NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
147 reportsClear category filterMileage unknown · Sep 14, 2000
Engine And Engine Cooling
I OWN A 1995 PLYMOUTH NEON,RECENTLY I NOTICED AN OIL LEAK,COME TO FIND OUT IN MY INVESTIGATION THAT MOST NEONS HAVE HAD THE SAME PROBLEM FROM 1995 TO 1999.THE HEAD GASKET CAN FAIL AT JUST ABOUT ANY MILEAGE ,FROM 10'000 ON UP. THE CHRYSLER CORP. IS BEING AFFORDED THE LUXERY OF HANDLING THIS PROBLEM ON A CASE TO CASE BASIS, UNDER…
Read full complaint
I OWN A 1995 PLYMOUTH NEON,RECENTLY I NOTICED AN OIL LEAK,COME TO FIND OUT IN MY INVESTIGATION THAT MOST NEONS HAVE HAD THE SAME PROBLEM FROM 1995 TO 1999.THE HEAD GASKET CAN FAIL AT JUST ABOUT ANY MILEAGE ,FROM 10'000 ON UP. THE CHRYSLER CORP. IS BEING AFFORDED THE LUXERY OF HANDLING THIS PROBLEM ON A CASE TO CASE BASIS, UNDER THERE SECRET WARRANTIES PROGRAM ,WHICH MEANS THAT A PERSON IGNORANT OF THIS EVIDENT PROBLEM WOULD MORE THAN LIKELY PAY MORE FOR REPAIRS THAN A PERSON WITH KNOWLEDGE OF THE PROBLEM ,THIS IS A VERY UNFAIR WAY TO LET THIS PROBLEM BE HANDLED , I BELIEVE CHRYSLER SHOULD BE MADE TO RECALL THIS PROBLEM HEAD GASKET ,SO THAT ALL CONSUMERS CAN BE TREATED EQUALLY AND HONESTLY. WHY SHOULD GRANDMA HAVE TO PAY $250.00 TO REPAIR HER HEAD GASKET WHEN CURIOUS GEORGE ONLY HAS TO PAY $50.00 . THANK YOU. *AK
NHTSA ODI #731447
Mileage unknown · Sep 13, 2000
Engine And Engine CoolingSuspension
WAS CHARGED A DEDUCTABLE FOR PAINT JOB THAT EQUALED THE COST OF THE PAINT WORK THEY DID. NO SAFETY DEFECT. *AK
NHTSA ODI #731308
Mileage unknown · Sep 2, 2000
Engine And Engine Cooling
CARS JUST CUTS OFF INTERMITTENTLY; NO WARNING, USUALLY WHEN CRUISING AT HIGHWAY SPEED
NHTSA ODI #729990
Mileage unknown · Aug 14, 2000
Engine And Engine Cooling
ENGINE MOUNT BOLTS SHEARED CAUSING ENGINE TO FALL TO THE RIGHT.
NHTSA ODI #727906
Mileage unknown · Aug 9, 2000
Engine And Engine CoolingEquipment
THE AIR CONDITIONING FAILED AT 33000 MILES AND SHOULD NOT HAVE, THE HEAD GASKET IS STILL HANGING IN THERE BUT IS LEAKING A LITTLE EACH DAY, NO EXCUSE, COOLING FANS NEVER RAN AFTER YOU SHUT THE CAR OFF, SOMETIMES ONE WILL RUN AND SOMETIMES BOTH WILL RUN. THEY WILL AT TIMES SHUT DOWN AND LEAVE ME ENOUGH BATTERY TO START THE CAR OR…
Read full complaint
THE AIR CONDITIONING FAILED AT 33000 MILES AND SHOULD NOT HAVE, THE HEAD GASKET IS STILL HANGING IN THERE BUT IS LEAKING A LITTLE EACH DAY, NO EXCUSE, COOLING FANS NEVER RAN AFTER YOU SHUT THE CAR OFF, SOMETIMES ONE WILL RUN AND SOMETIMES BOTH WILL RUN. THEY WILL AT TIMES SHUT DOWN AND LEAVE ME ENOUGH BATTERY TO START THE CAR OR IT MAY NOT. THE CAR IS NOT RUNNING HOT, LESS THAN HALF WAY ON THE GAGE. THE CAR IS MAINTAINED WITH COOLANT FLUSHED AND CHANGED YEARLY. HELP WIRH THIS PIECE OF JUNK. PLYMOUTH SHOULD REPLACE HEAD GASKETS , A/C UNITS ON EVERY ONE MADE AT THERE EXPENSE.
NHTSA ODI #727354
Mileage unknown · Aug 2, 2000
Engine And Engine Cooling
ENGINE STALLING DUE TO MOISTURE GETTING INTO THE POWER MODULE. DEALER NOTIFIED, AND INFORMED CONSUMER THAT ITEM WAS NOT UNDER A MANUFACTURER'S RECALL. FEEL FREE TO PROVIDE ANY FURTHER DETAILS. *AK
NHTSA ODI #866655
Mileage unknown · Aug 2, 2000
Engine And Engine Cooling
AFTER FINDING OIL EVERY TIME ON DRIVER, TOOK VEHICLE TO A TECHINICIAN, AND WAS TOLD THAT PROBLEM WAS THE MASTER SEAL ON THE ENGINE BROKE, ALLOWING OIL TO LEAK AND ENGINE TO OVERHEAT. *AK CUSTMER CALLING FOR ESTIMATED , THREE DIFFERENT MECHANIC SHOPS SAYS THIS PROBLEM WAS VERY COMMON AMONG NEON. *YH
NHTSA ODI #866646
Mileage unknown · Jul 31, 2000
Engine And Engine CoolingEquipmentExterior Lighting
WHILE DRIVING COULD STEP ON THE BRAKES PEDAL AND BRAKES WILL NOT STOP ON TIME.*AK POSSIBLE ENGINE FAILURE CAUSED CHECK THE ENGINE LIGHT TO ILLUMINATE DURING RAIN. BRAKES MAKE A WAILING SOUND. BACK UP LIGHTS FAILED. LIGHTS ON RADIO FAILED. HEAD GASKET LEAKS. *YH
NHTSA ODI #866442
Mileage unknown · Jul 20, 2000
Engine And Engine Cooling
WHILE DRIVING ENGINE COULD LOSE POWER, AND WILL STALL WITHOUT A WARNING SIMILAR TO RECALL 94V033000. *AK
NHTSA ODI #865802
Mileage unknown · Jul 7, 2000
Engine And Engine Cooling
DEFECTIVE HEAD GASKET CAUSED THE ENGINE TO LOCK UP WHICH ALMOST CAUSED A CRASH WHILE DRIVING. DEALER SAID THERE WAS NOT ENOUGH OIL, AND THAT WAS REASON WHY THE ENGINE LOCKED UP. BUT, VEHICLE NEVER RAN OUT OF OIL. PEP BOYS SAID IT WAS A DEFECTIVE HEAD GASKET. PLEASE PROVIDE FURTHER INFORMATION.*AK
NHTSA ODI #864990
Official recalls
6Oct 7, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE STEERING COLUMN COUPLER CAN BECOME DISCONNECTED WHEN THE VEHICLE EXPERIENCES AN UNDERBODY IMPACT.
Consequence & remedy
Consequence: LOSS OF STEERING CONTROL CAN OCCUR.
Remedy: DEALERS WILL REPLACE THE STEERING COLUMN COUPLER WITH A COUPLER DESIGN THAT COLLAPSES ON IMPACT.
Nov 18, 1996
THE FUEL AND REAR BRAKE TUBES CAN EXPERIENCE ACCELERATED CORROSION BETWEEN THE TUBES AND A RUBBER ISOLATOR.
Consequence & remedy
Consequence: CORROSION OF THE TUBES CAN LEAD TO BRAKE FLUID OR FUEL LEAKAGE. THIS CAN CAUSE A LOSS OF BRAKES OR RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE BRAKE, FUEL SUPPLY AND FUEL VAPOR TUBES FOR THE PRESENCE OF CORROSION. ANY TUBES SHOWING CORROSION WILL BE REPLACED. ALL VEHICLES WILL HAVE THE RUBBER ISOLATOR REPLACED WITH A PLASTIC CLIP.
Additional source detail variants (2)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
THE FUEL AND REAR BRAKE TUBES CAN EXPERIENCE ACCELERATED CORROSION BETWEEN THE TUBES AND A RUBBER ISOLATOR.
Consequence: CORROSION OF THE TUBES CAN LEAD TO BRAKE FLUID OR FUEL LEAKAGE. THIS CAN CAUSE A LOSS OF BRAKES OR RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE BRAKE, FUEL SUPPLY AND FUEL VAPOR TUBES FOR THE PRESENCE OF CORROSION. ANY TUBES SHOWING CORROSION WILL BE REPLACED. ALL VEHICLES WILL HAVE THE RUBBER ISOLATOR REPLACED WITH A PLASTIC CLIP.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
THE FUEL AND REAR BRAKE TUBES CAN EXPERIENCE ACCELERATED CORROSION BETWEEN THE TUBES AND A RUBBER ISOLATOR.
Consequence: CORROSION OF THE TUBES CAN LEAD TO BRAKE FLUID OR FUEL LEAKAGE. THIS CAN CAUSE A LOSS OF BRAKES OR RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE BRAKE, FUEL SUPPLY AND FUEL VAPOR TUBES FOR THE PRESENCE OF CORROSION. ANY TUBES SHOWING CORROSION WILL BE REPLACED. ALL VEHICLES WILL HAVE THE RUBBER ISOLATOR REPLACED WITH A PLASTIC CLIP.
May 3, 1996
THE BRAKE MASTER CYLINDER CAN LEAK BRAKE FLUID DUE TO A DAMAGED DOUBLE LIP REAR PISTON SEAL.
Consequence & remedy
Consequence: BRAKE FLUID LEAKAGE CAN RESULT IN DIMINISHED EFFECTIVENESS OF ONE HALF OF THE SPLIT BRAKE SYSTEM. THE INSTRUMENT PANEL WARNING LIGHT(S) WILL SIGNAL SYSTEM IMPAIRMENT PRIOR TO PARTIAL BRAKE SYSTEM LOSS.
Remedy: DEALERS WILL REPLACE THE REAR BRAKE MASTER CYLINDR PISTON ASSEMBLY.
Feb 23, 1994
MOISTURE CAN GET INTO THE POWERTRAIN CONTROL MODULE (PCM) CAUSING DRIVEABILITY MALFUNCTIONS, INCLUDING STALLING.
Consequence & remedy
Consequence: SHOULD DRIVE ABILITY MALFUNCTIONS OR STALLING OCCUR WHILETHE VEHICLE IS IN MOTION, A TRAFFIC ACCIDENT MAY OCCUR.
Remedy: THE POWERTRAIN CONTROL MODULES ON THESE VEHICLES WILL BE REPLACED.
Feb 23, 1994
THE REAR BRAKE HOSE MOUNTING BRACKET SCREWS CAN FAIL ALLOWING THE BRAKE HOSES TO MOVE OUT OF POSITION. THE UNRESTRAINED HOSES ARE THEN SUSCEPTIBLE TO DAMAGE WHICH COULD RESULT IN BRAKE FLUID LEAKAGE.
Consequence & remedy
Consequence: BRAKE FLUID LEAKAGE WILL REDUCE THE BRAKING PERFORMANCEOF THE VEHICLE, EXTEND STOPPING DISTANCES, AND COULD RESULT IN AN ACCIDENT.
Remedy: THE REAR BRAKE LINE HOSE BRACKET SCREWS ON THESE VEHICLES WILL BE REPLACED.
Jan 9, 1994
THE ABS BRAKE MASTER CYLINDER REAR SEAL ALLOWS AIR TO ENTER THE BRAKE SYSTEM, CAUSING SPONGY BRAKES OR PARTIAL BRAKE SYSTEM LOSS.
Consequence & remedy
Consequence: AIR ENTERING THE BRAKE SYSTEM CAUSED EXTENDED STOPPING DISTANCE OR PARTIAL LOSS OF BRAKES WHICH MAY RESULT IN AN ACCIDENT.
Remedy: MASTER CYLINDERS WILL BE INSPECTED FOR THE SUSPECT BUILD DATE CODE RANGE AND WILL BE REPLACED IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
PE98012 · Underhood Fires
Opened Feb 26, 1998 · Closed Jun 23, 1998
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
EA98003 · Oversensitive Air Bag Deployments
Opened Jan 30, 1998 · Closed Jan 5, 2000
Status: closed (inferred from source dates) · Air Bags
No summary supplied.
PE97042 · Oversensitive Air Bag Deployment
Opened Sep 21, 1997 · Closed Jan 30, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
EA97009 · Loss Of Steering Control
Opened Apr 30, 1997 · Closed Oct 8, 1997
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE97007 · Alleged Fires In Steering Column Area
Opened Jan 31, 1997 · Closed Apr 7, 1997
Status: closed (inferred from source dates) · Electrical System
THE APPARENT CAUSE OF THE PROBLEM IS THE ACCUMULATION OF BRASS POWDER, THAT WEARS OFF THE ELECTRICAL CONTACTS INSIDE THE TURN SIGNAL SWITCH.THIS POWDER COLLECTS IN SMALL TRAILS OF GREASE THAT TRACK FROM ONE CONTACT TO ANOTHER.WHEN THE CONCENTRATION OF BRASS IN THE GREASE GETS HIGH ENOUGH, IT CAN CAUSE A HIGH RESISTANCE SHORT.THIS SHORT, IN TURN CAN IGNITE THE GREASE AND CAUSE SMOKE TO BE EMITTED FROM THE STEERING COLUMN.THE GREASE USED INSIDE THE SWITCH, AS WELL AS THE VARIOUS PLASTIC COMPONENTS IN THE COLUMN, ARE FIRE RETARDANT AND WILL NOT BURN WITHOUT A SUSTAINED HEAT SOURCE.THERE HAS BEEN ONLY A SINGLE VERIFIED INCIDENT THAT RESULTED IN A VEHICLE FIRE AND THIS REPORTED FIRE WAS SMALL, INVOLVING SOME CHARRING OF THE STEERING WHEEL.ALL OTHER VERIFIED INCIDENTS WERE LIMITED TO SMOKE FROM THE COLUMN AND MINOR INTERNAL DAMAGE TO THE STEERING COLUMN.
PE96069 · Loss Of Steering Control
Opened Nov 26, 1996 · Closed Apr 30, 1997
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE94095 · Loss Of Steering Control
Opened Dec 28, 1994 · Closed Apr 25, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
Illustration