. IN ADDITION, SERVICED TRANSMISSION DUE TO PROBLEMS/A/C PROBLEMS IN AUGUST 94, AND BATTERY PROBLEMS DUE TO ELECTRICAL SHORT, REPLACED BATTERY AND REPAIRED ELECTRICAL SYSTEM IN FEBRURY, 95. POWER STEERING PROBLEMS, REPAIRWORK D…
Read full complaint
ABS BRAKES CONTROL UNIT REPLACED IN SEPTEMBER 94/IN OCTOBER, 96, AND ABS MODULE CHANGED IN JULY, 94. IN ADDITION, SERVICED TRANSMISSION DUE TO PROBLEMS/A/C PROBLEMS IN AUGUST 94, AND BATTERY PROBLEMS DUE TO ELECTRICAL SHORT, REPLACED BATTERY AND REPAIRED ELECTRICAL SYSTEM IN FEBRURY, 95. POWER STEERING PROBLEMS, REPAIRWORK DONE IN MARCH, 95. ENGINE PROBLEMS OCCURRED, REPAIRWORK DONE TO ROCKER SHAFT/PUSH RODS AND OIL FILTER IN MARCH 95. FINALLY, IN MAY 95 STARTER BURNED OUT AND REPLACED/IN JULY, 95/EMERGENCY LIGHT BECAME DEFECTIVE AND RESET/RECALL JUN. 96, LIFTGATE LATCH REPLACED/DECEMBER 97, SEAT BELT REPAIRED/ APR, 97 RESET MAINTENANCE LIGHT AND SPEEDOMETER/ MAY, 97 BELT DRIVE PROBLEMS AND TENSIONER PROBLEMS ALSO EXIT. DEALER AWARE OF THE PROBLEMS AND PROBLEMS GO ON. REPAIRWORK AT OWNER'S EXPENSE WITH EXTENDED COVERAGE ON SOME. PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #834544
Mileage unknown · Feb 3, 1999
Service Brakes, Hydraulic
ABS SENSOR LIGHT KEEPS COMING ON INTERMITTENTLY. VEHICLE WAS TAKEN TO DEALER FOR NHTSA RECALL # 96 V 099 000. DEALER INFORMED CONSUMER OF A CODE NEEDED TO CORRECT THE PROBLEM. CONSUMER WOULD LIKE TO KNOW IF THIS IS PROPER PROCEDURE. *AK
NHTSA ODI #833195
Mileage unknown · Jul 27, 1998
Service Brakes, Hydraulic
ABS BRAKE LIGHT COMES ON WHILE DRIVING. DEALER CANNOT DUPLICATE. *AK
NHTSA ODI #825912
Mileage unknown · Jun 19, 1998
Service Brakes, Hydraulic
RECEIVED RECALL NOTICE (#96V099000). NOTIFIED DEALER. TOOK VEHICLE IN FOR BRAKE REPAIR ON DATE GIVEN. HAD NO PARTS. TOOK TO SECOND DEALER. *AK
NHTSA ODI #824489
Mileage unknown · Feb 5, 1998
Service Brakes, Hydraulic
RECALL STATES DEALER WILL REPAIR AND NOT CHARGE FOR PARTS. DEALER WANTS TO CHARGE FOR PARTS. *AK
NHTSA ODI #821163
Mileage unknown · Oct 6, 1997
Service Brakes, Hydraulic
WHEN TRAVELING AND UPON DEPRESSING THE BRAKE PEDAL, THE PEDAL TRAVELED TO THE FLOORBOARD, CAUSING EXTENDED STOPPING DISTANCE AND BRAKE FADE AWAY. CONSUMER HAS CONTACTED THE DEALER, DEALER HAS YET TO CORRECT THE PROBLEM. *AK
NHTSA ODI #816878
Mileage unknown · Aug 27, 1997
Electrical SystemService Brakes, Hydraulic
BRAKE PADS FAILED.
NHTSA ODI #521595
Mileage unknown · Aug 18, 1997
Power TrainService Brakes, Hydraulic
TRANSMISSION FAILED.
NHTSA ODI #521146
Mileage unknown · Jul 1, 1997
Service Brakes, HydraulicCrash
RECEIVED RECALL NOTICE IN 1996 FOR ABS. DID NOT TAKE VEHICLE IN FOR REPAIRS BECAUSE DID NOT GET THE LETTER FROM HIS WIFE UNTIL 1997.HAD ACCIDENT ON 6-12-97, WAS DRIVING APPROXIMATELY 50MPH WHEN ABS LIGHT CAME ON; LOST CONTROL OF VEHICLE AND RAN INTO AN EMBANKMENT, RECALL #96V009. *AK
NHTSA ODI #813668
35,673 miles · May 12, 1997
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
THE ANTI LOCK BRAKES FAILED PRIOR TO/AFTER RECALL REPAIRS. MR THE ABS LIGHT WAS INTERMITTENT. THE HYD ASSEMBLY AND THE BRAKE SYSTEM WAS REPLACED. THERE WAS A GRINDING NOISE IN THE ENGINE, TRANSMISSION, AND WHEN BRAKING. THE REPAIRS AND OR REPLACEMENT PARTS ARE AS FOLLOWED: REPLACED THE GASKET, REPAIRED THE GROUND WIRING O…
Read full complaint
THE ANTI LOCK BRAKES FAILED PRIOR TO/AFTER RECALL REPAIRS. MR THE ABS LIGHT WAS INTERMITTENT. THE HYD ASSEMBLY AND THE BRAKE SYSTEM WAS REPLACED. THERE WAS A GRINDING NOISE IN THE ENGINE, TRANSMISSION, AND WHEN BRAKING. THE REPAIRS AND OR REPLACEMENT PARTS ARE AS FOLLOWED: REPLACED THE GASKET, REPAIRED THE GROUND WIRING OF THE ABS, REPLACED THE SERPENTINE BELT AND MOTOR MOUNT . THE TRANSMISSION SHIFT WAS OUT OF GEAR. THE CONSUMER HAS REQUESTED REIMBURSEMENT. SCC
NHTSA ODI #517155
Official recalls
9Jul 16, 1999
VEHICLE DESCRIPTION: MINIVANS. THE LEFT HAND WINDSHIELD WIPER PIVOT DRIVE ARM WAS NOT MECHANICALLY STAKED TO THE PIVOT SHAFT.
Consequence & remedy
Consequence: THIS COULD ALLOW THE DRIVE ARM TO DISENGAGE FROM THE SHAFT LEADING TO A LOSS OF WIPER FUNCTION. THE DRIVER'S VISIBILITY WOULD BE IMPAIRED, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE LEFT HAND SIDE WINDSHIELD WIPER PIVOT ASSEMBLY.
Sep 9, 1997
VEHICLE DESCRIPTION: PASSENGER MINI-VANS. COVERS ON THE SOLID STALK MOUNTED SEAT BELT BUCKLES CAN BECOME DISLODGED CAUSING THE RELEASE BUTTON TO STICK INSIDE THE COVER. THE BUCKLE WOULD THEN BE ONLY PARTIALLY LATCHED.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSTALL A COVER RETAINING CLIP TO THE STALK MOUNTED BUCKLE COVER TO PREVENT DISLOCATION OF THE BUCKLE COVER.
Sep 9, 1997
VEHICLE DESCRIPTION: PASSENGER MINI-VANS. THE CENTER REAR SEAT, RIGHT OUTBOARD SIDE, SAFETY BELT ANCHOR HOOK CAN BECOME UNATTACHED FROM THE BODY ANCHOR POSITION.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE ANCHOR HOOK RETAINING CLIP WITH A REVISED PROFILE CLIP AND A COVER PLATE.
May 16, 1997
THE BOLTS USED TO ATTACH THE STRUT TO THE BODY AND THE REAR LIFTGATE CAN ACCUMULATE FATIGUE DAMAGE IF THREE FACTORS COMBINE. IF THE BOLT IS LOOSE, THE GAS STRUT IS OVER-PRESSURIZED, AND THE FREQUENCY OF OPENING AND CLOSING CYCLES IS HIGHER THAN FOR THE AVERAGE CUSTOMER, THE BOLT CAN FAIL.
Consequence & remedy
Consequence: PERSONAL INJURY COULD OCCUR IF THE BOLTS BREAK ALLOWING THE LIFTGATE TO FALL SUDDENLY.
Remedy: DEALERS WILL INSPECT FOR LOOSE FASTENERS, IF THE FASTENERS ARE LOOSE, THE STRUT (AND INTEGRAL BOLTS) WILL BE REPLACED. IF THE BOLT SHOWS EVIDENCE OF TORQUE, THE BOLT WILL BE REMOVED, LARGER WASHERS WILL REPLACE THE EXISTING WASHER AND THE BOLT WILL BE REINSTALLED AND HAND TIGHTENED TO THE TARGET TORQUED.
Nov 18, 1996
THE STEERING WHEEL ARMATURE STAMPING CAN CRACK AND SEPARATE FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN.
Consequence & remedy
Consequence: IF THE STEERING WHEEL SEPARATES FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN, LOSS OF CONTROL CAN OCCUR INCREASING THE RISK OF AN ACCIDENT.
Remedy: DEALERS WILL INSPECT THE STEERING WHEEL FOR ARMATURE CRACKS IN THE CENTER HUB ATTACHMENT AREA. ANY STEERING WHEELS SHOWING CRACKS WILL BE REPLACED. ALL OTHER VEHICLES WILL HAVE A REINFORCEMENT PLATE INSTALLED TO PREVENT STEERING WHEEL SEPARATION IN THE EVENT CRACKING OCCURS.
Jun 13, 1996
THE ABS HYDRAULIC CONTROL UNIT CAN EXPERIENCE EXCESSIVE BRAKE ACTUATOR PISTON SEAL WEAR CAUSING PUMP-MOTOR DETERIORATION.
Consequence & remedy
Consequence: IF THIS CONDITION OCCURS, THE ABS FUNCTION COULD BE LOST AND REDUCED POWER ASSIST WOULD BE EXPERIENCED DURING VEHICLE BRAKING INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL TEST THE VEHICLE'S ANTI-LOCK BRAKE SYSTEM AND REPAIR THE VEHICLES IF NECESSARY. ALSO THE WARRANTY ON ALL ABS COMPONENTS WILL BE EXTENDED TO 10 YEARS OR 100,000 MILES (EXCEPT FOR THE BRAKE ACTUATOR PISTON ASSEMBLY AND THE PUMP-MOTOR ASSEMBLY WHICH WILL HAVE A LIFETIME COVERAGE). OWNERS WILL ALSO BE REIMBURSED FOR PREVIOUS ABS COMPONENT REPAIR COSTS.
Oct 14, 1992
FUEL TANK FLANGES WERE NOT BENT AS REQUIRED TO ALLOW THE SPECIFIED CLEARANCE FOR THE FUEL TANK MOUNTING STRAPS AND FUEL LINES AT THE TANK.
Consequence & remedy
Consequence: THE UNBENT FLANGES TO THE FUEL TANK WILL DAMAGE THEMOUNTING STRAPS AND/OR FUEL LINES. THE DAMAGED MOUNTING STRAPS MAY BREAK CAUSINGTHE TANK TO DROP AND THE DAMAGED FUEL LINE WILL LEAK FUEL. IN EITHER CASE A FIRECOULD RESULT IF THE SPILLED FUEL IS EXPOSED TO AN IGNITION SOURCE.
Remedy: REPAIR THE FLANGE BY BENDING TO THE CORRECT ANGLE; REPLACE DAMAGED FUEL LINES AND MOUNTING STRAPS.
Feb 14, 1992
THE ZINC PLATING OPERATION PERFORMED ON THE UPPER STEERING COLUMN SHAFT COUPLING BOLT CAUSED HYDROGEN EMBRITTLEMENT AND BREAKAGE OF THE BOLT.
Consequence & remedy
Consequence: FRACTURES OF THE UPPER STEERING COLUMN SHAFT COUPLINGBOLT RESULT IN A LACK OF COUPLING LOAD ON THE SHAFT AND LOSS OF STEERINGCONTROL.
Remedy: REPLACE THE ZINC PLATED BOLT WITH A PHOSPHATE PLATED BOLT.
Oct 4, 1991
THE BRAKE PEDAL PAD ATTACHMENT TO THE PEDAL ARM MAY NOT HAVE ADEQUATE STRENGTH DUE TO MISLOCATION OF WELDS, AND COULD BREAK.
Consequence & remedy
Consequence: FAILURE OF THE PEDAL PAD TO PEDAL ARM ATTACHMENT RESULTSIN LOSS OF BRAKING ABILITY, AND COULD RESULT IN AN ACCIDENT.
Remedy: REPLACE INADEQUATE BRAKE PEDALS WITH PROPERLY MANUFACTURED PEDALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
14EA97020 · Front Windshield Wiper
Opened Sep 30, 1997 · Closed Jul 27, 1999
Status: closed (inferred from source dates) · Visibility
ALLEGED FAILURES OF WINDSHIELD WIPER SYSTEMS
PE97013 · Windshield Wiper Failure
Opened Apr 2, 1997 · Closed Sep 30, 1997
Status: closed (inferred from source dates) · Visibility
ALLEGED WINDSHIELD WIPERS FAIL WHILE IN USE
DP97001 · Windshield Wiper Failure
Opened Mar 12, 1997 · Closed Apr 2, 1997
Status: closed (inferred from source dates) · Visibility
CFAS PETITIONED THE AGENCY TO CONDUCT A DEFECT INVESTIGATION ON WINDSHIELD WIPER FAILURE ON 1989 AND LATER CHRYSLER MODELS WHICH SHOULD INCLUDE, BUT NOT LIMITED TO SPIRIT/ACCLAIM: DYNASTY/NEW YORKER/LANDAU; LANCE/LEBARON; SHADOW/SUNDANCE; CARAVAN/VOYAGER.HOWEVER, BASED ON ODI'S COMPLAINT RECORDS, ONLY CERTAIN MINIVANS WILL BE INVESTIGATED
EA96027 · Alleged Rear Liftgate Support Failure
Opened Oct 31, 1996 · Closed May 16, 1997
Status: closed (inferred from source dates) · Structure
THE RETAINER BOLT OF THE REAR LIFTGATE SUPPORT CYLINDERS MAY SHEAR RESULTING IN SUDDEN COLLAPSE OF THE REAR HATCH DOOR.
PE96035 · Alleged Rear Liftgate Support Failure
Opened May 6, 1996 · Closed Oct 31, 1996
Status: closed (inferred from source dates) · Structure
THE RETAINER BOLT OF THE REAR LIFT GATE SUPPORT CYLINDERS MAY SHEER RESULTING IN THE SUDDEN COLLAPSE OF THE REAR HATCH DOOR.
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
EA95029 · Steering Wheel Separation
Opened Sep 26, 1995 · Closed Nov 13, 1996
Status: closed (inferred from source dates) · Steering
AFTER AN EXTENSIVE INVESTIGATION AND ANALYSIS, CHRYSLER HAS IDENTIFIED THE DEFECT AS A FATIGUE FAILURE, ORIGINATION IN THE HEAT AFFECTED REGION OF THE PROJECTION WELDS OF THE STEERING WHEEL HUB TO STEERING WHEEL ARMATURE ATTACHMENT.THE HUB IS THE PORTION OF THE STEERING WHEEL ASSEMBLY THAT CONNECTS IT TO THE STEERING COLUMN SHAFT AND IS ATTACHED TO THE UNDERSIDE OF THE STEERING WHEEL ASSEMBLY BY 4 WELDS.IF CRACKS DEVELOP IN THE HEAT AFFECTED REGION OF THE WELDS AND PROPAGATE THROUGH THE STEERING WHEEL ARMATURE TO EACH OF THE WELDS, THE STEERING WHEEL CAN SEPARATE FROM THE HUB.THIS IS A SLOW PROGRESSIVE FAILURE WHICH NORMALLY OCCURS AT HIGH MILEAGE.IN SOME CASES COMPLAINANTS HAVE REPORTED A LOOSENESS OR WOBBLING OF THE STEERING WHEEL PRIOR TO SEPARATION.TO REMEDY THIS DEFECT, CHRYSLER WILL INSPECT THE STEERING WHEELS OF THE AFFECTED VEHICLES FOR CRACKS IN THE HUB AREA.IF ANY CRACKS ARE FOUND, THE STEERING WHEEL WILL BE REPLACED.ALL OTHER VEHICLES WILL HAVE REINFORCING PLATES INSTALLED WHICH WOULD PREVENT A STEERING WHEEL SEPARATION SHOULD CRACKING OCCUR.
EA94028 · Abs Braking System Fails
Opened Jul 29, 1994 · Closed Jun 24, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE94024 · Abs Braking System Fails
Opened Mar 7, 1994 · Closed Jul 29, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
EA94005 · Liftgate Latches
Opened Jan 31, 1994 · Closed Oct 25, 1995
Status: closed (inferred from source dates) · Structure
LIFTGATE LATCHES IN THE SUBJECT VEHICLES HAVE FAILED IN LOW AND MODERATE SPEED IMPACTS RESULTING IN OCCUPANT EJECTIONS, INJURIES, AND FATALITIES.THERE ARE TWO FAILURE MODES ASSOCIATED WITH LATCH FAILURE: FORK BOLT-DETENT LEVER BYPASS, AND INERTIAL UNLATCHING.NHTSA ANALYSES OF CHRYSLER AND PEER MINIVANS TOOK THE FORM OF STATIC AND DYNAMIC CRASH TESTING, ENGINEERING EVALUATIONS, COMPLAINT AND FIELD ANALYSES, AND REAL WORLD DATA ANALYSES.A TECHNICAL REPORT DISCUSSING THESE ANALYSES CAN BE FOUND IN THE ENGINEERING ANALYSIS TECHNICAL REPORT IN THE PUBLIC VIEWING FILE.CHRYSLER HAS ADVISED NHTSA THAT IT WILL CONDUCT A CAMPAIGN TO REPLACE THE LATCHES ON ALL THE SUBJECT VEHICLES.THE CHRYSLER CAMPAIGN WILL CONSIST OF NOTIFICATION LETTERS TO ALL OWNERS; FREE REPLACEMENT OF ALL LATCHES WITH STRONGER, SAFER LATCHES REGARDLESS OF THE AGE OF THE MINIVANS; NATIONAL ADVERTISING TO PROMOTE CUSTOMER AWARENESS OF THE CAMPAIGN; QUARTERLY REPORTS REGARDING CAMPAIGN COMPLETION RATES; AS WELL AS ADDITIONAL MEASURES TO ENSURE A HIGH COMPLETION RATE, ABOVE AND BEYOND THE ACTIONS THAT NORMALLY WOULD BE TAKEN IN A FORMAL SAFETY RECALL.THESE INCLUDE FOLLOW UP WRITTEN AND TELEPHONIC NOTIFICATIONS TO OWNERS WHO DO NOT BRING THEIR VEHICLES IN FOR CORRECTIVE ACTION.NHTSA FIRMLY BELIEVES THAT THE CRASH PERFORMANCE OF THE LATCHES ON THESE MINIVANS RAISES SERIOUS SAFETY CONCERNS, AND THAT THE CAMPAIGN ADDRESSES THESE CONCERNS.THE CHRYSLER CORRECTIVE ACTION WILL INCREASE THE STRENGTH OF THE LIFTGATE LATCHES AND DECREASE THE POTENTIAL FOR INERTIAL UNLATCHING, THEREBY REDUCING THE RISK OF CRASH-RELATED OPENINGS OF THE LIFTGATE AND POSSIBLE OCCUPANT EJECTION THROUGH THE LIFTGATE OPENING.OWNERS OF CHRYSLER MINIVANS WILL GET A STRONGER, SAFER LATCH FREE OF CHARGE AT THE EARLIEST POSSIBLE TIME, WITHOUT THE NEED FOR FURTHER TECHNICAL INVESTIGATION AND COMPLEX AND TIME-CONSUMING LITIGATION WITH AN UNCERTAIN OUTCOME.BASED ON THE ABOVE, ODI IS CLOSING THIS INVESTIGATION.
PE93084 · Rear Hatch Latch Failure
Opened Sep 30, 1993 · Closed Jan 31, 1994
Status: closed (inferred from source dates) · Structure
There is no summary currently available
EA92033 · Rear Window Shattering
Opened Oct 9, 1992 · Closed Apr 29, 1993
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
PE92053 · Window Shattering
Opened Jun 8, 1992 · Closed Oct 9, 1992
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
PE92004 · Steering Shaft Separations
Opened Jan 9, 1992 · Closed Feb 26, 1992
Status: closed (inferred from source dates) · Steering
There is no summary currently available
Illustration