NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
364 reports104,000 miles · Feb 15, 2014
Electrical SystemEngine
THIS HAS HAPPENED TO ME IN MY 2001 OLDSMOBILE ALERO OVER AND OVER AGAIN FOR THE PAST 4 YEARS,AND HAVE HAD IT AT 4 OR 5 DIFFERENT SHOPS AND NOBODY CAN FIX IT. BUT THE CAR TURNS OFF ON ME IN THE MIDDLE OF DRIVING AND THEN WONT RESTART. BUT AFTER I HAVE IT TOWED HOME IT WILL START A DAY OR TWO LATER.. I'VE HAD THE BATTERY REPLACED,…
Read full complaint
THIS HAS HAPPENED TO ME IN MY 2001 OLDSMOBILE ALERO OVER AND OVER AGAIN FOR THE PAST 4 YEARS,AND HAVE HAD IT AT 4 OR 5 DIFFERENT SHOPS AND NOBODY CAN FIX IT. BUT THE CAR TURNS OFF ON ME IN THE MIDDLE OF DRIVING AND THEN WONT RESTART. BUT AFTER I HAVE IT TOWED HOME IT WILL START A DAY OR TWO LATER.. I'VE HAD THE BATTERY REPLACED, THE STARTER, THE FUEL PUMP, THE ALTERNATOR AND HAVE HAD IT HOOKED UP TO THE COMPUTER TO SEE IF ANY WARNING SIGNALS GO OFF AND NOTHING COMES UP.. ITS HAPPENED ON THE HIGHWAY ON BACK ROADS AND WHILE SITTING AT A STOP LIGHT. IT IS VERY DANGEROUS AND I THINK AND HOPE THAT OLDSMOBILE WILL DO SOMETHING ABOUT IT TO HELP ITS CUSTOMERS HAVE A SAFER COMMUTE TO AND FROM THEIR DESTINATION... *TR
NHTSA ODI #10564518
117,000 miles · Oct 30, 2013
Electrical SystemVisibility
REAR DEFROSTER STOPPED WORKING. WENT TO DEALER FOR ANOTHER ISSUE AND DEALER TOLD ME SOMEONE PUT IN AN INADEQUATE WIRE TO MODULE AND CAUSED IT TO MELT. WENT TO 3 JUNKYARDS TODAY AND FOUND 6 ALERO AROUND THE SAME YEAR THAT ALL HAD THE WIRE MELTED TO THE MODULE. FOUND THIS ONLINE SO HERE I AM.. DEALER TRIED TO POINT FINGER AT SOMEO…
Read full complaint
REAR DEFROSTER STOPPED WORKING. WENT TO DEALER FOR ANOTHER ISSUE AND DEALER TOLD ME SOMEONE PUT IN AN INADEQUATE WIRE TO MODULE AND CAUSED IT TO MELT. WENT TO 3 JUNKYARDS TODAY AND FOUND 6 ALERO AROUND THE SAME YEAR THAT ALL HAD THE WIRE MELTED TO THE MODULE. FOUND THIS ONLINE SO HERE I AM.. DEALER TRIED TO POINT FINGER AT SOMEONE ELSE BUT ITS OBVIOUS THIS IS AN ALERO PROBLEM. I'LL BE CONTACTING THE DEALER AGAIN TO SEE WHAT THEY'LL DO ABOUT IT BEFORE IT CAUSES A FIRE. *TR
NHTSA ODI #10550161
68,000 miles · Sep 27, 2013
Electrical SystemExterior LightingCrash
HAZARD SWITCH FAILED RESULTING IN TURN SIGNALS ALSO NOT WORKING. PART WAS REPLACED IN 2004 UNDER RECALL ID 34013 BUT REPLACEMENT PART HAS FAILED. *TR
NHTSA ODI #10545734
123,111 miles · Aug 16, 2013
Electrical System
WHILE SITTING AT A RED LIGHT VEHICLE SHUT OFF AND WOULD NOT RESTART, HAD TO PUSH VEHICLE OFF OF ROAD, INTO PARKING LOT, WAITED A FEW MINUTES AND RESTARTED VEHICLE, ADDED FUEL TO VEHICLE WENT INSIDE TO PAY AND WHEN I RETURNED VEHICLE WOULD NOT RESTART. HAS CONTINUED TO FAIL TO START. DIAGNOSIS PASS LOCK SYSTEM FOR SECURITY CAUSES…
Read full complaint
WHILE SITTING AT A RED LIGHT VEHICLE SHUT OFF AND WOULD NOT RESTART, HAD TO PUSH VEHICLE OFF OF ROAD, INTO PARKING LOT, WAITED A FEW MINUTES AND RESTARTED VEHICLE, ADDED FUEL TO VEHICLE WENT INSIDE TO PAY AND WHEN I RETURNED VEHICLE WOULD NOT RESTART. HAS CONTINUED TO FAIL TO START. DIAGNOSIS PASS LOCK SYSTEM FOR SECURITY CAUSES VEHICLE TO SHUT OFF UNEXPECTEDLY OR NOT START UNEXPECTEDLY. *TR
NHTSA ODI #10535752
87,000 miles · Aug 2, 2013
Exterior Lighting
TL* THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. THE VEHICLE WAS REMEDIED FOR RECALL NHTSA CAMPAIGN NUMBER: 03V327000 (EXTERIOR LIGHTING). THE CONTACT STATED BOTH OF THE TURN SIGNALS ON THE VEHICLE COME ON SPORADICALLY. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC BUT THE CAUSE OF FAILURE HAD NOT BEEN DIAGNOSED. THE MANUFAC…
Read full complaint
TL* THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. THE VEHICLE WAS REMEDIED FOR RECALL NHTSA CAMPAIGN NUMBER: 03V327000 (EXTERIOR LIGHTING). THE CONTACT STATED BOTH OF THE TURN SIGNALS ON THE VEHICLE COME ON SPORADICALLY. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC BUT THE CAUSE OF FAILURE HAD NOT BEEN DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 87,000. THE CURRENT MILEAGE WAS 92,000.
NHTSA ODI #10533230
1,177,000 miles · Jun 6, 2013
Electrical SystemExterior LightingVisibility/wiper
I RECENTLY BOUGHT A USED 2001 OLDSMOBILE ALERO GL AND NOT EVEN A DAY LATER, THE TURN SIGNALS HAVE STOPPED WORKING. THE FUSES ARE STILL IN GREAT SHAPE AND THE HAZARD LIGHTS STILL WORK. I HAVE DONE MY RESEARCH AND HAVE FOUND THAT A RECALL WAS ISSUED FOR CERTAIN VIN #'S FOR THE TURN SIGNAL RELAY AND HAZARD LIGHT RELAY TO BE REPLACE…
Read full complaint
I RECENTLY BOUGHT A USED 2001 OLDSMOBILE ALERO GL AND NOT EVEN A DAY LATER, THE TURN SIGNALS HAVE STOPPED WORKING. THE FUSES ARE STILL IN GREAT SHAPE AND THE HAZARD LIGHTS STILL WORK. I HAVE DONE MY RESEARCH AND HAVE FOUND THAT A RECALL WAS ISSUED FOR CERTAIN VIN #'S FOR THE TURN SIGNAL RELAY AND HAZARD LIGHT RELAY TO BE REPLACED. ALTHOUGH MY VIN IS NOT ONE OF THE ISSUED NUMBERS, I AM EXPERIENCING THE SAME PROBLEMS. THIS IS A DANGER WHEN DRIVING AND I WANT MY VIN TO BE INVESTIGATED FOR THE SAME RECALL. I JUST BOUGHT THIS CAR AND WAS UNAWARE OF THESE ISSUES. MY SAFETY AND THE SAFETY OF MY FAMILY MEAN THE MOST, AND I CAN'T AFFORD TO FIX THIS PROBLEM MYSELF WHEN IT WASN'T CAUSED BY ME IN THE BEGINNING. OLDSMOBILE/GM SHOULD BE RESPONSIBLE FOR FIXING ALL AFFECTED VEHICLES AND NOT JUST THE ONES IN THE RECALL BULLETIN. *TR
NHTSA ODI #10515554
110,000 miles · Apr 25, 2013
Electrical SystemEngine
TL* THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE VEHICLE STALLED WITHOUT WARNING. SEVERAL MINUTES LATER THE VEHICLE WAS RESTARTED AND OPERATED AS DESIGNED. ONE MONTH LATER WHILE THE CONTACT WAS DRIVING 60 MPH, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FO…
Read full complaint
TL* THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE VEHICLE STALLED WITHOUT WARNING. SEVERAL MINUTES LATER THE VEHICLE WAS RESTARTED AND OPERATED AS DESIGNED. ONE MONTH LATER WHILE THE CONTACT WAS DRIVING 60 MPH, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS BUT NO CAUSE FOR THE FAILURE WAS DETERMINED. THE SUGGESTION WAS MADE TO THE CONTACT TO USE A DIFFERENT KEY. THE CONTACT FOLLOWED THE DEALERS RECOMMENDATIONS HOWEVER, THE FAILURE RECURRED ONE MONTH LATER. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 110,000. UPDATED 6/13/13 *CN THE CONSUMER BELIEVED THE REASON THE VEHICLE CONTINUOUSLY STALLED, WAS DUE TO THE ANTI-THEFT SYSTEM. THE SYSTEM BELIEVED THE VEHICLE WAS BEING STOLEN AND SHUT OFF THE GAS LINE, SO THE VEHICLE WOULD STALL. UPDATED 06/17/13
NHTSA ODI #10509558
22,000 miles · Apr 1, 2013
Service Brakes, HydraulicStructureVisibility
SEVERAL FAILURES OF EITHER FRONT BRAKES OR REAR BRAKES REQUIRING COMPLETE REPLACEMENT. FAILURE HAPPENS AFTER LESS THAN 20,000 ON EACH SET OF BRAKES. THERE HAS BEEN AT LEAST 3 WHEEL HUB REPLACEMENTS ON DRIVER SIDE AS WELL AS 2 WHEEL HUB REPLACEMENTS ON THE PASSENGER SIDE. BOTH DRIVERS WINDOW AND PASSENGER WINDOW MOTORS HAVE BE…
Read full complaint
SEVERAL FAILURES OF EITHER FRONT BRAKES OR REAR BRAKES REQUIRING COMPLETE REPLACEMENT. FAILURE HAPPENS AFTER LESS THAN 20,000 ON EACH SET OF BRAKES. THERE HAS BEEN AT LEAST 3 WHEEL HUB REPLACEMENTS ON DRIVER SIDE AS WELL AS 2 WHEEL HUB REPLACEMENTS ON THE PASSENGER SIDE. BOTH DRIVERS WINDOW AND PASSENGER WINDOW MOTORS HAVE BEEN REPLACED TWICE.... UPDATED 04/11/13 *BF
NHTSA ODI #10506095
134,000 miles · Feb 22, 2013
Electrical SystemVisibility
JUST BOUGHT MY 2001 ALERO RIGHT OFF THE CAR LOT, BUT NOW THE RIGHT SIDE PASSENGER MIRROR ISN'T WORKING, LIGHTER ISN'T WORKING, CALLED THE CAR LOT TO TELL THEM THAT AND HE SAID THAT IT COULD BE THE FUSE WAS BAD! SO I BUY A USED CAR FOR THREE GRAND AND MINOR STUFF STARTS HAPPENING TO IT.... HOW MUCH IS A FUSE?? *TR
NHTSA ODI #10499697
100,000 miles · Dec 10, 2012
Exterior Lighting
TL* THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN SHE NOTICED THAT THE TURN SIGNALS AND HAZARD LIGHTS WOULD NOT ILLUMINATE. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 03V327…
Read full complaint
TL* THE CONTACT OWNS A 2001 OLDSMOBILE ALERO. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN SHE NOTICED THAT THE TURN SIGNALS AND HAZARD LIGHTS WOULD NOT ILLUMINATE. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 03V327000 (EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH) THAT COULD HAVE BEEN RELATED TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. UPDATED 01/15/13*LJ UPDATED 1/23/2013*JS
NHTSA ODI #10487887
Official recalls
4Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Aug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Nov 13, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSAXLES (RPO M86) FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." WHEN A DRIVER ATTEMPTS TO SHIFT FROM 5TH GEAR TO REVERSE, A SHIFT INHIBITOR CAUSES THE TRANSMISSION TO BE MECHANICALLY IN 4TH GEAR EVEN THOUGH THE SHIFT LEVER INDICATES REVERSE GEAR.
Consequence & remedy
Consequence: IN THIS SITUATION, THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE TRANSMISSION IS IN A FORWARD GEAR, WHICH IS NOT PERMITTED BY THE STANDARD.
Remedy: DEALERS WILL DISABLE THE 5TH/REVERSE INHIBITOR BY REMOVING A RETAINING PIN AND REPLACE THE SHIFTER ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02037 · Turn Signal Failures
Opened Dec 23, 2002 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Illustration