NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
364 reports34,058 miles · Sep 6, 2005
Electrical System
DT: 2001 OLDSMOBILE ALERO. THE CONSUMER STATED THE SECURITY LIGHT KEPT COMING ON AND THE VEHICLE EVENTUALLY SHUT DOWN DUE TO THIS. THE VEHICLE HAS BEEN TO THE DEALERSHIP FIVE TIMES. THE DEALERSHIP REPLACED THE IGNITION SWITCH HOUSING. THIS COULD GO ON BETWEEN ONE TO SIX MONTHS BEFORE THE PROBLEM HAPPENED AGAIN. THE CUSTOM…
Read full complaint
DT: 2001 OLDSMOBILE ALERO. THE CONSUMER STATED THE SECURITY LIGHT KEPT COMING ON AND THE VEHICLE EVENTUALLY SHUT DOWN DUE TO THIS. THE VEHICLE HAS BEEN TO THE DEALERSHIP FIVE TIMES. THE DEALERSHIP REPLACED THE IGNITION SWITCH HOUSING. THIS COULD GO ON BETWEEN ONE TO SIX MONTHS BEFORE THE PROBLEM HAPPENED AGAIN. THE CUSTOMER SERVICE LINE AT OLDSMOBILE CONTINUOUSLY TOLD THE CONSUMER THEY WERE LOOKING INTO THE PROBLEM. SHE HAS CONTACTED THE MANUFACTURER THREE TIMES. THE PROBLEM STARTED ON NOVEMBER 14, 2003. THE PAST TWO TIMES THIS HAS OCCURRED THE SECURITY LIGHT CAME ON WHILE DRIVING. THE OWNER'S MANUAL STATED AT THAT A T THIS POINT THE CONSUMER SHOULD PULL OVER AND RESTART THE VEHICLE OR IT WILL SHUT DOWN WHILE DRIVING.*AK
NHTSA ODI #10135386
20,600 miles · Aug 25, 2005
Vehicle Speed Control
ON JULY 25, 2005 I CONTACTED OLDSMOBILE CUSTOMER ASSISTANCE CENTER REGARDING SERVICE NEEDED ON MY 2001 ALERO. I STATED THAT IT WAS MY UNDERSTANDING THAT THE SPEED CONTROL ACCELERATOR PEDAL ON MY VEHICLE WAS THE SUBJECT OF A RECALL BY THE MANUFACTURER. I HAVE NOT, HOWEVER, RECEIVED ANY NOTICE THAT CORRECTIVE REPAIRS WILL BE PERFO…
Read full complaint
ON JULY 25, 2005 I CONTACTED OLDSMOBILE CUSTOMER ASSISTANCE CENTER REGARDING SERVICE NEEDED ON MY 2001 ALERO. I STATED THAT IT WAS MY UNDERSTANDING THAT THE SPEED CONTROL ACCELERATOR PEDAL ON MY VEHICLE WAS THE SUBJECT OF A RECALL BY THE MANUFACTURER. I HAVE NOT, HOWEVER, RECEIVED ANY NOTICE THAT CORRECTIVE REPAIRS WILL BE PERFORMED. SPECIFICALLY, MY VEHICLE FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, ACCELERATOR CONTROL SYSTEMS. IN HOT AMBIENT CONDITIONS, THE ACCELERATOR PEDAL ARM MAY STICK AT THE ATTACHMENT TO THE BRACKET AND NOT RETURN TO THE ENGINE IDLE POSITION WHEN I LIFT MY FOOT FROM THE ACCELERATOR PEDAL. AS A RESULT, FAILURE TO RETURN TO IDLE COULD RESULT IN A VEHICLE CRASH. I INITIALLY ADVISED THE DEALER OF THIS PROBLEM ON MAY 11, 2004 AND THEY INFORMED ME THAT MY CAR REQUIRED THROTTLE BODY CLEANING AND SERVICE, WHICH THEY CHARGED $82.95. I RETURNED THE CAR TO THE DEALER AGAIN ON JUNE 27, 2005 FOR THE SAME PROBLEM AND THEY PERFORMED THE SAME SERVICE FOR $84.95. ON JULY 25, 2005 I BROUGHT THE CAR BACK TO THE DEALER WITH THE SAME COMPLAINT. THEY LUBRICATED THE THROTTLE PIVOT AND CHARGED ME $44.11. TO DATE I HAVE PAID $212.01 AND THE DEALER NEVER INFORMED ME THAT A RECALL HAD BEEN ISSUED FOR THIS PROBLEM. I WOULD APPRECIATE YOUR HELP IN VERIFYING IF THE REPAIR SHOULD BE COVERED BY THE MANUFACTURERS RECALL PROGRAM AND THE EXACT REMEDY TO CORRECT THIS PROBLEM.
NHTSA ODI #10134242
Mileage unknown · Aug 19, 2005
Electrical SystemFuel System, Gasoline
DT: 2001 OLDSMOBILE ALERO. WHILE DRIVING AT 65 MPH IN 5 PM TRAFFIC, THE CAR ENGINE SHUT OFF AND COASTED FROM THE LEFT LANE TO THE EMERGENCY LANE. IT WAS THEN TOWED TO AN OLDSMOBILE DEALERSHIP; WHO SAID THAT THE FUEL PUMP WAS THE PROBLEM FOR A SECOND TIME. THIS CAR HAS HAD MANY PROBLEMS. SOMETIME THE CAR WILL NOT CRANK AT AL…
Read full complaint
DT: 2001 OLDSMOBILE ALERO. WHILE DRIVING AT 65 MPH IN 5 PM TRAFFIC, THE CAR ENGINE SHUT OFF AND COASTED FROM THE LEFT LANE TO THE EMERGENCY LANE. IT WAS THEN TOWED TO AN OLDSMOBILE DEALERSHIP; WHO SAID THAT THE FUEL PUMP WAS THE PROBLEM FOR A SECOND TIME. THIS CAR HAS HAD MANY PROBLEMS. SOMETIME THE CAR WILL NOT CRANK AT ALL. IT ALSO HAS A LEAK IN THE PASSENGER SIDE FLOOR WHEN IT RAINS. THE CONSUMER HEARD ABOUT THE VOLVO PROBLEMS AND THE SAME THING IS HAPPENING TO THIS VEHICLE. THE ENGINE HAD ONLY SHUT OFF ONE TIME. THIS HAPPENED AROUND JULY 11, 2005. NO INJURIES FIRES NO CRASH REPORTED. *AK THE FUEL PUMP HAD BEEN REPLACED 3 TIMES. THE FUEL PUMP HAD AN INTERNAL SHORT. THE VEHICLE WOULD HAVE TO BE PLACED IN NEUTRAL, WOULD START THEN DIE. THE IGNITION SWITCH WAS REPLACED. THE FUEL GAUGE WOULD FALL TO EMPTY, AND THE FUEL LIGHT WOULD COME ON. THE VEHICLE WOULD CRANK BUT NOT START. *SC
NHTSA ODI #10131352
40,003 miles · Aug 8, 2005
Vehicle Speed Control
I HAVE BEEN HAVING PROBLEMS WITH THE ENGINE IDLING HIGH WHILE DRIVING, MAKING IT POSSIBLE TO SLOW DOWN, BRAKES WERE NOT WORKING, CAUSING ME TO PULL OVER TO THE EMERGENCY LANE, PUTTING THE CAR IN NEUTRAL, SHUTTING MY ENGINE OFF, IN ORDER TO GET CAR TO STOP. MY CAR HAS BEEN IN THE DEALER SHOP WHERE I BOUGHT IT, SINCE JULY 21, 200…
Read full complaint
I HAVE BEEN HAVING PROBLEMS WITH THE ENGINE IDLING HIGH WHILE DRIVING, MAKING IT POSSIBLE TO SLOW DOWN, BRAKES WERE NOT WORKING, CAUSING ME TO PULL OVER TO THE EMERGENCY LANE, PUTTING THE CAR IN NEUTRAL, SHUTTING MY ENGINE OFF, IN ORDER TO GET CAR TO STOP. MY CAR HAS BEEN IN THE DEALER SHOP WHERE I BOUGHT IT, SINCE JULY 21, 2005, THEY SAID THEY CAN'T FIND ANYTHING WRONG WITH IT, CAR IS STILL UNDER WARRANTY, BUT DUE TO NOT FINDING ANYTHING WRONG WITH THE CAR, THEY ARE CHARGING ME FOR TOWING FEE AND FOR DOING A PREFERMENT CHECK ON THE ENGINE, OUT OF POCKET IS OVER $100.00 TO SAY, WE CAN'T FIND ANYTHING WRONG. THIS WASN'T THE FIRST TIME, ON JUNE 13, 2005 THE SAME THING HAPPEN, PUTTING IT IN THE GRANGE FOR 4 DAYS ONLY TO SAY THEY COULDN'T FIND A THING WRONG WITH IT, I FEEL THERE IS DEFECT IN THE COMPUTER OR IDLE CONTROL, AS I FEEL THIS VEHICLE IS VERY UNSAFE WHILE DRIVING IT, NOT ONLY FOR MYSELF BUT FOR ANYONE ELSE TO BE AROUND WHEN THIS OCCURS AGAIN. *JB
NHTSA ODI #10131976
70,000 miles · Aug 6, 2005
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
2001 ALERO (2 DR. COUPE) I HAVE BEEN ON SEVERAL SITES AND AM FINDING MANY ALERO OWNERS HAVING THE SAME PROBLEMS THAT I HAVE ENCOUNTERED OVER THE LAST COUPLE OF YEARS. FUEL PUMP, WHEEL HUB ASSEMBLIES, INTAKE MANIFOLD GASKETS, POWER WINDOW FAILURE(GRINDING/BREAKING CLIPS/REGULATORS), SERV ENGINE AND TRACTION CONTROL LIGHTS CONST…
Read full complaint
2001 ALERO (2 DR. COUPE) I HAVE BEEN ON SEVERAL SITES AND AM FINDING MANY ALERO OWNERS HAVING THE SAME PROBLEMS THAT I HAVE ENCOUNTERED OVER THE LAST COUPLE OF YEARS. FUEL PUMP, WHEEL HUB ASSEMBLIES, INTAKE MANIFOLD GASKETS, POWER WINDOW FAILURE(GRINDING/BREAKING CLIPS/REGULATORS), SERV ENGINE AND TRACTION CONTROL LIGHTS CONSTANTLY ON, ELECTRICAL PROBLEMS, BRAKE PROBLEMS ETC. IT IS MY BELIEF THAT OLDS KNEW THEY WEREN'T MAKING THIS CAR ANYMORE, AND SENT A SUB-PAR PRODUCT OUT INTO THE MARKET "HOPING" TO GET AWAY WITH AS FEW RECALLS AS POSSIBLE. I HAVE NUMEROUS COMPLAINTS FILED WITH OLDS AND GENERAL MOTORS. GENERAL MOTORS HAS GONE WAY OUT AND OFFERED ME A $500.00 CERTIFICATE TOWARDS THE PURCHASE OF A NEW VEHICLE. GIVE ME ONE REASON I SHOULD GO THROUGH ANOTHER NIGHTMARE LIKE THIS ONE. RECALLS HAVE NEVER BEEN ISSUED ON ANY OF THESE COMPLAINTS BECAUSE IT WOULD PROBABLY COST MILLIONS OF DOLLARS FOR THEM TO FIX THE PROBLEMS. I CONSTANTLY WAIT TO SEE IF ANY CLASS ACTION SUITS INVOLVING THESE VEHICLES OCCURS AS I WILL BE ONE OF THE FIRST TO JUMP IN. WHAT'S THE SAYING..."IF IT LOOKS LIKE DOG CRAP AND SMELLS LIKE DOG CRAP DON'T STEP IN IT, IT'S PROBABLY DOG CRAP". THERE'S A DEFINED PROBLEM WITH THESE VEHICLES AND GM SHOULD BE TAKING RESPONSIBILITY FOR THEM. *JB
NHTSA ODI #10131778
20,600 miles · Jul 26, 2005
Vehicle Speed Control
STICKING THROTTLE CONCERN - VEHICLE ACCELERATOR STICKS, CAUSING THE CAR TO CONTINUE SPEEDING AND POSSIBLY RESULT IN A CRASH. PROBLEM FIRST OCCURRED IN THE SUMMER OF 2004 AND HAS REOCCURRED IN SUMMER OF 2005. THIS PROBLEM OCCURRED AFTER THROTTLE BODY CLEANING AND SERVICE WAS PERFORMED AT THE DEALER.
NHTSA ODI #10130041
Mileage unknown · Jul 22, 2005
Visibility
I HAVE A 2001 OLDMOBILE ALERO WITH AUTOMATIC WINDOWS. I HAVE HAD TO REPLACE 3 OF THE 4 WINDOWS DUE TO THE MOTOR GOING OUT CAUSING THE WINDOW TO NOT ROLL UP OR DOWN. I AM WAITING FOR THE 4TH WINDOW TO BREAK.
NHTSA ODI #10129717
Mileage unknown · Jun 17, 2005
Electrical System
I HAVE BEEN EXPERIENCING PROBLEMS WITH MY ELECTRICAL SYSTEM IN MY VEHICLE SINCE THE DAY I PURCHASED IT. I HAVE EXPERIENCED SEVERAL PROBLEMS THAT I BELIEVED TO HAVE LEAD TO WHAT I AM EXPERIENCING NOW. I HAVE TO TURN ON MY LIGHTS MANUALLY NOW. THAT ISN'T SO MUCH OF A PROBLEM, THE PROBLEM IS THAT WHEN MY CAR DOES NOT AUTOMATICAL…
Read full complaint
I HAVE BEEN EXPERIENCING PROBLEMS WITH MY ELECTRICAL SYSTEM IN MY VEHICLE SINCE THE DAY I PURCHASED IT. I HAVE EXPERIENCED SEVERAL PROBLEMS THAT I BELIEVED TO HAVE LEAD TO WHAT I AM EXPERIENCING NOW. I HAVE TO TURN ON MY LIGHTS MANUALLY NOW. THAT ISN'T SO MUCH OF A PROBLEM, THE PROBLEM IS THAT WHEN MY CAR DOES NOT AUTOMATICALLY TURN ON MY LIGHTS THIS MEANS MY AC DOES NOT WORK, MY POWER WINDOWS DO NOT WORK, MY STEREO DOES NOT WORK, CRUISE CONTROL DOES NOT WORK, MY SPEEDOMETER DOES NOT WORK, MY GAS GAUGE DOES NOT WORK OR MY THERMOSTAT DOES NOT WORK (THE INSIDE PANEL OF THE INSIDE OF MY CAR DOES NOT WORK). I CAN START UP MY CAR, BUT NOTHING INSIDE MY CAR WORKS. DRIVING IN AZ WITH NO AC AND NOT BEING ABLE TO LOWER YOUR WINDOWS BECAUSE THERE IS AN ELECTRICAL GADGET NOT ALLOWING THE VEHICAL TO WORK PROPERLY. I HAVE WRITTEN TO OLDSMOBILE ASKING THEM TO LOOK INTO THE PROBLEM, THEY HAVE NEGLECTED ALL RESPONSIBILTIES FROM ALL THE PROBLEMS I HAVE AND AM EXPERIENCING WITH MY VEHICAL. I HAVE ALSO MADE A FORMAL COMPLAINT THROUGH THE B.B.B., GENERAL MOTORS HAVE YET TO RESPOND. I FEEL IT IS VERY DANGEROUS DRIVING AROUND IN A VEHICAL THAT DECIDES TO WORK WHEN IT WANTS TO. ALL OF THE OTHER COMPLAINTS I HAVE READ ARE VERY SIMILAR TO MINE.
NHTSA ODI #10125570
Mileage unknown · Jun 14, 2005
Vehicle Speed Control
DT: THE CONTACT STATES THAT VEHICLE ACCELERATES BY ITSELF EVEN WHEN PRESS THE BRAKES. VEHICLE WILL NOT STOP, IT STILL ACCELERATES. THE GM REPAIR SHOP TOLD HER THREE TIMES THEY CANNOT FIND ANYTHING WRONG WITH THE VEHICLE, THEY HAVE THE VEHICLE NOW.*AK
NHTSA ODI #10125267
Mileage unknown · Jun 4, 2005
Service Brakes, AirService Brakes, Hydraulic
BRAKING SYSTEM MALFUCTION. EXTREMLEY LOUD LOW TONED GRINDING NOISE UPON BRAKING OCCURS AT QUICK STOPS AND WHEN TRAVELING ABOVE 30 MPHR. BRAKES WERE INSPECTED NOTHING TO BE FOIUND WRONG. 3 INDICTORS LIGHTS LIGHT INTERMITINIATLY WHILE DRIVING. REPAIR SHOP RESET ON 3 DIFFERENT OCCATIONS, INSPECTED BRKES ND SYSTEM NOTHING TO BE …
Read full complaint
BRAKING SYSTEM MALFUCTION. EXTREMLEY LOUD LOW TONED GRINDING NOISE UPON BRAKING OCCURS AT QUICK STOPS AND WHEN TRAVELING ABOVE 30 MPHR. BRAKES WERE INSPECTED NOTHING TO BE FOIUND WRONG. 3 INDICTORS LIGHTS LIGHT INTERMITINIATLY WHILE DRIVING. REPAIR SHOP RESET ON 3 DIFFERENT OCCATIONS, INSPECTED BRKES ND SYSTEM NOTHING TO BE FOUND WRONG. DUE TO CONTINUED ISSUES WITH INDICATOR LIGHTS AND NOISE I HAVE HAD BRAKES AND SYSTEM RECHECKED AND REPLACED 3 DIFFERENT TIMES IN THE PAST 1.5 YEARS. CURRENTLY STIL HAVING SAME ISSUES WITH NOISE, LIGHTS AND GRINDING.
NHTSA ODI #10124207
Official recalls
4Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Aug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Nov 13, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSAXLES (RPO M86) FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." WHEN A DRIVER ATTEMPTS TO SHIFT FROM 5TH GEAR TO REVERSE, A SHIFT INHIBITOR CAUSES THE TRANSMISSION TO BE MECHANICALLY IN 4TH GEAR EVEN THOUGH THE SHIFT LEVER INDICATES REVERSE GEAR.
Consequence & remedy
Consequence: IN THIS SITUATION, THE KEY CAN BE REMOVED FROM THE IGNITION WHILE THE TRANSMISSION IS IN A FORWARD GEAR, WHICH IS NOT PERMITTED BY THE STANDARD.
Remedy: DEALERS WILL DISABLE THE 5TH/REVERSE INHIBITOR BY REMOVING A RETAINING PIN AND REPLACE THE SHIFTER ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02037 · Turn Signal Failures
Opened Dec 23, 2002 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Illustration