NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
147 reportsClear category filterMileage unknown · Dec 10, 2005
Electrical SystemEngine And Engine CoolingStructure
NUMEROUS HEATING COOLING PROBLEMS. INCORRECT TEMPERATURE GAUGE, OVERHEATING, RADIATOR FANS NOT COMING ON, ERRATIC FAN OPERATION, WATER LEAKING IN FROM FIREWALL POURING INTO THE BLOWER MOTOR CAUSING BLOWN FUSES, FAULTY BLOWER MOTORS AND SOAKING CARPETS. WIRING PROBLEMS CAUSING FUSES TO BLOW WHEN FANS WOULD KICK ON, A/C WAS TURN…
Read full complaint
NUMEROUS HEATING COOLING PROBLEMS. INCORRECT TEMPERATURE GAUGE, OVERHEATING, RADIATOR FANS NOT COMING ON, ERRATIC FAN OPERATION, WATER LEAKING IN FROM FIREWALL POURING INTO THE BLOWER MOTOR CAUSING BLOWN FUSES, FAULTY BLOWER MOTORS AND SOAKING CARPETS. WIRING PROBLEMS CAUSING FUSES TO BLOW WHEN FANS WOULD KICK ON, A/C WAS TURNED ON, OR DASH WOULD EMIT SMOKE WHEN THE PARKING BREAK WAS ENGAGED WITH THE VEHICLE RUNNING, ERRATIC GAUGE CLUSTER, OFF AND ON GAUGES, INTERIOR LIGHTS FAILURE. *NM
NHTSA ODI #10144880
Mileage unknown · Aug 20, 2004
Engine And Engine Cooling
THE VEHICLE'S HEAD GASKET BLEW.*MR THE CONSUMER REPLACED THE HEAD GASKET . *NM
NHTSA ODI #10089546
Mileage unknown · Jan 21, 2004
Engine And Engine Cooling
POOR DESIGN LEADS TO HEAD GASKET OF PLYMOUTH NEONS TO BLOW FREQUENTLY. CHRYSLER OFFERS NO RE-CALL OR FINANCIAL ASSISTANCE TO CUSTOMERS WITH THIS PROBLEM. MY CAR HAS 63,000 MILES ON IT AND THIS HAS HAPPENED 3 TIMES.*AK
NHTSA ODI #10054593
Mileage unknown · May 1, 2003
Engine And Engine CoolingFire
WHILE DRIVING THE VEHICLE BEGAN MAKING NOISE. THE DRIVER PULLED OVER THEN NOTICED THAT THE VEHICLE WAS ON FIRE. *NLM
NHTSA ODI #10017976
100,070 miles · Dec 17, 2002
Engine And Engine Cooling
UPON INSPECTION OF VEHICLE, CONSUMER NOTICED A LEAK COMING FROM THE VALVE COVER. CONSUMER STATED THAT IF THIS LEAK CONTINUED, IT COULD RESULT IN AN ENGINE FIRE. PLEASE PROVIDE MORE DETAILS. TS
NHTSA ODI #10001068
63,400 miles · Dec 17, 2002
Engine And Engine Cooling
I RECENTLY DISCOVERED THAT MY 1995 PLYMOUTH NEON HAS A BLOWN HEAD GASKET. THE DEALER THAT I TOOK IT TO FOR REPAIRS TOLD ME THAT IT WAS NO LONGER UNDER WARRENTY, BUT THAT I COULD CONTACT CHRYSLER TO SEE IF THEY WOULD COVER THE REPAIRS. MY CAR IS IN EXCELLENT SHAPE AND ONLY HAS 63,000 MILES ON IT. CHRYSLER HAS DECLINED TO COVER AN…
Read full complaint
I RECENTLY DISCOVERED THAT MY 1995 PLYMOUTH NEON HAS A BLOWN HEAD GASKET. THE DEALER THAT I TOOK IT TO FOR REPAIRS TOLD ME THAT IT WAS NO LONGER UNDER WARRENTY, BUT THAT I COULD CONTACT CHRYSLER TO SEE IF THEY WOULD COVER THE REPAIRS. MY CAR IS IN EXCELLENT SHAPE AND ONLY HAS 63,000 MILES ON IT. CHRYSLER HAS DECLINED TO COVER ANY OF THE COST OF PARTS AND SERVICE FOR THIS REPAIR, DESPITE THE FACT THAT THEY ARE AWARE THAT HEAD GASKETS ARE A DEFECT IN THIS CAR. I HAVE DONE SOME RESEARCH AND DISCOVERED THAT MANY NEON OWNERS ARE FIGHTING THIS SAME BATTLE. I AM APALLED THAT A RECALL WAS NEVER DONE ON THIS PART. VIEW OTHERS PROBLEMS WITH THE NEON HEAD GASTKET AT THIS WEBSITE. <HTTP://GROUPS.GOOGLE.COM/GROUPS?Q=NEON+HEAD+GASKET&IE=ISO-8859-1&HL=EN> I WOULD APPRECIATE IT IF YOU COULD GIVE ME ANY ADVICE ON THIS MATTER. DO YOU BELIEVE THAT THIS DEFECT WARRANTS A RECALL?
NHTSA ODI #10000185
Mileage unknown · Nov 15, 2002
Engine And Engine CoolingFuel System, Gasoline
HAVE HAD PROBLEMS WITH A/C CLUTCH, SEIZED UP AND STARTED SMOKING CAR IS MAJOR HAZARD. DT
NHTSA ODI #769732
Mileage unknown · Nov 8, 2002
Engine And Engine Cooling
HEAD GASKET FAILED AT APPROXIMATELY 75,000 MILES; LEAKED OIL THROUGHOUT COOLANT SYSTEM, WHICH REQUIRED THE REPLACEMENT OF ALL COMPONENT PARTS, SAVE FOR THE RADIATOR, AND THE OXYGEN FLOW SENSOR. CHRYSLER PAID ALL BUT $200 OF THE GASKET REPAIR, AND I AM ATTEMPTING TO RECOVER THE COST OF THE REMAINING REPAIR WORK. DT
NHTSA ODI #769478
Mileage unknown · Oct 24, 2002
Engine And Engine Cooling
HEAD GASKET FAILED CAUSING OIL TO LEAK INTO COOLANT AND ENGINE TO OVERHEAT. OVERHEATING OCCURED ON EXPRESSWAY CASUING ME TO PULL TO THE SIDE OF THE ROAD. OIL AND COOLANT SPILLED OUT THROUGH THE OVERFLOW BOTTLE. DT
NHTSA ODI #768854
Mileage unknown · Sep 24, 2002
Engine And Engine Cooling
CONSUMER STATES HEAD GASKET BLEW 2 DIFFERENT TIMES WHILE DRIVING CAUSING VEHICLE TO STALL.*JB
NHTSA ODI #8019297
Official recalls
6Oct 7, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE STEERING COLUMN COUPLER CAN BECOME DISCONNECTED WHEN THE VEHICLE EXPERIENCES AN UNDERBODY IMPACT.
Consequence & remedy
Consequence: LOSS OF STEERING CONTROL CAN OCCUR.
Remedy: DEALERS WILL REPLACE THE STEERING COLUMN COUPLER WITH A COUPLER DESIGN THAT COLLAPSES ON IMPACT.
Nov 18, 1996
THE FUEL AND REAR BRAKE TUBES CAN EXPERIENCE ACCELERATED CORROSION BETWEEN THE TUBES AND A RUBBER ISOLATOR.
Consequence & remedy
Consequence: CORROSION OF THE TUBES CAN LEAD TO BRAKE FLUID OR FUEL LEAKAGE. THIS CAN CAUSE A LOSS OF BRAKES OR RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE BRAKE, FUEL SUPPLY AND FUEL VAPOR TUBES FOR THE PRESENCE OF CORROSION. ANY TUBES SHOWING CORROSION WILL BE REPLACED. ALL VEHICLES WILL HAVE THE RUBBER ISOLATOR REPLACED WITH A PLASTIC CLIP.
Additional source detail variants (2)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
THE FUEL AND REAR BRAKE TUBES CAN EXPERIENCE ACCELERATED CORROSION BETWEEN THE TUBES AND A RUBBER ISOLATOR.
Consequence: CORROSION OF THE TUBES CAN LEAD TO BRAKE FLUID OR FUEL LEAKAGE. THIS CAN CAUSE A LOSS OF BRAKES OR RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE BRAKE, FUEL SUPPLY AND FUEL VAPOR TUBES FOR THE PRESENCE OF CORROSION. ANY TUBES SHOWING CORROSION WILL BE REPLACED. ALL VEHICLES WILL HAVE THE RUBBER ISOLATOR REPLACED WITH A PLASTIC CLIP.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
THE FUEL AND REAR BRAKE TUBES CAN EXPERIENCE ACCELERATED CORROSION BETWEEN THE TUBES AND A RUBBER ISOLATOR.
Consequence: CORROSION OF THE TUBES CAN LEAD TO BRAKE FLUID OR FUEL LEAKAGE. THIS CAN CAUSE A LOSS OF BRAKES OR RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE BRAKE, FUEL SUPPLY AND FUEL VAPOR TUBES FOR THE PRESENCE OF CORROSION. ANY TUBES SHOWING CORROSION WILL BE REPLACED. ALL VEHICLES WILL HAVE THE RUBBER ISOLATOR REPLACED WITH A PLASTIC CLIP.
May 3, 1996
THE BRAKE MASTER CYLINDER CAN LEAK BRAKE FLUID DUE TO A DAMAGED DOUBLE LIP REAR PISTON SEAL.
Consequence & remedy
Consequence: BRAKE FLUID LEAKAGE CAN RESULT IN DIMINISHED EFFECTIVENESS OF ONE HALF OF THE SPLIT BRAKE SYSTEM. THE INSTRUMENT PANEL WARNING LIGHT(S) WILL SIGNAL SYSTEM IMPAIRMENT PRIOR TO PARTIAL BRAKE SYSTEM LOSS.
Remedy: DEALERS WILL REPLACE THE REAR BRAKE MASTER CYLINDR PISTON ASSEMBLY.
Feb 23, 1994
MOISTURE CAN GET INTO THE POWERTRAIN CONTROL MODULE (PCM) CAUSING DRIVEABILITY MALFUNCTIONS, INCLUDING STALLING.
Consequence & remedy
Consequence: SHOULD DRIVE ABILITY MALFUNCTIONS OR STALLING OCCUR WHILETHE VEHICLE IS IN MOTION, A TRAFFIC ACCIDENT MAY OCCUR.
Remedy: THE POWERTRAIN CONTROL MODULES ON THESE VEHICLES WILL BE REPLACED.
Feb 23, 1994
THE REAR BRAKE HOSE MOUNTING BRACKET SCREWS CAN FAIL ALLOWING THE BRAKE HOSES TO MOVE OUT OF POSITION. THE UNRESTRAINED HOSES ARE THEN SUSCEPTIBLE TO DAMAGE WHICH COULD RESULT IN BRAKE FLUID LEAKAGE.
Consequence & remedy
Consequence: BRAKE FLUID LEAKAGE WILL REDUCE THE BRAKING PERFORMANCEOF THE VEHICLE, EXTEND STOPPING DISTANCES, AND COULD RESULT IN AN ACCIDENT.
Remedy: THE REAR BRAKE LINE HOSE BRACKET SCREWS ON THESE VEHICLES WILL BE REPLACED.
Jan 9, 1994
THE ABS BRAKE MASTER CYLINDER REAR SEAL ALLOWS AIR TO ENTER THE BRAKE SYSTEM, CAUSING SPONGY BRAKES OR PARTIAL BRAKE SYSTEM LOSS.
Consequence & remedy
Consequence: AIR ENTERING THE BRAKE SYSTEM CAUSED EXTENDED STOPPING DISTANCE OR PARTIAL LOSS OF BRAKES WHICH MAY RESULT IN AN ACCIDENT.
Remedy: MASTER CYLINDERS WILL BE INSPECTED FOR THE SUSPECT BUILD DATE CODE RANGE AND WILL BE REPLACED IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
PE98012 · Underhood Fires
Opened Feb 26, 1998 · Closed Jun 23, 1998
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
EA98003 · Oversensitive Air Bag Deployments
Opened Jan 30, 1998 · Closed Jan 5, 2000
Status: closed (inferred from source dates) · Air Bags
No summary supplied.
PE97042 · Oversensitive Air Bag Deployment
Opened Sep 21, 1997 · Closed Jan 30, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
EA97009 · Loss Of Steering Control
Opened Apr 30, 1997 · Closed Oct 8, 1997
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE97007 · Alleged Fires In Steering Column Area
Opened Jan 31, 1997 · Closed Apr 7, 1997
Status: closed (inferred from source dates) · Electrical System
THE APPARENT CAUSE OF THE PROBLEM IS THE ACCUMULATION OF BRASS POWDER, THAT WEARS OFF THE ELECTRICAL CONTACTS INSIDE THE TURN SIGNAL SWITCH.THIS POWDER COLLECTS IN SMALL TRAILS OF GREASE THAT TRACK FROM ONE CONTACT TO ANOTHER.WHEN THE CONCENTRATION OF BRASS IN THE GREASE GETS HIGH ENOUGH, IT CAN CAUSE A HIGH RESISTANCE SHORT.THIS SHORT, IN TURN CAN IGNITE THE GREASE AND CAUSE SMOKE TO BE EMITTED FROM THE STEERING COLUMN.THE GREASE USED INSIDE THE SWITCH, AS WELL AS THE VARIOUS PLASTIC COMPONENTS IN THE COLUMN, ARE FIRE RETARDANT AND WILL NOT BURN WITHOUT A SUSTAINED HEAT SOURCE.THERE HAS BEEN ONLY A SINGLE VERIFIED INCIDENT THAT RESULTED IN A VEHICLE FIRE AND THIS REPORTED FIRE WAS SMALL, INVOLVING SOME CHARRING OF THE STEERING WHEEL.ALL OTHER VERIFIED INCIDENTS WERE LIMITED TO SMOKE FROM THE COLUMN AND MINOR INTERNAL DAMAGE TO THE STEERING COLUMN.
PE96069 · Loss Of Steering Control
Opened Nov 26, 1996 · Closed Apr 30, 1997
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE94095 · Loss Of Steering Control
Opened Dec 28, 1994 · Closed Apr 25, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
Illustration