NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
15 reportsClear category filter82,274 miles · Apr 9, 2007
Engine And Engine Cooling
INTAKE MANIFOLD GASKET FAILED TWICE. FIRST REPAIRED AT MONROE SERVICE ON 11-18-2005 AT 76655 MILES THE COST WAS $731.16. SECOND REPAIR WAS AT GOODYEAR GEMINI ON 12-21-2006 AT 82274MILES. THE COST WAS $642.40. BOTH FACILITIES WERE ASE CERTIFIED. I HAVE BEEN AN ASSISTANT STORE MANAGER IN THE PAST FOR BOTH PROCARE AND GOO…
Read full complaint
INTAKE MANIFOLD GASKET FAILED TWICE. FIRST REPAIRED AT MONROE SERVICE ON 11-18-2005 AT 76655 MILES THE COST WAS $731.16. SECOND REPAIR WAS AT GOODYEAR GEMINI ON 12-21-2006 AT 82274MILES. THE COST WAS $642.40. BOTH FACILITIES WERE ASE CERTIFIED. I HAVE BEEN AN ASSISTANT STORE MANAGER IN THE PAST FOR BOTH PROCARE AND GOODYEAR, AND RARELY SAW A FAILURE OF AN INTAKE MANIFOLD GASKET, EXCEPT IN EARLY FORIEGN ENGINES WITH ALUMINUM BLOCKS OR ALUMINUM HEADS OR BOTH. I JUST HAD A FRONT BRAKE OVERHAUL AT MIDAS, AND THE TECH NICIAN ASKED IF I HAD HAD ANY PROBLEMS WITH THEINTAKE MANIFOLD GASKET, WHICH SET ME OFF ON THIS SEARCH. I TALKED TO THE MANAGERS AT BOTH MONROE AND GOODYEAR ,AND BOTH SAID THEY HAVE HAD MANY PROBLEMS WITH THESE GASKETS THAT THEY HAVE HAD TO REPAIR. DID A GOOGLE SEARCH AND FOUND MANY COMPLAINTS ABOUT IT, AND SAW THAT A CLASS ACTION LAWSUIT OUT OF CANADA WAS BEING FILED. I COULD PROVIDE THE NECESSARY DOCUMENTATION OF BOTH REPAIRS. TALKED TO GM ABOUT IT, AND AS I EXPECTED, SAID THAT I DIDN'T BRING IT TO A GM FACILITY FOR REPAIR, AND THAT IT HAD EXCESSIVE MILEAGE. I DID NOT CONSIDER 76665 OR 82274 AS EXCESSIVE MILEAGE FOR THE YEAR OF THE CAR OR THIS TYPE OF FAILURE. WHAT WOULD HAVE HAPPENED IF THIS DEFECT CAUSED FUEL TO LEAK OUT ONTO HOT EXTERIOR OF THE ENGINE? *AK
NHTSA ODI #10187341
129,000 miles · Apr 4, 2006
Engine And Engine Cooling
INTAKE MANIFOLD GASKET- 3100 V6 ENGINE ON GM PRODUCT. *JB
NHTSA ODI #10154524
41,000 miles · Nov 16, 2005
Engine And Engine Cooling
DT:THE CONTACT STATED THE INTAKE MANIFOLD GASKET LEAKED OIL AND ANTIFREEZE DUE TO THE TYPE OF PLASTIC THAT WAS MANUFACTURED FOR THIS GASKET. THE GASKET HAS NOT BEEN REPAIRED BECAUSE THE MANUFACTURER WILL NOT ASSIST IN THE COST. *AK UPDATED 11/30/2005 - ALTHOUGH THE DEALER VERIFIED THE PROBLEM AS REQUESTED BY THE MANUFACTURER …
Read full complaint
DT:THE CONTACT STATED THE INTAKE MANIFOLD GASKET LEAKED OIL AND ANTIFREEZE DUE TO THE TYPE OF PLASTIC THAT WAS MANUFACTURED FOR THIS GASKET. THE GASKET HAS NOT BEEN REPAIRED BECAUSE THE MANUFACTURER WILL NOT ASSIST IN THE COST. *AK UPDATED 11/30/2005 - ALTHOUGH THE DEALER VERIFIED THE PROBLEM AS REQUESTED BY THE MANUFACTURER THEY REFUSED REFUSED TO COVER THE COST OF THE REPAIR. *NM
NHTSA ODI #10142877
59,850 miles · Mar 24, 2005
Engine And Engine Cooling
CONSUMER STATED THAT THE VEHICLE CONTINUED TO SHUT DOWN IN TRAFFIC, AND LEAKED ANTIFREEZE CONTINUOUSLY. *AK
NHTSA ODI #10115725
101,000 miles · Dec 10, 2004
Engine And Engine Cooling
ENGINE OVERHEATED. CONSUMER MADE IT HOME, AND AFTER THE VEHICLE WAS INSPECTED, IT WAS DISCOVERED THAT ENGINE WAS DEFECTIVE. THE MANUFACTURER OFFERED NO ASSISTANCE.*AK
NHTSA ODI #10103537
60,000 miles · Feb 18, 2004
Engine And Engine Cooling
WHILE DRIVING AT 30 MPH CONSUMER HEARD A LOUD NOISE COMING THROUGH THE ENGINE. SUDDENLY, STEERING WHEEL LOCKED . VEHICLE WAS TAKEN TO THE DEALERSHIP, AND THE TECHNICIAN DETERMINED THAT SERPENTINE BELT BROKE. *AK
NHTSA ODI #10059221
52,400 miles · Nov 21, 2003
Engine And Engine Cooling
I HAVE A 97 AND 99 OLDSMOBILE CUTLAS WITH V6-191 3.1L VIN M SFI ENGINES. THEY BOTH LEAK COOLANT FROM THE INTAKE MANIFOLD AT THE REAR OF THE ENGINE. I AM TOLD THIS IS A COMMON PROBLEM WITH THIS ENGINE AND IS CAUSED BY THE DEX COOL ANTI-FREEZE INSTALLED BY THE MFG. THE COST EST. FROM THE OLDS DEALER IS $850.00 TO REPLACE THE GASK…
Read full complaint
I HAVE A 97 AND 99 OLDSMOBILE CUTLAS WITH V6-191 3.1L VIN M SFI ENGINES. THEY BOTH LEAK COOLANT FROM THE INTAKE MANIFOLD AT THE REAR OF THE ENGINE. I AM TOLD THIS IS A COMMON PROBLEM WITH THIS ENGINE AND IS CAUSED BY THE DEX COOL ANTI-FREEZE INSTALLED BY THE MFG. THE COST EST. FROM THE OLDS DEALER IS $850.00 TO REPLACE THE GASKET. THESE CARS EACH HAVE 50,000 MI. IF THIS IS IN FACT A COMMON PROBLEM I SHOULD GET SOME RELIEF FROM THE MANUFACTURE. *LA
NHTSA ODI #10047305
137,000 miles · Aug 21, 2003
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
SINCE I PURCHASED THE VEHICLE IN 1997, THERE HAVE BEEN NUMEROUS PROBLEMS. THE FRONT BRAKES HAVE BEEN REPLACED 3 TIMES, ONCE WHILE STILL UNDER WARRANTY. THE AIR CONDITIONING UNIT FAILED, AN $800 REPAIR. THE MOTOR ON THE DRIVER SIDE WINDOW MALFUNCTIONED, A $400 REPAIR. TODAY, WHILE DRIVING HOME THE BATTERY LIGHT CAME ON, I WAS…
Read full complaint
SINCE I PURCHASED THE VEHICLE IN 1997, THERE HAVE BEEN NUMEROUS PROBLEMS. THE FRONT BRAKES HAVE BEEN REPLACED 3 TIMES, ONCE WHILE STILL UNDER WARRANTY. THE AIR CONDITIONING UNIT FAILED, AN $800 REPAIR. THE MOTOR ON THE DRIVER SIDE WINDOW MALFUNCTIONED, A $400 REPAIR. TODAY, WHILE DRIVING HOME THE BATTERY LIGHT CAME ON, I WAS WITHIN A MILE OF HOME, SO I JUST KEPT GOING. AS I WAS TURNING INTO MY DRIVEWAY, ALL OF THE CONTROLS ON THE DASHBOARD FAILED, SPEED LIMIT, GAS GAUGE, ETC. I ALSO APPARENTLY HAD NO LIGHTS BECAUSE THE CAR BEHIND ME ALMOST RAN INTO ME WHEN THE TURN SIGNALS DIDN'T WORK.*AK
NHTSA ODI #10033265
Mileage unknown · Jul 30, 2001
Electrical SystemEngine And Engine CoolingUnknown Or Other
ENGINE REAR NUT BOLTS BROKEN, ENGINE MOVES AT THE LEAST BUMP ON PAVEMENT. TICKING NOISE FROM THE ENGINE. SOMETIMES THE CAR WILL NOT START RIGHT AWAY. COOLANT CONSTANT NEEDED. ENGINE LIGHT/OR BATTERY LIGHT COMES ON.*AK
NHTSA ODI #749416
Mileage unknown · Jun 14, 2001
Electrical SystemEngine And Engine CoolingEquipment
ABS LIGHT HAS BEEN COMING ON INTERMITTENTLY, BRAKING DISTANCE IS NORMAL. VEHICLE TAKEN TO DEALER 15-20 TIMES. REPLACED BRAKE PADS/ ALTERNATOR/ BATTERY/ WIRING HARNESS, AND PUT IN SENSOR. DID NOT REMEDY PROBLEM, VEHICLE AT DEALER AT THIS TIME. *AK SERPENTINE AND TENSIONER BELT BROKEN. SECURITY LIGHT BLINKS DUE TO BAD THEFT …
Read full complaint
ABS LIGHT HAS BEEN COMING ON INTERMITTENTLY, BRAKING DISTANCE IS NORMAL. VEHICLE TAKEN TO DEALER 15-20 TIMES. REPLACED BRAKE PADS/ ALTERNATOR/ BATTERY/ WIRING HARNESS, AND PUT IN SENSOR. DID NOT REMEDY PROBLEM, VEHICLE AT DEALER AT THIS TIME. *AK SERPENTINE AND TENSIONER BELT BROKEN. SECURITY LIGHT BLINKS DUE TO BAD THEFT LOCK SENSOR ASSEMBLY . BLOWER SPEEDS INOPERATIVE. A/C CONTROL INOPERATIVE. LEFT FRONT SEAT BELT BUCKLE FALLS TO FLOOR. POWER WINDOW INOPERABLE DUE TO ELECTRICAL SWITCH FAILURE. *YH
NHTSA ODI #890371
Official recalls
2Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
Mar 8, 2001
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE "SALT BELT" STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. IF A BUILDUP OF SNOW OR ICE RESTRICTS THE MOVEMENT OF THE PASSENGER SIDE WINDSHIELD WIPER ARM, THE PIVOT HOUSING CAN CRACK AND THE WIPERS WILL NOT OPERATE.
Consequence & remedy
Consequence: REDUCED VISIBILITY IN INCLEMENT WEATHER COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE WINDSHIELD WIPER PIVOT HOUSING. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR OLDSMOBILE AT 1-800-442-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6RQ04006 · Windshield Wiper Failure
Opened Jul 7, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA02003 · Power Rack And Pinion Steering Failure
Opened Apr 4, 2002 · Closed Dec 10, 2002
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Steering
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
PE01038 · Steering Rack And Pinion
Opened Nov 14, 2001 · Closed Apr 4, 2002
Status: closed (inferred from source dates) · Steering
ODI HAS RECEIVED 200 COMPLAINTS FROMT CONSUMERS AND 1,238 FROM GM ALLEGING FAILURE OR LOCKUP OF THE STEERING RACK AND PINION UNIT (R&P).THIS ALLEGED CONDITION CAN RESULT IN THE LOSS OF STEERING CONTROL OF THE VEHICLE AND A CRASH CAN RESULT.GM HAS REPORTED SIX CRASHES IN WHICH EIGHT PEOPLE HAVE SUSTAINED INJURIES RANGING FROM BRUISES, AIRBAG BURN, SEAT BELT ABRASION, FACIAL INJURY, NECK AND BACK PAIN.ALL CRASHES WERE SINGLE VEHICLE CRASHES.GM STATES THAT ONE POSSIBLE FAILURE MODE IS FAILURE OF THE LOWER PINION BEARING IN THE R&P.AN ENGINEERING ANALYSIS HAS BEEN OPENED TO DETERMINE IF A SAFETY DEFECT TREND EXISTS.
EA00019 · Windshield Wiper
Opened Jul 12, 2000 · Closed Mar 6, 2001
Status: closed (inferred from source dates) · Visibility
ON FEBRUARY 22, 2000, THE OFFICE OF DEFECTS INVESTIGATION (ODI) INITIATED PE00-009 BASED ON SEVEN REPORTS OF WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 1997 & 1998 CHEVROLET MALIBU & OLDSMOBILE CUTLASS VEHICLES.THE INVESTIGATION WAS UPGRADED TO EA00-019 ON JULY 12, 2000.DURING THE COURSE OF THE INVESTIGATION, IT WAS FOUND THAT THE FAILURES WERE THE RESULT OF FRACTURE OF THE PASSENGER-SIDE WINDSHIELD WIPER PIVOT HOUSING (SUBJECT COMPONENT).SUCH A FRACTURE LED TO AN IMMEDIATE AND IRRECOVERABLE LOSS OF WINDSHIELD WIPER FUNCTION.GMREPORTED THAT THE MATERIAL COMPOSITION (50% GLASS-REINFORCED ACETAL) OF THE SUBJECT COMPONENT WAS INSUFFICIENT TO WITHSTAND STRESSES IMPOSED BY CERTAIN FROZEN PRECIPITIATION ACCUMULATIONS.THE SUBJECT COMPONENT MATERIAL WAS CHANGED TO THE STRONGER 50% GLASS-REINFORCEDNYLON-6, EFFECTIVE JANUARY 98.OBSOLETE SERVICE PART WERE DISCARDED.GM WILL REPLACE THE SUBJECT COMPONENTS IN 129,427 SUBJECT VEHICLES FOUND IN 28 STATES (AK, CO, CT, DE, ID, IL, IN, IA ME, MD, MA, MI, MN, MT, NE, NH, NJ, NY, ND, OH, PA, RI, SD, UT, VT, WV, WI, WY), THE DISTRICT OF COLUMBIA, AND ALL CANADIAN PROVINCES.THESE STATES ACCOUNTED FOR 91% OF THE CONSUMER COMPLAINTS IDENTIFIED ABOVE.ODI WILL MONITOR THIS COMPAIGN FOR ADEQUATE EFFCTIVENESS AND, IF NECESSARY, TAKE FURTHER ACTION IN THE FUTURE.FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS MATTER IS UNJUSTIFIED AT THIS TIME.THE ENGINEERING ANALYSIS IS CLOSED.
PE00009 · Windshield Wiper
Opened Feb 22, 2000 · Closed Jul 12, 2000
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
Illustration